Manual Transmission On-Vehicle Service - Lancer Evolution
- General Description
- Manual Transaxle Diagnosis < ACD >
- Troubleshooting Strategy
- Introduction
- Diagnostic Function
- Reading Diagnosis Code
- On-Board Diagnostics
- HOW TO READ AND ERASE DIAGNOSTIC TROUBLE CODES (When using the ACD mode indicator light)
- Understanding The ACD Mode Indicator Light Flashes
- How To Connect The Scan Tool (M.U.T.-III)
- How To Read And Erase Diagnostic Trouble Codes
- How To Read Data List
- How To Perform Actuator Test
- Diagnostic Trouble Code Chart
- Symptom Chart
- Diagnostic Trouble Code Procedures
- DTC 12: Power Supply Voltage (Valve Power Supply) System
- DTC 13: Fail-safe Relay System < Inside AWD-ECU >
- DTC 21: ABS Sensor < FR > System; DTC 22: ABS Sensor < FL > System; DTC 23: ABS Sensor < RR > System; DTC 24: ABS Sensor < RL > System; < Vehicles without ABS >
- DTC 21: ABS Sensor < FR > System; DTC 22: ABS Sensor < FL > System; DTC 23: ABS Sensor < RR > System; DTC 24: ABS Sensor < RL > System; < Vehicles with ABS >
- DTC 25: Wrong-diameter Tire < Vehicles without ABS >
- DTC 25: Wrong-diameter Tire < Vehicles with ABS >
- DTC 26: ABS Sensor System (Faulty Output Signal) < Vehicles without ABS >
- DTC 26: ABS Sensor System (Faulty Output Signal) < Vehicles with ABS >
- DTC 31: Steering Angular Velocity Sensor < ST-1, ST-2, ST-N > System
- DTC 32, 33: Steering Angular Velocity Sensor < ST-N > System
- DTC 34: Steering Angular Velocity Sensor < ST-1, ST-2 > System
- DTC 41, 42: Throttle Position Sensor System
- DTC 45: Pressure Sensor System (Open Circuit or Short Circuit)
- DTC 46: Pressure Sensor System (Open Ground)
- DTC 47: Pressure Sensor System (Abnormal Power Supply)
- DTC 51: G-sensor (Longitudinal) System (Open Circuit or Short Circuit)
- DTC 52: G-sensor (Longitudinal) System (Defective Sensor)
- DTC 56: G-sensor (Lateral) System Open Circuit or Short Circuit)
- DTC 57: G-sensor (Lateral) System (Defective Sensor)
- DTC 61: Stoplight Switch System
- DTC 62: ACD Mode Changeover Switch System
- DTC 63: Parking Brake Switch System
- DTC 65: ABS Monitor System < Vehicles with ABS >
- DTC 74: Proportioning Valve System
- DTC 81: Electric Pump Relay System (Open Circuit or Short Circuit)
- DTC 82: Electric Pump Relay System
- Symptom Procedures
- INSPECTION PROCEDURE 1: No Communication Possible Between Scan Tool and All Systems.
- INSPECTION PROCEDURE 2: No Communication is Possible Between the scan tool and AWD-ECU.
- INSPECTION PROCEDURE 3: The ACD Mode Indicator Light Does Not Light Up When The Ignition Switch Is Turned "ON" (Engine Is Stopped).
- INSPECTION PROCEDURE 4: More Than Two ACD Mode Indicator Lights Remain Lit Even After The Engine Is Started.
- INSPECTION PROCEDURE 5: The ACD Does Not Operate (No Diagnosis Code
- Data List Reference Table
- Actuator Test Reference Table
- AWD-Ecu Terminal Voltage Reference Chart For ACD
- Manual Transaxle Diagnosis < M/T >
- Special Tools
- On-Vehicle Service
- Transaxle Control
- Removal And Installation
- < W5M51 >
- Removal Service Point
- Installation Service Points
- >> A << Gearshift Link Clip Installation
- >> B << Shift Cable And Select Cable Assembly/Shift Cable Connection (Transaxle Side)/Select Cable Connection (Transaxle Side) Installation
- >> C << Shift Cable Connection (Shift Lever Side) Installation
- >> D << Sleeve/Shift Knob Installation
- >> A << Gear Shift Link Clip Installation
- >> B << Select Cable Connection (Transaxle Side) Installation
- >> C << Select Cable Connection (Shift Lever Side) Installation
- < W6MAA >
- Removal Service Points
- Shift Lever Assembly < W5M51 >
- Select Cable (Cabin Side) Adjustment < W6MAA >
- Removal And Installation
- Transfer Assembly
- Transaxle Assembly
- AWD-Ecu
- Hydraulic Unit
- Sensor, Switch And Relay
- Specifications