Manual Transaxle On-Vehicle Service - Evolution

• General Description
  • Notes
  • Sectional View (Vehicles With Helical Gear LSD)
  • Sectional View (Vehicles Without Helical Gear LSD)
• Manual Transaxle Diagnosis
  • Introduction
  • Troubleshooting Strategy
  • Symptom Chart
  • Symptom Procedures
    • INSPECTION PROCEDURE 1: Noise, Vibration
      • Diagnosis
    • INSPECTION PROCEDURE 2: Oil Leaks
      • Diagnosis
    • INSPECTION PROCEDURE 3: Hard Shifting
      • Diagnosis
    • INSPECTION PROCEDURE 4: Jumps Out of Gear
      • Diagnosis
• Special Tools
• On-Vehicle Service
  • Transaxle Oil Level Check
  • Transaxle Oil Replacement
  • Transfer Oil Check
  • Transfer Oil Replacement
• Transaxle Control
  • Removal And Installation
    • Notes
    • Removal Service Point
      • << A >> Gearshift Link Clip/Select Cable Connection (Transaxle Side)/Gear Shift Cable Connection (Transaxle Side) Installation
    • Installation Service Point
      • >> A << Gearshift Cable And Select Cable Assembly/Gearshift Cable Connection (Transaxle Side)/Select Cable Connection (Transaxle Side)/Gearshift Link Clip
      • >> B << Shift Cable Connection (Shift Lever Side) Installation
  • Shift Lever Assembly
    • Disassembly And Assembly
• Transfer Assembly
  • Removal And Installation
    • Notes
    • Removal Service Points
      • << A >> Drive Shaft Nut Removal
      • << B >>Lower Arm Ball Joint/Tie Rod End Disconnection
      • << C >> Drive Shaft < LH >/Drive Shaft < RH > Disconnection
      • << D >> Output Shaft Removal
      • << E >> Transfer Assembly Removal
    • Installation Service Points
      • >> A << Output Shaft Installation
      • >> B << Drive Shaft Nut Installation
• Transaxle Assembly
  • Removal And Installation
    • Notes
    • Removal Service Points
      • << A >> Engine And Transaxle Assembly Supporting/Transaxle Mount Assembly Removal
      • << B >>Engine Assembly Support
      • << C >> Clutch Release Bearing Separation
    • Installation Service Points
      • >> A << Transaxle Mount Stopper Installation
• Specifications
  • Fastener Tightening Specifications
  • Lubricant