Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups
Common Specs & Procedures
DTC Index
Electrical Component Locations
Fluids
Technical Bulletins
Tire Fitment
Wiring Diagrams- System Wiring Diagrams
- Using lemon2025'S Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Body Control Modules
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Windows
- Radio
- Starting/Charging
- Supplemental Restraints
- Transmission
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- System Wiring Diagrams
- Accessories & Equipment
- Anti-Theft Systems
- Anti-Theft Systems
- Power Door Lock System & Liftgate Release
- Remote Keyless Entry Systems
- Description
- Operation
- Component Locations
- Programming
- Trouble Shooting
- Notes
- RKE System Or Door Lock Switches Inoperative
- Transmitter Will Not Lock Or Unlock Doors
- Power Locks Don't Work With RKE, But Work With Lock Switches
- Power Locks Work With RKE, But Do Not Work With One Or Both Lock Switches
- One Power Lock Does Not Work With RKE Or Lock Switches
- Anti-Theft Features (If Equipped) Do Not Work
- Component Tests
- System Tests
- Removal & Installation
- Wiring Diagrams
- Body Interior
- Body Control Modules
- Description
- Operation
- Component Locations
- Trouble Shooting
- Self-Diagnostic System
- Connector Identification
- System Tests
- Notes
- Chime System
- Communications
- Notes
- Bus (+) &/Or Bus (-) Open
- Bus (+) & Bus (-) Shorted Together
- Bus Bias Level Too Low Or Too High
- No Bus Bias
- No Response: Air Bag Control Module (ACM)
- No Response: Controller Anti-Lock Brake (CAB) Module
- No Response: Central Timer Module (CTM)
- No Response: Compass Mini Trip Computer (CMTC)
- No Response: Mechanical Instrument Cluster (MIC)
- No Response: Powertrain Control Module (PCM)
- No Response From Radio
- No Termination
- Not Receiving Bus Messages Correctly
- Bus Short To 5 Volts
- Bus Short To Battery
- Bus Short To Ground
- Door Ajar System
- Mechanical Instrument Cluster (Mic)
- Overhead Console
- Power Door Lock & RKE Systems
- Notes
- Door Lock Switch Failure
- Door Unlock Switch Failure
- All Doors Fail To Lock From Any Switch
- All Doors Fail To Lock From One Switch
- All Doors Fail To Lock/Unlock From Any Switch
- All Doors Fail To Unlock From Any Switch
- All Doors Fail To Unlock From One Switch
- Automatic (Rolling) Door Locks Inoperative
- Driver Door Fails To Lock From Any Switch
- Driver Door Fails To Unlock From Any Switch
- Liftgate Fails To Lock/Unlock From Any Switch (Durango)
- One Door Fails To Lock/Unlock From Any Switch
- Remote Keyless Entry (RKE) Problem
- Doors Lock With Key In Ignition & Left Door Open
- Vehicle Theft Security System
- Windshield Wiper System
- Verification Test
- Wiring Diagrams
- Body Control Modules
- Communication Devices
- Body Control Modules
- Description
- Operation
- Component Locations
- Trouble Shooting
- Self-Diagnostic System
- Connector Identification
- System Tests
- Notes
- Chime System
- Communications
- Notes
- Bus (+) &/Or Bus (-) Open
- Bus (+) & Bus (-) Shorted Together
- Bus Bias Level Too Low Or Too High
- No Bus Bias
- No Response: Air Bag Control Module (ACM)
- No Response: Controller Anti-Lock Brake (CAB) Module
- No Response: Central Timer Module (CTM)
- No Response: Compass Mini Trip Computer (CMTC)
- No Response: Mechanical Instrument Cluster (MIC)
- No Response: Powertrain Control Module (PCM)
- No Response From Radio
- No Termination
- Not Receiving Bus Messages Correctly
- Bus Short To 5 Volts
- Bus Short To Battery
- Bus Short To Ground
- Door Ajar System
- Mechanical Instrument Cluster (Mic)
- Overhead Console
- Power Door Lock & RKE Systems
- Notes
- Door Lock Switch Failure
- Door Unlock Switch Failure
- All Doors Fail To Lock From Any Switch
- All Doors Fail To Lock From One Switch
- All Doors Fail To Lock/Unlock From Any Switch
- All Doors Fail To Unlock From Any Switch
- All Doors Fail To Unlock From One Switch
- Automatic (Rolling) Door Locks Inoperative
- Driver Door Fails To Lock From Any Switch
- Driver Door Fails To Unlock From Any Switch
- Liftgate Fails To Lock/Unlock From Any Switch (Durango)
- One Door Fails To Lock/Unlock From Any Switch
- Remote Keyless Entry (RKE) Problem
- Doors Lock With Key In Ignition & Left Door Open
- Vehicle Theft Security System
- Windshield Wiper System
- Verification Test
- Wiring Diagrams
- Body Control Modules
- Cruise Control Systems
- Description
- Operation
- Component Locations
- Trouble Shooting
- Connector Identification
- Self-Diagnostic System
- Diagnostic Tests
- DTC P1595: Speed Control Solenoid Circuits (All Models) Or DTC P1683: Speed Control Power Relay Circuit (Except Ram Pickup)
- DTC P1596: Speed Control Switch Always High (Ram Pickup)
- DTC P1596: Speed Control Switch Always High (DAKOTA, DURANGO, Ram Van & Ram Wagon)
- DTC P1597: Speed Control Switch Always Low
- DTC P1683: Speed Control Power Relay Circuit (Ram Pickup)
- DTC P1899: Park/Neutral Position (PNP) Switch Stuck In Park Or In Gear (A/T Models)
- System Tests
- Verification Tests
- Component Tests
- Removal & Installation
- Wiring Diagrams
- Entertainment Systems
- Description & Operation
- Component Locations
- Trouble Shooting
- Diagnosis & Testing
- Symptom Tests
- Notes
- Test A: Cassette Error/Cd Error/Radio Error
- Test B: Left Channel Shorted
- Test C: Right Channel Shorted
- Test D: Shorted Front Channel
- Test E: Shorted Rear Channel
- Test F: 1-5 Presets Inoperative
- Test G: No Sound From All Speakers
- Test H: No Sound From One Speaker
- Test I: Poor Sound From All Speakers
- Test J: Poor Sound From One Speaker
- Test K: Radio Controls Inoperative
- Body Verification Test VER-1
- Removal & Installation
- Wiring Diagrams
- Exterior Lights
- Gauges & Instrument Panels
- Headlights
- Heated Glass/Defoggers
- Infotainment
- Entertainment Systems
- Description & Operation
- Component Locations
- Trouble Shooting
- Diagnosis & Testing
- Symptom Tests
- Notes
- Test A: Cassette Error/Cd Error/Radio Error
- Test B: Left Channel Shorted
- Test C: Right Channel Shorted
- Test D: Shorted Front Channel
- Test E: Shorted Rear Channel
- Test F: 1-5 Presets Inoperative
- Test G: No Sound From All Speakers
- Test H: No Sound From One Speaker
- Test I: Poor Sound From All Speakers
- Test J: Poor Sound From One Speaker
- Test K: Radio Controls Inoperative
- Body Verification Test VER-1
- Removal & Installation
- Wiring Diagrams
- Entertainment Systems
- Interior/Illumination Lights
- Power Mirrors
- Seats
- Steering Column Switches
- Warning Systems
- Window Motors & Regulators
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Data Link Connector Wiring Diagrams
- Data Link Connectors Wiring Diagram (Avenger & SEBRING Coupe)
- Data Link Connectors Wiring Diagram (Breeze, Cirrus & Stratus)
- Data Link Connectors Wiring Diagram (Caravan, Town & Country, & Voyager)
- Data Link Connectors Wiring Diagram (CONCORDE, Intrepid, LHS & 300M)
- Data Link Connectors Wiring Diagram (DAKOTA)
- Data Link Connectors Wiring Diagram (DURANGO)
- Data Link Connectors Wiring Diagram (Neon)
- Data Link Connectors Wiring Diagram (Ram Van & Ram Wagon)
- Data Link Connectors Wiring Diagram (Ram Pickup)
- Ground Distribution - Wiring Diagrams
- Avenger & SEBRING Ground Distribution Wiring Diagram
- Breeze, Cirrus & Stratus Ground Distribution Wiring Diagram
- Caravan, Town & Country, & Voyager Ground Distribution Wiring Diagram
- CONCORDE, Intrepid, LHS & 300M Ground Distribution Wiring Diagram
- DAKOTA Ground Distribution Wiring Diagram
- DURANGO Ground Distribution Wiring Diagram
- Neon Ground Distribution Wiring Diagram
- Ram Pickup Ground Distribution Wiring Diagram
- Ram Van & Ram Wagon Ground Distribution Wiring Diagram
- Power Distribution - Wiring Diagrams
- Avenger & SEBRING Coupe Power Distribution Wiring Diagram
- Breeze, Cirrus & Stratus Power Distribution Wiring Diagram
- Caravan, Town & Country, & Voyager Power Distribution Wiring Diagram
- CONCORDE, Intrepid, LHS & 300M Power Distribution Wiring Diagram
- DAKOTA Power Distribution Wiring Diagram
- DURANGO Power Distribution Wiring Diagram
- Neon Power Distribution Wiring Diagram
- Ram Pickup Power Distribution Wiring Diagram
- Ram Van & Ram Wagon Power Distribution Wiring Diagram
- SEBRING Convertible Power Distribution Wiring Diagram
- Data Link Connector Wiring Diagrams
- Anti-Theft Systems
- Body & Frame
- Body, Cab Control Systems
- Body Control Modules
- Description
- Operation
- Component Locations
- Trouble Shooting
- Self-Diagnostic System
- Connector Identification
- System Tests
- Notes
- Chime System
- Communications
- Notes
- Bus (+) &/Or Bus (-) Open
- Bus (+) & Bus (-) Shorted Together
- Bus Bias Level Too Low Or Too High
- No Bus Bias
- No Response: Air Bag Control Module (ACM)
- No Response: Controller Anti-Lock Brake (CAB) Module
- No Response: Central Timer Module (CTM)
- No Response: Compass Mini Trip Computer (CMTC)
- No Response: Mechanical Instrument Cluster (MIC)
- No Response: Powertrain Control Module (PCM)
- No Response From Radio
- No Termination
- Not Receiving Bus Messages Correctly
- Bus Short To 5 Volts
- Bus Short To Battery
- Bus Short To Ground
- Door Ajar System
- Mechanical Instrument Cluster (Mic)
- Overhead Console
- Power Door Lock & RKE Systems
- Notes
- Door Lock Switch Failure
- Door Unlock Switch Failure
- All Doors Fail To Lock From Any Switch
- All Doors Fail To Lock From One Switch
- All Doors Fail To Lock/Unlock From Any Switch
- All Doors Fail To Unlock From Any Switch
- All Doors Fail To Unlock From One Switch
- Automatic (Rolling) Door Locks Inoperative
- Driver Door Fails To Lock From Any Switch
- Driver Door Fails To Unlock From Any Switch
- Liftgate Fails To Lock/Unlock From Any Switch (Durango)
- One Door Fails To Lock/Unlock From Any Switch
- Remote Keyless Entry (RKE) Problem
- Doors Lock With Key In Ignition & Left Door Open
- Vehicle Theft Security System
- Windshield Wiper System
- Verification Test
- Wiring Diagrams
- Body Control Modules
- Door Locks
- Anti-Theft Systems
- Power Door Lock System & Liftgate Release
- Remote Keyless Entry Systems
- Description
- Operation
- Component Locations
- Programming
- Trouble Shooting
- Notes
- RKE System Or Door Lock Switches Inoperative
- Transmitter Will Not Lock Or Unlock Doors
- Power Locks Don't Work With RKE, But Work With Lock Switches
- Power Locks Work With RKE, But Do Not Work With One Or Both Lock Switches
- One Power Lock Does Not Work With RKE Or Lock Switches
- Anti-Theft Features (If Equipped) Do Not Work
- Component Tests
- System Tests
- Removal & Installation
- Wiring Diagrams
- Power Mirrors
- Seats
- Power Windows
- Body, Cab Control Systems
- Brakes
- Anti-Lock Brakes
- Anti-Lock Brake System - KELSEY-HAYES EBC 2 & EBC 325
- Identification
- Description
- Operation
- Bleeding Brake System
- Diagnosis & Testing
- Connector Identification
- Diagnostic Tests
- Notes
- Test 2A: Right Front Sensor Open (EBC 325)
- Test 3A: No Signal From Right Front Sensor (EBC 325)
- Test 4A: Intermittent Signal From Right Front Sensor (EBC 325)
- Test 5A: Left Front Sensor Open (EBC 325)
- Test 6A: No Signal From Left Front Sensor (EBC 325)
- Test 7A: Intermittent Signal From Left Front Sensor (EBC 325)
- Test 8A: Rear Sensor Open
- Test 9A: No Signal From Rear Sensor
- Test 10A: Intermittent Signal From Rear Sensor
- Test 11A: Wheel Speed Mismatch (EBC 325)
- Test 12A: Internal Cab Fault (EBC 325)
- Test 12B: Rear Isolation Solenoid Open (EBC 2)
- Test 12C: Rear Dump Solenoid Open (EBC 2)
- Test 12D: Rear Isolation Solenoid Shorted (EBC 2)
- Test 12E: Rear Dump Solenoid Shorted (EBC 2)
- Test 13A: Rear Reset Switch Closed (EBC 2)
- Test 14A: Internal Main Relay (Ram Van & Ram Wagon)
- Test 14B: Internal Main Relay (DAKOTA & DURANGO)
- Test 15A: Pump Motor Fault (EBC 325)
- Test 16A: Excessive Dump Time
- Test 17A: System Control Mode Timeout (EBC 325)
- Test 18A: Foundation Brake
- Test 19A: Brake Lamp Switch Circuit
- Test 20A: Number Of Tone Wheel Teeth Out Of Range
- Test 21A: Tire Revolutions Per Mile Out Of Range
- Test 22A: Mismatched VIN
- Test 23A: Abs Warning Light
- Test 24A: 4WD Sense Circuit (DAKOTA & DURANGO)
- Test 25A: No Response From Cab
- Test 26A: Vehicle Speed Signal Output
- Test 27A: Wheel Speed Sensor Harness Visual Inspection
- Test 28A: Replacing The Cab
- Test 29A: Repairing DTC Ram Read/Write, ROM Checksum, Watchdog
- Removal & Installation
- Adjustments
- Torque Specifications
- Wiring Diagrams
- Anti-Lock Brake System - Wiring
- Anti-Lock Brake System - KELSEY-HAYES EBC 2 & EBC 325
- Mechanical - Hydraulic
- Disc Brakes & Drum Brakes
- Description & Operation
- Bleeding Brake System
- Adjustments
- System Tests
- Component Tests
- Service
- Removal & Installation
- Overhaul
- Disc Brake Specifications
- Drum Brake Specifications
- Torque Specifications
- Disc Brakes & Drum Brakes
- Parking Brake System
- Disc Brakes & Drum Brakes
- Description & Operation
- Bleeding Brake System
- Adjustments
- System Tests
- Component Tests
- Service
- Removal & Installation
- Overhaul
- Disc Brake Specifications
- Drum Brake Specifications
- Torque Specifications
- Disc Brakes & Drum Brakes
- Traction Control
- Anti-Lock Brake System - KELSEY-HAYES EBC 2 & EBC 325
- Identification
- Description
- Operation
- Bleeding Brake System
- Diagnosis & Testing
- Connector Identification
- Diagnostic Tests
- Notes
- Test 2A: Right Front Sensor Open (EBC 325)
- Test 3A: No Signal From Right Front Sensor (EBC 325)
- Test 4A: Intermittent Signal From Right Front Sensor (EBC 325)
- Test 5A: Left Front Sensor Open (EBC 325)
- Test 6A: No Signal From Left Front Sensor (EBC 325)
- Test 7A: Intermittent Signal From Left Front Sensor (EBC 325)
- Test 8A: Rear Sensor Open
- Test 9A: No Signal From Rear Sensor
- Test 10A: Intermittent Signal From Rear Sensor
- Test 11A: Wheel Speed Mismatch (EBC 325)
- Test 12A: Internal Cab Fault (EBC 325)
- Test 12B: Rear Isolation Solenoid Open (EBC 2)
- Test 12C: Rear Dump Solenoid Open (EBC 2)
- Test 12D: Rear Isolation Solenoid Shorted (EBC 2)
- Test 12E: Rear Dump Solenoid Shorted (EBC 2)
- Test 13A: Rear Reset Switch Closed (EBC 2)
- Test 14A: Internal Main Relay (Ram Van & Ram Wagon)
- Test 14B: Internal Main Relay (DAKOTA & DURANGO)
- Test 15A: Pump Motor Fault (EBC 325)
- Test 16A: Excessive Dump Time
- Test 17A: System Control Mode Timeout (EBC 325)
- Test 18A: Foundation Brake
- Test 19A: Brake Lamp Switch Circuit
- Test 20A: Number Of Tone Wheel Teeth Out Of Range
- Test 21A: Tire Revolutions Per Mile Out Of Range
- Test 22A: Mismatched VIN
- Test 23A: Abs Warning Light
- Test 24A: 4WD Sense Circuit (DAKOTA & DURANGO)
- Test 25A: No Response From Cab
- Test 26A: Vehicle Speed Signal Output
- Test 27A: Wheel Speed Sensor Harness Visual Inspection
- Test 28A: Replacing The Cab
- Test 29A: Repairing DTC Ram Read/Write, ROM Checksum, Watchdog
- Removal & Installation
- Adjustments
- Torque Specifications
- Wiring Diagrams
- Anti-Lock Brake System - Wiring
- Anti-Lock Brake System - KELSEY-HAYES EBC 2 & EBC 325
- Anti-Lock Brakes
- Drivelines & Axles
- Axle Shafts
- Differentials & Drive Axles
- Rear Axle - 8 1/4" & 9 1/4" Ring Gears
- TRAC-LOK - Locking Differential
- Driveshaft & Universal Joints
- Electrical
- Charging Systems
- Charging System - Generators & Regulators
- Description
- Operation
- Adjustments
- Trouble Shooting
- Self-Diagnostic System
- Self-Diagnostic Tests
- Notes
- DTC Test: Checking System For Diagnostic Trouble Codes
- DTC P0562: Charging System Voltage Too Low (Diesel Only)
- DTC P0563: Charging System Voltage Too High (Diesel Only)
- DTC P0622: Generator Field Not Switching Properly
- DTC P1492: Battery Temp Sensor Voltage Too High
- DTC P1493: Battery Temp Sensor Voltage Too Low
- DTC P1594: Charging System Voltage Too High
- DTC P1682: Charging System Voltage Too Low
- Test Ch-1A: Charging System No Code Test
- Test VER-2A: Road Test Verification
- Test VER-3A: Charging Verification
- Test VER-5A: Road Test Verification
- On-Vehicle Testing
- Component Testing
- Removal & Installation
- Overhaul
- Torque Specifications
- Wiring Diagrams
- Charging System - Generators & Regulators
- Component Locations
- Fuses & Circuit Breakers
- Gauges
- Starter
- Starting System - Except Coupe
- Description
- Trouble Shooting
- On-Vehicle Testing
- Bench Testing
- Overhaul
- Starter Motor
- Starter Specifications
- Torque Specifications
- Wiring Diagrams
- Starting System - Except Coupe
- Wiring Diagrams
- System Wiring Diagrams
- Using lemon2025'S Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Body Control Modules
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Windows
- Radio
- Starting/Charging
- Supplemental Restraints
- Transmission
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- System Wiring Diagrams
- Charging Systems
- Engine Mechanical
- Accessory Drive Belts
- Engine Cooling System Specifications & Drive Belt Routing
- Cooling System Bleeding
- Belt Adjustment
- Drive Belt Routing
- Drive Belt (2.0L & 2.4L Neon & Pt Cruiser)
- Drive Belt (2.0L, 2.4L, 2.5L, 2.7L & 3.0L V6 Breeze, Caravan, Cirrus, SEBRING Convertible, Stratus Sedan - 2000 & Voyager)
- Drive Belt (2.4L SEBRING Coupe & Stratus Coupe)
- Drive Belt (2.4L SEBRING Sedan & Stratus Sedan - 2001)
- Drive Belt (2.5L Avenger, SEBRING Coupe & Stratus Coupe)
- DRIVE BELT (2.5L Dakota With A/C)
- DRIVE BELT (2.5L Dakota Without A/C)
- Drive Belt (2.7L CONCORDE, Intrepid, LHS & 300M)
- Drive Belt (3.0L Caravan & Voyager)
- Drive Belt (3.0L SEBRING Coupe & Stratus Coupe)
- Drive Belt (3.2L & 3.5L CONCORDE, Intrepid, LHS, Prowler & 300M)
- Drive Belt (3.3L & 3.8L Caravan, Town & Country, & Voyager) (2000)
- Drive Belt (3.3L & 3.8L Caravan, Town & Country, & Voyager) (2001)
- Drive Belt (3.9L, 5.2L & 5.9L Gasoline - DAKOTA, DURANGO, Ram Pickup & Ram Van/Wagon)
- Drive Belt (4.7L DAKOTA & DURANGO)
- Drive Belt (5.9L Diesel - Ram Pickup)
- Drive Belt (5.9L & 8.0L Gasoline - Ram Pickup)
- Specifications
- Engine Cooling System Specifications & Drive Belt Routing
- Auxiliary Emission Control Systems
- Emission Control System Visual Inspection Procedures - General Information
- * Please Read This First *
- Emission Control Labels
- Emission Control Visual Inspection
- Notes
- Positive Crankcase Ventilation (PCV)
- Thermostatic Air Cleaner (TAC)
- Fuel Evaporative System (EVAP)
- Catalytic Converters
- Fill Pipe RESTRICTOR (Fr)
- Exhaust Gas RECIRCULATION (EGR) System
- Spark Controls (SPK)
- Air Injection System (AIS)
- Oxygen Sensor (O2)
- Computerized Engine Controls (CEC)
- Early Fuel Evaporation (EFE)
- Emission Maintenance Reminder Light (EMR) (If Equipped)
- Malfunction Indicator Light (Mil)
- Emission Control System Visual Inspection Procedures - General Information
- Cooling Fan
- Electric Cooling Fans - Except Coupe
- Description
- Operation
- Trouble Shooting
- System Tests
- Cooling Fan Motor
- Fan Control Relays & Pcm
- Notes
- Breeze, Cirrus & Stratus Sedan - 2000 (High Speed Fan Control Relay Circuit)
- Breeze, Cirrus & Stratus Sedan - 2000 (Low Speed Fan Control Relay Circuit)
- Caravan, Town & Country, & Voyager - 2000
- Caravan, Town & Country, & Voyager - 2001
- Dakota
- Durango
- Neon - 2000
- Neon - 2001
- PT Cruiser
- Sebring Convertible - 2000 (High Speed Fan Control Relay Circuit)
- Sebring Convertible - 2000 (Low Speed Fan Control Relay Circuit)
- Sebring Convertible, Sebring Sedan & Stratus Sedan - 2001 (High Speed Fan Control Relay Circuit)
- Sebring Convertible, Sebring Sedan & Stratus Sedan - 2001 (Low Speed Fan Control Relay Circuit)
- Wiring Diagrams
- Electric Cooling Fans - Wiring
- Electric Cooling Fans - Except Coupe
- Cooling System (Mechanical)
- Engine Cooling System Specifications & Drive Belt Routing
- Cooling System Bleeding
- Belt Adjustment
- Drive Belt Routing
- Drive Belt (2.0L & 2.4L Neon & Pt Cruiser)
- Drive Belt (2.0L, 2.4L, 2.5L, 2.7L & 3.0L V6 Breeze, Caravan, Cirrus, SEBRING Convertible, Stratus Sedan - 2000 & Voyager)
- Drive Belt (2.4L SEBRING Coupe & Stratus Coupe)
- Drive Belt (2.4L SEBRING Sedan & Stratus Sedan - 2001)
- Drive Belt (2.5L Avenger, SEBRING Coupe & Stratus Coupe)
- DRIVE BELT (2.5L Dakota With A/C)
- DRIVE BELT (2.5L Dakota Without A/C)
- Drive Belt (2.7L CONCORDE, Intrepid, LHS & 300M)
- Drive Belt (3.0L Caravan & Voyager)
- Drive Belt (3.0L SEBRING Coupe & Stratus Coupe)
- Drive Belt (3.2L & 3.5L CONCORDE, Intrepid, LHS, Prowler & 300M)
- Drive Belt (3.3L & 3.8L Caravan, Town & Country, & Voyager) (2000)
- Drive Belt (3.3L & 3.8L Caravan, Town & Country, & Voyager) (2001)
- Drive Belt (3.9L, 5.2L & 5.9L Gasoline - DAKOTA, DURANGO, Ram Pickup & Ram Van/Wagon)
- Drive Belt (4.7L DAKOTA & DURANGO)
- Drive Belt (5.9L Diesel - Ram Pickup)
- Drive Belt (5.9L & 8.0L Gasoline - Ram Pickup)
- Specifications
- Engine Cooling System Specifications & Drive Belt Routing
- Starter
- Starting System - Except Coupe
- Description
- Trouble Shooting
- On-Vehicle Testing
- Bench Testing
- Overhaul
- Starter Motor
- Starter Specifications
- Torque Specifications
- Wiring Diagrams
- Starting System - Except Coupe
- Accessory Drive Belts
- Engine Performance
- Engine Controls - On-Vehicle Adjustments - Trucks
- Application
- Emissions
- Emission Applications
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Mode 6 - CHRYSLER
- Introduction
- 1996
- 1997-1998
- 1999
- 2000
- 2001
- 2002
- 2003-2004
- 2005
- 2006
- 2007
- 2007-09 Diesel Engines
- 2008
- 2008-10 Viper
- 2009-10 Pt Cruiser
- 2009 - All Vehicles With V6 Or V8 Engines
- 2009 Vehicles With The "World I4" 4 Cylinder Engine
- 2010 Vehicles
- 2011 Vehicles
- 2012 Vehicles
- Remove, Overhaul & Install
- Engine Controls - Removal, Overhaul & Installation
- Introduction
- Computerized Engine Controls
- Engine Sensors & Switches
- Battery Temperature Sensor
- Brake Switch
- Camshaft Position Sensor
- Crankshaft Position Sensor
- Downstream Oxygen Sensor
- Engine Coolant Temperature Sensor
- Fuel Level Sensor
- Intake Air Temperature (IAT) Sensor
- Manifold Absolute Pressure (Map) Sensor
- Oil Pressure Sensor
- Output Shaft Speed Sensor
- Park/Neutral Switch
- Power Steering Pressure Switch
- Power Take-Off (PTO) Switch
- Throttle Position (TP) Sensor
- Removal (Dakota 2.5, 3.9L, 4.7L & 5.9L, Durango 3.9L, 4.7L, 5.2L & 5.9L, Ram Pickup 3.9L, 5.2L & 5.9L, Ram Van & Ram Wagon)
- Installation (Dakota 2.5, 3.9L, 4.7L & 5.9L, Durango 3.9L, 4.7L, 5.2L & 5.9L, Ram Pickup 3.9L, 5.2L & 5.9L, Ram Van & Ram Wagon)
- Removal (Ram Pickup 8.0L)
- Installation (Ram Pickup 8.0L)
- Transmission Governor Pressure Sensor
- Transmission Overdrive Switch
- Transmission Speed Sensor
- Transmission Temperature Sensor
- Upstream Oxygen Sensor
- Motors, Relays & Solenoids
- Ignition System
- Camshaft Position Sensor
- Removal & Installation (Dakota 2.5L, 3.9L & 5.9L, Durango 5.2L & 5.9L, Ram Pickup 3.9L, 5.2L & 5.9L, Ram Van & Ram Wagon)
- Removal (Dakota & Durango 4.7L)
- Removal (Ram Pickup 8.0L)
- Installation (NEW Camshaft Position Sensor) (Ram Pickup 8.0L)
- Installation (Original Or Used Camshaft Position Sensor) (Ram Pickup 8.0L)
- Crankshaft Position Sensor
- Distributor
- Ignition Coil
- Camshaft Position Sensor
- Fuel Systems
- Fuel System Pressure Release
- Fuel Line Disconnect Fittings
- Fuel Line At Fuel Rail
- Fuel Filter
- Fuel Filter/Fuel Pressure Regulator
- Fuel Level Sensor
- Fuel Pressure Regulator
- Fuel Pump
- Fuel Pump Inlet Strainer
- Fuel Pump Module
- Fuel Rail & Injectors
- Removal (Dakota 2.5L)
- Installation (Dakota 2.5L)
- Removal (Dakota 3.9L & 5.9L, Durango 5.2L & 5.9L, Ram Pickup 3.9L, 5.2L & 5.9L, Ram Van & Ram Wagon)
- Installation (Dakota 3.9L & 5.9L, Durango 5.2L & 5.9, Ram Pickup 3.9L, 5.2L & 5.9L, Ram Van & Ram Wagon)
- Removal (Dakota & Durango 4.7L)
- Installation (Dakota & Durango 4.7L)
- Removal (Ram Pickup 8.0L)
- Installation (Ram Pickup 8.0L)
- Fuel Tank
- Rollover Valve
- Throttle Body
- Emission Systems
- Torque Specifications
- Engine Controls - Removal, Overhaul & Installation
- Specifications
- Engine Controls - Service & Adjustment Specifications - Trucks
- Introduction
- Capacities
- Quick-Service
- Service Intervals & Specifications
- Replacement Intervals (Caravan, Town & Country, & Voyager)
- Replacement Intervals (DAKOTA)
- Replacement Intervals (DURANGO)
- Replacement Intervals (Ram Pickup - Light-Duty)
- Replacement Intervals (Ram Pickup - Medium-Duty - Gasoline)
- Replacement Intervals (Ram Pickup - Heavy-Duty - Gasoline)
- Replacement Intervals (Ram Pickup - MEDIMUM & Heavy Duty - 5.9L Diesel)
- Replacement Intervals (Ram Van & Ram Wagon)
- Belt Adjustment
- Service Intervals & Specifications
- Mechanical Checks
- Ignition System
- Ignition Coil
- High Tension Wire Resistance
- Spark Plugs
- Firing Order & Timing Marks
- Notes
- Firing Order & Coil Identification 2.4L 4-Cyl. (Caravan & Voyager)
- Firing Order & Distributor Rotation 2.5L 4-Cyl. (Dakota)
- Firing Order & Distributor Rotation 3.0L V6 (Caravan & Voyager)
- Firing Order & Coil Identification 3.3L & 3.8L V6 (Caravan, Town & Country, & Voyager)
- Firing Order & Distributor Rotation 3.9L V6 (Dakota, Durango, Ram Pickup, Ram Van & Ram Wagon)
- Firing Order & Coil Identification 4.7L V8 (Dakota & Durango)
- Firing Order & Distributor Rotation 5.2L & 5.9L Gasoline V8 (Dakota, Durango, Ram Pickup, Ram Van & Ram Wagon)
- Firing Order 5.9L Diesel 6-Cyl. (Ram Pickup)
- Firing Order & Coil Identification 8.0L V10 (Ram Pickup)
- Ignition Timing
- Fuel System
- Firing Order & Cylinder Identification
- Engine Controls - Service & Adjustment Specifications - Trucks
- System
- Engine Controls - Basic Diagnostic Procedures - Trucks & RWD Vans - Gasoline
- Engine Controls - Self Diagnostics
- Introduction
- Self-Diagnostic System
- Powertrain Control Module Location
- Programming
- Summary
- Fuel System Pressure Release
- Diagnostic Trouble Code Definitions
- Connector Identification
- Diagnostic Tests
- Notes
- DTC P0107: Map Sensor Voltage Too Low
- DTC P0108: Map Sensor Voltage Too High
- DTC P0112: Intake Air Temp Sensor Voltage Low
- DTC P0113: Intake Air Temp Sensor Voltage High
- DTC P0117: ECT Sensor Voltage Too Low
- DTC P0118: ECT Sensor Voltage Too High
- DTC P0121: TPS Voltage Does Not Agree With Map
- DTC P0122: Throttle Position Sensor Voltage Low
- DTC P0123: Throttle Position Sensor Voltage High
- DTC P0125: Closed Loop Temp Not Reached
- DTC P0130: 1/1 O2 Sensor Heater Circuit Malfunction
- DTC P0131: 1/1 O2 Sensor Shorted To Ground
- DTC P0132: 1/1 O2 Sensor Shorted To Voltage
- DTC P0133: 1/1 O2 Sensor Slow Response
- DTC P0135: 1/1 O2 Sensor Heater Failure
- DTC P0136: 1/2 O2 Sensor Heater Circuit Malfunction
- DTC P0137 1/2 O2 Sensor Shorted To Ground
- DTC P0138: 1/2 O2 Sensor Shorted To Voltage
- DTC P0139: 1/2 O2 Sensor Slow Response
- DTC P0141: 1/2 O2 Sensor Heater Failure
- DTC P0151: 2/1 O2 Sensor Shorted To Ground
- DTC P0152: 2/1 O2 Sensor Shorted To Voltage
- DTC P0153: 2/1 O2 Sensor Slow Response
- DTC P0155: 2/1 O2 Sensor Heater Failure
- DTC P0157: 2/2 O2 Sensor Shorted To Ground
- DTC P0158: 2/2 O2 Sensor Shorted To Voltage
- DTC P0159: 2/2 O2 Sensor Slow Response
- DTC P0161: 2/2 O2 Sensor Heater Failure
- DTC P0171 & DTC P0174: Fuel System Lean
- DTC P0172 & DTC P0175: Fuel System Rich
- DTC P0201: Injector #1 Control Circuit
- DTC P0202: Injector #2 Control Circuit
- DTC P0203: Injector #3 Control Circuit
- DTC P0204: Injector #4 Control Circuit
- DTC P0205: Injector #5 Control Circuit
- DTC P0206: Injector #6 Control Circuit
- DTC P0207: Injector #7 Control Circuit
- DTC P0208: Injector #8 Control Circuit
- DTC P0300-0308: Multiple Cylinder Misfire
- DTC P0320: No Crank Reference Signal At Pcm
- DTC P0340: No Cam Signal At Pcm
- DTC P0351: Ignition Coil #1 Primary Circuit
- DTC P0352: Ignition Coil #2 Primary Circuit
- DTC P0353: Ignition Coil #3 Primary Circuit
- DTC P0354: Ignition Coil #4 Primary Circuit
- DTC P0355: Ignition Coil #5 Primary Circuit
- DTC P0356: Ignition Coil #6 Primary Circuit
- DTC P0357: Ignition Coil #7 Primary Circuit
- DTC P0358: Ignition Coil #8 Primary Circuit
- DTC P0420: 1/1 Catalytic Converter Efficiency
- DTC P0432: 2/1 Catalytic Converter Efficiency
- DTC P0441: EVAP Purge Flow Monitor
- DTC P0442, P0455 & DTC P0456: EVAP Leak Monitor Medium/Large/Small Leak Detected
- DTC P0443: EVAP Purge Solenoid Circuit
- DTC P0460: Fuel Level Unit No Change Over Miles
- DTC P0461: Fuel Level Unit No Change Over Time
- DTC P0462: Fuel Level Sending Unit Volts Too Low
- DTC P0463: Fuel Level Sending Unit Volts Too High
- DTC P0500: No Vehicle Speed Sensor Signal
- DTC P0505: Idle Air Control Motor Circuits
- DTC P0551: Power Steering Switch Failure
- DTC P0601: Pcm Internal Controller Failure
- DTC P0622: Generator Field Not Switching Properly
- DTC P0645: A/C Clutch Relay Circuit
- DTC P0700: EATX Controller DTC Present
- DTC P1195: 1/1 O2 Sensor Slow During Catalyst Monitor
- DTC P1196: 2/1 O2 Sensor Slow During Catalyst Monitor
- DTC P1197: 1/2 O2 Sensor Slow During Catalyst Monitor
- DTC P1281: Engine Is Cold Too Long
- DTC P1282: Fuel Pump Relay Control Circuit
- DTC P1294: Target Idle Not Reached
- DTC P1296: No 5 Volts To Map Sensor
- DTC P1297: No Change In Map From Start To Run
- DTC P1388: Auto Shutdown Relay Control Circuit
- DTC P1389: No ASD Relay Output Voltage At Pcm
- DTC P1391: Intermittent Loss Of CMP Or CKP
- DTC P1398: Mis-Fire Adaptive Numerator At Limit
- DTC P1486: EVAP Leak Monitor Pinched Hose Found
- DTC P1491: Rad Fan Control Relay Circuit
- DTC P1492: Ambient/Batt Temp Sen Volts Too High
- DTC P1493: Ambient/Batt Temp Sen Volts Too Low
- DTC P1494: Leak Detection Pump SW Or Mechanical Fault
- DTC P1495: Leak Detection Pump Solenoid Circuit
- DTC P1594: Charging System Voltage Too High
- DTC P1595: Speed Control Solenoid Circuits
- DTC P1596: Speed Control Switch Always High
- DTC P1597: Speed Control Switch Always Low
- DTC P1682: Charging System Voltage Too Low
- DTC P1683: SPD CTRL PWR Relay; Or S/C 12V Driver Circuit
- DTC P1687: No Cluster Bus Message
- DTC P1696: Pcm Failure EEPROM Write Denied
- DTC P1698: No Bus Message From Trans Control Module
- Test NTC-1: No Trouble Code Test Menu
- Test NTC-2: No Response From TCM (4.7L Only)
- Test NTC-3: Checking Brake Switch
- Test NTC-4: Checking Engine Mechanical Systems
- Test NTC-5: Checking Engine Vacuum
- Test NTC-6: Checking Evaporative Emission System
- Test NTC-7: Checking Fuel Delivery
- Test NTC-8: Checking Idle Air Control Motor
- Test NTC-9: Checking Manifold Absolute Pressure (Map) Sensor
- Test NTC-10: Checking Engine Coolant Temperature (ECT) Sensor
- Test NTC-11: Checking Intake Air Temperature (IAT) Sensor
- Test NTC-12: Checking Oil Pressure Sensor
- Test NTC-13: Checking Pcm Power & Ground Circuits
- Test NTC-14: Checking Throttle Position (TP) Sensor
- Test NTC-15: Checking A/C System
- Test NTC-16: Checking Charging System
- Test NTC-17: Checking Battery Temperature Sensor
- Test NTC-18: Checking Park/Neutral Switch
- Test NS-SEL: No Start Test Selection
- Test NS-1: Engine Cranks But Will Not Start
- Test NS-2: Engine Will Not Crank
- Test NS-3: Engine Does Not Start & Scan Tool Displays No Response
- Test NS-4: Start & Stall Condition
- Test VER-1: Powertrain Verification
- Test VER-2: Road Test Verification
- Test VER-3: Charging System Verification
- Test VER-4: Speed Control Verification
- Test VER-5: OBD-II Monitor Verification
- Test VER-6: Leak Detection Pump (LDP) Verification
- Test VER-7: Fuel/Misfire Verification
- Test VER-8: Transmission Verification
- Test VER-9: Transmission Verification
- Engine Controls - System & Component Testing - Trucks & RWD Vans - Gasoline
- Introduction
- Computerized Engine Controls
- Engine Sensors & Switches
- Camshaft Position (CMP) Sensor
- Crankshaft Position (CKP) Sensor
- Engine Coolant Temperature (ECT) Sensor
- Heated Oxygen Sensor (Ho2S)
- Intake Air Temperature (IAT) Sensor
- Leak Detection Pump (LDP) Switch
- Manifold Absolute Pressure (Map) Sensor
- Park/Neutral (P/N) Switch
- Power Steering (PS) Switch
- Speed Control Switch
- Throttle Position (TP) Sensor
- Transmission Temperature (Trans Temp) Sensor
- Vehicle Speed Sensor (VSS)
- Relays & Solenoids
- A/C Clutch Relay
- Auto Shutdown (ASD) Relay
- Evaporative (EVAP) Purge Solenoid
- Fuel Pump Relay
- Leak Detection Pump (LDP) Solenoid
- Radiator Fan Control Relay
- Speed Control (SC) Relay
- Speed Control (S/C) Solenoid
- Torque Converter Clutch (TCC) Relay
- Transmission Governor Pressure Solenoid
- Transmission Governor Pressure Solenoid Relay
- Transmission 3-4 Solenoid
- Transmission 12-Volt Supply Relay
- Fuel Systems
- Idle Control Systems
- Ignition Systems
- Emission Systems & Sub-Systems
- Miscellaneous Controls
- Notes
- A/C Clutch Relay
- Park/Neutral (P/N) Switch
- Radiator Fan Control Relay
- Speed Control (SC) Relay
- Speed Control (S/C) Solenoid
- Torque Converter Clutch (TCC) Relay
- Transmission Governor Pressure Solenoid
- Transmission Governor Pressure Solenoid Relay
- Transmission Temperature (Trans Temp) Sensor
- Transmission 3-4 Solenoid
- Transmission 12-Volt Supply Relay
- Engine Controls - Tests W/O Codes - Except Diesel
- O2 Sensor Location & Identification
- Testing & Diagnosis
- Engine Controls - Basic Diagnostic Procedures - Trucks & RWD Vans - Gasoline
- Engine Controls - Self Diagnostics
- Introduction
- Self-Diagnostic System
- Powertrain Control Module Location
- Programming
- Summary
- Fuel System Pressure Release
- Diagnostic Trouble Code Definitions
- Connector Identification
- Diagnostic Tests
- Notes
- DTC P0107: Map Sensor Voltage Too Low
- DTC P0108: Map Sensor Voltage Too High
- DTC P0112: Intake Air Temp Sensor Voltage Low
- DTC P0113: Intake Air Temp Sensor Voltage High
- DTC P0117: ECT Sensor Voltage Too Low
- DTC P0118: ECT Sensor Voltage Too High
- DTC P0121: TPS Voltage Does Not Agree With Map
- DTC P0122: Throttle Position Sensor Voltage Low
- DTC P0123: Throttle Position Sensor Voltage High
- DTC P0125: Closed Loop Temp Not Reached
- DTC P0130: 1/1 O2 Sensor Heater Circuit Malfunction
- DTC P0131: 1/1 O2 Sensor Shorted To Ground
- DTC P0132: 1/1 O2 Sensor Shorted To Voltage
- DTC P0133: 1/1 O2 Sensor Slow Response
- DTC P0135: 1/1 O2 Sensor Heater Failure
- DTC P0136: 1/2 O2 Sensor Heater Circuit Malfunction
- DTC P0137 1/2 O2 Sensor Shorted To Ground
- DTC P0138: 1/2 O2 Sensor Shorted To Voltage
- DTC P0139: 1/2 O2 Sensor Slow Response
- DTC P0141: 1/2 O2 Sensor Heater Failure
- DTC P0151: 2/1 O2 Sensor Shorted To Ground
- DTC P0152: 2/1 O2 Sensor Shorted To Voltage
- DTC P0153: 2/1 O2 Sensor Slow Response
- DTC P0155: 2/1 O2 Sensor Heater Failure
- DTC P0157: 2/2 O2 Sensor Shorted To Ground
- DTC P0158: 2/2 O2 Sensor Shorted To Voltage
- DTC P0159: 2/2 O2 Sensor Slow Response
- DTC P0161: 2/2 O2 Sensor Heater Failure
- DTC P0171 & DTC P0174: Fuel System Lean
- DTC P0172 & DTC P0175: Fuel System Rich
- DTC P0201: Injector #1 Control Circuit
- DTC P0202: Injector #2 Control Circuit
- DTC P0203: Injector #3 Control Circuit
- DTC P0204: Injector #4 Control Circuit
- DTC P0205: Injector #5 Control Circuit
- DTC P0206: Injector #6 Control Circuit
- DTC P0207: Injector #7 Control Circuit
- DTC P0208: Injector #8 Control Circuit
- DTC P0300-0308: Multiple Cylinder Misfire
- DTC P0320: No Crank Reference Signal At Pcm
- DTC P0340: No Cam Signal At Pcm
- DTC P0351: Ignition Coil #1 Primary Circuit
- DTC P0352: Ignition Coil #2 Primary Circuit
- DTC P0353: Ignition Coil #3 Primary Circuit
- DTC P0354: Ignition Coil #4 Primary Circuit
- DTC P0355: Ignition Coil #5 Primary Circuit
- DTC P0356: Ignition Coil #6 Primary Circuit
- DTC P0357: Ignition Coil #7 Primary Circuit
- DTC P0358: Ignition Coil #8 Primary Circuit
- DTC P0420: 1/1 Catalytic Converter Efficiency
- DTC P0432: 2/1 Catalytic Converter Efficiency
- DTC P0441: EVAP Purge Flow Monitor
- DTC P0442, P0455 & DTC P0456: EVAP Leak Monitor Medium/Large/Small Leak Detected
- DTC P0443: EVAP Purge Solenoid Circuit
- DTC P0460: Fuel Level Unit No Change Over Miles
- DTC P0461: Fuel Level Unit No Change Over Time
- DTC P0462: Fuel Level Sending Unit Volts Too Low
- DTC P0463: Fuel Level Sending Unit Volts Too High
- DTC P0500: No Vehicle Speed Sensor Signal
- DTC P0505: Idle Air Control Motor Circuits
- DTC P0551: Power Steering Switch Failure
- DTC P0601: Pcm Internal Controller Failure
- DTC P0622: Generator Field Not Switching Properly
- DTC P0645: A/C Clutch Relay Circuit
- DTC P0700: EATX Controller DTC Present
- DTC P1195: 1/1 O2 Sensor Slow During Catalyst Monitor
- DTC P1196: 2/1 O2 Sensor Slow During Catalyst Monitor
- DTC P1197: 1/2 O2 Sensor Slow During Catalyst Monitor
- DTC P1281: Engine Is Cold Too Long
- DTC P1282: Fuel Pump Relay Control Circuit
- DTC P1294: Target Idle Not Reached
- DTC P1296: No 5 Volts To Map Sensor
- DTC P1297: No Change In Map From Start To Run
- DTC P1388: Auto Shutdown Relay Control Circuit
- DTC P1389: No ASD Relay Output Voltage At Pcm
- DTC P1391: Intermittent Loss Of CMP Or CKP
- DTC P1398: Mis-Fire Adaptive Numerator At Limit
- DTC P1486: EVAP Leak Monitor Pinched Hose Found
- DTC P1491: Rad Fan Control Relay Circuit
- DTC P1492: Ambient/Batt Temp Sen Volts Too High
- DTC P1493: Ambient/Batt Temp Sen Volts Too Low
- DTC P1494: Leak Detection Pump SW Or Mechanical Fault
- DTC P1495: Leak Detection Pump Solenoid Circuit
- DTC P1594: Charging System Voltage Too High
- DTC P1595: Speed Control Solenoid Circuits
- DTC P1596: Speed Control Switch Always High
- DTC P1597: Speed Control Switch Always Low
- DTC P1682: Charging System Voltage Too Low
- DTC P1683: SPD CTRL PWR Relay; Or S/C 12V Driver Circuit
- DTC P1687: No Cluster Bus Message
- DTC P1696: Pcm Failure EEPROM Write Denied
- DTC P1698: No Bus Message From Trans Control Module
- Test NTC-1: No Trouble Code Test Menu
- Test NTC-2: No Response From TCM (4.7L Only)
- Test NTC-3: Checking Brake Switch
- Test NTC-4: Checking Engine Mechanical Systems
- Test NTC-5: Checking Engine Vacuum
- Test NTC-6: Checking Evaporative Emission System
- Test NTC-7: Checking Fuel Delivery
- Test NTC-8: Checking Idle Air Control Motor
- Test NTC-9: Checking Manifold Absolute Pressure (Map) Sensor
- Test NTC-10: Checking Engine Coolant Temperature (ECT) Sensor
- Test NTC-11: Checking Intake Air Temperature (IAT) Sensor
- Test NTC-12: Checking Oil Pressure Sensor
- Test NTC-13: Checking Pcm Power & Ground Circuits
- Test NTC-14: Checking Throttle Position (TP) Sensor
- Test NTC-15: Checking A/C System
- Test NTC-16: Checking Charging System
- Test NTC-17: Checking Battery Temperature Sensor
- Test NTC-18: Checking Park/Neutral Switch
- Test NS-SEL: No Start Test Selection
- Test NS-1: Engine Cranks But Will Not Start
- Test NS-2: Engine Will Not Crank
- Test NS-3: Engine Does Not Start & Scan Tool Displays No Response
- Test NS-4: Start & Stall Condition
- Test VER-1: Powertrain Verification
- Test VER-2: Road Test Verification
- Test VER-3: Charging System Verification
- Test VER-4: Speed Control Verification
- Test VER-5: OBD-II Monitor Verification
- Test VER-6: Leak Detection Pump (LDP) Verification
- Test VER-7: Fuel/Misfire Verification
- Test VER-8: Transmission Verification
- Test VER-9: Transmission Verification
- Engine Controls - System & Component Testing - Trucks & RWD Vans - Gasoline
- Introduction
- Computerized Engine Controls
- Engine Sensors & Switches
- Camshaft Position (CMP) Sensor
- Crankshaft Position (CKP) Sensor
- Engine Coolant Temperature (ECT) Sensor
- Heated Oxygen Sensor (Ho2S)
- Intake Air Temperature (IAT) Sensor
- Leak Detection Pump (LDP) Switch
- Manifold Absolute Pressure (Map) Sensor
- Park/Neutral (P/N) Switch
- Power Steering (PS) Switch
- Speed Control Switch
- Throttle Position (TP) Sensor
- Transmission Temperature (Trans Temp) Sensor
- Vehicle Speed Sensor (VSS)
- Relays & Solenoids
- A/C Clutch Relay
- Auto Shutdown (ASD) Relay
- Evaporative (EVAP) Purge Solenoid
- Fuel Pump Relay
- Leak Detection Pump (LDP) Solenoid
- Radiator Fan Control Relay
- Speed Control (SC) Relay
- Speed Control (S/C) Solenoid
- Torque Converter Clutch (TCC) Relay
- Transmission Governor Pressure Solenoid
- Transmission Governor Pressure Solenoid Relay
- Transmission 3-4 Solenoid
- Transmission 12-Volt Supply Relay
- Fuel Systems
- Idle Control Systems
- Ignition Systems
- Emission Systems & Sub-Systems
- Miscellaneous Controls
- Notes
- A/C Clutch Relay
- Park/Neutral (P/N) Switch
- Radiator Fan Control Relay
- Speed Control (SC) Relay
- Speed Control (S/C) Solenoid
- Torque Converter Clutch (TCC) Relay
- Transmission Governor Pressure Solenoid
- Transmission Governor Pressure Solenoid Relay
- Transmission Temperature (Trans Temp) Sensor
- Transmission 3-4 Solenoid
- Transmission 12-Volt Supply Relay
- Engine Controls - Tests W/O Codes - Except Diesel
- O2 Sensor Location & Identification
- Theory and Operation
- Engine Controls - Theory & Operation
- Introduction
- Computerized Engine Controls
- Powertrain Control Module (Pcm)
- Input Devices
- Notes
- A/C Switch (All Models)
- Battery Temperature Sensor (All Models)
- Battery Voltage (All Models)
- Brake Switch (All Models)
- Camshaft Position (CMP) Sensor (All Models)
- Crankshaft Position (CKP) Sensor (All Models)
- Cruise Control Switch (All Models)
- Engine Coolant Temperature (ECT) Sensor (All Models)
- Fuel Level Sensor (All Models)
- Heated Oxygen Sensor (All Models)
- Ignition Switch (All Models)
- Intake Air Temperature Sensor (All Models)
- Manifold Absolute Pressure Sensor (All Models)
- Oil Pressure Sensor (All Models)
- Output Speed Sensor (All Models)
- Park/Neutral (P/N) Switch (A/T Models)
- Power Steering Pressure (PSP) Switch (2.5L & 4.7L)
- Rear Anti-Lock Brake System Wheel Speed Sensor (All Models)
- Serial Communication Interface (SCI) Receive (All Models)
- Throttle Position Sensor (All Models)
- Transmission Governor Pressure Sensor (A/T Models)
- Transmission Overdrive/Override (OD/OR) Switch (A/T Models)
- Transmission Temperature Sensor (A/T Models)
- Output Signals
- Notes
- A/C Clutch Relay
- Auto Shutdown (ASD) Relay
- Distributorless Ignition System (DIS)
- Evaporative Canister Purge Control Solenoid (EVAP-CPCS)
- Fuel Injectors
- Fuel Pump Relay
- Generator
- Idle Air Control (IAC) Motor
- Ignition Coil
- In-Tank Fuel Pump
- Limp-In Mode
- Malfunction Indicator Light (MIL)
- Radiator Fan Relay
- Serial Communications Interface (SCI) Transmit
- Shift Indicator Light
- Speed Control Servo
- Tachometer
- Torque Converter Clutch (TCC) Solenoid
- Transmission Governor Pressure Solenoid
- Transmission Overdrive/Override (OD/OR) Switch Indicator Light
- Transmission Overdrive (OD) Solenoid
- Fuel System
- Ignition System
- Emission Systems
- Self-Diagnostic System
- Miscellaneous Controls
- Notes
- A/C Clutch Relay
- Auto Shutdown (ASD) Relay & Fuel Pump Relay
- Generator
- Limp-In Mode
- Radiator Fan Relay
- Shift Indicator Light
- Speed Control Servo
- Tachometer
- Torque Converter Clutch (TCC) Solenoid
- Transmission Governor Solenoid
- Transmission Overdrive/Override (Od/Or) Switch Indicator Light
- Transmission Overdrive (Od) Solenoid
- Engine Controls - Theory & Operation
- Vacuum Diagrams - Trucks
- Engine Performance Wiring Diagrams
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- Computer Relearn Procedures
- Introduction
- Relearn Procedures
- Notes
- Control Module (DAKOTA, DURANGO & Ram Pickup)
- Engine Control Module Programming (Diesel)
- Powertrain Control Module Programming
- Electronic Time Alarm Control System Electronic Control Unit (ETACS-Ecu) (Avenger & SEBRING Coupe)
- Pinion Factor Procedure (All Fwd Cars Except Avenger & SEBRING Coupe, & All Fwd Vans)
- Pinion Factor Procedure (Avenger & SEBRING Coupe)
- Programming Pcm & Clearing DTCS From Abs & SRS Modules
- Sentry Key Immobilizer System (Skis) Initialization Procedure
- Transmission Control Module (TCM) Resetting Procedure (Avenger & SEBRING Coupe)
- Transaxle Shift Quality Quick Learn Procedure (Avenger & SEBRING Coupe)
- Transaxle/Transmission Shift Quality Quick Learn Procedure (All Fwd Cars Except Avenger & SEBRING Coupe, All Fwd Vans & DAKOTA 4.7L, DURANGO 4.7L & Grand CHEROKEE 4.7L)
- Vehicle DRIVEABILITY Computer Relearn Procedure
- Vehicle Theft Security System (Caravan, Town & Country, & Voyager)
- OBD-II Drive Cycles
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- DTC Index
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Identification
- Metric Conversions
- OEM General Information
- Diagnostic Trouble Code Definitions - General Information
- How To Use The Engine Performance Section
- Maintenance Reminder Light (Reset Procedures)
- Emissions Maintenance Reminder (EGR)
- Emissions Maintenance Reminder (EMR Mileage)
- Emissions Maintenance Reminder (MAINT REQD Or Check EGR)
- Emissions Maintenance Reminder (Sri)
- Engine Oil Replacement Reminder
- Maintenance Service Reminder (ASSYST Maintenance Computer)
- Maintenance Service Reminder (Perform Service)
- Maintenance Service Reminder (Service Reminder Indicator)
- Maintenance Service Reminder (Service Reminder Message)
- Tire Pressure Monitor System Reminder
- Air Bag Restraints & SRS Components - Inspection & Replacement Tables
- Specifications Index
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Traction Control Disable Procedures
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- General Servicing
- Cabin Air Filter (Special Applications) - General Information
- HVAC System - Compressor Applications & Body Designations
- HVAC System - Compressor Refrigerant Oil Checking
- Refrigerant Oils
- Servicing Precautions
- Checking Compressor Oil
- DELPHI-Thermal (HARRISON) Hd6/Ht6/HU6 & Hd6/Hr-6HE 6-CYL., V5 5-CYL. & V7 7-CYL.
- Ford FS-10 10-Cylinder
- Ford SC90V Variable Scroll
- Ford SC115 Fixed Scroll
- NIPPONDENSO 10-Cylinder
- NIPPONDENSO 10S15/10S17/10S20
- NIPPONDENSO 10PA17/10PA17C 10-CYL.
- SANDEN Scroll
- SANDEN MSC90-C Scroll
- SANDEN SD-7H15 7-Cylinder
- SANDEN TRS-90 & Tr-105 Scroll
- ZEXEL Rotary Vane
- HVAC System - Compressor Servicing
- DELPHI-Thermal (HARRISON) Hd6/Ht6/HU6 & Hd6/Hr-6HE 6-CYL., V5 5-CYL. & V7 7-CYL.
- Ford FS-10 10-Cylinder
- Ford SC90V Scroll
- Ford SC115 Scroll
- NIPPONDENSO 10-Cylinder
- NIPPONDENSO 10S15/10S17/10S20
- NIPPONDENSO 10PA17/10PA17C 10-Cylinder
- SANDEN Scroll
- SANDEN MSC90-C Scroll
- SANDEN SD-7H15 7-Cylinder
- SANDEN TRS-90 Scroll
- SANDEN TRS-105 Scroll
- ZEXEL Rotary Vane
- HVAC System - General Servicing Procedures
- USING R-134a REFRIGERANT
- System Service Valves
- Service Equipment
- Manifold Gauge Set
- Pressure-Temperature Relationship
- Pressure Gauge Readings
- Orifice Tube Replacement
- Refrigerant Recovery/Recycling
- Flushing A/C System
- Evacuating A/C System
- Charging A/C System
- Leak Testing
- HVAC System - Refrigerant Oil & Refrigerant Specifications
- HVAC Control Systems
- Heater System - RWD Trucks & Vans
- Description
- Operation
- Adjustments
- Trouble Shooting
- System Tests
- Component Tests
- Removal & Installation
- Torque Specifications
- Vacuum Hose Diagram(S)
- Wiring Diagrams
- Heater System - Wiring
- HVAC System - Manual - Trouble Shooting
- A/C System Diagnosis
- Rapid Compressor Clutch Cycling
- Compressor Will Not Engage
- Temperature Is Too High With A/C On
- Low Side Pressure Is Low-To-Normal & High Side Pressure Is Low
- Low Side Pressure Is High-To-Normal & High Side Pressure Is High
- Low Side Pressure Is High & High Side Pressure Is Low
- Low Side Pressure Is Low & High Side Pressure Is High
- Blower Motor Diagnosis
- Vacuum Control System Diagnosis
- Trouble Shooting
- A/C System Diagnosis
- Manual A/C-Heater Systems
- Specifications
- Description
- Operation
- Adjustments
- System Tests
- Component Tests
- Removal & Installation
- Notes
- A/C-Heater Assembly
- A/C-Heater Control Panel
- Accumulator/Receiver-DRER
- Blend Air Door Actuator Motor
- Blower Motor
- Blower Motor Resistor
- Compressor
- Condenser
- Evaporator & Heater Core
- Instrument Panel
- Rear A/C Overhead Assembly
- Rear Blower Motor
- Rear Blower Motor Resistor
- Rear Blower Motor Switch
- Temperature Control Cable
- Torque Specifications
- Vacuum Hose Diagram(S)
- Wiring Diagrams
- Manual HVAC Systems - Wiring
- Heater System - RWD Trucks & Vans
- General Servicing
- Maintenance
- Maintenance Reminder Light (Reset Procedures)
- Emissions Maintenance Reminder (EGR)
- Emissions Maintenance Reminder (EMR Mileage)
- Emissions Maintenance Reminder (MAINT REQD Or Check EGR)
- Emissions Maintenance Reminder (Sri)
- Engine Oil Replacement Reminder
- Maintenance Service Reminder (ASSYST Maintenance Computer)
- Maintenance Service Reminder (Perform Service)
- Maintenance Service Reminder (Service Reminder Indicator)
- Maintenance Service Reminder (Service Reminder Message)
- Tire Pressure Monitor System Reminder
- Maintenance Reminder Light (Reset Procedures)
- Restraints
- Air Bag, SRS
- Air Bag Restraint Systems
- Description & Operation
- Component Locations
- Servicing
- System Operation Check
- Air Bag Safety Precautions
- Adjustments
- Disabling & Activating Air Bag System
- Disposal Procedures
- Post-Collision Inspection
- Removal & Installation
- Notes
- Air Bag Control Module (ACM)
- CLOCKSPRING
- Driver-Side Air Bag Module
- Driver-Side Air Bag Trim Cover & Horn Switch
- Instrument Cluster
- Instrument Cluster Bezel
- Instrument Panel Assembly
- Instrument Panel Lower Bezel
- Instrument Panel Top Cover
- Passenger-Side Air Bag Door
- Passenger-Side Air Bag Module
- Passenger Air Bag Disarm (Pad) Switch
- Diagnostics
- Diagnostic Tests
- Test 1A: Identifying System Problems
- Test 1B: Repairing Stored Codes
- Test 1C: Repairing Passenger-Side Air Bag Disable (Pad) Switch
- Test 2A: Cluster Message Mismatch (Active Code)
- Test 3A: Driver Squib Circuit Open (Active Code)
- Test 4A: Driver Squib Circuit Shorted (Active Code)
- Test 5A: Driver Squib Circuit Shorted To Battery (Active Code)
- Test 6A: Driver Squib Circuit Shorted To Ground (Active Code)
- Test 7A: Loss Of Ignition Run Only (Active Code)
- Test 8A: Loss Of Ignition Run/Start (Active Code)
- Test 8B: Loss Of Ignition Run/Start With Pad Switch (Active Code)
- Test 9A: No CCD Communication (Stored Code)
- Test 10A: No Cluster CCD Messages (Active Code)
- Test 11A: Passenger Squib Circuit Open (Active Code)
- Test 11B: Passenger Squib Circuit Open W/ Pad Switch (Active Code)
- Test 12A: Passenger Squib Circuit Shorted (Active Code)
- Test 12B: Passenger Squib Circuit Shorted W/ Pad Switch (Active Code)
- Test 13A: Passenger Squib Circuit Shorted To Battery (Active Code)
- Test 13B: Passenger Squib Circuit Shorted To Battery W/ Pad Switch (Active Code)
- Test 14A: Passenger Squib Circuit Shorted To Ground (Active Code)
- Test 14B: Passenger Squib Circuit Shorted To Ground W/ Pad Switch (Active Code)
- Test 15A: Warning Lamp Open/Short (Active Code)
- Test VER-1A: Air Bag Verification Test
- Test VER-2A: Body Verification Test
- Vehicle Communications
- Torque Specifications
- Wiring Diagrams
- Supplemental Inflatable Restraint System Deactivation Procedures
- Special Care During Mechanical Repairs
- DAIMLERCHRYSLER
- Ford Motor Co.
- System Operation Check
- Service Precautions
- Disabling & Activating Air Bag System
- Notes
- Disabling System (Continental & Town Car)
- Activating System (Continental & Town Car)
- Disabling System (Contour, Mustang, Mystique & Ranger)
- Activating System (Contour, Mustang, Mystique & Ranger)
- Disabling System (Cougar)
- Activating System (Cougar)
- Disabling System (Crown Victoria & Grand Marquis)
- Activating System (Crown Victoria & Grand Marquis)
- Disabling System (Econoline)
- Activating System (Econoline)
- Disabling System (Escort)
- Activating System (Escort)
- Disabling System (Excursion & F250/350 Super Duty)
- Activating System (Excursion & F250/350 Super Duty)
- Disabling System (Expedition & Navigator)
- Activating System (Expedition & Navigator)
- Disabling System (Explorer & Mountaineer)
- Activating System (Explorer & Mountaineer)
- Disabling System (Focus)
- Activating System (Focus)
- Disabling System (F150 & F250 Light Duty)
- Activating System (F150 & F250 Light Duty)
- Disabling System (LS)
- Activating System (LS)
- Disabling System (Sable & Taurus)
- Activating System (Sable & Taurus)
- Disabling System (Villager)
- Activating System (Villager)
- Disabling System (Windstar)
- Activating System (Windstar)
- Air Bag Simulator
- Driver Air Bag Module
- Notes
- Removal & Installation (Continental, Contour, Cougar, Escort, Escort Coupe, Focus, LS, Mustang, Mystique, Ranger & Town Car)
- Removal & Installation (Crown Victoria & Grand Marquis)
- Removal & Installation (Econoline, Excursion, Explorer, F150, F250 Light Duty, F250/350 Super Duty, Expedition, Mountaineer & Navigator)
- Passenger Air Bag Module
- Torque Specifications
- General Motors
- Notes
- System Operation Check
- Service Precautions
- Disabling & Activating Air Bag System
- Notes
- Disabling System (Alero, Grand Am & Malibu)
- Activating System (Alero, Grand Am & Malibu)
- Disabling System (Astro & Safari)
- Activating System (Astro & Safari)
- Disabling System (Bonneville, LeSabre & Park Avenue)
- Activating System (Bonneville, LeSabre & Park Avenue)
- Disabling System (Blazer, Bravada, Envoy, Jimmy, Sonoma & S10)
- Activating System (Blazer, Bravada, Envoy, Jimmy, Sonoma & S10)
- Disabling System ("C" & "K" Pickup, & Escalade)
- Activating System ("C" & "K" Pickup, & Escalade)
- Disabling System (Camaro & Firebird)
- Activating System (Camaro & Firebird)
- Disabling System (Catera)
- Activating System (Catera)
- Disabling System (Cavalier & Sunfire)
- Activating System (Cavalier & Sunfire)
- Disabling System (Century, Grand Prix, Intrigue & Regal)
- Activating System (Century, Grand Prix, Intrigue & Regal)
- Disabling System (Corvette)
- Activating System (Corvette)
- Disabling System (DeVille & Seville)
- Activating System (DeVille & Seville)
- Disabling System (Eldorado)
- Activating System (Eldorado)
- Disabling System (Express, Van & Savana)
- Activating System (Express, Van & Savana)
- Disabling System (Impala & Monte Carlo)
- Activating System (Impala & Monte Carlo)
- Disabling System (Lumina)
- Activating System (Lumina)
- Disabling System (Metro & Firefly (Canadian))
- Activating System (Metro & Firefly (Canadian))
- Disabling System (Montana, Silhouette & Venture)
- Activating System (Montana, Silhouette & Venture)
- Disabling System (Prizm)
- Activating System (Prizm)
- Disabling System (Saturn "L" Series)
- Activating System (Saturn "L" Series)
- Disabling System (Saturn "S" Series)
- Activating System (Saturn "S" Series)
- Disabling System (Sierra, Silverado, Suburban, Tahoe & Yukon)
- Activating System (Sierra, Silverado, Suburban, Tahoe & Yukon)
- Disabling System (Tracker)
- Activating System (Tracker)
- Jeep
- Air Bag Restraint Systems
- Air Bag, SRS
- Steering
- Steering Wheel & Steering Column
- Steering Gear
- Suspension
- Front Suspension - 2WD Coil Spring
- Rear Suspension
- Wheel Alignment Specifications & Adjustment Procedures
- Transmission
- Automatic Trans
- Automatic Transmission (RFE Series Transmissions) (Service Information)
- Overhaul - 42RE & 44RE Automatic Transmission
- Application
- Identification
- Description & Operation
- Lubrication
- On-Vehicle Service
- Trouble Shooting
- Notes
- Symptom Diagnosis
- Notes
- Buzzing Noise
- Delayed Engagement From Neutral To Drive Or Reverse
- Drags Or Locks Up
- Growling, Grating Or Scraping Noise
- Harsh Engagement From Neutral To Drive Or Reverse
- No Drive Range In Any Position (Reverse Is Okay)
- No Kickdown Or Normal Downshift
- No Low Gear (Moves In 2nd & 3rd Gears Only)
- No Reverse
- Shifts Delayed Or Erratic
- Slips In All Forward Gears
- Slips In Low & Drive But Not In 1st Gear
- Slips In Reverse Only
- Harsh 1-2, 2-3, 3-4 Or 3-2 Shifts
- Torque Converter Locks Up In 2nd &/Or 3rd Gear
- Vehicle Moves In Neutral
- Vehicle Moves In 2nd Or 3rd Gear & Abruptly Downshifts To Low
- Vehicle Will Not Move In Any Gear
- Will Not Upshift From Low Gear
- No Start In Park Or Neutral
- 1st & Reverse Gears Only
- Noise Related To Engine Speed
- Overdrive Unit Symptom Diagnosis
- Delayed 3-4 Upshift
- No Reverse Or Slips In Reverse
- No 3-4 Upshift
- No 4-3 Downshift
- No 4-3 Downshift With Overdrive Switch In OFF Position
- Noisy Operation In 4th Gear Only
- Slips In 4th Gear
- 3-4 Upshift Occurs Immediately After Completing 2-3 Upshift
- Clunk Noise From Driveline On Closed Throttle 4-3 Downshift
- Performance Tests
- Road Test
- Hydraulic Pressure Tests
- Notes
- Test Preparation
- Pressure Test With Transmission In "1" (Low Gear)
- Pressure Test With Transmission In "2" (2nd Gear)
- Pressure Test With Transmission In "D" (Drive Gear)
- Pressure Test With Transmission In "R" (Reverse Gear)
- Pressure Test With Transmission In Overdrive (4th Gear)
- Transmission Governor Pressure
- Hydraulic Pressure Test Results
- Hydraulic Pressure Adjustments
- Torque Converter
- Clutch & Servo Air Pressure Test
- Removal & Installation
- Transmission Disassembly
- Transmission Component Disassembly & Reassembly
- Transmission Reassembly
- Overdrive Unit
- Torque Specifications
- Transmission Specifications
- Automatic Transmission Hydraulic Diagrams - 42RE & 44RE & 46RE & 47RE
- Automatic Trans
- External Pages