Engine Controls - Tests W/Codes - 2.5L
- Introduction
- Self-Diagnostic System
- Inactive DTC Condition
- Fuel Pressure Release
- Trouble Codes/Messages
- Connector Identification
- Self-Diagnostic Tests
- Notes
- Test TC-1A - Checking For DTCS
- Test TC-2A - No Crank Reference Signal At Pcm (DTC 11)
- Test TC-2B - No Crank Reference Signal At Pcm
- Test TC-3A - No Cam Sync Signal At Pcm (DTC 54)
- Test TC-4A - Map Sensor Voltage Too Low (DTC 14)
- Test TC-5A - Map Sensor Voltage Too High (DTC 14)
- Test TC-6A - No Change In Map From Start To Run And Slow Change In Idle Map Sensor Signal (DTC 13)
- Test TC-7A - O2S Stays At Center (DTC 21)
- Test TC-8A - O2S Stays Above Center (Rich) (DTC 52)
- Test TC-9A - O2S Stays Below Center (Lean) (DTC 51)
- Test TC-10A - O2S Shorted To Voltage (DTC 21)
- Test TC-11A - No Vehicle Speed Sensor Signal (DTC 15)
- Test TC-11B - No Vehicle Speed Sensor Signal
- Test TC-11C - No Vehicle Speed Sensor Signal
- Test TC-11D - No Vehicle Speed Sensor Signal
- Test TC-11E - No Vehicle Speed Sensor Signal
- Test TC-12A - Idle Air Control Motor Circuits (DTC 25)
- Test TC-12B - Idle Air Control Motor Circuits
- Test TC-12C - Idle Air Control Motor Circuits
- Test TC-12D - Idle Air Control Motor Circuits
- Test TC-12E - Idle Air Control Motor Circuits
- Test TC-13A - Injector Control Circuit (DTC 27)
- Test TC-13B - Injector Control Circuit
- Test TC-17A - EGR System Failure (DTC 32)
- Test TC-18A - EGR Solenoid Circuit (DTC 32)
- Test TC-19A - EVAP Purge Solenoid Circuit (DTC 31)
- Test TC-20A - Torque Converter Clutch Solenoid Circuit (DTC 37)
- Test TC-21A - Throttle Position Sensor Voltage Low (DTC 24)
- Test TC-22A - Throttle Position Sensor Voltage High (DTC 24)
- Test TC-23A - Throttle Body Temp Sensor Voltage Low (DTC 23)
- Test TC-24A - Throttle Body Temp Sensor Voltage High (DTC 23)
- Test TC-25A - ECT Sensor Voltage Too Low (DTC 22)
- Test TC-26A - ECT Sensor Voltage Too High (DTC 22)
- Test TC-27A - No ASD Relay Output Voltage At Pcm (DTC 42)
- Test TC-28A - Auto Shutdown Relay Control Circuit (DTC 42)
- Test TC-29A - Rad Fan Control Relay Circuit (DTC 35)
- Test TC-30A - Low Speed Fan CTRL Relay Circuit (DTC 35)
- Test TC-31A - High Speed Fan CTRL Relay Circuit (DTC 35)
- Test TC-32A - A/C Clutch Relay Circuit (DTC 33)
- Test TC-36A - Pcm Failure Sri Mile Not Stored And Pcm Failure EEPROM Write Denied (DTC 62 & 63)
- Test TC-37A - Battery Temp Sensor Volts Out Of Limit (DTC 44)
- Test NTC-1A - No DTC Test Menu
- Test NTC-2A - Checking Secondary Ignition & Timing
- Test NTC-3A - Checking Fuel Pressure
- Test NTC-3B - Checking Fuel Pressure
- Test NTC-4A - Checking Coolant Sensor Calibration & Radiator Fan Operation
- Test NTC-5A - Checking TP Sensor Calibration
- Test NTC-6A - Checking Map Sensor Calibration
- Test NTC-7A - Checking Oxygen Sensor (O2S) Switching
- Test NTC-7B - Checking Oxygen Sensor (O2S) Switching
- Test NTC-8A - Checking Oxygen Sensor (O2S) Heater
- Test NTC-9A - Checking Idle Air Control Motor
- Test NTC-9B - Checking Idle Air Control Motor
- Test NTC-10A - Checking Solenoid Operations
- Test NTC-11A - Checking Park/Neutral Switch
- Test NTC-12A - Checking Pcm Ground & Power Circuits
- Test NTC-14A - Checking Engine Vacuum
- Test NTC-15A - Checking Minimum Idle Airflow
- Test NTC-16A - No DTC Mechanical Test
- No-Start Tests
- Test NS-1A - Qualifying No Start Condition
- Test NS-2A - Inspecting Fuel System
- Test NS-3A - Inspecting Mechanical System
- Test NS-4A - Correcting Fuel Delivery
- Test NS-4B - Correcting Fuel Delivery
- Test NS-4C - Correcting Fuel Delivery
- Test NS-5A - Inspecting Fuel Pump
- Test NS-5B - Inspecting Fuel Pump
- Test NS-5C - Inspecting Fuel Pump
- Test NS-6A - Correcting No Response Condition
- Test NS-6B - Correcting No Response Condition
- Test NS-6C - Correcting No Response Condition
- Test NS-6D - Correcting No Response Condition
- Test NS-7A - Inspecting Idle Air Control Motor Operation
- Test NS-7B - Inspecting Idle Air Control Motor Operation
- Test NS-7C - Inspecting Idle Air Control Motor Operation
- Test NS-7D - Inspecting Idle Air Control Motor Operation
- Test NS-7E - Inspecting Idle Air Control Motor Operation
- Test NS-8A - Correcting Start & Stall Condition
- Test NS-9A - Repairing No Crank Condition
- Test NS-9B - Repairing No Crank Condition
- Test NS-9C - Repairing No Crank Condition
- Verification Tests
- Summary
- Wiring Diagrams