Section 444 (Battery, Charging System And Starting System)
WARNING: This page does not describe the selected car, but rather 8 other vehicles, including the 2004 GMC Yukon XL, 2004 GMC Yukon, 2004 Chevrolet Tahoe, 2004 Chevrolet Suburban, and 2004 Chevrolet Avalanche. However, it is still accessible from the selected car via links, so may be relevant.
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Engine Electrical
- Diagnostic System Check - Engine Electrical
- Scan Tool Data List
- Scan Tool Data Definitions
- Diagnostic Trouble Code (DTC) List
- DTC B1327: System Voltage Low
- DTC B1328: System Voltage High
- DTC P0562: System Voltage Low
- DTC P0563: System Voltage High
- DTC P0615: Starter Relay Control Circuit
- DTC P0622: Generator F-Terminal Circuit
- DTC P1637: Generator L-Terminal Circuit
- Symptoms - Engine Electrical
- Battery Inspection/Test (Non-HP2)
- Battery Charging
- Battery Electrical Drain/Parasitic Load Test (w/ BCM)
- Battery Common Causes of Failure
- Jump Starting in Case of Emergency (Non HP2)
- Charging System Test (CS/AD/SI Generators)
- Charge Indicator Always On
- Charge Indicator Inoperative
- Generator Noise Diagnosis
- Starter Solenoid Does Not Click
- Starter Solenoid Clicks, Engine Does Not Crank
- Engine Cranks Slowly
- Starter Motor Noise Diagnosis
- Repair Instructions
- Battery Negative Cable Disconnect/Connect Procedure
- Battery Negative Cable Replacement
- Battery Positive Cable Replacement
- Generator Cable Replacement
- Battery Replacement
- Battery Tray Replacement
- Ground Strap Replacement
- Starter Motor Replacement (4.8L, 5.3L, and 6.0L Engines)
- Starter Motor Replacement (8.1L Engine)
- Starter Shield Replacement
- Generator Bracket Replacement (4.8L, 5.3L, and 6.0L Engines)
- Generator Bracket Replacement (8.1L Engine)
- Generator Replacement (4.8L, 5.3L, and 6.0L Engines)
- Generator Replacement (8.1L Engine)
- Description and Operation
- Special Tools and Equipment