Fuel, Ignition & Engine Control Systems - Removal, Installation & Specifications
- Ignition and control systems
- Accelerator pedal (AP), replacing
- Adapter wiring switch, replacing
- Air leakage in the intake system, checking
- Air leaks in the intake system, checking
- Camshaft position sensor (CMP), replacing
- Camshaft seal / variable valve timing (VVT) unit, replacing (B6xx4T -1999)
- Camshaft seal/variable valve timing (VVT) unit, replacing (B5244T5; B5254T2; B5254T4; 2005-2007)
- Camshaft seal/variable valve timing (VVT) unit, replacing (B5244S; B5244S6; 2005-2007)
- Camshaft seal/variable valve timing (VVT) unit, replacing (B6xx4S; -1999; B5234T3; B5244T3; 2001)
- CAN network
- Carbon filter container, replacing (B5234T3; 2002-2004; B5244T5; B5254T2; B5254T4; 2005-2007)
- Checking engine control module (ECM) power supply and ground terminal
- Checking for air leakage in the exhaust system (B5244T5; B5254T2; B5254T4; 2005-2006)
- Checking fuel and residual pressures
- Checking fuel pressure and residual pressure in the workshop
- Component specifications (5 cylinder turbocharged engines -2002)
- Bosch ME 7 engine control module (ECM)
- Throttle unit
- Accelerator pedal (AP) position sensor
- Pressure regulator
- The mass air flow (MAF) sensor
- Fuel pump
- Injector
- Boost pressure sensor
- Turbocharger (TC) control valve
- Camshaft reset valve
- Intake air temperature (IAT) sensor
- Engine coolant temperature (ECT) sensor
- Knock sensor (KS)
- Camshaft position (CMP) sensor
- Engine speed (RPM) sensor
- Front heated oxygen sensor (HO2S)
- Preheating, front heated oxygen sensor (HO2S)
- Rear heated oxygen sensor (HO2S)
- Preheating, rear heated oxygen sensor (HO2S)
- Ignition coil
- Spark plugs
- Outside temperature sensor
- A/C pressure sensor
- Air conditioning (A/C) pressure switch (Pressostat)
- Canister purge (CP) valve
- EVAP canister shut-off valve
- Fuel tank pressure sensor
- Fuel pump (FP) relay
- Air conditioning (A/C) relay
- Engine cooling fan (FC) relay
- System relay (1)
- Clutch pedal sensor
- Brake pedal sensor
- Stop (brake) lamp switch
- Engine coolant level switch
- Oil pressure switch
- Component specifications (B5234T3; B5244T3; B5244T5; B5254T2; B5254T4; 2001-2007)
- Compression test
- Construction of the network
- Control modules in the Control area network (CAN)
- Crankcase ventilation and electronic throttle module (ETM), cleaning
- Checking spark plugs
- Description of diagnostic trouble code (DTC) status
- Description of frozen values Me7
- Description of parameters, quick test of the fuel tank system
- Draining fuel injection system
- Draining the fuel tank AWD and 2WD/ORVR
- Draining/vacuum pumping/filling with coolant and leak-finding
- Engine control module (ECM), replacing
- Engine coolant temperature (ECT) sensor, replacing (B5234T3; 2001-2004)
- Engine coolant temperature (ECT) sensor, replacing (B5244S; 2001-2007)
- Engine cooling fan (FC), replacing
- Engine speed (RPM) sensor, replacing (B5244T5; B5254T2; B5254T4; 2003-2007)
- Engine temperature sensor, replacing
- Error management in the Controller area network (CAN)
- Frozen values DENSO, description
- Diagnostic Trouble Code (DTC)
- Read off fault type
- Previous fault type
- Time before the data was frozen
- Time after engine start
- Outside temperature
- Atmospheric pressure
- Vehicle speed
- Engine speed
- Mass air flow g/stroke
- Intake pressure
- Engine coolant temperature (ECT)
- Lambda compensation
- Long term fuel trim
- Accelerator pedal (AP) affected
- Probe control
- Fuel shut-off system
- Operating cycle
- Warm-up cycle
- Gear selected
- Engine cooling fan (FC)
- A/C requested
- Air conditioning (A/C) compressor active
- Brake pedal switch
- EVAP canister purge valve active
- Cruise control active
- EVAP canister shut-off valve
- State, fuel trim
- Battery voltage
- Passenger compartment temperature
- Odometer setting
- Frozen values dependent on diagnostic trouble codes (DTCs)
- Fuel pressure gauge
- Fuel pressure sensor