Common Specs & Procedures
LAND CRUISER COMMON SPECS & PROCEDURES
| System | Specification/Procedure | |||
|---|---|---|---|---|
| Air Conditioning | ||||
| Service | SERVICE DATA [08/2015 - ] | |||
| Torque | TORQUE SPECIFICATIONS [08/2015 - ] | |||
| Axle Nut/Hub Nut | ||||
| Front | FRONT AXLE HUB | |||
| Rear Hub Bolt | REAR AXLE HUB BOLT | |||
| Battery | SERVICE DATA [08/2015 - ] | |||
| Brakes | ||||
| Bleeding Sequence | BLEEDING [08/2015 - ] | |||
| Front Brakes | SERVICE DATA [08/2015 - ] | |||
| Torque | TORQUE SPECIFICATIONS [08/2015 - ] | |||
| Rear Brakes | SERVICE DATA [08/2015 - ] | |||
| Torque | TORQUE SPECIFICATIONS [08/2015 - ] | |||
| Charging | ||||
| Generator | SERVICE DATA [08/2015 - ] | |||
| Torque | TORQUE SPECIFICATIONS [08/2015 - ] | |||
| Drive Belts | ||||
| Adjustment | Engine has belt tensioner, no adjustment necessary, ON-VEHICLE INSPECTION [08/2015 - ] | |||
| Belt Routing | INSTALLATION [08/2015 - ] | |||
| Engine Cooling | ||||
| General Service Specifications | SERVICE DATA [08/2015 - ] | |||
| Radiator Cap Pressure | New 93 to 123 kPa (1.0 to 1.3 kgf/cm2 , 13.5 to 17.8 psi) Minimum Standard Value, Used 79 kPa (0.8 kgf/cm2 , 11.4 psi) |
|||
| Thermostat R & I | THERMOSTAT | |||
| Water Pump R & I | WATER PUMP | |||
| Engine Mechanical | ||||
| Compression | SERVICE DATA [08/2015 - 08/2016] or SERVICE DATA [08/2016 - ] | |||
| Oil Pressure | At idle: 70 kPa (0.7 kgf-cm2
, 10.1 psi) or more At 2500 RPM: 220 kPa (2.2 kgf-cm2 , 32 psi) |
|||
| Overhaul | SERVICE DATA [08/2015 - 08/2016] or SERVICE DATA [08/2016 - ] | |||
| Torque | TORQUE SPECIFICATIONS [08/2015 - ] | |||
| Fluid Specifications | See FLUIDS under MAINTENANCE tab. | |||
| Flywheel/Flex Plate (Drive Plate) Torque | INSTALLATION [08/2015 - ] | |||
| Fuel System | ||||
| Pressure Specification | At idle: 281 - 287 kPa (2.87 to 2.93 kgf/cm2
, 41 - 42 psi) 5 min. after engine stopped: 147 kPa, (1.5 kgf/cm2 , 21 psi) or more |
|||
| Fuel Pressure Test Procedure | ON-VEHICLE INSPECTION [08/2015 - ] | |||
| Fuel Filter Location | FUEL FILTER | |||
| Ignition | ||||
| Firing Order & Cylinder Identification | FIRING ORDER & CYLINDER IDENTIFICATION | |||
| Spark Plugs | ||||
| Type | DENSO SK20HR11 | |||
| Gap | New: 0.0394 to 0.0433 in. (1.0 to 1.1 mm) Maximum used: 0.0512 in. (1.3 mm)) |
|||
| Torque | 21 N*m (214 kgf*cm, 15 ft.*lbf) | |||
| Starting | ||||
| Starter | SERVICE DATA [08/2015 - ] | |||
| Torque | TORQUE SPECIFICATIONS [08/2015 - ] | |||
| Wheel Alignment | ||||
| Adjustment Specifications | SERVICE DATA [08/2015 - 08/2016] or SERVICE DATA [08/2016 - ] | |||
| Torque | TORQUE SPECIFICATIONS [08/2015 - ] | |||
| Wheel & Tire | ||||
| Wheel Lug Nut Torque | 131 Nm (1336 kgf-cm, 97 lbf-ft.) | |||