ESC (Electronic Stability Control) System
- Components(1)
- Description of ESC
- ESC Operation Mode
- EBD (Electronic Brake-Force Distribution) Operation
- ESC Circuit Diagram (1)
- ESC Circuit Diagram (2)
- ESC Circuit Diagram (3)
- ESC Connector Input/Output
- Failure Diagnosis
- Scan Tool Check
- Standard Flow of Diagnostic Troubleshooting
- Problem Symptoms Table
- Notes
- ABS Does Not Operate
- ABS Does Not Operate (Intermittently)
- Communication with Scan-Tool is not possible. (Communication with any system is not possible)
- Communication with Scan Tool is not possible. (Communication with ABS only is not possible)
- When Ignition Key Is Turned ON (engine OFF), The ABS Warning Lamp Does Not Light Up
- Even After The Engine Is Started, The ABS Warning Lamp Remains ON
- Bleeding of Brake System
- Diagnostic Trouble Codes (DTC)
- Notes
- C1101 Battery Voltage High
- C1102 Battery Voltage Low
- C1200 Wheel Speed Sensor Front-LH Open/Short
- C1201 Wheel Speed Sensor Front-LH Range/Performance/Intermittent
- C1202 Wheel Speed Sensor Front-LH Invalid/no Signal
- C1203 Wheel Speed Sensor Front-RH Open/Short
- C1204 Wheel Speed Sensor Front-RH Range/Performance/Intermittent
- C1205 Wheel Speed Sensor Front-RH Invalid/no Signal
- C1206 Wheel Speed Sensor Rear-LH Open/Short
- C1207 Wheel Speed Sensor Rear-LH Range/Performance/Intermittent
- C1208 Wheel Speed Sensor Rear-LH Invalid/no Signal
- C1209 Wheel Speed Sensor Rear-RH Open/Short
- C1210 Wheel Speed Sensor Rear-RH Range/Performance/Intermittent
- C1211 Wheel Speed Sensor Rear-RH Invalid/no Signal
- C1235 Primary Pressure Sensor-Electrical
- C1237 Primary Pressure Sensor-Signal
- C1260 Steering Angle Sensor Circuit-Signal
- C1261 Steering Angle Sensor Not Calibrated
- C1282 Yaw Rate & Lateral G Sensor-Electrical
- C1283 Yaw Rate & Lateral G Sensor-Signal
- C1503 TCS/ESC(ESP) Switch error
- C1513 Brake switch error
- General Description
- DTC Description
- DTC Detecting Condition
- Diagnostic Circuit Diagram
- Monitor Scantool Data
- Terminal and Connector Inspection
- Signal Circuit Inspection (In case of brake-pedal released)
- Signal Circuit Inspection (In case of brake-pedal pressed)
- Component Inspection
- Verification of Vehicle Repair
- C1604 ECU Hardware Error
- C1605 CAN Hardware error
- C1611 CAN Time-out ECM
- C1612 CAN Time-out TCM
- C1613 CAN signal error ECM (Check ECM)
- C1616 CAN Communication Bus Off
- C1623 CAN Time-out Steering Angle Sensor
- C1626 Implausible Control
- C1702 Variant Coding Error
- C2112 Valve Relay Error
- C2227 Excessive Temperature Of Brake Disc
- C2312 Front-LH Valve error (Outlet Valve)
- C2308 Front-LH Valve error (Inlet Valve)
- C2316 Front-RH Valve error (Inlet Valve)
- C2320 Front-RH Valve error (Outlet Valve)
- C2324 Rear-LH Valve error (Inlet Valve)
- C2328 Rear-LH Valve error (Outlet Valve)
- C2332 Rear-RH Valve error (Inlet Valve)
- C2336 Rear-RH Valve error (Outlet Valve)
- C2366 TC Valve Primary (USV1) Error
- C2370 TC Valve Secondary (USV2) Error
- C2372 Electronic Shuttle Valve Primary (HSV1) Error
- C2374 Electronic Shuttle Valve Secondary (HSV2) Error
- C2380 ABS/TCS/ESP valve error
- C2402 Motor Failure
- ESC Control Unit
- Front Wheel Speed Sensor
- Rear Wheel Speed Sensor
- Yaw-rate and Lateral G Sensor
- ESC OFF Switch
- Steering Angle Sensor