Problem Symptoms Table
HINT:
Use the table below to help you find the cause of the problem. The numbers indicate the probability of the cause of the problem. Check each part in the order shown. If necessary, repair or replace these parts.
POWER STEERING SYSTEM
PROBLEM SYMPTOMS CHART
| Symptom | Suspected area | See example |
|---|---|---|
| Hard steering | 1. Tires (Improperly inflated) | INSPECTION |
| 2. Power steering fluid level (Low) | ON-VEHICLE INSPECTION | |
| 3. Drive belt (Loose) | ENGINE | |
| 4. Front wheel alignment (Incorrect) | FRONT WHEEL ALIGNMENT | |
| 5. Steering system joints (Worn) | - | |
| 6. Suspension arm ball joints (Worn) | COMPONENTS | |
| 7. Steering column (Binding) | - | |
| 8. Power steering vane pump | VANE PUMP | |
| 9. Power steering gear | RACK AND PINION POWER STEERING GEAR | |
| Poor return | 1. Tires (Improperly inflated) | INSPECTION |
| 2. Front wheel alignment (Incorrect) | FRONT WHEEL ALIGNMENT | |
| 3. Steering column (Binding) | - | |
| 4. Power steering gear | RACK AND PINION POWER STEERING GEAR | |
| Excessive play | 1. Steering system joints (Worn) | - |
| 2. Suspension arm ball joints (Worn) | COMPONENTS | |
| 3. Intermediate shaft, Sliding yoke (Worn) | - | |
| 4. Front wheel bearing (Worn) | COMPONENTS | |
| 5. Power steering gear | RACK AND PINION POWER STEERING GEAR | |
| Abnormal noise | 1. Power steering fluid level (Low) | ON-VEHICLE INSPECTION |
| 2. Steering system joints (Worn) | - | |
| 3. Power steering vane pump | VANE PUMP | |
| 4. Power steering gear | RACK AND PINION POWER STEERING GEAR |