Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups
Common Specs & Procedures
DTC Index
Electrical Component Locations
Fluids
Technical Bulletins
Tire Fitment
Wiring Diagrams- Connector End Views
- Connector End Views
- A/C Compressor Clutch - Black 2 Way Connector End View
- A/C Low Pressure Switch - DK. Green 2 Way Connector End View
- A/C Pressure Transducer - Black 4 Way Connector End View
- A/C-Heater Control C1 - Black 10 Way Connector End View
- A/C-Heater Control C2 - Black 16 Way Connector End View
- Adjustable Pedals Motor - White 2 Way Connector End View
- Adjustable Pedals Switch - White 6 Way Connector End View
- Airbag Control Module C1 (Orc) - Yellow 32 Way Connector End View
- Airbag Control Module C2 (Orc) - Yellow 32 Way Connector End View
- Airbag On/Off Switch-Passenger - Yellow 6 Way Connector End View
- Airbag Squib 1-Driver - Yellow/Black 2 Way Connector End View
- Airbag Squib 2-Driver - Yellow/Gray 2 Way Connector End View
- Airbag Squib-Passenger - Yellow 4 Way Connector End View
- Ajar Switch-DECKLID - Black 3 Way Connector End View
- Ajar Switch-Driver Door - Black 4 Way Connector End View
- Ajar Switch-Hood - Natural 3 Way Connector End View
- Ajar Switch-Passenger Door - Black 4 Way Connector End View
- Back-Up Lamp Switch - Brown 2 Way Connector End View
- Back-Up Lamp-Left - Gray 3 Way Connector End View
- Back-Up Lamp-Right - Gray 3 Way Connector End View
- Battery Temperature Sensor - 2 Way Connector End View
- Blend Door Actuator - Gray 2 Way Connector End View
- Blower Motor - Orange 2 Way Connector End View
- Blower Motor Resistor Block - Black 4 Way Connector End View
- Body Control Module C1 - Black 6 Way Connector End View
- Body Control Module C2 - Black/Green 34 Way Connector End View
- Body Control Module C3 - Black/White 34 Way Connector End View
- Body Control Module C4 - Black/Gray 34 Way Connector End View
- Body Control Module C5 - Black/Black 34 Way Connector End View
- Brake Fluid Level Switch - Black 2 Way Connector End View
- Brake Lamp Switch - Black 6 Way Connector End View
- C100 - (Headlamp And Dash Side) Connector End View
- C100 - (Instrument Panel Side) Connector End View
- C101 - (Headlamp And Dash Side) Connector End View
- C101 - (Instrument Panel Side) Connector End View
- C102 - Black (Body Side) Connector End View
- C102 - Black (Headlamp And Dash Side) Connector End View
- C103 - Gray (Body Side) Connector End View
- C103 - Gray (Headlamp And Dash Side) Connector End View
- C104 - Black (Engine Side) Connector End View
- C104 - Black (Headlamp And Dash Side) Connector End View
- C106 - Black (Headlamp And Dash Side) Connector End View
- C106 - Black (Headlamp Jumper Side) Connector End View
- C107 - Black (Headlamp And Dash Side) Connector End View
- C107 - Black (Headlamp Jumper Side) Connector End View
- C200 - Black (Body Side) Connector End View
- C200 - Black (Instrument Panel Side) Connector End View
- C201 - Yellow (Body Side) Connector End View
- C201 - Yellow (Instrument Panel Side) Connector End View
- C202 - White (Instrument Panel Side) Connector End View
- C202 - White (Left Door Side) Connector End View
- C203 - White (Instrument Panel Side) Connector End View
- C203 - White (Right Door Side) Connector End View
- C204 - (HVAC Jumper Side) Connector End View
- C204 - (Instrument Panel Side) Connector End View
- C205 - Black (Instrument Panel Side) Connector End View
- C205 - Black (Mirror Jumper Side) 2 Way Connector End View
- C206 - Red (Console Jumper Side) Connector End View
- C206 - Red (Instrument Panel Side) Connector End View
- C207 - White (Instrument Panel Side) Connector End View
- C207 - White (Right Door Side) Connector End View
- C300 - Black (Body Side) Connector End View
- C300 - Black (Transmission Side) Connector End View
- C301 - Black (Body Side) Connector End View
- C301 - Black (Left Tail Lamp Side) Connector End View
- C302 - Black (Body Side) Connector End View
- C302 - Black (Right Tail Lamp Side) Connector End View
- C303 - Black (Body Side) Connector End View
- C303 - Black (DECKLID Jumper Side) Connector End View
- Camshaft Position Sensor - Gray 3 Way Connector End View
- Center High Mounted Stop Lamp - Gray 2 Way Connector End View
- Cigar Lighter Outlet - Gray 3 Way Connector End View
- CLOCKSPRING - White 8 Way Connector End View
- Clutch Interlock Switch - DK. Green 2 Way Connector End View
- Controller Antilock Brake - Black 24 Way Connector End View
- Crankshaft Position Sensor - Black 3 Way Connector End View
- Cylinder Unlock Switch-Driver - Black 2 Way Connector End View
- Data Link Connector - Black 16 Way Connector End View
- DECKLID Release Motor - Black 2 Way Connector End View
- Door Latch Motor-Driver - 2 Way Connector End View
- Door Latch Motor-Passenger - 2 Way -. Connector End View
- Door Lock Switch-Driver - Black 3 Way Connector End View
- Door Lock Switch-Passenger - Black 3 Way Connector End View
- Engine Coolant Temperature Sensor - Black 2 Way Connector End View
- Engine Oil Pressure Sensor - Black 3 Way Connector End View
- Engine Oil Temperature Sensor - Black 2 Way Connector End View
- EVAP/Purge Solenoid - Black 2 Way Connector End View
- Exterior Door Handle Switch-Driver - Black 2 Way Connector End View
- Exterior Door Handle Switch-Passenger - Black 2 Way Connector End View
- Fog Lamp-Left - Black 2 Way Connector End View
- Fog Lamp-Right - Black 2 Way Connector End View
- FOOTWELL Lamp-Left - Black 2 Way Connector End View
- FOOTWELL Lamp-Right - Black 2 Way Connector End View
- Fuel Injector No. 1 - Black 2 Way Connector End View
- Fuel Injector No. 2 - Black 2 Way Connector End View
- Fuel Injector No. 3 - Black 2 Way Connector End View
- Fuel Injector No. 4 - Black 2 Way Connector End View
- Fuel Injector No. 5 - Black 2 Way Connector End View
- Fuel Injector No. 6 - Black 2 Way Connector End View
- Fuel Injector No. 7 - Black 2 Way Connector End View
- Fuel Injector No. 8 - Black 2 Way Connector End View
- Fuel Injector No. 9 - Black 2 Way Connector End View
- Fuel Injector No. 10 - Black 2 Way Connector End View
- Fuel Tank Module - Gray 4 Way Connector End View
- Gauge Cluster C1 - White 3 Way Connector End View
- Gauge Cluster C2 - Black 20 Way Connector End View
- Generator - Gray 2 Way Connector End View
- Glove Box Lamp - Black 2 Way Connector End View
- Hid Lamp-Left - Gray 2 Way Connector End View
- Hid Lamp-Right - Gray 2 Way Connector End View
- High Beam Headlamp-Left - Black 2 Way Connector End View
- High Beam Headlamp-Right - Black 2 Way Connector End View
- Horn-High Note - Black 2 Way Connector End View
- Horn-Low Note - Black 2 Way Connector End View
- Hydraulic Cooling Module - Black 3 Way Connector End View
- Idle Air Control Motor - Black 4 Way Connector End View
- Ignition Coil Pack-Left - Black 4 Way Connector End View
- Ignition Coil Pack-Right - Black 3 Way Connector End View
- Ignition Switch - Black 5 Way Connector End View
- Illuminated Rearview Mirror - Black 7 Way Connector End View
- Instrument Cluster C1 - Black 16 Way Connector End View
- Instrument Cluster C2 - Black 20 Way Connector End View
- Intake Air Temperature Sensor - Black 2 Way Connector End View
- Interior Door Handle Switch-Driver - Black 2 Way Connector End View
- Interior Door Handle Switch-Passenger - Black 2 Way Connector End View
- Key-In Switch/Halo Lamp - White 2 Way Connector End View
- Leak Detection Pump - Black 4 Way Connector End View
- License Lamp-Left - Natural 2 Way Connector End View
- License Lamp-Right - Natural 2 Way Connector End View
- Manifold Absolute Pressure Sensor - Black 3 Way Connector End View
- Marker Lamp-Left Front - DK. Gray 2 Way Connector End View
- Marker Lamp-Left Rear - LT Gray 2 Way Connector End View
- Marker Lamp-Right Front - DK. Gray 2 Way Connector End View
- Marker Lamp-Right Rear - LT. Gray 2 Way Connector End View
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way Connector End View
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way Connector End View
- Multi-Function Switch - Gray 20 Way Connector End View
- Oxygen Sensor 1/1 Left Bank Up - Black 4 Way Connector End View
- Oxygen Sensor 1/2 Left Bank Down - Black 4 Way Connector End View
- Oxygen Sensor 2/1 Right Bank Up - Black 4 Way Connector End View
- Oxygen Sensor 2/2 Right Bank Down - Black 4 Way Connector End View
- Park/Turn Lamp-Left - Black 3 Way Connector End View
- Park/Turn Lamp-Right - Black 3 Way Connector End View
- Power Amplifier C1 - DK. Gray 14 Way Connector End View
- Power Amplifier C2 - Green 16 Way Connector End View
- Power Mirror Switch - Black 10 Way Connector End View
- Power Mirror-Driver - White 3 Way Connector End View
- Power Mirror-Passenger - White 3 Way Connector End View
- Power Outlet - Black 2 Way Connector End View
- Power Window Motor-Driver - 6 Way Connector End View
- Power Window Motor-Passenger - 6 Way Connector End View
- Power Window Switch-Driver - Gray 3 Way Connector End View
- Power Window Switch-Passenger - Gray 3 Way Connector End View
- Powertrain Control Module C1 - Black/Black 32 Way Connector End View
- Powertrain Control Module C2 - Black/White 32 Way Connector End View
- Powertrain Control Module C3 - Black/Gray 32 Way Connector End View
- Push-Button Starter Switch - Natural 6 Way Connector End View
- Radio - Gray 22 Way Connector End View
- RECIRCULATION Door Actuator - Gray 2 Way Connector End View
- Remote Keyless Entry Module - Black 6 Way Connector End View
- Remote Radio Switch-Left Provision - Black 2 Way Connector End View
- Remote Radio Switch-Right Provision - Black 2 Way Connector End View
- Reverse Lock-Out Solenoid - White 2 Way Connector End View
- Seat Belt Switch-Driver - White 2 Way Connector End View
- Seat Belt Switch-Passenger - White 2 Way Connector End View
- Seat Belt TENSIONER-Driver - Yellow 2 Way Connector End View
- Seat Belt TENSIONER-Passenger - Yellow 2 Way Connector End View
- Shutter Motor-Left - White 2 Way Connector End View
- Shutter Motor-Right - White 2 Way Connector End View
- Skip Shift Solenoid - White 2 Way Connector End View
- Speaker-Left Door - Black 2 Way Connector End View
- Speaker-Left Instrument Panel - White 2 Way Connector End View
- Speaker-Left Rear - White 3 Way Connector End View
- Speaker-Rear Woofer - Gray 4 Way Connector End View
- Speaker-Right Door - Black 2 Way Connector End View
- Speaker-Right Instrument Panel - White 2 Way Connector End View
- Speaker-Right Rear - White 3 Way Connector End View
- Tail Lamp-Left - LT. Gray 2 Way Connector End View
- Tail Lamp-Right - LT. Gray 2 Way Connector End View
- Tail/Stop Lamp-Left - DK. Gray 3 Way Connector End View
- Tail/Stop Lamp-Right - DK. Gray 3 Way Connector End View
- Throttle Position Sensor - Black 3 Way Connector End View
- Tire Pressure Monitor Module - Blue 6 Way Connector End View
- Turn Signal Lamp-Left Rear - Black 3 Way Connector End View
- Turn Signal Lamp-Right Rear - Black 3 Way Connector End View
- VTSS Led - Black 2 Way Connector End View
- Washer Pump Motor - Black 2 Way Connector End View
- Wheel Speed Sensor-Left Front - LT. Gray 2 Way Connector End View
- Wheel Speed Sensor-Left Rear - Gray 2 Way Connector End View
- Wheel Speed Sensor-Right Front - LT. Gray 2 Way Connector End View
- Wheel Speed Sensor-Right Rear - Gray 2 Way Connector End View
- Window Down Relay-Passenger - Black 5 Way Connector End View
- Window Up Relay-Passenger - Black 5 Way Connector End View
- Wiper Control Module - Gray 7 Way Connector End View
- Wiper Motor - Black 6 Way Connector End View
- Connector End Views
- Using lemon2025'S System Wiring Diagrams
- Connector End Views
- Accessories & Equipment
- Anti-Theft Systems
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Body Control Module
- Chime Warning System
- Communication
- Door Ajar System
- Exterior Lighting System
- Relays Controlled By The BCM
- Heating & A/C System
- Instrument Cluster / Gauge Cluster
- Interior Lighting
- Tire Pressure Monitoring System (TPMS)
- Power Door Entry System
- Power Windows
- Electrically Heated Systems
- Vehicle Theft Security System
- Using The DRBIII®
- DRBIII® Error Messages
- DRBIII® Does Not Power Up (Blank Screen)
- Display Is Not Visible
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Air Bag
- Symptom List: ACCELEROMETER 1; ACCELEROMETER 2; INTERNAL 1; OUTPUT DRIVER 1; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: DRIVER SQUIB 2 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 2 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 2 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 2 SHORT TO GROUND
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH OPEN
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO BATTERY
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO GROUND
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO BATTERY
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: PASSENGER SQUIB 2 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 2 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 2 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 2 SHORT TO GROUND
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: All OUTPUTS SHORT
- Symptom List; CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH BCM
- Chime
- Communication
- Symptom: ACM MESSAGES NOT RECEIVED
- Symptom: AUDIO MESSAGES NOT RECEIVED
- Symptom: COUNTRY CODE NOT PROGRAMMED
- Symptom: INTERNAL BCM FAILURE
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom List: PCI BUS SHORTED TO BATTERY; PCI BUS SHORTED TO GROUND
- Symptom: PCI INTERNAL FAULT
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *NO RESPONSE FROM ACM
- Symptom: *NO RESPONSE FROM BODY CONTROL MODULE
- Symptom: *NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE
- Symptom: *NO RESPONSE FROM HVAC
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM PCM (PCI BUS)
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY)
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM TIRE PRESSURE MONITOR MODULE
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Door Ajar
- Symptom: *DECKLID AJAR CIRCUIT OPEN
- Symptom: *DECKLID AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *DRIVER DOOR AJAR CIRCUIT OPEN
- Symptom: *DRIVER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *HOOD AJAR CIRCUIT OPEN
- Symptom: *HOOD AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *PASSENGER DOOR AJAR CIRCUIT OPEN
- Symptom: *PASSENGER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Electrically Heated Systems
- Exterior Lighting
- Symptom: LEFT FOG LAMP OUTPUT OPEN
- Symptom: LEFT FOG LAMP OUTPUT SHORTED
- Symptom: LEFT HIGH BEAM OUTPUT OPEN
- Symptom: LEFT HIGH BEAM OUTPUT SHORT
- Symptom: LOW BEAM RELAY COIL OUTPUT OPEN/SHORT TO GROUND
- Symptom: LOW BEAM RELAY COIL SHORT TO VOLTAGE
- Symptom: PARK LAMP OUTPUT SHORT
- Symptom: RIGHT FOG LAMP OUTPUT OPEN
- Symptom: RIGHT FOG LAMP OUTPUT SHORTED
- Symptom: RIGHT HIGH BEAM OUTPUT OPEN
- Symptom: RIGHT HIGH BEAM OUTPUT SHORT
- Heating & A/C
- Symptom List: A/C SWITCH FAULT (ACTIVE); CHECKSUM FAILURE (ACTIVE); DEFOG SWITCH FAULT (ACTIVE)
- Symptom List: A/C SWITCH FAULT (STORED); BACKLIGHT DIMMING RX FAILURE (STORED); BLEND OVERCURRENT (STORED); CHECKSUM FAILURE (STORED); DEFOG SWITCH FAULT (STORED); LOOPBACK TEST FAILURE (STORED); MODE 1 OVERCURRENT (STORED); MODE 2 OVERCURRENT (STORED); RECIRC OVERCURRENT (STORED); REFRIGERANT PRESS RX FAILURE (STORED); TX FAILURE (STORED); VIN RX FAILURE (STORED)
- Notes
- When Monitored and Set Condition:
- A/C Switch Fault (Stored)
- Backlight Dimming RX Failure (Stored)
- Blend OVERCURRENT (Stored)
- Checksum Failure (Stored)
- Defog Switch Fault (Stored)
- LOOPBACK Test Failure (Stored)
- Mode 1 OVERCURRENT (Stored)
- Mode 2 OVERCURRENT (Stored)
- RECIRC OVERCURRENT (Stored)
- Refrigerant Press RX Failure (Stored)
- TX Failure (Stored)
- VIN RX Failure (Stored)
- Possible Causes
- Diagnostic Procedure
- Symptom List: ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE; BLEND CIRCUIT SHORTED TO GROUND; BLEND CIRCUIT SHORTED TO IGN OR BATT; COMMON DRIVER SHORTED TO GROUND; COMMON DRIVER SHORTED TO IGN OR BATT; MODE 1 CIRCUIT SHORTED TO GROUND; MODE 1 CIRCUIT SHORTED TO IGN OR BATT; MODE 2 CIRCUIT SHORTED TO GROUND; MODE 2 CIRCUIT SHORTED TO IGN OR BATT; RECIRC CIRCUIT SHORTED TO GROUND; RECIRC CIRCUIT SHORTED TO IGN OR BATT; SHORT TOO COMPLEX
- Notes
- When Monitored and Set Condition:
- Act CKT Test Passed, OVERCURRENT DTCS Active
- Blend Circuit Shorted To Ground
- Blend Circuit Shorted To IGN Or Batt
- Common Driver Shorted To Ground
- Common Driver Shorted To IGN Or Batt
- Mode 1 Circuit Shorted To Ground
- Mode 1 Circuit Shorted To IGN Or Batt
- Mode 2 Circuit Shorted To Ground
- Mode 2 Circuit Shorted To IGN Or Batt
- RECIRC Circuit Shorted To Ground
- RECIRC Circuit Shorted To IGN Or Batt
- Short Too Complex
- Possible Causes
- Diagnostic Procedure
- Symptom: BACKLIGHT DIMMING RX FAILURE (ACTIVE)
- Symptom List: BLEND CALIBRATION FAULT; MODE 1 CALIBRATION FAULT; MODE 2 CALIBRATION FAULT; RECIRCULATION CALIBRATION FAULT
- Symptom List: BLEND OVERCURRENT (ACTIVE); MODE 1 OVERCURRENT (ACTIVE); MODE 2 OVERCURRENT (ACTIVE); RECIRC OVERCURRENT (ACTIVE)
- Symptom: DEFOG RELAY CONTROL CKT SHORTED TO BATT
- Symptom: LOOPBACK TEST FAILURE (ACTIVE)
- Symptom List: REFRIGERANT PRESSURE RX FAILURE (ACTIVE); VIN RX FAILURE (ACTIVE)
- Symptom: TX FAILURE (ACTIVE)
- Symptom: *A/C - HEATER CONTROL ILLUMINATION INOPERATIVE
- Symptom: *BLEND/MODE/RECIRC DOOR OPERATION IMPROPER
- Symptom: *BLOWER MOTOR INOPERATIVE
- Symptom: *BLOWER MOTOR SPEEDS INCORRECT
- Symptom: *EBL STATUS INDICATOR FLASHING
- Symptom: *HVAC SYSTEM TEST
- Ignition, Power, Accessory
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT OPEN
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT SHORT TO GROUND
- Symptom: BCM - IGNITION MUX SWITCH INPUT MISMATCH
- Symptom: BCM - IGNITION MUX SWITCH INPUT OPEN
- Symptom: BCM - IGNITION MUX SWITCH INPUT SHORT
- Symptom: BCM - IGNITION RUN 1 SHORT
- Symptom: BCM - IGNITION RUN 2 SHORT
- Symptom: BCM - IOD OUTPUT CIRCUIT SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT OPEN / SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT SHORT TO VOLTAGE
- Symptom: BCM - RUN/START HARDWIRE INPUT MISMATCH
- Symptom: HORN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: HORN RELAY COIL SHORT TO BATTERY
- Symptom: HORN SWITCH STUCK
- Symptom: *HORNS INOPERATIVE
- Instrument Cluster
- Symptom List: ABS LAMP CIRCUIT OPEN; ABS LAMP CIRCUIT SHORTED; AIRBAG LAMP CIRCUIT OPEN; AIRBAG LAMP CIRCUIT SHORTED
- Symptom: ABS MESSAGES NOT RECEIVED
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT OPEN / SHORTED TO VOLTAGE
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT SHORT TO GROUND
- Symptom: BCM - PWM DIMMING OUTPUT SHORT
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: ORC MESSAGES NOT RECEIVED
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *GAUGE CLUSTER DIAGNOSTIC TEST
- Symptom: *INSTRUMENT CLUSTER DIAGNOSTIC TEST
- Interior Lighting
- Power Door Locks/RKE
- Symptom: DECKLID RELEASE OUTPUT OPEN
- Symptom: DECKLID RELEASE OUTPUT SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH OPEN OR SHORT TO VOLTAGE
- Symptom: DRIVER CYLINDER UNLOCK SWITCH SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH STUCK
- Symptom: DRIVER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: DRIVER DOOR LOCK SWITCH STUCK
- Symptom: DRIVER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: DRIVER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: DRIVER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER DOOR LOCK SWITCH STUCK
- Symptom: PASSENGER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER/DRIVER DOOR UNLATCH RETURN SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT OPEN/SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT SHORT TO BATTERY
- Symptom: *ALL DOOR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR UNLATCH INOPERATIVE
- Symptom: *PASSENGER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *PASSENGER DOOR UNLATCH INOPERATIVE
- Symptom: *REMOTE KEYLESS ENTRY PROBLEM
- Power Windows
- Symptom: DRIVER WINDOW DOWN OUTPUT SHORT TO GROUND
- Symptom: DRIVER WINDOW HALL EFFECT FAILURE
- Symptom: DRIVER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: DRIVER WINDOW SWITCH SHORT TO GROUND
- Symptom: DRIVER WINDOW SWITCH STUCK DOWN
- Symptom: DRIVER WINDOW SWITCH STUCK UP
- Symptom: DRIVER WINDOW UP OUTPUT SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL SHORT TO BATTERY
- Symptom: PASSENGER WINDOW HALL EFFECT FAILURE
- Symptom: PASSENGER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: PASSENGER WINDOW SWITCH SHORT TO GROUND
- Symptom: PASSENGER WINDOW SWITCH STUCK DOWN
- Symptom: PASSENGER WINDOW SWITCH STUCK UP
- Symptom: PASSENGER WINDOW UP SHORT TO GROUND
- Symptom: *DRIVER WINDOW INOPERATIVE
- Symptom: *PASSENGER WINDOW INOPERATIVE
- Tire Pressure Monitoring
- Symptom: CRITICAL TIRE PRESSURE - BCM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM; LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM; RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM; RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM
- Symptom: TIRE PRESSURE LOW - BCM
- Symptom: TIRE PRESSURE MONITOR MODULE FAILURE - TPM
- Symptom: TPM DIAGNOSTIC - BCM
- Symptom: TPM MODULE INITIALIZED - BCM
- Symptom: *LO TIRE LCD MESSAGE FLASHING
- Symptom: VTSS INDICATOR OUTPUT OPEN
- Symptom: VTSS INDICATOR OUTPUT SHORT
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *DECKLID DOES NOT TRIP VTSS
- Symptom: *DRIVER DOOR DOES NOT TRIP VTSS
- Symptom: *EXTERIOR LAMPS FAIL TO FLASH WHEN ALARM IS TRIPPED
- Symptom: *HOOD DOES NOT TRIP VTSS
- Symptom: *HORN FAILS TO SOUND WHEN ALARM IS TRIPPED
- Symptom: *PASSENGER DOOR DOES NOT TRIP VTSS
- Symptom: *VTSS LAMP ON STEADY DURING ARMING
- Symptom: *VTSS WILL NOT ARM
- Verification Tests
- Air Bag
- Component Locations
- Connector PINOUTS
- A/C-Heater Control C1 - Black 10 Way
- A/C-Heater Control C2 - Black 16 Way
- Airbag Control Module C1 (Orc) - Yellow 32 Way
- Airbag Control Module C2 (Orc) Yellow 32 Way
- Airbag On/Off Switch-Passenger - Yellow 6 Way
- Airbag Squib 1-Driver - Yellow/Black 2 Way
- Airbag Squib 2-Driver - Yellow/Gray 2 Way
- Airbag Squib-Passenger - Yellow 4 Way
- Ajar Switch-DECKLID - Black 3 Way
- Ajar Switch-Driver Door - Black 4 Way
- Ajar Switch-Hood - Natural 3 Way
- Ajar Switch-Passenger Door - Black 4 Way
- Blend Door Actuator - Gray 2 Way
- Blower Motor - Orange 2 Way
- Blower Motor Resistor Block - Black 4 Way
- Body Control Module C1 - Black 6 Way
- Body Control Module C2 - Black/Green 34 Way
- Body Control Module C3 - Black/White 34 Way
- Body Control Module C4 - Black/Gray 34 Way
- Body Control Module C5 - Black/Black 34 Way
- Brake Fluid Level Switch - Black 2 Way
- C200 - Black (Body Side)
- C200 - Black (Instrument Panel Side)
- C201 - Yellow (Body Side)
- C201 - Yellow (Instrument Panel Side)
- C204 - (HVAC Jumper Side)
- C204 - (Instrument Panel Side)
- C206 - Red (Console Jumper Side)
- C206 - Red (Instrument Panel Side)
- CLOCKSPRING - White 8 Way
- Controller Antilock Brake - Black 24 Way
- Cylinder Unlock Switch-Driver - Black 2 Way
- Data Link Connector - Black 16 Way
- DECKLID Release Motor - Black 2 Way
- Door Latch Motor-Driver - 2 Way
- Door Latch Motor-Passenger - 2 Way
- Door Lock Switch-Driver - Black 3 Way
- Door Lock Switch-Passenger - Black 3 Way
- Exterior Door Handle Switch-Driver - Black 2 Way
- Exterior Door Handle Switch-Passenger Black 2 Way
- Fog Lamp-Left - Black 2 Way
- Gauge Cluster C1 - White 3 Way
- Gauge Cluster C2 - Black 20 Way
- Hid Lamp-Left - Gray 2 Way
- High Beam Headlamp-Left - Black 2 Way
- Horn-High Note - Black 2 Way
- Horn-Low Note - Black 2 Way
- Ignition Switch - Black 5 Way
- Instrument Cluster C1 - Black 16 Way
- Instrument Cluster C12 - Black 20 Way
- Interior Door Handle Switch-Driver - Black 2 Way
- Interior Door Handle Switch-Passenger - Black 2 Way
- Marker Lamp-Left Front - DK.Gray 2 Way
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way
- Multi-Function Switch - Gray 20 Way
- Park/Turn Lamp-Left - Black 3 Way
- Power Amplifier C1 - DK.Gray 14 Way
- Power Amplifier C2 - Green 16 Way
- Fuses (PDC)
- Power Window Motor-Driver - 6 Way
- Power Window Motor-Passenger - 6 Way
- Power Window Switch-Driver - Gray 3 Way
- Power Window Switch-Passenger - Gray 3 Way
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Radio - Gray 22 Way
- RECIRCULATION Door Actuator - Gray 2 Way
- Remote Keyless Entry Module - Black 6 Way
- Seat Belt Switch-Driver - White 2 Way
- Seat Belt Switch-Passenger - White 2 Way
- Seat Belt TENSIONER-Driver - Yellow 2 Way
- Seat Belt TENSIONER-Passenger - Yellow 2 Way
- Speaker-Left Door - Black 2 Way
- Speaker-Left Instrument Panel - White 2 Way
- Speaker-Left Rear - White 3 Way
- Speaker-Rear Woofer - Gray 4 Way
- Speaker-Right Door - Black 2 Way
- Speaker-Right Instrument Panel - White 2 Way
- Speaker-Right Rear - White 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Window Down Relay-Passenger - Black 5 Way
- Window Up Relay-Passenger - Black 5 Way
- Schematic Diagrams
- Airbag System
- Audio System
- Chime System
- Communication
- Door Ajar System
- Electrically Heated Systems
- Exterior Lighting
- Heating & A/C System
- Ignition, Power, Accessory
- Instrument Cluster/Gauge Cluster
- Interior Lighting
- Power Door Locks/RKE
- Power Window System
- Tire Pressure Monitor Module (TPM)
- Vehicle Theft Security System
- Door - Front
- Power Door Locks (Service Information)
- Power Locks
- Door Cylinder Unlock Switch
- Exterior Door Handle Switch
- Interior Door Handle Switch
- Power Lock Switch
- Remote Keyless Entry Module
- Remote Keyless Entry Transmitter
- Diagnosis And Testing - Remote Keyless Entry Transmitter
- Standard Procedure
- Specifications - Remote Keyless Entry Transmitter
- Vehicle Theft Security
- Body Diagnostic Procedures
- Body Interior
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Body Control Module
- Chime Warning System
- Communication
- Door Ajar System
- Exterior Lighting System
- Relays Controlled By The BCM
- Heating & A/C System
- Instrument Cluster / Gauge Cluster
- Interior Lighting
- Tire Pressure Monitoring System (TPMS)
- Power Door Entry System
- Power Windows
- Electrically Heated Systems
- Vehicle Theft Security System
- Using The DRBIII®
- DRBIII® Error Messages
- DRBIII® Does Not Power Up (Blank Screen)
- Display Is Not Visible
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Air Bag
- Symptom List: ACCELEROMETER 1; ACCELEROMETER 2; INTERNAL 1; OUTPUT DRIVER 1; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: DRIVER SQUIB 2 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 2 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 2 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 2 SHORT TO GROUND
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH OPEN
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO BATTERY
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO GROUND
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO BATTERY
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: PASSENGER SQUIB 2 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 2 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 2 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 2 SHORT TO GROUND
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: All OUTPUTS SHORT
- Symptom List; CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH BCM
- Chime
- Communication
- Symptom: ACM MESSAGES NOT RECEIVED
- Symptom: AUDIO MESSAGES NOT RECEIVED
- Symptom: COUNTRY CODE NOT PROGRAMMED
- Symptom: INTERNAL BCM FAILURE
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom List: PCI BUS SHORTED TO BATTERY; PCI BUS SHORTED TO GROUND
- Symptom: PCI INTERNAL FAULT
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *NO RESPONSE FROM ACM
- Symptom: *NO RESPONSE FROM BODY CONTROL MODULE
- Symptom: *NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE
- Symptom: *NO RESPONSE FROM HVAC
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM PCM (PCI BUS)
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY)
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM TIRE PRESSURE MONITOR MODULE
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Door Ajar
- Symptom: *DECKLID AJAR CIRCUIT OPEN
- Symptom: *DECKLID AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *DRIVER DOOR AJAR CIRCUIT OPEN
- Symptom: *DRIVER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *HOOD AJAR CIRCUIT OPEN
- Symptom: *HOOD AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *PASSENGER DOOR AJAR CIRCUIT OPEN
- Symptom: *PASSENGER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Electrically Heated Systems
- Exterior Lighting
- Symptom: LEFT FOG LAMP OUTPUT OPEN
- Symptom: LEFT FOG LAMP OUTPUT SHORTED
- Symptom: LEFT HIGH BEAM OUTPUT OPEN
- Symptom: LEFT HIGH BEAM OUTPUT SHORT
- Symptom: LOW BEAM RELAY COIL OUTPUT OPEN/SHORT TO GROUND
- Symptom: LOW BEAM RELAY COIL SHORT TO VOLTAGE
- Symptom: PARK LAMP OUTPUT SHORT
- Symptom: RIGHT FOG LAMP OUTPUT OPEN
- Symptom: RIGHT FOG LAMP OUTPUT SHORTED
- Symptom: RIGHT HIGH BEAM OUTPUT OPEN
- Symptom: RIGHT HIGH BEAM OUTPUT SHORT
- Heating & A/C
- Symptom List: A/C SWITCH FAULT (ACTIVE); CHECKSUM FAILURE (ACTIVE); DEFOG SWITCH FAULT (ACTIVE)
- Symptom List: A/C SWITCH FAULT (STORED); BACKLIGHT DIMMING RX FAILURE (STORED); BLEND OVERCURRENT (STORED); CHECKSUM FAILURE (STORED); DEFOG SWITCH FAULT (STORED); LOOPBACK TEST FAILURE (STORED); MODE 1 OVERCURRENT (STORED); MODE 2 OVERCURRENT (STORED); RECIRC OVERCURRENT (STORED); REFRIGERANT PRESS RX FAILURE (STORED); TX FAILURE (STORED); VIN RX FAILURE (STORED)
- Notes
- When Monitored and Set Condition:
- A/C Switch Fault (Stored)
- Backlight Dimming RX Failure (Stored)
- Blend OVERCURRENT (Stored)
- Checksum Failure (Stored)
- Defog Switch Fault (Stored)
- LOOPBACK Test Failure (Stored)
- Mode 1 OVERCURRENT (Stored)
- Mode 2 OVERCURRENT (Stored)
- RECIRC OVERCURRENT (Stored)
- Refrigerant Press RX Failure (Stored)
- TX Failure (Stored)
- VIN RX Failure (Stored)
- Possible Causes
- Diagnostic Procedure
- Symptom List: ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE; BLEND CIRCUIT SHORTED TO GROUND; BLEND CIRCUIT SHORTED TO IGN OR BATT; COMMON DRIVER SHORTED TO GROUND; COMMON DRIVER SHORTED TO IGN OR BATT; MODE 1 CIRCUIT SHORTED TO GROUND; MODE 1 CIRCUIT SHORTED TO IGN OR BATT; MODE 2 CIRCUIT SHORTED TO GROUND; MODE 2 CIRCUIT SHORTED TO IGN OR BATT; RECIRC CIRCUIT SHORTED TO GROUND; RECIRC CIRCUIT SHORTED TO IGN OR BATT; SHORT TOO COMPLEX
- Notes
- When Monitored and Set Condition:
- Act CKT Test Passed, OVERCURRENT DTCS Active
- Blend Circuit Shorted To Ground
- Blend Circuit Shorted To IGN Or Batt
- Common Driver Shorted To Ground
- Common Driver Shorted To IGN Or Batt
- Mode 1 Circuit Shorted To Ground
- Mode 1 Circuit Shorted To IGN Or Batt
- Mode 2 Circuit Shorted To Ground
- Mode 2 Circuit Shorted To IGN Or Batt
- RECIRC Circuit Shorted To Ground
- RECIRC Circuit Shorted To IGN Or Batt
- Short Too Complex
- Possible Causes
- Diagnostic Procedure
- Symptom: BACKLIGHT DIMMING RX FAILURE (ACTIVE)
- Symptom List: BLEND CALIBRATION FAULT; MODE 1 CALIBRATION FAULT; MODE 2 CALIBRATION FAULT; RECIRCULATION CALIBRATION FAULT
- Symptom List: BLEND OVERCURRENT (ACTIVE); MODE 1 OVERCURRENT (ACTIVE); MODE 2 OVERCURRENT (ACTIVE); RECIRC OVERCURRENT (ACTIVE)
- Symptom: DEFOG RELAY CONTROL CKT SHORTED TO BATT
- Symptom: LOOPBACK TEST FAILURE (ACTIVE)
- Symptom List: REFRIGERANT PRESSURE RX FAILURE (ACTIVE); VIN RX FAILURE (ACTIVE)
- Symptom: TX FAILURE (ACTIVE)
- Symptom: *A/C - HEATER CONTROL ILLUMINATION INOPERATIVE
- Symptom: *BLEND/MODE/RECIRC DOOR OPERATION IMPROPER
- Symptom: *BLOWER MOTOR INOPERATIVE
- Symptom: *BLOWER MOTOR SPEEDS INCORRECT
- Symptom: *EBL STATUS INDICATOR FLASHING
- Symptom: *HVAC SYSTEM TEST
- Ignition, Power, Accessory
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT OPEN
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT SHORT TO GROUND
- Symptom: BCM - IGNITION MUX SWITCH INPUT MISMATCH
- Symptom: BCM - IGNITION MUX SWITCH INPUT OPEN
- Symptom: BCM - IGNITION MUX SWITCH INPUT SHORT
- Symptom: BCM - IGNITION RUN 1 SHORT
- Symptom: BCM - IGNITION RUN 2 SHORT
- Symptom: BCM - IOD OUTPUT CIRCUIT SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT OPEN / SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT SHORT TO VOLTAGE
- Symptom: BCM - RUN/START HARDWIRE INPUT MISMATCH
- Symptom: HORN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: HORN RELAY COIL SHORT TO BATTERY
- Symptom: HORN SWITCH STUCK
- Symptom: *HORNS INOPERATIVE
- Instrument Cluster
- Symptom List: ABS LAMP CIRCUIT OPEN; ABS LAMP CIRCUIT SHORTED; AIRBAG LAMP CIRCUIT OPEN; AIRBAG LAMP CIRCUIT SHORTED
- Symptom: ABS MESSAGES NOT RECEIVED
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT OPEN / SHORTED TO VOLTAGE
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT SHORT TO GROUND
- Symptom: BCM - PWM DIMMING OUTPUT SHORT
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: ORC MESSAGES NOT RECEIVED
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *GAUGE CLUSTER DIAGNOSTIC TEST
- Symptom: *INSTRUMENT CLUSTER DIAGNOSTIC TEST
- Interior Lighting
- Power Door Locks/RKE
- Symptom: DECKLID RELEASE OUTPUT OPEN
- Symptom: DECKLID RELEASE OUTPUT SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH OPEN OR SHORT TO VOLTAGE
- Symptom: DRIVER CYLINDER UNLOCK SWITCH SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH STUCK
- Symptom: DRIVER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: DRIVER DOOR LOCK SWITCH STUCK
- Symptom: DRIVER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: DRIVER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: DRIVER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER DOOR LOCK SWITCH STUCK
- Symptom: PASSENGER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER/DRIVER DOOR UNLATCH RETURN SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT OPEN/SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT SHORT TO BATTERY
- Symptom: *ALL DOOR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR UNLATCH INOPERATIVE
- Symptom: *PASSENGER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *PASSENGER DOOR UNLATCH INOPERATIVE
- Symptom: *REMOTE KEYLESS ENTRY PROBLEM
- Power Windows
- Symptom: DRIVER WINDOW DOWN OUTPUT SHORT TO GROUND
- Symptom: DRIVER WINDOW HALL EFFECT FAILURE
- Symptom: DRIVER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: DRIVER WINDOW SWITCH SHORT TO GROUND
- Symptom: DRIVER WINDOW SWITCH STUCK DOWN
- Symptom: DRIVER WINDOW SWITCH STUCK UP
- Symptom: DRIVER WINDOW UP OUTPUT SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL SHORT TO BATTERY
- Symptom: PASSENGER WINDOW HALL EFFECT FAILURE
- Symptom: PASSENGER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: PASSENGER WINDOW SWITCH SHORT TO GROUND
- Symptom: PASSENGER WINDOW SWITCH STUCK DOWN
- Symptom: PASSENGER WINDOW SWITCH STUCK UP
- Symptom: PASSENGER WINDOW UP SHORT TO GROUND
- Symptom: *DRIVER WINDOW INOPERATIVE
- Symptom: *PASSENGER WINDOW INOPERATIVE
- Tire Pressure Monitoring
- Symptom: CRITICAL TIRE PRESSURE - BCM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM; LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM; RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM; RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM
- Symptom: TIRE PRESSURE LOW - BCM
- Symptom: TIRE PRESSURE MONITOR MODULE FAILURE - TPM
- Symptom: TPM DIAGNOSTIC - BCM
- Symptom: TPM MODULE INITIALIZED - BCM
- Symptom: *LO TIRE LCD MESSAGE FLASHING
- Symptom: VTSS INDICATOR OUTPUT OPEN
- Symptom: VTSS INDICATOR OUTPUT SHORT
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *DECKLID DOES NOT TRIP VTSS
- Symptom: *DRIVER DOOR DOES NOT TRIP VTSS
- Symptom: *EXTERIOR LAMPS FAIL TO FLASH WHEN ALARM IS TRIPPED
- Symptom: *HOOD DOES NOT TRIP VTSS
- Symptom: *HORN FAILS TO SOUND WHEN ALARM IS TRIPPED
- Symptom: *PASSENGER DOOR DOES NOT TRIP VTSS
- Symptom: *VTSS LAMP ON STEADY DURING ARMING
- Symptom: *VTSS WILL NOT ARM
- Verification Tests
- Air Bag
- Component Locations
- Connector PINOUTS
- A/C-Heater Control C1 - Black 10 Way
- A/C-Heater Control C2 - Black 16 Way
- Airbag Control Module C1 (Orc) - Yellow 32 Way
- Airbag Control Module C2 (Orc) Yellow 32 Way
- Airbag On/Off Switch-Passenger - Yellow 6 Way
- Airbag Squib 1-Driver - Yellow/Black 2 Way
- Airbag Squib 2-Driver - Yellow/Gray 2 Way
- Airbag Squib-Passenger - Yellow 4 Way
- Ajar Switch-DECKLID - Black 3 Way
- Ajar Switch-Driver Door - Black 4 Way
- Ajar Switch-Hood - Natural 3 Way
- Ajar Switch-Passenger Door - Black 4 Way
- Blend Door Actuator - Gray 2 Way
- Blower Motor - Orange 2 Way
- Blower Motor Resistor Block - Black 4 Way
- Body Control Module C1 - Black 6 Way
- Body Control Module C2 - Black/Green 34 Way
- Body Control Module C3 - Black/White 34 Way
- Body Control Module C4 - Black/Gray 34 Way
- Body Control Module C5 - Black/Black 34 Way
- Brake Fluid Level Switch - Black 2 Way
- C200 - Black (Body Side)
- C200 - Black (Instrument Panel Side)
- C201 - Yellow (Body Side)
- C201 - Yellow (Instrument Panel Side)
- C204 - (HVAC Jumper Side)
- C204 - (Instrument Panel Side)
- C206 - Red (Console Jumper Side)
- C206 - Red (Instrument Panel Side)
- CLOCKSPRING - White 8 Way
- Controller Antilock Brake - Black 24 Way
- Cylinder Unlock Switch-Driver - Black 2 Way
- Data Link Connector - Black 16 Way
- DECKLID Release Motor - Black 2 Way
- Door Latch Motor-Driver - 2 Way
- Door Latch Motor-Passenger - 2 Way
- Door Lock Switch-Driver - Black 3 Way
- Door Lock Switch-Passenger - Black 3 Way
- Exterior Door Handle Switch-Driver - Black 2 Way
- Exterior Door Handle Switch-Passenger Black 2 Way
- Fog Lamp-Left - Black 2 Way
- Gauge Cluster C1 - White 3 Way
- Gauge Cluster C2 - Black 20 Way
- Hid Lamp-Left - Gray 2 Way
- High Beam Headlamp-Left - Black 2 Way
- Horn-High Note - Black 2 Way
- Horn-Low Note - Black 2 Way
- Ignition Switch - Black 5 Way
- Instrument Cluster C1 - Black 16 Way
- Instrument Cluster C12 - Black 20 Way
- Interior Door Handle Switch-Driver - Black 2 Way
- Interior Door Handle Switch-Passenger - Black 2 Way
- Marker Lamp-Left Front - DK.Gray 2 Way
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way
- Multi-Function Switch - Gray 20 Way
- Park/Turn Lamp-Left - Black 3 Way
- Power Amplifier C1 - DK.Gray 14 Way
- Power Amplifier C2 - Green 16 Way
- Fuses (PDC)
- Power Window Motor-Driver - 6 Way
- Power Window Motor-Passenger - 6 Way
- Power Window Switch-Driver - Gray 3 Way
- Power Window Switch-Passenger - Gray 3 Way
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Radio - Gray 22 Way
- RECIRCULATION Door Actuator - Gray 2 Way
- Remote Keyless Entry Module - Black 6 Way
- Seat Belt Switch-Driver - White 2 Way
- Seat Belt Switch-Passenger - White 2 Way
- Seat Belt TENSIONER-Driver - Yellow 2 Way
- Seat Belt TENSIONER-Passenger - Yellow 2 Way
- Speaker-Left Door - Black 2 Way
- Speaker-Left Instrument Panel - White 2 Way
- Speaker-Left Rear - White 3 Way
- Speaker-Rear Woofer - Gray 4 Way
- Speaker-Right Door - Black 2 Way
- Speaker-Right Instrument Panel - White 2 Way
- Speaker-Right Rear - White 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Window Down Relay-Passenger - Black 5 Way
- Window Up Relay-Passenger - Black 5 Way
- Schematic Diagrams
- Airbag System
- Audio System
- Chime System
- Communication
- Door Ajar System
- Electrically Heated Systems
- Exterior Lighting
- Heating & A/C System
- Ignition, Power, Accessory
- Instrument Cluster/Gauge Cluster
- Interior Lighting
- Power Door Locks/RKE
- Power Window System
- Tire Pressure Monitor Module (TPM)
- Vehicle Theft Security System
- Electronic Control Modules
- Body Diagnostic Procedures
- Communication Devices
- Electronic Control Modules
- Powertrain Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- General Description
- Function Operation
- Fuel Control
- On-Board Diagnostics
- JTEC Controlled Rear Wheel Drive Vehicles
- Other Controls
- Charging System
- Leak Detection Pump System
- EVAP Leak Detection System Components
- Leak Detection Pump (LDP) Components
- LDP At Rest (Not Powered)
- Diaphragm Upward Movement
- Diaphragm Downward Movement
- Pumping Action
- Enabling Conditions To Run EVAP Leak Detection Test
- Section 1
- Section 2
- Section 3
- Section 4
- Section 5
- Diagnostic Tips
- Test Equipment
- Important
- Non-Monitored Circuits
- Diagnostic Trouble Codes
- Using The DRBIII®
- DRBIII® Error Messages And Blank Screen
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Acronyms
- Diagnostic Information And Procedures
- DTC Index
- Communication - Symptoms
- DRIVEABILITY - Gas - Symptoms
- Symptom: INTERMITTENT CONDITION
- Symptom: *BRAKE SWITCH SENSE STATUS DOES NOT CHANGE ON DRBIII™
- Symptom: *CANNOT SHIFT INTO 2ND AND 3RD GEARS
- Symptom: *CANNOT SHIFT INTO REVERSE
- Symptom: *CHECKING A/C SYSTEM OPERATION WITH NO DTCS
- Symptom: CHECKING CHARGING SYSTEM OPERATION WITH NO DTCS
- Symptom: CHECKING RADIATOR FAN OPERATION
- Symptom: CHECKING THE PCM POWER AND GROUNDS
- DRIVEABILITY - Gas - Diagnostic Tests
- P0031-O2 Sensor 1/1 Heater Circuit Low, P0032-O2 Sensor 1/1 Heater Circuit High, P0051-O2 Sensor 2/1 Heater Circuit Low, P0052-O2 Sensor 2/1 Heater Circuit High
- P0071-Ambient/Battery Temp Sensor Performance
- P0107-Map Sensor Voltage Too Low
- P0108-Map Sensor Voltage Too High
- P0111-Intake Air Temp Performance
- P0112-Intake Air Temp Sensor Voltage Too Low
- P0113-Intake Air Temp Sensor Voltage Too High
- P0117-Engine Coolant Temp Sensor Voltage Too Low
- P0118-Engine Coolant Temp Sensor Voltage Too High
- P0121-TP Sensor Voltage Does Not Agree With Map
- P0122-Throttle Position Sensor #1 Voltage Too Low
- P0123-Throttle Position Sensor #1 Voltage Too High
- P0125-Closed Loop Temp Not Reached
- P0131-O2 Sensor 1/1 Circuit Voltage Too Low, P0137-O2 Sensor 1/2 Circuit Voltage Too Low, P0151-O2 Sensor 2/1 Circuit Voltage Too Low, P0157-O2 Sensor 2/2 Circuit Voltage Too Low
- P0132-O2 Sensor 1/1 Circuit Voltage Too High, P0138-O2 Sensor 1/2 Circuit Voltage Too High, P0152-O2 Sensor 2/1 Circuit Voltage Too High, P0158-O2 Sensor 2/2 Circuit Voltage Too High
- P0133-O2 Sensor 1/1 Slow Response, P0139-O2 Sensor 1/2 Slow Response, P0153-O2 Sensor 2/1 Slow Response, P0159-O2 Sensor 2/2 Slow Response
- P0135-O2 Sensor 1/1 Heater Failure, P0141-O2 Sensor 1/2 Heater Failure, P0155-O2 Sensor 2/1 Heater Failure, P0161-O2 Sensor 2/2 Heater Failure
- P0136-O2 Sensor 1/2 Heater Circuit Malfunction
- P0171-1/1 Fuel System Lean, P0174-2/1 Fuel System Lean
- P0172-1/1 Fuel System Rich, P0175-2/1 Fuel System Rich
- P0197-Engine Oil Temperature Sensor Voltage Too Low
- P0198-Engine Oil Temperature Sensor Voltage Too High
- P0201-Injector #1 Control Circuit, P0202-Injector #2 Control Circuit, P0203-Injector #3 Control Circuit, P0204-Injector #4 Control Circuit, P0205-Injector #5 Control Circuit, P0206-Injector #6 Control Circuit, P0207-Injector #7 Control Circuit, P0208-Injector #8 Control Circuit, P0209-Injector #9 Control Circuit, P0210-Injector #10 Control Circuit
- P0300-Multiple Cylinder Mis-Fire, P0301-Cylinder #1 Misfire, P0302-Cylinder #2 Misfire, P0303-Cylinder #3 Misfire, P0304-Cylinder #4 Misfire, P0305-Cylinder #5 Misfire, P0306-Cylinder #6 Misfire, P0307-Cylinder #7 Misfire, P0308-Cylinder #8 Misfire, P0309-Cylinder #9 Misfire, P0310-Cylinder #10 Misfire
- P0320-No Crank Reference Signal At Pcm
- P0340-No Cam Reference Signal At Pcm
- P0351-Ignition Coil #1 Primary Circuit, P0352-Ignition Coil #2 Primary Circuit, P0353-Ignition Coil #3 Primary Circuit, P0354-Ignition Coil #4 Primary Circuit, P0355-Ignition Coil #5 Primary Circuit
- P0420-1/1 Catalytic Converter Efficiency, P0432-2/1 Catalytic Converter Efficiency
- P0441-EVAP Purge Flow Monitor
- P0442-EVAP Leak Monitor Medium (0.040) Leak Detected, P0445-EVAP Leak Monitor Large Leak Detected
- P0443-EVAP Purge Solenoid Circuit
- P0460-Fuel Level Sending Unit No Change Over Miles
- P0462-Fuel Level Sending Unit Volts Too Low
- P0463-Fuel Level Sending Unit Volts Too High
- P0500-No Vehicle Speed Signal
- P0505-Idle Air Control Motor Circuits
- P0522-Oil Pressure Circuit Low
- P0523-Oil Pressure Circuit High
- P0601-Pcm Internal Controller Failure
- P0622-Generator Field Not Switching Properly
- P0645-A/C Clutch Relay Circuit
- P0801-Reverse Gear Lockout Circuit Open Or Shorted
- P1195-O2 Sensor 1/1 Slow During Catalyst Monitor, P1196-O2 Sensor 2/1 Slow During Catalyst Monitor
- P1281-Engine Is Cold Too Long
- P1282-Fuel Pump/System Relay Control Circuit
- P1294-Target Idle Not Reached
- P1296-No 5-Volts To Map Sensor
- P1297-No Change In Map From Start To Run
- P1388-Auto Shutdown Relay Control Circuit
- P1389-No ASD Relay Output Voltage At Pcm
- P1391-Intermittent Loss Of CMP Or CKP
- P1398-Mis-Fire Adaptive Numerator At Limit
- P1486-EVAP Leak Monitor Pinched Hose Found
- P1492-Ambient/Battery Temperature Sensor Voltage Too High
- P1493-Ambient/Battery Temperature Sensor Voltage Too Low
- P1494-Leak Detection Pump Switch Or Mechanical Fault
- P1495-Leak Detection Pump Solenoid Circuit
- P1499-Hydraulic Fan Solenoid Circuit
- P1594-Charging System Voltage Too High
- P1598-A/C Pressure Sensor Voltage Too High
- P1599-A/C Pressure Sensor Voltage Too Low
- P1682-Charging System Voltage Too Low
- P1687-No Cluster Bus Message
- P1695-Bus Message From Body Control Module
- P1696-Pcm Failure EEPROM Write Denied
- P1719-Skip Shift Solenoid Circuit Open Or Shorted
- Starting - Symptoms
- Verification Tests
- Component Locations
- Control Modules And PDC
- Data Link Connector Location
- Sensors And Solenoids
- Battery Temperature Sensor Location
- Cam Position Sensor Location
- Crank Position Sensor Location
- MAP Sensor, ECT Sensor And Fuel Injector Locations
- IAT Sensor Location
- Engine Oil Pressure And Engine Oil Temperature Sensor Locations
- Oxygen Sensor Locations
- Throttle Position Sensor And IAC Motor Locations
- Ignition Coil Location
- Skip Shift Solenoid, Reverse Lockout Solenoid And Vehicle Speed Sensor Locations
- Fuel System
- Connector End Views
- A/C Compressor Clutch - Black 2 Way
- A/C Compressor Switch - DK. Green 2 Way
- A/C Pressure Transducer - Black 4 Way
- Battery Temperature Sensor - Way
- Brake Lamp Switch - Black 6 Way
- Camshaft Position Sensor - Gray 3 Way
- CLOCKSPRING - White 8 Way
- Clutch Interlock Switch - DK.Green 2 Way
- Crankshaft Position Sensor - Black 3 Way
- Data Link Connector - Black 2 Way
- Engine Coolant Temperature Sensor - Black 2 Way
- Engine Oil Pressure Sensor - Black 3 Way
- Engine Oil Temperature Sensor - Black 2 Way
- EVAP/Purge Solenoid - Black 2 Way
- Fuel Injector No. 1 - Black 2 Way
- Fuel Injector No. 2 - Black 2 Way
- Fuel Injector No. 3 - Black 2 Way
- Fuel Injector No. 4 - Black 2 Way
- Fuel Injector No. 5 - Black 2 Way
- Fuel Injector No. 6 - Black 2 Way
- Fuel Injector No. 7 - Black 2 Way
- Fuel Injector No. 8 - Black 2 Way
- Fuel Injector No. 9 - Black 2 Way
- Fuel Injector No. 10 - Black 2 Way
- Fuel Tank Module - Gray 2 Way
- Generator - Gray 2 Way
- Hydraulic Cooling Module - Black 3 Way
- Idle Air Control Motor-Black 4 Way
- Ignition Coil Pack-Left-Black 4 Way
- Ignition Coil Pack-Right-Black 3 Way
- Ignition Switch-Black 5 Way
- Intake Air Temperature Sensor-Black 2 Way
- Leak Detection Pump-Black 4 Way
- Manifold Absolute Pressure Sensor-Black 3 Way
- Multi-Function Switch-Gray 2 Way
- Oxygen Sensor 1/1 Left Bank Up-Black 4 Way
- Oxygen Sensor 1/2 Left Bank Down-Black 4 Way
- Oxygen Sensor 2/1 Right Bank Up-Black 4 Way
- Oxygen Sensor 2/2 Right Bank Down-Black 4 Way
- Power Distribution Center
- Fuses (PDC)
- A/C Compressor Clutch Relay
- Auto Shut Down Relay
- Fuel Pump Relay
- Oxygen Sensor Heater Relay
- Run/Acc Relay
- Starter Motor Relay
- Powertrain Control Module C1-Black/Black 32 Way
- Powertrain Control Module C2-Black/White 32 Way
- Powertrain Control Module C3-Black/Gray 32 Way
- Push-Button Starter Switch-Natural 6 Way
- Reverse Lock-Out Solenoid-White 2 Way
- Skip Shift Solenoid-White 2 Way
- Throttle Position Sensor-Black 3 Way
- Tire Pressure Monitor Module-Blue 6 Way
- VTSS Led-Black 2 Way
- Schematic Diagrams
- Charts And Graphs
- Entertainment Systems
- Audio System (Service Information)
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Body Control Module
- Chime Warning System
- Communication
- Door Ajar System
- Exterior Lighting System
- Relays Controlled By The BCM
- Heating & A/C System
- Instrument Cluster / Gauge Cluster
- Interior Lighting
- Tire Pressure Monitoring System (TPMS)
- Power Door Entry System
- Power Windows
- Electrically Heated Systems
- Vehicle Theft Security System
- Using The DRBIII®
- DRBIII® Error Messages
- DRBIII® Does Not Power Up (Blank Screen)
- Display Is Not Visible
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Air Bag
- Symptom List: ACCELEROMETER 1; ACCELEROMETER 2; INTERNAL 1; OUTPUT DRIVER 1; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: DRIVER SQUIB 2 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 2 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 2 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 2 SHORT TO GROUND
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH OPEN
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO BATTERY
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO GROUND
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO BATTERY
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: PASSENGER SQUIB 2 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 2 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 2 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 2 SHORT TO GROUND
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: All OUTPUTS SHORT
- Symptom List; CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH BCM
- Chime
- Communication
- Symptom: ACM MESSAGES NOT RECEIVED
- Symptom: AUDIO MESSAGES NOT RECEIVED
- Symptom: COUNTRY CODE NOT PROGRAMMED
- Symptom: INTERNAL BCM FAILURE
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom List: PCI BUS SHORTED TO BATTERY; PCI BUS SHORTED TO GROUND
- Symptom: PCI INTERNAL FAULT
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *NO RESPONSE FROM ACM
- Symptom: *NO RESPONSE FROM BODY CONTROL MODULE
- Symptom: *NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE
- Symptom: *NO RESPONSE FROM HVAC
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM PCM (PCI BUS)
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY)
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM TIRE PRESSURE MONITOR MODULE
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Door Ajar
- Symptom: *DECKLID AJAR CIRCUIT OPEN
- Symptom: *DECKLID AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *DRIVER DOOR AJAR CIRCUIT OPEN
- Symptom: *DRIVER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *HOOD AJAR CIRCUIT OPEN
- Symptom: *HOOD AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *PASSENGER DOOR AJAR CIRCUIT OPEN
- Symptom: *PASSENGER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Electrically Heated Systems
- Exterior Lighting
- Symptom: LEFT FOG LAMP OUTPUT OPEN
- Symptom: LEFT FOG LAMP OUTPUT SHORTED
- Symptom: LEFT HIGH BEAM OUTPUT OPEN
- Symptom: LEFT HIGH BEAM OUTPUT SHORT
- Symptom: LOW BEAM RELAY COIL OUTPUT OPEN/SHORT TO GROUND
- Symptom: LOW BEAM RELAY COIL SHORT TO VOLTAGE
- Symptom: PARK LAMP OUTPUT SHORT
- Symptom: RIGHT FOG LAMP OUTPUT OPEN
- Symptom: RIGHT FOG LAMP OUTPUT SHORTED
- Symptom: RIGHT HIGH BEAM OUTPUT OPEN
- Symptom: RIGHT HIGH BEAM OUTPUT SHORT
- Heating & A/C
- Symptom List: A/C SWITCH FAULT (ACTIVE); CHECKSUM FAILURE (ACTIVE); DEFOG SWITCH FAULT (ACTIVE)
- Symptom List: A/C SWITCH FAULT (STORED); BACKLIGHT DIMMING RX FAILURE (STORED); BLEND OVERCURRENT (STORED); CHECKSUM FAILURE (STORED); DEFOG SWITCH FAULT (STORED); LOOPBACK TEST FAILURE (STORED); MODE 1 OVERCURRENT (STORED); MODE 2 OVERCURRENT (STORED); RECIRC OVERCURRENT (STORED); REFRIGERANT PRESS RX FAILURE (STORED); TX FAILURE (STORED); VIN RX FAILURE (STORED)
- Notes
- When Monitored and Set Condition:
- A/C Switch Fault (Stored)
- Backlight Dimming RX Failure (Stored)
- Blend OVERCURRENT (Stored)
- Checksum Failure (Stored)
- Defog Switch Fault (Stored)
- LOOPBACK Test Failure (Stored)
- Mode 1 OVERCURRENT (Stored)
- Mode 2 OVERCURRENT (Stored)
- RECIRC OVERCURRENT (Stored)
- Refrigerant Press RX Failure (Stored)
- TX Failure (Stored)
- VIN RX Failure (Stored)
- Possible Causes
- Diagnostic Procedure
- Symptom List: ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE; BLEND CIRCUIT SHORTED TO GROUND; BLEND CIRCUIT SHORTED TO IGN OR BATT; COMMON DRIVER SHORTED TO GROUND; COMMON DRIVER SHORTED TO IGN OR BATT; MODE 1 CIRCUIT SHORTED TO GROUND; MODE 1 CIRCUIT SHORTED TO IGN OR BATT; MODE 2 CIRCUIT SHORTED TO GROUND; MODE 2 CIRCUIT SHORTED TO IGN OR BATT; RECIRC CIRCUIT SHORTED TO GROUND; RECIRC CIRCUIT SHORTED TO IGN OR BATT; SHORT TOO COMPLEX
- Notes
- When Monitored and Set Condition:
- Act CKT Test Passed, OVERCURRENT DTCS Active
- Blend Circuit Shorted To Ground
- Blend Circuit Shorted To IGN Or Batt
- Common Driver Shorted To Ground
- Common Driver Shorted To IGN Or Batt
- Mode 1 Circuit Shorted To Ground
- Mode 1 Circuit Shorted To IGN Or Batt
- Mode 2 Circuit Shorted To Ground
- Mode 2 Circuit Shorted To IGN Or Batt
- RECIRC Circuit Shorted To Ground
- RECIRC Circuit Shorted To IGN Or Batt
- Short Too Complex
- Possible Causes
- Diagnostic Procedure
- Symptom: BACKLIGHT DIMMING RX FAILURE (ACTIVE)
- Symptom List: BLEND CALIBRATION FAULT; MODE 1 CALIBRATION FAULT; MODE 2 CALIBRATION FAULT; RECIRCULATION CALIBRATION FAULT
- Symptom List: BLEND OVERCURRENT (ACTIVE); MODE 1 OVERCURRENT (ACTIVE); MODE 2 OVERCURRENT (ACTIVE); RECIRC OVERCURRENT (ACTIVE)
- Symptom: DEFOG RELAY CONTROL CKT SHORTED TO BATT
- Symptom: LOOPBACK TEST FAILURE (ACTIVE)
- Symptom List: REFRIGERANT PRESSURE RX FAILURE (ACTIVE); VIN RX FAILURE (ACTIVE)
- Symptom: TX FAILURE (ACTIVE)
- Symptom: *A/C - HEATER CONTROL ILLUMINATION INOPERATIVE
- Symptom: *BLEND/MODE/RECIRC DOOR OPERATION IMPROPER
- Symptom: *BLOWER MOTOR INOPERATIVE
- Symptom: *BLOWER MOTOR SPEEDS INCORRECT
- Symptom: *EBL STATUS INDICATOR FLASHING
- Symptom: *HVAC SYSTEM TEST
- Ignition, Power, Accessory
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT OPEN
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT SHORT TO GROUND
- Symptom: BCM - IGNITION MUX SWITCH INPUT MISMATCH
- Symptom: BCM - IGNITION MUX SWITCH INPUT OPEN
- Symptom: BCM - IGNITION MUX SWITCH INPUT SHORT
- Symptom: BCM - IGNITION RUN 1 SHORT
- Symptom: BCM - IGNITION RUN 2 SHORT
- Symptom: BCM - IOD OUTPUT CIRCUIT SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT OPEN / SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT SHORT TO VOLTAGE
- Symptom: BCM - RUN/START HARDWIRE INPUT MISMATCH
- Symptom: HORN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: HORN RELAY COIL SHORT TO BATTERY
- Symptom: HORN SWITCH STUCK
- Symptom: *HORNS INOPERATIVE
- Instrument Cluster
- Symptom List: ABS LAMP CIRCUIT OPEN; ABS LAMP CIRCUIT SHORTED; AIRBAG LAMP CIRCUIT OPEN; AIRBAG LAMP CIRCUIT SHORTED
- Symptom: ABS MESSAGES NOT RECEIVED
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT OPEN / SHORTED TO VOLTAGE
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT SHORT TO GROUND
- Symptom: BCM - PWM DIMMING OUTPUT SHORT
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: ORC MESSAGES NOT RECEIVED
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *GAUGE CLUSTER DIAGNOSTIC TEST
- Symptom: *INSTRUMENT CLUSTER DIAGNOSTIC TEST
- Interior Lighting
- Power Door Locks/RKE
- Symptom: DECKLID RELEASE OUTPUT OPEN
- Symptom: DECKLID RELEASE OUTPUT SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH OPEN OR SHORT TO VOLTAGE
- Symptom: DRIVER CYLINDER UNLOCK SWITCH SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH STUCK
- Symptom: DRIVER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: DRIVER DOOR LOCK SWITCH STUCK
- Symptom: DRIVER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: DRIVER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: DRIVER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER DOOR LOCK SWITCH STUCK
- Symptom: PASSENGER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER/DRIVER DOOR UNLATCH RETURN SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT OPEN/SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT SHORT TO BATTERY
- Symptom: *ALL DOOR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR UNLATCH INOPERATIVE
- Symptom: *PASSENGER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *PASSENGER DOOR UNLATCH INOPERATIVE
- Symptom: *REMOTE KEYLESS ENTRY PROBLEM
- Power Windows
- Symptom: DRIVER WINDOW DOWN OUTPUT SHORT TO GROUND
- Symptom: DRIVER WINDOW HALL EFFECT FAILURE
- Symptom: DRIVER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: DRIVER WINDOW SWITCH SHORT TO GROUND
- Symptom: DRIVER WINDOW SWITCH STUCK DOWN
- Symptom: DRIVER WINDOW SWITCH STUCK UP
- Symptom: DRIVER WINDOW UP OUTPUT SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL SHORT TO BATTERY
- Symptom: PASSENGER WINDOW HALL EFFECT FAILURE
- Symptom: PASSENGER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: PASSENGER WINDOW SWITCH SHORT TO GROUND
- Symptom: PASSENGER WINDOW SWITCH STUCK DOWN
- Symptom: PASSENGER WINDOW SWITCH STUCK UP
- Symptom: PASSENGER WINDOW UP SHORT TO GROUND
- Symptom: *DRIVER WINDOW INOPERATIVE
- Symptom: *PASSENGER WINDOW INOPERATIVE
- Tire Pressure Monitoring
- Symptom: CRITICAL TIRE PRESSURE - BCM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM; LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM; RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM; RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM
- Symptom: TIRE PRESSURE LOW - BCM
- Symptom: TIRE PRESSURE MONITOR MODULE FAILURE - TPM
- Symptom: TPM DIAGNOSTIC - BCM
- Symptom: TPM MODULE INITIALIZED - BCM
- Symptom: *LO TIRE LCD MESSAGE FLASHING
- Symptom: VTSS INDICATOR OUTPUT OPEN
- Symptom: VTSS INDICATOR OUTPUT SHORT
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *DECKLID DOES NOT TRIP VTSS
- Symptom: *DRIVER DOOR DOES NOT TRIP VTSS
- Symptom: *EXTERIOR LAMPS FAIL TO FLASH WHEN ALARM IS TRIPPED
- Symptom: *HOOD DOES NOT TRIP VTSS
- Symptom: *HORN FAILS TO SOUND WHEN ALARM IS TRIPPED
- Symptom: *PASSENGER DOOR DOES NOT TRIP VTSS
- Symptom: *VTSS LAMP ON STEADY DURING ARMING
- Symptom: *VTSS WILL NOT ARM
- Verification Tests
- Air Bag
- Component Locations
- Connector PINOUTS
- A/C-Heater Control C1 - Black 10 Way
- A/C-Heater Control C2 - Black 16 Way
- Airbag Control Module C1 (Orc) - Yellow 32 Way
- Airbag Control Module C2 (Orc) Yellow 32 Way
- Airbag On/Off Switch-Passenger - Yellow 6 Way
- Airbag Squib 1-Driver - Yellow/Black 2 Way
- Airbag Squib 2-Driver - Yellow/Gray 2 Way
- Airbag Squib-Passenger - Yellow 4 Way
- Ajar Switch-DECKLID - Black 3 Way
- Ajar Switch-Driver Door - Black 4 Way
- Ajar Switch-Hood - Natural 3 Way
- Ajar Switch-Passenger Door - Black 4 Way
- Blend Door Actuator - Gray 2 Way
- Blower Motor - Orange 2 Way
- Blower Motor Resistor Block - Black 4 Way
- Body Control Module C1 - Black 6 Way
- Body Control Module C2 - Black/Green 34 Way
- Body Control Module C3 - Black/White 34 Way
- Body Control Module C4 - Black/Gray 34 Way
- Body Control Module C5 - Black/Black 34 Way
- Brake Fluid Level Switch - Black 2 Way
- C200 - Black (Body Side)
- C200 - Black (Instrument Panel Side)
- C201 - Yellow (Body Side)
- C201 - Yellow (Instrument Panel Side)
- C204 - (HVAC Jumper Side)
- C204 - (Instrument Panel Side)
- C206 - Red (Console Jumper Side)
- C206 - Red (Instrument Panel Side)
- CLOCKSPRING - White 8 Way
- Controller Antilock Brake - Black 24 Way
- Cylinder Unlock Switch-Driver - Black 2 Way
- Data Link Connector - Black 16 Way
- DECKLID Release Motor - Black 2 Way
- Door Latch Motor-Driver - 2 Way
- Door Latch Motor-Passenger - 2 Way
- Door Lock Switch-Driver - Black 3 Way
- Door Lock Switch-Passenger - Black 3 Way
- Exterior Door Handle Switch-Driver - Black 2 Way
- Exterior Door Handle Switch-Passenger Black 2 Way
- Fog Lamp-Left - Black 2 Way
- Gauge Cluster C1 - White 3 Way
- Gauge Cluster C2 - Black 20 Way
- Hid Lamp-Left - Gray 2 Way
- High Beam Headlamp-Left - Black 2 Way
- Horn-High Note - Black 2 Way
- Horn-Low Note - Black 2 Way
- Ignition Switch - Black 5 Way
- Instrument Cluster C1 - Black 16 Way
- Instrument Cluster C12 - Black 20 Way
- Interior Door Handle Switch-Driver - Black 2 Way
- Interior Door Handle Switch-Passenger - Black 2 Way
- Marker Lamp-Left Front - DK.Gray 2 Way
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way
- Multi-Function Switch - Gray 20 Way
- Park/Turn Lamp-Left - Black 3 Way
- Power Amplifier C1 - DK.Gray 14 Way
- Power Amplifier C2 - Green 16 Way
- Fuses (PDC)
- Power Window Motor-Driver - 6 Way
- Power Window Motor-Passenger - 6 Way
- Power Window Switch-Driver - Gray 3 Way
- Power Window Switch-Passenger - Gray 3 Way
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Radio - Gray 22 Way
- RECIRCULATION Door Actuator - Gray 2 Way
- Remote Keyless Entry Module - Black 6 Way
- Seat Belt Switch-Driver - White 2 Way
- Seat Belt Switch-Passenger - White 2 Way
- Seat Belt TENSIONER-Driver - Yellow 2 Way
- Seat Belt TENSIONER-Passenger - Yellow 2 Way
- Speaker-Left Door - Black 2 Way
- Speaker-Left Instrument Panel - White 2 Way
- Speaker-Left Rear - White 3 Way
- Speaker-Rear Woofer - Gray 4 Way
- Speaker-Right Door - Black 2 Way
- Speaker-Right Instrument Panel - White 2 Way
- Speaker-Right Rear - White 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Window Down Relay-Passenger - Black 5 Way
- Window Up Relay-Passenger - Black 5 Way
- Schematic Diagrams
- Airbag System
- Audio System
- Chime System
- Communication
- Door Ajar System
- Electrically Heated Systems
- Exterior Lighting
- Heating & A/C System
- Ignition, Power, Accessory
- Instrument Cluster/Gauge Cluster
- Interior Lighting
- Power Door Locks/RKE
- Power Window System
- Tire Pressure Monitor Module (TPM)
- Vehicle Theft Security System
- Exterior Lights
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Body Control Module
- Chime Warning System
- Communication
- Door Ajar System
- Exterior Lighting System
- Relays Controlled By The BCM
- Heating & A/C System
- Instrument Cluster / Gauge Cluster
- Interior Lighting
- Tire Pressure Monitoring System (TPMS)
- Power Door Entry System
- Power Windows
- Electrically Heated Systems
- Vehicle Theft Security System
- Using The DRBIII®
- DRBIII® Error Messages
- DRBIII® Does Not Power Up (Blank Screen)
- Display Is Not Visible
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Air Bag
- Symptom List: ACCELEROMETER 1; ACCELEROMETER 2; INTERNAL 1; OUTPUT DRIVER 1; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: DRIVER SQUIB 2 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 2 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 2 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 2 SHORT TO GROUND
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH OPEN
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO BATTERY
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO GROUND
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO BATTERY
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: PASSENGER SQUIB 2 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 2 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 2 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 2 SHORT TO GROUND
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: All OUTPUTS SHORT
- Symptom List; CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH BCM
- Chime
- Communication
- Symptom: ACM MESSAGES NOT RECEIVED
- Symptom: AUDIO MESSAGES NOT RECEIVED
- Symptom: COUNTRY CODE NOT PROGRAMMED
- Symptom: INTERNAL BCM FAILURE
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom List: PCI BUS SHORTED TO BATTERY; PCI BUS SHORTED TO GROUND
- Symptom: PCI INTERNAL FAULT
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *NO RESPONSE FROM ACM
- Symptom: *NO RESPONSE FROM BODY CONTROL MODULE
- Symptom: *NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE
- Symptom: *NO RESPONSE FROM HVAC
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM PCM (PCI BUS)
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY)
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM TIRE PRESSURE MONITOR MODULE
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Door Ajar
- Symptom: *DECKLID AJAR CIRCUIT OPEN
- Symptom: *DECKLID AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *DRIVER DOOR AJAR CIRCUIT OPEN
- Symptom: *DRIVER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *HOOD AJAR CIRCUIT OPEN
- Symptom: *HOOD AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *PASSENGER DOOR AJAR CIRCUIT OPEN
- Symptom: *PASSENGER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Electrically Heated Systems
- Exterior Lighting
- Symptom: LEFT FOG LAMP OUTPUT OPEN
- Symptom: LEFT FOG LAMP OUTPUT SHORTED
- Symptom: LEFT HIGH BEAM OUTPUT OPEN
- Symptom: LEFT HIGH BEAM OUTPUT SHORT
- Symptom: LOW BEAM RELAY COIL OUTPUT OPEN/SHORT TO GROUND
- Symptom: LOW BEAM RELAY COIL SHORT TO VOLTAGE
- Symptom: PARK LAMP OUTPUT SHORT
- Symptom: RIGHT FOG LAMP OUTPUT OPEN
- Symptom: RIGHT FOG LAMP OUTPUT SHORTED
- Symptom: RIGHT HIGH BEAM OUTPUT OPEN
- Symptom: RIGHT HIGH BEAM OUTPUT SHORT
- Heating & A/C
- Symptom List: A/C SWITCH FAULT (ACTIVE); CHECKSUM FAILURE (ACTIVE); DEFOG SWITCH FAULT (ACTIVE)
- Symptom List: A/C SWITCH FAULT (STORED); BACKLIGHT DIMMING RX FAILURE (STORED); BLEND OVERCURRENT (STORED); CHECKSUM FAILURE (STORED); DEFOG SWITCH FAULT (STORED); LOOPBACK TEST FAILURE (STORED); MODE 1 OVERCURRENT (STORED); MODE 2 OVERCURRENT (STORED); RECIRC OVERCURRENT (STORED); REFRIGERANT PRESS RX FAILURE (STORED); TX FAILURE (STORED); VIN RX FAILURE (STORED)
- Notes
- When Monitored and Set Condition:
- A/C Switch Fault (Stored)
- Backlight Dimming RX Failure (Stored)
- Blend OVERCURRENT (Stored)
- Checksum Failure (Stored)
- Defog Switch Fault (Stored)
- LOOPBACK Test Failure (Stored)
- Mode 1 OVERCURRENT (Stored)
- Mode 2 OVERCURRENT (Stored)
- RECIRC OVERCURRENT (Stored)
- Refrigerant Press RX Failure (Stored)
- TX Failure (Stored)
- VIN RX Failure (Stored)
- Possible Causes
- Diagnostic Procedure
- Symptom List: ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE; BLEND CIRCUIT SHORTED TO GROUND; BLEND CIRCUIT SHORTED TO IGN OR BATT; COMMON DRIVER SHORTED TO GROUND; COMMON DRIVER SHORTED TO IGN OR BATT; MODE 1 CIRCUIT SHORTED TO GROUND; MODE 1 CIRCUIT SHORTED TO IGN OR BATT; MODE 2 CIRCUIT SHORTED TO GROUND; MODE 2 CIRCUIT SHORTED TO IGN OR BATT; RECIRC CIRCUIT SHORTED TO GROUND; RECIRC CIRCUIT SHORTED TO IGN OR BATT; SHORT TOO COMPLEX
- Notes
- When Monitored and Set Condition:
- Act CKT Test Passed, OVERCURRENT DTCS Active
- Blend Circuit Shorted To Ground
- Blend Circuit Shorted To IGN Or Batt
- Common Driver Shorted To Ground
- Common Driver Shorted To IGN Or Batt
- Mode 1 Circuit Shorted To Ground
- Mode 1 Circuit Shorted To IGN Or Batt
- Mode 2 Circuit Shorted To Ground
- Mode 2 Circuit Shorted To IGN Or Batt
- RECIRC Circuit Shorted To Ground
- RECIRC Circuit Shorted To IGN Or Batt
- Short Too Complex
- Possible Causes
- Diagnostic Procedure
- Symptom: BACKLIGHT DIMMING RX FAILURE (ACTIVE)
- Symptom List: BLEND CALIBRATION FAULT; MODE 1 CALIBRATION FAULT; MODE 2 CALIBRATION FAULT; RECIRCULATION CALIBRATION FAULT
- Symptom List: BLEND OVERCURRENT (ACTIVE); MODE 1 OVERCURRENT (ACTIVE); MODE 2 OVERCURRENT (ACTIVE); RECIRC OVERCURRENT (ACTIVE)
- Symptom: DEFOG RELAY CONTROL CKT SHORTED TO BATT
- Symptom: LOOPBACK TEST FAILURE (ACTIVE)
- Symptom List: REFRIGERANT PRESSURE RX FAILURE (ACTIVE); VIN RX FAILURE (ACTIVE)
- Symptom: TX FAILURE (ACTIVE)
- Symptom: *A/C - HEATER CONTROL ILLUMINATION INOPERATIVE
- Symptom: *BLEND/MODE/RECIRC DOOR OPERATION IMPROPER
- Symptom: *BLOWER MOTOR INOPERATIVE
- Symptom: *BLOWER MOTOR SPEEDS INCORRECT
- Symptom: *EBL STATUS INDICATOR FLASHING
- Symptom: *HVAC SYSTEM TEST
- Ignition, Power, Accessory
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT OPEN
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT SHORT TO GROUND
- Symptom: BCM - IGNITION MUX SWITCH INPUT MISMATCH
- Symptom: BCM - IGNITION MUX SWITCH INPUT OPEN
- Symptom: BCM - IGNITION MUX SWITCH INPUT SHORT
- Symptom: BCM - IGNITION RUN 1 SHORT
- Symptom: BCM - IGNITION RUN 2 SHORT
- Symptom: BCM - IOD OUTPUT CIRCUIT SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT OPEN / SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT SHORT TO VOLTAGE
- Symptom: BCM - RUN/START HARDWIRE INPUT MISMATCH
- Symptom: HORN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: HORN RELAY COIL SHORT TO BATTERY
- Symptom: HORN SWITCH STUCK
- Symptom: *HORNS INOPERATIVE
- Instrument Cluster
- Symptom List: ABS LAMP CIRCUIT OPEN; ABS LAMP CIRCUIT SHORTED; AIRBAG LAMP CIRCUIT OPEN; AIRBAG LAMP CIRCUIT SHORTED
- Symptom: ABS MESSAGES NOT RECEIVED
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT OPEN / SHORTED TO VOLTAGE
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT SHORT TO GROUND
- Symptom: BCM - PWM DIMMING OUTPUT SHORT
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: ORC MESSAGES NOT RECEIVED
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *GAUGE CLUSTER DIAGNOSTIC TEST
- Symptom: *INSTRUMENT CLUSTER DIAGNOSTIC TEST
- Interior Lighting
- Power Door Locks/RKE
- Symptom: DECKLID RELEASE OUTPUT OPEN
- Symptom: DECKLID RELEASE OUTPUT SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH OPEN OR SHORT TO VOLTAGE
- Symptom: DRIVER CYLINDER UNLOCK SWITCH SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH STUCK
- Symptom: DRIVER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: DRIVER DOOR LOCK SWITCH STUCK
- Symptom: DRIVER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: DRIVER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: DRIVER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER DOOR LOCK SWITCH STUCK
- Symptom: PASSENGER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER/DRIVER DOOR UNLATCH RETURN SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT OPEN/SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT SHORT TO BATTERY
- Symptom: *ALL DOOR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR UNLATCH INOPERATIVE
- Symptom: *PASSENGER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *PASSENGER DOOR UNLATCH INOPERATIVE
- Symptom: *REMOTE KEYLESS ENTRY PROBLEM
- Power Windows
- Symptom: DRIVER WINDOW DOWN OUTPUT SHORT TO GROUND
- Symptom: DRIVER WINDOW HALL EFFECT FAILURE
- Symptom: DRIVER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: DRIVER WINDOW SWITCH SHORT TO GROUND
- Symptom: DRIVER WINDOW SWITCH STUCK DOWN
- Symptom: DRIVER WINDOW SWITCH STUCK UP
- Symptom: DRIVER WINDOW UP OUTPUT SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL SHORT TO BATTERY
- Symptom: PASSENGER WINDOW HALL EFFECT FAILURE
- Symptom: PASSENGER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: PASSENGER WINDOW SWITCH SHORT TO GROUND
- Symptom: PASSENGER WINDOW SWITCH STUCK DOWN
- Symptom: PASSENGER WINDOW SWITCH STUCK UP
- Symptom: PASSENGER WINDOW UP SHORT TO GROUND
- Symptom: *DRIVER WINDOW INOPERATIVE
- Symptom: *PASSENGER WINDOW INOPERATIVE
- Tire Pressure Monitoring
- Symptom: CRITICAL TIRE PRESSURE - BCM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM; LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM; RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM; RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM
- Symptom: TIRE PRESSURE LOW - BCM
- Symptom: TIRE PRESSURE MONITOR MODULE FAILURE - TPM
- Symptom: TPM DIAGNOSTIC - BCM
- Symptom: TPM MODULE INITIALIZED - BCM
- Symptom: *LO TIRE LCD MESSAGE FLASHING
- Symptom: VTSS INDICATOR OUTPUT OPEN
- Symptom: VTSS INDICATOR OUTPUT SHORT
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *DECKLID DOES NOT TRIP VTSS
- Symptom: *DRIVER DOOR DOES NOT TRIP VTSS
- Symptom: *EXTERIOR LAMPS FAIL TO FLASH WHEN ALARM IS TRIPPED
- Symptom: *HOOD DOES NOT TRIP VTSS
- Symptom: *HORN FAILS TO SOUND WHEN ALARM IS TRIPPED
- Symptom: *PASSENGER DOOR DOES NOT TRIP VTSS
- Symptom: *VTSS LAMP ON STEADY DURING ARMING
- Symptom: *VTSS WILL NOT ARM
- Verification Tests
- Air Bag
- Component Locations
- Connector PINOUTS
- A/C-Heater Control C1 - Black 10 Way
- A/C-Heater Control C2 - Black 16 Way
- Airbag Control Module C1 (Orc) - Yellow 32 Way
- Airbag Control Module C2 (Orc) Yellow 32 Way
- Airbag On/Off Switch-Passenger - Yellow 6 Way
- Airbag Squib 1-Driver - Yellow/Black 2 Way
- Airbag Squib 2-Driver - Yellow/Gray 2 Way
- Airbag Squib-Passenger - Yellow 4 Way
- Ajar Switch-DECKLID - Black 3 Way
- Ajar Switch-Driver Door - Black 4 Way
- Ajar Switch-Hood - Natural 3 Way
- Ajar Switch-Passenger Door - Black 4 Way
- Blend Door Actuator - Gray 2 Way
- Blower Motor - Orange 2 Way
- Blower Motor Resistor Block - Black 4 Way
- Body Control Module C1 - Black 6 Way
- Body Control Module C2 - Black/Green 34 Way
- Body Control Module C3 - Black/White 34 Way
- Body Control Module C4 - Black/Gray 34 Way
- Body Control Module C5 - Black/Black 34 Way
- Brake Fluid Level Switch - Black 2 Way
- C200 - Black (Body Side)
- C200 - Black (Instrument Panel Side)
- C201 - Yellow (Body Side)
- C201 - Yellow (Instrument Panel Side)
- C204 - (HVAC Jumper Side)
- C204 - (Instrument Panel Side)
- C206 - Red (Console Jumper Side)
- C206 - Red (Instrument Panel Side)
- CLOCKSPRING - White 8 Way
- Controller Antilock Brake - Black 24 Way
- Cylinder Unlock Switch-Driver - Black 2 Way
- Data Link Connector - Black 16 Way
- DECKLID Release Motor - Black 2 Way
- Door Latch Motor-Driver - 2 Way
- Door Latch Motor-Passenger - 2 Way
- Door Lock Switch-Driver - Black 3 Way
- Door Lock Switch-Passenger - Black 3 Way
- Exterior Door Handle Switch-Driver - Black 2 Way
- Exterior Door Handle Switch-Passenger Black 2 Way
- Fog Lamp-Left - Black 2 Way
- Gauge Cluster C1 - White 3 Way
- Gauge Cluster C2 - Black 20 Way
- Hid Lamp-Left - Gray 2 Way
- High Beam Headlamp-Left - Black 2 Way
- Horn-High Note - Black 2 Way
- Horn-Low Note - Black 2 Way
- Ignition Switch - Black 5 Way
- Instrument Cluster C1 - Black 16 Way
- Instrument Cluster C12 - Black 20 Way
- Interior Door Handle Switch-Driver - Black 2 Way
- Interior Door Handle Switch-Passenger - Black 2 Way
- Marker Lamp-Left Front - DK.Gray 2 Way
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way
- Multi-Function Switch - Gray 20 Way
- Park/Turn Lamp-Left - Black 3 Way
- Power Amplifier C1 - DK.Gray 14 Way
- Power Amplifier C2 - Green 16 Way
- Fuses (PDC)
- Power Window Motor-Driver - 6 Way
- Power Window Motor-Passenger - 6 Way
- Power Window Switch-Driver - Gray 3 Way
- Power Window Switch-Passenger - Gray 3 Way
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Radio - Gray 22 Way
- RECIRCULATION Door Actuator - Gray 2 Way
- Remote Keyless Entry Module - Black 6 Way
- Seat Belt Switch-Driver - White 2 Way
- Seat Belt Switch-Passenger - White 2 Way
- Seat Belt TENSIONER-Driver - Yellow 2 Way
- Seat Belt TENSIONER-Passenger - Yellow 2 Way
- Speaker-Left Door - Black 2 Way
- Speaker-Left Instrument Panel - White 2 Way
- Speaker-Left Rear - White 3 Way
- Speaker-Rear Woofer - Gray 4 Way
- Speaker-Right Door - Black 2 Way
- Speaker-Right Instrument Panel - White 2 Way
- Speaker-Right Rear - White 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Window Down Relay-Passenger - Black 5 Way
- Window Up Relay-Passenger - Black 5 Way
- Schematic Diagrams
- Airbag System
- Audio System
- Chime System
- Communication
- Door Ajar System
- Electrically Heated Systems
- Exterior Lighting
- Heating & A/C System
- Ignition, Power, Accessory
- Instrument Cluster/Gauge Cluster
- Interior Lighting
- Power Door Locks/RKE
- Power Window System
- Tire Pressure Monitor Module (TPM)
- Vehicle Theft Security System
- Electronic Control Modules
- Lamp System & Lighting System - Exterior
- Lamps/Lighting - Exterior
- Backup Lamp
- Back Up Lamp Unit
- Brake Lamp Switch
- Center High Mounted Stop Lamp Unit
- Fog Lamp
- Fog Lamp Unit
- Front Side Marker Lamp
- Headlamp
- Headlamp Unit
- License Plate Lamp
- License Plate Lamp Unit
- Multi-Function Switch
- Rear Side Marker Lamp
- Tail Lamp
- Tail Lamp Unit
- Body Diagnostic Procedures
- Gauges & Instrument Panels
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Body Control Module
- Chime Warning System
- Communication
- Door Ajar System
- Exterior Lighting System
- Relays Controlled By The BCM
- Heating & A/C System
- Instrument Cluster / Gauge Cluster
- Interior Lighting
- Tire Pressure Monitoring System (TPMS)
- Power Door Entry System
- Power Windows
- Electrically Heated Systems
- Vehicle Theft Security System
- Using The DRBIII®
- DRBIII® Error Messages
- DRBIII® Does Not Power Up (Blank Screen)
- Display Is Not Visible
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Air Bag
- Symptom List: ACCELEROMETER 1; ACCELEROMETER 2; INTERNAL 1; OUTPUT DRIVER 1; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: DRIVER SQUIB 2 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 2 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 2 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 2 SHORT TO GROUND
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH OPEN
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO BATTERY
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO GROUND
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO BATTERY
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: PASSENGER SQUIB 2 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 2 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 2 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 2 SHORT TO GROUND
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: All OUTPUTS SHORT
- Symptom List; CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH BCM
- Chime
- Communication
- Symptom: ACM MESSAGES NOT RECEIVED
- Symptom: AUDIO MESSAGES NOT RECEIVED
- Symptom: COUNTRY CODE NOT PROGRAMMED
- Symptom: INTERNAL BCM FAILURE
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom List: PCI BUS SHORTED TO BATTERY; PCI BUS SHORTED TO GROUND
- Symptom: PCI INTERNAL FAULT
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *NO RESPONSE FROM ACM
- Symptom: *NO RESPONSE FROM BODY CONTROL MODULE
- Symptom: *NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE
- Symptom: *NO RESPONSE FROM HVAC
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM PCM (PCI BUS)
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY)
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM TIRE PRESSURE MONITOR MODULE
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Door Ajar
- Symptom: *DECKLID AJAR CIRCUIT OPEN
- Symptom: *DECKLID AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *DRIVER DOOR AJAR CIRCUIT OPEN
- Symptom: *DRIVER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *HOOD AJAR CIRCUIT OPEN
- Symptom: *HOOD AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *PASSENGER DOOR AJAR CIRCUIT OPEN
- Symptom: *PASSENGER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Electrically Heated Systems
- Exterior Lighting
- Symptom: LEFT FOG LAMP OUTPUT OPEN
- Symptom: LEFT FOG LAMP OUTPUT SHORTED
- Symptom: LEFT HIGH BEAM OUTPUT OPEN
- Symptom: LEFT HIGH BEAM OUTPUT SHORT
- Symptom: LOW BEAM RELAY COIL OUTPUT OPEN/SHORT TO GROUND
- Symptom: LOW BEAM RELAY COIL SHORT TO VOLTAGE
- Symptom: PARK LAMP OUTPUT SHORT
- Symptom: RIGHT FOG LAMP OUTPUT OPEN
- Symptom: RIGHT FOG LAMP OUTPUT SHORTED
- Symptom: RIGHT HIGH BEAM OUTPUT OPEN
- Symptom: RIGHT HIGH BEAM OUTPUT SHORT
- Heating & A/C
- Symptom List: A/C SWITCH FAULT (ACTIVE); CHECKSUM FAILURE (ACTIVE); DEFOG SWITCH FAULT (ACTIVE)
- Symptom List: A/C SWITCH FAULT (STORED); BACKLIGHT DIMMING RX FAILURE (STORED); BLEND OVERCURRENT (STORED); CHECKSUM FAILURE (STORED); DEFOG SWITCH FAULT (STORED); LOOPBACK TEST FAILURE (STORED); MODE 1 OVERCURRENT (STORED); MODE 2 OVERCURRENT (STORED); RECIRC OVERCURRENT (STORED); REFRIGERANT PRESS RX FAILURE (STORED); TX FAILURE (STORED); VIN RX FAILURE (STORED)
- Notes
- When Monitored and Set Condition:
- A/C Switch Fault (Stored)
- Backlight Dimming RX Failure (Stored)
- Blend OVERCURRENT (Stored)
- Checksum Failure (Stored)
- Defog Switch Fault (Stored)
- LOOPBACK Test Failure (Stored)
- Mode 1 OVERCURRENT (Stored)
- Mode 2 OVERCURRENT (Stored)
- RECIRC OVERCURRENT (Stored)
- Refrigerant Press RX Failure (Stored)
- TX Failure (Stored)
- VIN RX Failure (Stored)
- Possible Causes
- Diagnostic Procedure
- Symptom List: ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE; BLEND CIRCUIT SHORTED TO GROUND; BLEND CIRCUIT SHORTED TO IGN OR BATT; COMMON DRIVER SHORTED TO GROUND; COMMON DRIVER SHORTED TO IGN OR BATT; MODE 1 CIRCUIT SHORTED TO GROUND; MODE 1 CIRCUIT SHORTED TO IGN OR BATT; MODE 2 CIRCUIT SHORTED TO GROUND; MODE 2 CIRCUIT SHORTED TO IGN OR BATT; RECIRC CIRCUIT SHORTED TO GROUND; RECIRC CIRCUIT SHORTED TO IGN OR BATT; SHORT TOO COMPLEX
- Notes
- When Monitored and Set Condition:
- Act CKT Test Passed, OVERCURRENT DTCS Active
- Blend Circuit Shorted To Ground
- Blend Circuit Shorted To IGN Or Batt
- Common Driver Shorted To Ground
- Common Driver Shorted To IGN Or Batt
- Mode 1 Circuit Shorted To Ground
- Mode 1 Circuit Shorted To IGN Or Batt
- Mode 2 Circuit Shorted To Ground
- Mode 2 Circuit Shorted To IGN Or Batt
- RECIRC Circuit Shorted To Ground
- RECIRC Circuit Shorted To IGN Or Batt
- Short Too Complex
- Possible Causes
- Diagnostic Procedure
- Symptom: BACKLIGHT DIMMING RX FAILURE (ACTIVE)
- Symptom List: BLEND CALIBRATION FAULT; MODE 1 CALIBRATION FAULT; MODE 2 CALIBRATION FAULT; RECIRCULATION CALIBRATION FAULT
- Symptom List: BLEND OVERCURRENT (ACTIVE); MODE 1 OVERCURRENT (ACTIVE); MODE 2 OVERCURRENT (ACTIVE); RECIRC OVERCURRENT (ACTIVE)
- Symptom: DEFOG RELAY CONTROL CKT SHORTED TO BATT
- Symptom: LOOPBACK TEST FAILURE (ACTIVE)
- Symptom List: REFRIGERANT PRESSURE RX FAILURE (ACTIVE); VIN RX FAILURE (ACTIVE)
- Symptom: TX FAILURE (ACTIVE)
- Symptom: *A/C - HEATER CONTROL ILLUMINATION INOPERATIVE
- Symptom: *BLEND/MODE/RECIRC DOOR OPERATION IMPROPER
- Symptom: *BLOWER MOTOR INOPERATIVE
- Symptom: *BLOWER MOTOR SPEEDS INCORRECT
- Symptom: *EBL STATUS INDICATOR FLASHING
- Symptom: *HVAC SYSTEM TEST
- Ignition, Power, Accessory
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT OPEN
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT SHORT TO GROUND
- Symptom: BCM - IGNITION MUX SWITCH INPUT MISMATCH
- Symptom: BCM - IGNITION MUX SWITCH INPUT OPEN
- Symptom: BCM - IGNITION MUX SWITCH INPUT SHORT
- Symptom: BCM - IGNITION RUN 1 SHORT
- Symptom: BCM - IGNITION RUN 2 SHORT
- Symptom: BCM - IOD OUTPUT CIRCUIT SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT OPEN / SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT SHORT TO VOLTAGE
- Symptom: BCM - RUN/START HARDWIRE INPUT MISMATCH
- Symptom: HORN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: HORN RELAY COIL SHORT TO BATTERY
- Symptom: HORN SWITCH STUCK
- Symptom: *HORNS INOPERATIVE
- Instrument Cluster
- Symptom List: ABS LAMP CIRCUIT OPEN; ABS LAMP CIRCUIT SHORTED; AIRBAG LAMP CIRCUIT OPEN; AIRBAG LAMP CIRCUIT SHORTED
- Symptom: ABS MESSAGES NOT RECEIVED
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT OPEN / SHORTED TO VOLTAGE
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT SHORT TO GROUND
- Symptom: BCM - PWM DIMMING OUTPUT SHORT
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: ORC MESSAGES NOT RECEIVED
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *GAUGE CLUSTER DIAGNOSTIC TEST
- Symptom: *INSTRUMENT CLUSTER DIAGNOSTIC TEST
- Interior Lighting
- Power Door Locks/RKE
- Symptom: DECKLID RELEASE OUTPUT OPEN
- Symptom: DECKLID RELEASE OUTPUT SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH OPEN OR SHORT TO VOLTAGE
- Symptom: DRIVER CYLINDER UNLOCK SWITCH SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH STUCK
- Symptom: DRIVER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: DRIVER DOOR LOCK SWITCH STUCK
- Symptom: DRIVER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: DRIVER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: DRIVER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER DOOR LOCK SWITCH STUCK
- Symptom: PASSENGER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER/DRIVER DOOR UNLATCH RETURN SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT OPEN/SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT SHORT TO BATTERY
- Symptom: *ALL DOOR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR UNLATCH INOPERATIVE
- Symptom: *PASSENGER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *PASSENGER DOOR UNLATCH INOPERATIVE
- Symptom: *REMOTE KEYLESS ENTRY PROBLEM
- Power Windows
- Symptom: DRIVER WINDOW DOWN OUTPUT SHORT TO GROUND
- Symptom: DRIVER WINDOW HALL EFFECT FAILURE
- Symptom: DRIVER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: DRIVER WINDOW SWITCH SHORT TO GROUND
- Symptom: DRIVER WINDOW SWITCH STUCK DOWN
- Symptom: DRIVER WINDOW SWITCH STUCK UP
- Symptom: DRIVER WINDOW UP OUTPUT SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL SHORT TO BATTERY
- Symptom: PASSENGER WINDOW HALL EFFECT FAILURE
- Symptom: PASSENGER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: PASSENGER WINDOW SWITCH SHORT TO GROUND
- Symptom: PASSENGER WINDOW SWITCH STUCK DOWN
- Symptom: PASSENGER WINDOW SWITCH STUCK UP
- Symptom: PASSENGER WINDOW UP SHORT TO GROUND
- Symptom: *DRIVER WINDOW INOPERATIVE
- Symptom: *PASSENGER WINDOW INOPERATIVE
- Tire Pressure Monitoring
- Symptom: CRITICAL TIRE PRESSURE - BCM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM; LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM; RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM; RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM
- Symptom: TIRE PRESSURE LOW - BCM
- Symptom: TIRE PRESSURE MONITOR MODULE FAILURE - TPM
- Symptom: TPM DIAGNOSTIC - BCM
- Symptom: TPM MODULE INITIALIZED - BCM
- Symptom: *LO TIRE LCD MESSAGE FLASHING
- Symptom: VTSS INDICATOR OUTPUT OPEN
- Symptom: VTSS INDICATOR OUTPUT SHORT
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *DECKLID DOES NOT TRIP VTSS
- Symptom: *DRIVER DOOR DOES NOT TRIP VTSS
- Symptom: *EXTERIOR LAMPS FAIL TO FLASH WHEN ALARM IS TRIPPED
- Symptom: *HOOD DOES NOT TRIP VTSS
- Symptom: *HORN FAILS TO SOUND WHEN ALARM IS TRIPPED
- Symptom: *PASSENGER DOOR DOES NOT TRIP VTSS
- Symptom: *VTSS LAMP ON STEADY DURING ARMING
- Symptom: *VTSS WILL NOT ARM
- Verification Tests
- Air Bag
- Component Locations
- Connector PINOUTS
- A/C-Heater Control C1 - Black 10 Way
- A/C-Heater Control C2 - Black 16 Way
- Airbag Control Module C1 (Orc) - Yellow 32 Way
- Airbag Control Module C2 (Orc) Yellow 32 Way
- Airbag On/Off Switch-Passenger - Yellow 6 Way
- Airbag Squib 1-Driver - Yellow/Black 2 Way
- Airbag Squib 2-Driver - Yellow/Gray 2 Way
- Airbag Squib-Passenger - Yellow 4 Way
- Ajar Switch-DECKLID - Black 3 Way
- Ajar Switch-Driver Door - Black 4 Way
- Ajar Switch-Hood - Natural 3 Way
- Ajar Switch-Passenger Door - Black 4 Way
- Blend Door Actuator - Gray 2 Way
- Blower Motor - Orange 2 Way
- Blower Motor Resistor Block - Black 4 Way
- Body Control Module C1 - Black 6 Way
- Body Control Module C2 - Black/Green 34 Way
- Body Control Module C3 - Black/White 34 Way
- Body Control Module C4 - Black/Gray 34 Way
- Body Control Module C5 - Black/Black 34 Way
- Brake Fluid Level Switch - Black 2 Way
- C200 - Black (Body Side)
- C200 - Black (Instrument Panel Side)
- C201 - Yellow (Body Side)
- C201 - Yellow (Instrument Panel Side)
- C204 - (HVAC Jumper Side)
- C204 - (Instrument Panel Side)
- C206 - Red (Console Jumper Side)
- C206 - Red (Instrument Panel Side)
- CLOCKSPRING - White 8 Way
- Controller Antilock Brake - Black 24 Way
- Cylinder Unlock Switch-Driver - Black 2 Way
- Data Link Connector - Black 16 Way
- DECKLID Release Motor - Black 2 Way
- Door Latch Motor-Driver - 2 Way
- Door Latch Motor-Passenger - 2 Way
- Door Lock Switch-Driver - Black 3 Way
- Door Lock Switch-Passenger - Black 3 Way
- Exterior Door Handle Switch-Driver - Black 2 Way
- Exterior Door Handle Switch-Passenger Black 2 Way
- Fog Lamp-Left - Black 2 Way
- Gauge Cluster C1 - White 3 Way
- Gauge Cluster C2 - Black 20 Way
- Hid Lamp-Left - Gray 2 Way
- High Beam Headlamp-Left - Black 2 Way
- Horn-High Note - Black 2 Way
- Horn-Low Note - Black 2 Way
- Ignition Switch - Black 5 Way
- Instrument Cluster C1 - Black 16 Way
- Instrument Cluster C12 - Black 20 Way
- Interior Door Handle Switch-Driver - Black 2 Way
- Interior Door Handle Switch-Passenger - Black 2 Way
- Marker Lamp-Left Front - DK.Gray 2 Way
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way
- Multi-Function Switch - Gray 20 Way
- Park/Turn Lamp-Left - Black 3 Way
- Power Amplifier C1 - DK.Gray 14 Way
- Power Amplifier C2 - Green 16 Way
- Fuses (PDC)
- Power Window Motor-Driver - 6 Way
- Power Window Motor-Passenger - 6 Way
- Power Window Switch-Driver - Gray 3 Way
- Power Window Switch-Passenger - Gray 3 Way
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Radio - Gray 22 Way
- RECIRCULATION Door Actuator - Gray 2 Way
- Remote Keyless Entry Module - Black 6 Way
- Seat Belt Switch-Driver - White 2 Way
- Seat Belt Switch-Passenger - White 2 Way
- Seat Belt TENSIONER-Driver - Yellow 2 Way
- Seat Belt TENSIONER-Passenger - Yellow 2 Way
- Speaker-Left Door - Black 2 Way
- Speaker-Left Instrument Panel - White 2 Way
- Speaker-Left Rear - White 3 Way
- Speaker-Rear Woofer - Gray 4 Way
- Speaker-Right Door - Black 2 Way
- Speaker-Right Instrument Panel - White 2 Way
- Speaker-Right Rear - White 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Window Down Relay-Passenger - Black 5 Way
- Window Up Relay-Passenger - Black 5 Way
- Schematic Diagrams
- Airbag System
- Audio System
- Chime System
- Communication
- Door Ajar System
- Electrically Heated Systems
- Exterior Lighting
- Heating & A/C System
- Ignition, Power, Accessory
- Instrument Cluster/Gauge Cluster
- Interior Lighting
- Power Door Locks/RKE
- Power Window System
- Tire Pressure Monitor Module (TPM)
- Vehicle Theft Security System
- Instrument Cluster
- Instrument Panel
- Body Diagnostic Procedures
- Heated Glass/Defoggers
- Horns
- Infotainment
- Audio System (Service Information)
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Body Control Module
- Chime Warning System
- Communication
- Door Ajar System
- Exterior Lighting System
- Relays Controlled By The BCM
- Heating & A/C System
- Instrument Cluster / Gauge Cluster
- Interior Lighting
- Tire Pressure Monitoring System (TPMS)
- Power Door Entry System
- Power Windows
- Electrically Heated Systems
- Vehicle Theft Security System
- Using The DRBIII®
- DRBIII® Error Messages
- DRBIII® Does Not Power Up (Blank Screen)
- Display Is Not Visible
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Air Bag
- Symptom List: ACCELEROMETER 1; ACCELEROMETER 2; INTERNAL 1; OUTPUT DRIVER 1; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: DRIVER SQUIB 2 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 2 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 2 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 2 SHORT TO GROUND
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH OPEN
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO BATTERY
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO GROUND
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO BATTERY
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: PASSENGER SQUIB 2 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 2 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 2 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 2 SHORT TO GROUND
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: All OUTPUTS SHORT
- Symptom List; CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH BCM
- Chime
- Communication
- Symptom: ACM MESSAGES NOT RECEIVED
- Symptom: AUDIO MESSAGES NOT RECEIVED
- Symptom: COUNTRY CODE NOT PROGRAMMED
- Symptom: INTERNAL BCM FAILURE
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom List: PCI BUS SHORTED TO BATTERY; PCI BUS SHORTED TO GROUND
- Symptom: PCI INTERNAL FAULT
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *NO RESPONSE FROM ACM
- Symptom: *NO RESPONSE FROM BODY CONTROL MODULE
- Symptom: *NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE
- Symptom: *NO RESPONSE FROM HVAC
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM PCM (PCI BUS)
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY)
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM TIRE PRESSURE MONITOR MODULE
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Door Ajar
- Symptom: *DECKLID AJAR CIRCUIT OPEN
- Symptom: *DECKLID AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *DRIVER DOOR AJAR CIRCUIT OPEN
- Symptom: *DRIVER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *HOOD AJAR CIRCUIT OPEN
- Symptom: *HOOD AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *PASSENGER DOOR AJAR CIRCUIT OPEN
- Symptom: *PASSENGER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Electrically Heated Systems
- Exterior Lighting
- Symptom: LEFT FOG LAMP OUTPUT OPEN
- Symptom: LEFT FOG LAMP OUTPUT SHORTED
- Symptom: LEFT HIGH BEAM OUTPUT OPEN
- Symptom: LEFT HIGH BEAM OUTPUT SHORT
- Symptom: LOW BEAM RELAY COIL OUTPUT OPEN/SHORT TO GROUND
- Symptom: LOW BEAM RELAY COIL SHORT TO VOLTAGE
- Symptom: PARK LAMP OUTPUT SHORT
- Symptom: RIGHT FOG LAMP OUTPUT OPEN
- Symptom: RIGHT FOG LAMP OUTPUT SHORTED
- Symptom: RIGHT HIGH BEAM OUTPUT OPEN
- Symptom: RIGHT HIGH BEAM OUTPUT SHORT
- Heating & A/C
- Symptom List: A/C SWITCH FAULT (ACTIVE); CHECKSUM FAILURE (ACTIVE); DEFOG SWITCH FAULT (ACTIVE)
- Symptom List: A/C SWITCH FAULT (STORED); BACKLIGHT DIMMING RX FAILURE (STORED); BLEND OVERCURRENT (STORED); CHECKSUM FAILURE (STORED); DEFOG SWITCH FAULT (STORED); LOOPBACK TEST FAILURE (STORED); MODE 1 OVERCURRENT (STORED); MODE 2 OVERCURRENT (STORED); RECIRC OVERCURRENT (STORED); REFRIGERANT PRESS RX FAILURE (STORED); TX FAILURE (STORED); VIN RX FAILURE (STORED)
- Notes
- When Monitored and Set Condition:
- A/C Switch Fault (Stored)
- Backlight Dimming RX Failure (Stored)
- Blend OVERCURRENT (Stored)
- Checksum Failure (Stored)
- Defog Switch Fault (Stored)
- LOOPBACK Test Failure (Stored)
- Mode 1 OVERCURRENT (Stored)
- Mode 2 OVERCURRENT (Stored)
- RECIRC OVERCURRENT (Stored)
- Refrigerant Press RX Failure (Stored)
- TX Failure (Stored)
- VIN RX Failure (Stored)
- Possible Causes
- Diagnostic Procedure
- Symptom List: ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE; BLEND CIRCUIT SHORTED TO GROUND; BLEND CIRCUIT SHORTED TO IGN OR BATT; COMMON DRIVER SHORTED TO GROUND; COMMON DRIVER SHORTED TO IGN OR BATT; MODE 1 CIRCUIT SHORTED TO GROUND; MODE 1 CIRCUIT SHORTED TO IGN OR BATT; MODE 2 CIRCUIT SHORTED TO GROUND; MODE 2 CIRCUIT SHORTED TO IGN OR BATT; RECIRC CIRCUIT SHORTED TO GROUND; RECIRC CIRCUIT SHORTED TO IGN OR BATT; SHORT TOO COMPLEX
- Notes
- When Monitored and Set Condition:
- Act CKT Test Passed, OVERCURRENT DTCS Active
- Blend Circuit Shorted To Ground
- Blend Circuit Shorted To IGN Or Batt
- Common Driver Shorted To Ground
- Common Driver Shorted To IGN Or Batt
- Mode 1 Circuit Shorted To Ground
- Mode 1 Circuit Shorted To IGN Or Batt
- Mode 2 Circuit Shorted To Ground
- Mode 2 Circuit Shorted To IGN Or Batt
- RECIRC Circuit Shorted To Ground
- RECIRC Circuit Shorted To IGN Or Batt
- Short Too Complex
- Possible Causes
- Diagnostic Procedure
- Symptom: BACKLIGHT DIMMING RX FAILURE (ACTIVE)
- Symptom List: BLEND CALIBRATION FAULT; MODE 1 CALIBRATION FAULT; MODE 2 CALIBRATION FAULT; RECIRCULATION CALIBRATION FAULT
- Symptom List: BLEND OVERCURRENT (ACTIVE); MODE 1 OVERCURRENT (ACTIVE); MODE 2 OVERCURRENT (ACTIVE); RECIRC OVERCURRENT (ACTIVE)
- Symptom: DEFOG RELAY CONTROL CKT SHORTED TO BATT
- Symptom: LOOPBACK TEST FAILURE (ACTIVE)
- Symptom List: REFRIGERANT PRESSURE RX FAILURE (ACTIVE); VIN RX FAILURE (ACTIVE)
- Symptom: TX FAILURE (ACTIVE)
- Symptom: *A/C - HEATER CONTROL ILLUMINATION INOPERATIVE
- Symptom: *BLEND/MODE/RECIRC DOOR OPERATION IMPROPER
- Symptom: *BLOWER MOTOR INOPERATIVE
- Symptom: *BLOWER MOTOR SPEEDS INCORRECT
- Symptom: *EBL STATUS INDICATOR FLASHING
- Symptom: *HVAC SYSTEM TEST
- Ignition, Power, Accessory
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT OPEN
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT SHORT TO GROUND
- Symptom: BCM - IGNITION MUX SWITCH INPUT MISMATCH
- Symptom: BCM - IGNITION MUX SWITCH INPUT OPEN
- Symptom: BCM - IGNITION MUX SWITCH INPUT SHORT
- Symptom: BCM - IGNITION RUN 1 SHORT
- Symptom: BCM - IGNITION RUN 2 SHORT
- Symptom: BCM - IOD OUTPUT CIRCUIT SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT OPEN / SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT SHORT TO VOLTAGE
- Symptom: BCM - RUN/START HARDWIRE INPUT MISMATCH
- Symptom: HORN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: HORN RELAY COIL SHORT TO BATTERY
- Symptom: HORN SWITCH STUCK
- Symptom: *HORNS INOPERATIVE
- Instrument Cluster
- Symptom List: ABS LAMP CIRCUIT OPEN; ABS LAMP CIRCUIT SHORTED; AIRBAG LAMP CIRCUIT OPEN; AIRBAG LAMP CIRCUIT SHORTED
- Symptom: ABS MESSAGES NOT RECEIVED
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT OPEN / SHORTED TO VOLTAGE
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT SHORT TO GROUND
- Symptom: BCM - PWM DIMMING OUTPUT SHORT
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: ORC MESSAGES NOT RECEIVED
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *GAUGE CLUSTER DIAGNOSTIC TEST
- Symptom: *INSTRUMENT CLUSTER DIAGNOSTIC TEST
- Interior Lighting
- Power Door Locks/RKE
- Symptom: DECKLID RELEASE OUTPUT OPEN
- Symptom: DECKLID RELEASE OUTPUT SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH OPEN OR SHORT TO VOLTAGE
- Symptom: DRIVER CYLINDER UNLOCK SWITCH SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH STUCK
- Symptom: DRIVER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: DRIVER DOOR LOCK SWITCH STUCK
- Symptom: DRIVER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: DRIVER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: DRIVER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER DOOR LOCK SWITCH STUCK
- Symptom: PASSENGER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER/DRIVER DOOR UNLATCH RETURN SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT OPEN/SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT SHORT TO BATTERY
- Symptom: *ALL DOOR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR UNLATCH INOPERATIVE
- Symptom: *PASSENGER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *PASSENGER DOOR UNLATCH INOPERATIVE
- Symptom: *REMOTE KEYLESS ENTRY PROBLEM
- Power Windows
- Symptom: DRIVER WINDOW DOWN OUTPUT SHORT TO GROUND
- Symptom: DRIVER WINDOW HALL EFFECT FAILURE
- Symptom: DRIVER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: DRIVER WINDOW SWITCH SHORT TO GROUND
- Symptom: DRIVER WINDOW SWITCH STUCK DOWN
- Symptom: DRIVER WINDOW SWITCH STUCK UP
- Symptom: DRIVER WINDOW UP OUTPUT SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL SHORT TO BATTERY
- Symptom: PASSENGER WINDOW HALL EFFECT FAILURE
- Symptom: PASSENGER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: PASSENGER WINDOW SWITCH SHORT TO GROUND
- Symptom: PASSENGER WINDOW SWITCH STUCK DOWN
- Symptom: PASSENGER WINDOW SWITCH STUCK UP
- Symptom: PASSENGER WINDOW UP SHORT TO GROUND
- Symptom: *DRIVER WINDOW INOPERATIVE
- Symptom: *PASSENGER WINDOW INOPERATIVE
- Tire Pressure Monitoring
- Symptom: CRITICAL TIRE PRESSURE - BCM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM; LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM; RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM; RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM
- Symptom: TIRE PRESSURE LOW - BCM
- Symptom: TIRE PRESSURE MONITOR MODULE FAILURE - TPM
- Symptom: TPM DIAGNOSTIC - BCM
- Symptom: TPM MODULE INITIALIZED - BCM
- Symptom: *LO TIRE LCD MESSAGE FLASHING
- Symptom: VTSS INDICATOR OUTPUT OPEN
- Symptom: VTSS INDICATOR OUTPUT SHORT
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *DECKLID DOES NOT TRIP VTSS
- Symptom: *DRIVER DOOR DOES NOT TRIP VTSS
- Symptom: *EXTERIOR LAMPS FAIL TO FLASH WHEN ALARM IS TRIPPED
- Symptom: *HOOD DOES NOT TRIP VTSS
- Symptom: *HORN FAILS TO SOUND WHEN ALARM IS TRIPPED
- Symptom: *PASSENGER DOOR DOES NOT TRIP VTSS
- Symptom: *VTSS LAMP ON STEADY DURING ARMING
- Symptom: *VTSS WILL NOT ARM
- Verification Tests
- Air Bag
- Component Locations
- Connector PINOUTS
- A/C-Heater Control C1 - Black 10 Way
- A/C-Heater Control C2 - Black 16 Way
- Airbag Control Module C1 (Orc) - Yellow 32 Way
- Airbag Control Module C2 (Orc) Yellow 32 Way
- Airbag On/Off Switch-Passenger - Yellow 6 Way
- Airbag Squib 1-Driver - Yellow/Black 2 Way
- Airbag Squib 2-Driver - Yellow/Gray 2 Way
- Airbag Squib-Passenger - Yellow 4 Way
- Ajar Switch-DECKLID - Black 3 Way
- Ajar Switch-Driver Door - Black 4 Way
- Ajar Switch-Hood - Natural 3 Way
- Ajar Switch-Passenger Door - Black 4 Way
- Blend Door Actuator - Gray 2 Way
- Blower Motor - Orange 2 Way
- Blower Motor Resistor Block - Black 4 Way
- Body Control Module C1 - Black 6 Way
- Body Control Module C2 - Black/Green 34 Way
- Body Control Module C3 - Black/White 34 Way
- Body Control Module C4 - Black/Gray 34 Way
- Body Control Module C5 - Black/Black 34 Way
- Brake Fluid Level Switch - Black 2 Way
- C200 - Black (Body Side)
- C200 - Black (Instrument Panel Side)
- C201 - Yellow (Body Side)
- C201 - Yellow (Instrument Panel Side)
- C204 - (HVAC Jumper Side)
- C204 - (Instrument Panel Side)
- C206 - Red (Console Jumper Side)
- C206 - Red (Instrument Panel Side)
- CLOCKSPRING - White 8 Way
- Controller Antilock Brake - Black 24 Way
- Cylinder Unlock Switch-Driver - Black 2 Way
- Data Link Connector - Black 16 Way
- DECKLID Release Motor - Black 2 Way
- Door Latch Motor-Driver - 2 Way
- Door Latch Motor-Passenger - 2 Way
- Door Lock Switch-Driver - Black 3 Way
- Door Lock Switch-Passenger - Black 3 Way
- Exterior Door Handle Switch-Driver - Black 2 Way
- Exterior Door Handle Switch-Passenger Black 2 Way
- Fog Lamp-Left - Black 2 Way
- Gauge Cluster C1 - White 3 Way
- Gauge Cluster C2 - Black 20 Way
- Hid Lamp-Left - Gray 2 Way
- High Beam Headlamp-Left - Black 2 Way
- Horn-High Note - Black 2 Way
- Horn-Low Note - Black 2 Way
- Ignition Switch - Black 5 Way
- Instrument Cluster C1 - Black 16 Way
- Instrument Cluster C12 - Black 20 Way
- Interior Door Handle Switch-Driver - Black 2 Way
- Interior Door Handle Switch-Passenger - Black 2 Way
- Marker Lamp-Left Front - DK.Gray 2 Way
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way
- Multi-Function Switch - Gray 20 Way
- Park/Turn Lamp-Left - Black 3 Way
- Power Amplifier C1 - DK.Gray 14 Way
- Power Amplifier C2 - Green 16 Way
- Fuses (PDC)
- Power Window Motor-Driver - 6 Way
- Power Window Motor-Passenger - 6 Way
- Power Window Switch-Driver - Gray 3 Way
- Power Window Switch-Passenger - Gray 3 Way
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Radio - Gray 22 Way
- RECIRCULATION Door Actuator - Gray 2 Way
- Remote Keyless Entry Module - Black 6 Way
- Seat Belt Switch-Driver - White 2 Way
- Seat Belt Switch-Passenger - White 2 Way
- Seat Belt TENSIONER-Driver - Yellow 2 Way
- Seat Belt TENSIONER-Passenger - Yellow 2 Way
- Speaker-Left Door - Black 2 Way
- Speaker-Left Instrument Panel - White 2 Way
- Speaker-Left Rear - White 3 Way
- Speaker-Rear Woofer - Gray 4 Way
- Speaker-Right Door - Black 2 Way
- Speaker-Right Instrument Panel - White 2 Way
- Speaker-Right Rear - White 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Window Down Relay-Passenger - Black 5 Way
- Window Up Relay-Passenger - Black 5 Way
- Schematic Diagrams
- Airbag System
- Audio System
- Chime System
- Communication
- Door Ajar System
- Electrically Heated Systems
- Exterior Lighting
- Heating & A/C System
- Ignition, Power, Accessory
- Instrument Cluster/Gauge Cluster
- Interior Lighting
- Power Door Locks/RKE
- Power Window System
- Tire Pressure Monitor Module (TPM)
- Vehicle Theft Security System
- Interior/Exterior Trim
- Body Panel Repair
- Warning
- Diagnosis And Testing
- Standard Procedure
- Standard Procedure - Plastic Body Panel Repair
- Notes
- Rigid Plastics:
- Semi-Rigid Plastics:
- Flexible Plastics:
- Repair Procedure:
- Adhesion Promoter/Surface Modifier:
- Safety Precaution And Warnings
- Rigid, Semi-Rigid, And Flexible Plastic Parts Types
- Panel Sectioning
- Panel Reinforcement
- Visual Inspection
- Panel Surface Preparation
- Patching Panels
- Panel Patch Fabrications
- Panel Patch Installation
- Patched Panel Surfacing
- Standard Procedure - Heat Staking
- Standard Procedure - Plastic Body Panel Repair
- Specifications
- Special Tools
- DECKLID
- Door - Front
- Instrument Panel
- Interior
- Body Panel Repair
- Interior/Illumination Lights
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Body Control Module
- Chime Warning System
- Communication
- Door Ajar System
- Exterior Lighting System
- Relays Controlled By The BCM
- Heating & A/C System
- Instrument Cluster / Gauge Cluster
- Interior Lighting
- Tire Pressure Monitoring System (TPMS)
- Power Door Entry System
- Power Windows
- Electrically Heated Systems
- Vehicle Theft Security System
- Using The DRBIII®
- DRBIII® Error Messages
- DRBIII® Does Not Power Up (Blank Screen)
- Display Is Not Visible
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Air Bag
- Symptom List: ACCELEROMETER 1; ACCELEROMETER 2; INTERNAL 1; OUTPUT DRIVER 1; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: DRIVER SQUIB 2 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 2 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 2 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 2 SHORT TO GROUND
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH OPEN
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO BATTERY
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO GROUND
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO BATTERY
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: PASSENGER SQUIB 2 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 2 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 2 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 2 SHORT TO GROUND
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: All OUTPUTS SHORT
- Symptom List; CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH BCM
- Chime
- Communication
- Symptom: ACM MESSAGES NOT RECEIVED
- Symptom: AUDIO MESSAGES NOT RECEIVED
- Symptom: COUNTRY CODE NOT PROGRAMMED
- Symptom: INTERNAL BCM FAILURE
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom List: PCI BUS SHORTED TO BATTERY; PCI BUS SHORTED TO GROUND
- Symptom: PCI INTERNAL FAULT
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *NO RESPONSE FROM ACM
- Symptom: *NO RESPONSE FROM BODY CONTROL MODULE
- Symptom: *NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE
- Symptom: *NO RESPONSE FROM HVAC
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM PCM (PCI BUS)
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY)
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM TIRE PRESSURE MONITOR MODULE
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Door Ajar
- Symptom: *DECKLID AJAR CIRCUIT OPEN
- Symptom: *DECKLID AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *DRIVER DOOR AJAR CIRCUIT OPEN
- Symptom: *DRIVER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *HOOD AJAR CIRCUIT OPEN
- Symptom: *HOOD AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *PASSENGER DOOR AJAR CIRCUIT OPEN
- Symptom: *PASSENGER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Electrically Heated Systems
- Exterior Lighting
- Symptom: LEFT FOG LAMP OUTPUT OPEN
- Symptom: LEFT FOG LAMP OUTPUT SHORTED
- Symptom: LEFT HIGH BEAM OUTPUT OPEN
- Symptom: LEFT HIGH BEAM OUTPUT SHORT
- Symptom: LOW BEAM RELAY COIL OUTPUT OPEN/SHORT TO GROUND
- Symptom: LOW BEAM RELAY COIL SHORT TO VOLTAGE
- Symptom: PARK LAMP OUTPUT SHORT
- Symptom: RIGHT FOG LAMP OUTPUT OPEN
- Symptom: RIGHT FOG LAMP OUTPUT SHORTED
- Symptom: RIGHT HIGH BEAM OUTPUT OPEN
- Symptom: RIGHT HIGH BEAM OUTPUT SHORT
- Heating & A/C
- Symptom List: A/C SWITCH FAULT (ACTIVE); CHECKSUM FAILURE (ACTIVE); DEFOG SWITCH FAULT (ACTIVE)
- Symptom List: A/C SWITCH FAULT (STORED); BACKLIGHT DIMMING RX FAILURE (STORED); BLEND OVERCURRENT (STORED); CHECKSUM FAILURE (STORED); DEFOG SWITCH FAULT (STORED); LOOPBACK TEST FAILURE (STORED); MODE 1 OVERCURRENT (STORED); MODE 2 OVERCURRENT (STORED); RECIRC OVERCURRENT (STORED); REFRIGERANT PRESS RX FAILURE (STORED); TX FAILURE (STORED); VIN RX FAILURE (STORED)
- Notes
- When Monitored and Set Condition:
- A/C Switch Fault (Stored)
- Backlight Dimming RX Failure (Stored)
- Blend OVERCURRENT (Stored)
- Checksum Failure (Stored)
- Defog Switch Fault (Stored)
- LOOPBACK Test Failure (Stored)
- Mode 1 OVERCURRENT (Stored)
- Mode 2 OVERCURRENT (Stored)
- RECIRC OVERCURRENT (Stored)
- Refrigerant Press RX Failure (Stored)
- TX Failure (Stored)
- VIN RX Failure (Stored)
- Possible Causes
- Diagnostic Procedure
- Symptom List: ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE; BLEND CIRCUIT SHORTED TO GROUND; BLEND CIRCUIT SHORTED TO IGN OR BATT; COMMON DRIVER SHORTED TO GROUND; COMMON DRIVER SHORTED TO IGN OR BATT; MODE 1 CIRCUIT SHORTED TO GROUND; MODE 1 CIRCUIT SHORTED TO IGN OR BATT; MODE 2 CIRCUIT SHORTED TO GROUND; MODE 2 CIRCUIT SHORTED TO IGN OR BATT; RECIRC CIRCUIT SHORTED TO GROUND; RECIRC CIRCUIT SHORTED TO IGN OR BATT; SHORT TOO COMPLEX
- Notes
- When Monitored and Set Condition:
- Act CKT Test Passed, OVERCURRENT DTCS Active
- Blend Circuit Shorted To Ground
- Blend Circuit Shorted To IGN Or Batt
- Common Driver Shorted To Ground
- Common Driver Shorted To IGN Or Batt
- Mode 1 Circuit Shorted To Ground
- Mode 1 Circuit Shorted To IGN Or Batt
- Mode 2 Circuit Shorted To Ground
- Mode 2 Circuit Shorted To IGN Or Batt
- RECIRC Circuit Shorted To Ground
- RECIRC Circuit Shorted To IGN Or Batt
- Short Too Complex
- Possible Causes
- Diagnostic Procedure
- Symptom: BACKLIGHT DIMMING RX FAILURE (ACTIVE)
- Symptom List: BLEND CALIBRATION FAULT; MODE 1 CALIBRATION FAULT; MODE 2 CALIBRATION FAULT; RECIRCULATION CALIBRATION FAULT
- Symptom List: BLEND OVERCURRENT (ACTIVE); MODE 1 OVERCURRENT (ACTIVE); MODE 2 OVERCURRENT (ACTIVE); RECIRC OVERCURRENT (ACTIVE)
- Symptom: DEFOG RELAY CONTROL CKT SHORTED TO BATT
- Symptom: LOOPBACK TEST FAILURE (ACTIVE)
- Symptom List: REFRIGERANT PRESSURE RX FAILURE (ACTIVE); VIN RX FAILURE (ACTIVE)
- Symptom: TX FAILURE (ACTIVE)
- Symptom: *A/C - HEATER CONTROL ILLUMINATION INOPERATIVE
- Symptom: *BLEND/MODE/RECIRC DOOR OPERATION IMPROPER
- Symptom: *BLOWER MOTOR INOPERATIVE
- Symptom: *BLOWER MOTOR SPEEDS INCORRECT
- Symptom: *EBL STATUS INDICATOR FLASHING
- Symptom: *HVAC SYSTEM TEST
- Ignition, Power, Accessory
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT OPEN
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT SHORT TO GROUND
- Symptom: BCM - IGNITION MUX SWITCH INPUT MISMATCH
- Symptom: BCM - IGNITION MUX SWITCH INPUT OPEN
- Symptom: BCM - IGNITION MUX SWITCH INPUT SHORT
- Symptom: BCM - IGNITION RUN 1 SHORT
- Symptom: BCM - IGNITION RUN 2 SHORT
- Symptom: BCM - IOD OUTPUT CIRCUIT SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT OPEN / SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT SHORT TO VOLTAGE
- Symptom: BCM - RUN/START HARDWIRE INPUT MISMATCH
- Symptom: HORN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: HORN RELAY COIL SHORT TO BATTERY
- Symptom: HORN SWITCH STUCK
- Symptom: *HORNS INOPERATIVE
- Instrument Cluster
- Symptom List: ABS LAMP CIRCUIT OPEN; ABS LAMP CIRCUIT SHORTED; AIRBAG LAMP CIRCUIT OPEN; AIRBAG LAMP CIRCUIT SHORTED
- Symptom: ABS MESSAGES NOT RECEIVED
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT OPEN / SHORTED TO VOLTAGE
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT SHORT TO GROUND
- Symptom: BCM - PWM DIMMING OUTPUT SHORT
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: ORC MESSAGES NOT RECEIVED
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *GAUGE CLUSTER DIAGNOSTIC TEST
- Symptom: *INSTRUMENT CLUSTER DIAGNOSTIC TEST
- Interior Lighting
- Power Door Locks/RKE
- Symptom: DECKLID RELEASE OUTPUT OPEN
- Symptom: DECKLID RELEASE OUTPUT SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH OPEN OR SHORT TO VOLTAGE
- Symptom: DRIVER CYLINDER UNLOCK SWITCH SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH STUCK
- Symptom: DRIVER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: DRIVER DOOR LOCK SWITCH STUCK
- Symptom: DRIVER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: DRIVER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: DRIVER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER DOOR LOCK SWITCH STUCK
- Symptom: PASSENGER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER/DRIVER DOOR UNLATCH RETURN SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT OPEN/SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT SHORT TO BATTERY
- Symptom: *ALL DOOR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR UNLATCH INOPERATIVE
- Symptom: *PASSENGER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *PASSENGER DOOR UNLATCH INOPERATIVE
- Symptom: *REMOTE KEYLESS ENTRY PROBLEM
- Power Windows
- Symptom: DRIVER WINDOW DOWN OUTPUT SHORT TO GROUND
- Symptom: DRIVER WINDOW HALL EFFECT FAILURE
- Symptom: DRIVER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: DRIVER WINDOW SWITCH SHORT TO GROUND
- Symptom: DRIVER WINDOW SWITCH STUCK DOWN
- Symptom: DRIVER WINDOW SWITCH STUCK UP
- Symptom: DRIVER WINDOW UP OUTPUT SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL SHORT TO BATTERY
- Symptom: PASSENGER WINDOW HALL EFFECT FAILURE
- Symptom: PASSENGER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: PASSENGER WINDOW SWITCH SHORT TO GROUND
- Symptom: PASSENGER WINDOW SWITCH STUCK DOWN
- Symptom: PASSENGER WINDOW SWITCH STUCK UP
- Symptom: PASSENGER WINDOW UP SHORT TO GROUND
- Symptom: *DRIVER WINDOW INOPERATIVE
- Symptom: *PASSENGER WINDOW INOPERATIVE
- Tire Pressure Monitoring
- Symptom: CRITICAL TIRE PRESSURE - BCM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM; LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM; RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM; RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM
- Symptom: TIRE PRESSURE LOW - BCM
- Symptom: TIRE PRESSURE MONITOR MODULE FAILURE - TPM
- Symptom: TPM DIAGNOSTIC - BCM
- Symptom: TPM MODULE INITIALIZED - BCM
- Symptom: *LO TIRE LCD MESSAGE FLASHING
- Symptom: VTSS INDICATOR OUTPUT OPEN
- Symptom: VTSS INDICATOR OUTPUT SHORT
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *DECKLID DOES NOT TRIP VTSS
- Symptom: *DRIVER DOOR DOES NOT TRIP VTSS
- Symptom: *EXTERIOR LAMPS FAIL TO FLASH WHEN ALARM IS TRIPPED
- Symptom: *HOOD DOES NOT TRIP VTSS
- Symptom: *HORN FAILS TO SOUND WHEN ALARM IS TRIPPED
- Symptom: *PASSENGER DOOR DOES NOT TRIP VTSS
- Symptom: *VTSS LAMP ON STEADY DURING ARMING
- Symptom: *VTSS WILL NOT ARM
- Verification Tests
- Air Bag
- Component Locations
- Connector PINOUTS
- A/C-Heater Control C1 - Black 10 Way
- A/C-Heater Control C2 - Black 16 Way
- Airbag Control Module C1 (Orc) - Yellow 32 Way
- Airbag Control Module C2 (Orc) Yellow 32 Way
- Airbag On/Off Switch-Passenger - Yellow 6 Way
- Airbag Squib 1-Driver - Yellow/Black 2 Way
- Airbag Squib 2-Driver - Yellow/Gray 2 Way
- Airbag Squib-Passenger - Yellow 4 Way
- Ajar Switch-DECKLID - Black 3 Way
- Ajar Switch-Driver Door - Black 4 Way
- Ajar Switch-Hood - Natural 3 Way
- Ajar Switch-Passenger Door - Black 4 Way
- Blend Door Actuator - Gray 2 Way
- Blower Motor - Orange 2 Way
- Blower Motor Resistor Block - Black 4 Way
- Body Control Module C1 - Black 6 Way
- Body Control Module C2 - Black/Green 34 Way
- Body Control Module C3 - Black/White 34 Way
- Body Control Module C4 - Black/Gray 34 Way
- Body Control Module C5 - Black/Black 34 Way
- Brake Fluid Level Switch - Black 2 Way
- C200 - Black (Body Side)
- C200 - Black (Instrument Panel Side)
- C201 - Yellow (Body Side)
- C201 - Yellow (Instrument Panel Side)
- C204 - (HVAC Jumper Side)
- C204 - (Instrument Panel Side)
- C206 - Red (Console Jumper Side)
- C206 - Red (Instrument Panel Side)
- CLOCKSPRING - White 8 Way
- Controller Antilock Brake - Black 24 Way
- Cylinder Unlock Switch-Driver - Black 2 Way
- Data Link Connector - Black 16 Way
- DECKLID Release Motor - Black 2 Way
- Door Latch Motor-Driver - 2 Way
- Door Latch Motor-Passenger - 2 Way
- Door Lock Switch-Driver - Black 3 Way
- Door Lock Switch-Passenger - Black 3 Way
- Exterior Door Handle Switch-Driver - Black 2 Way
- Exterior Door Handle Switch-Passenger Black 2 Way
- Fog Lamp-Left - Black 2 Way
- Gauge Cluster C1 - White 3 Way
- Gauge Cluster C2 - Black 20 Way
- Hid Lamp-Left - Gray 2 Way
- High Beam Headlamp-Left - Black 2 Way
- Horn-High Note - Black 2 Way
- Horn-Low Note - Black 2 Way
- Ignition Switch - Black 5 Way
- Instrument Cluster C1 - Black 16 Way
- Instrument Cluster C12 - Black 20 Way
- Interior Door Handle Switch-Driver - Black 2 Way
- Interior Door Handle Switch-Passenger - Black 2 Way
- Marker Lamp-Left Front - DK.Gray 2 Way
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way
- Multi-Function Switch - Gray 20 Way
- Park/Turn Lamp-Left - Black 3 Way
- Power Amplifier C1 - DK.Gray 14 Way
- Power Amplifier C2 - Green 16 Way
- Fuses (PDC)
- Power Window Motor-Driver - 6 Way
- Power Window Motor-Passenger - 6 Way
- Power Window Switch-Driver - Gray 3 Way
- Power Window Switch-Passenger - Gray 3 Way
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Radio - Gray 22 Way
- RECIRCULATION Door Actuator - Gray 2 Way
- Remote Keyless Entry Module - Black 6 Way
- Seat Belt Switch-Driver - White 2 Way
- Seat Belt Switch-Passenger - White 2 Way
- Seat Belt TENSIONER-Driver - Yellow 2 Way
- Seat Belt TENSIONER-Passenger - Yellow 2 Way
- Speaker-Left Door - Black 2 Way
- Speaker-Left Instrument Panel - White 2 Way
- Speaker-Left Rear - White 3 Way
- Speaker-Rear Woofer - Gray 4 Way
- Speaker-Right Door - Black 2 Way
- Speaker-Right Instrument Panel - White 2 Way
- Speaker-Right Rear - White 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Window Down Relay-Passenger - Black 5 Way
- Window Up Relay-Passenger - Black 5 Way
- Schematic Diagrams
- Airbag System
- Audio System
- Chime System
- Communication
- Door Ajar System
- Electrically Heated Systems
- Exterior Lighting
- Heating & A/C System
- Ignition, Power, Accessory
- Instrument Cluster/Gauge Cluster
- Interior Lighting
- Power Door Locks/RKE
- Power Window System
- Tire Pressure Monitor Module (TPM)
- Vehicle Theft Security System
- Lamp System & Lighting System - Interior
- Body Diagnostic Procedures
- Mirrors
- Exterior Trim
- Interior
- Power Mirrors
- Seats
- Steering Column Switches
- Lamp System & Lighting System - Exterior
- Lamps/Lighting - Exterior
- Backup Lamp
- Back Up Lamp Unit
- Brake Lamp Switch
- Center High Mounted Stop Lamp Unit
- Fog Lamp
- Fog Lamp Unit
- Front Side Marker Lamp
- Headlamp
- Headlamp Unit
- License Plate Lamp
- License Plate Lamp Unit
- Multi-Function Switch
- Rear Side Marker Lamp
- Tail Lamp
- Tail Lamp Unit
- Steering Wheel & Steering Column
- Lamp System & Lighting System - Exterior
- Warning Systems
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Body Control Module
- Chime Warning System
- Communication
- Door Ajar System
- Exterior Lighting System
- Relays Controlled By The BCM
- Heating & A/C System
- Instrument Cluster / Gauge Cluster
- Interior Lighting
- Tire Pressure Monitoring System (TPMS)
- Power Door Entry System
- Power Windows
- Electrically Heated Systems
- Vehicle Theft Security System
- Using The DRBIII®
- DRBIII® Error Messages
- DRBIII® Does Not Power Up (Blank Screen)
- Display Is Not Visible
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Air Bag
- Symptom List: ACCELEROMETER 1; ACCELEROMETER 2; INTERNAL 1; OUTPUT DRIVER 1; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: DRIVER SQUIB 2 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 2 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 2 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 2 SHORT TO GROUND
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH OPEN
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO BATTERY
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO GROUND
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO BATTERY
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: PASSENGER SQUIB 2 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 2 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 2 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 2 SHORT TO GROUND
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: All OUTPUTS SHORT
- Symptom List; CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH BCM
- Chime
- Communication
- Symptom: ACM MESSAGES NOT RECEIVED
- Symptom: AUDIO MESSAGES NOT RECEIVED
- Symptom: COUNTRY CODE NOT PROGRAMMED
- Symptom: INTERNAL BCM FAILURE
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom List: PCI BUS SHORTED TO BATTERY; PCI BUS SHORTED TO GROUND
- Symptom: PCI INTERNAL FAULT
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *NO RESPONSE FROM ACM
- Symptom: *NO RESPONSE FROM BODY CONTROL MODULE
- Symptom: *NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE
- Symptom: *NO RESPONSE FROM HVAC
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM PCM (PCI BUS)
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY)
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM TIRE PRESSURE MONITOR MODULE
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Door Ajar
- Symptom: *DECKLID AJAR CIRCUIT OPEN
- Symptom: *DECKLID AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *DRIVER DOOR AJAR CIRCUIT OPEN
- Symptom: *DRIVER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *HOOD AJAR CIRCUIT OPEN
- Symptom: *HOOD AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *PASSENGER DOOR AJAR CIRCUIT OPEN
- Symptom: *PASSENGER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Electrically Heated Systems
- Exterior Lighting
- Symptom: LEFT FOG LAMP OUTPUT OPEN
- Symptom: LEFT FOG LAMP OUTPUT SHORTED
- Symptom: LEFT HIGH BEAM OUTPUT OPEN
- Symptom: LEFT HIGH BEAM OUTPUT SHORT
- Symptom: LOW BEAM RELAY COIL OUTPUT OPEN/SHORT TO GROUND
- Symptom: LOW BEAM RELAY COIL SHORT TO VOLTAGE
- Symptom: PARK LAMP OUTPUT SHORT
- Symptom: RIGHT FOG LAMP OUTPUT OPEN
- Symptom: RIGHT FOG LAMP OUTPUT SHORTED
- Symptom: RIGHT HIGH BEAM OUTPUT OPEN
- Symptom: RIGHT HIGH BEAM OUTPUT SHORT
- Heating & A/C
- Symptom List: A/C SWITCH FAULT (ACTIVE); CHECKSUM FAILURE (ACTIVE); DEFOG SWITCH FAULT (ACTIVE)
- Symptom List: A/C SWITCH FAULT (STORED); BACKLIGHT DIMMING RX FAILURE (STORED); BLEND OVERCURRENT (STORED); CHECKSUM FAILURE (STORED); DEFOG SWITCH FAULT (STORED); LOOPBACK TEST FAILURE (STORED); MODE 1 OVERCURRENT (STORED); MODE 2 OVERCURRENT (STORED); RECIRC OVERCURRENT (STORED); REFRIGERANT PRESS RX FAILURE (STORED); TX FAILURE (STORED); VIN RX FAILURE (STORED)
- Notes
- When Monitored and Set Condition:
- A/C Switch Fault (Stored)
- Backlight Dimming RX Failure (Stored)
- Blend OVERCURRENT (Stored)
- Checksum Failure (Stored)
- Defog Switch Fault (Stored)
- LOOPBACK Test Failure (Stored)
- Mode 1 OVERCURRENT (Stored)
- Mode 2 OVERCURRENT (Stored)
- RECIRC OVERCURRENT (Stored)
- Refrigerant Press RX Failure (Stored)
- TX Failure (Stored)
- VIN RX Failure (Stored)
- Possible Causes
- Diagnostic Procedure
- Symptom List: ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE; BLEND CIRCUIT SHORTED TO GROUND; BLEND CIRCUIT SHORTED TO IGN OR BATT; COMMON DRIVER SHORTED TO GROUND; COMMON DRIVER SHORTED TO IGN OR BATT; MODE 1 CIRCUIT SHORTED TO GROUND; MODE 1 CIRCUIT SHORTED TO IGN OR BATT; MODE 2 CIRCUIT SHORTED TO GROUND; MODE 2 CIRCUIT SHORTED TO IGN OR BATT; RECIRC CIRCUIT SHORTED TO GROUND; RECIRC CIRCUIT SHORTED TO IGN OR BATT; SHORT TOO COMPLEX
- Notes
- When Monitored and Set Condition:
- Act CKT Test Passed, OVERCURRENT DTCS Active
- Blend Circuit Shorted To Ground
- Blend Circuit Shorted To IGN Or Batt
- Common Driver Shorted To Ground
- Common Driver Shorted To IGN Or Batt
- Mode 1 Circuit Shorted To Ground
- Mode 1 Circuit Shorted To IGN Or Batt
- Mode 2 Circuit Shorted To Ground
- Mode 2 Circuit Shorted To IGN Or Batt
- RECIRC Circuit Shorted To Ground
- RECIRC Circuit Shorted To IGN Or Batt
- Short Too Complex
- Possible Causes
- Diagnostic Procedure
- Symptom: BACKLIGHT DIMMING RX FAILURE (ACTIVE)
- Symptom List: BLEND CALIBRATION FAULT; MODE 1 CALIBRATION FAULT; MODE 2 CALIBRATION FAULT; RECIRCULATION CALIBRATION FAULT
- Symptom List: BLEND OVERCURRENT (ACTIVE); MODE 1 OVERCURRENT (ACTIVE); MODE 2 OVERCURRENT (ACTIVE); RECIRC OVERCURRENT (ACTIVE)
- Symptom: DEFOG RELAY CONTROL CKT SHORTED TO BATT
- Symptom: LOOPBACK TEST FAILURE (ACTIVE)
- Symptom List: REFRIGERANT PRESSURE RX FAILURE (ACTIVE); VIN RX FAILURE (ACTIVE)
- Symptom: TX FAILURE (ACTIVE)
- Symptom: *A/C - HEATER CONTROL ILLUMINATION INOPERATIVE
- Symptom: *BLEND/MODE/RECIRC DOOR OPERATION IMPROPER
- Symptom: *BLOWER MOTOR INOPERATIVE
- Symptom: *BLOWER MOTOR SPEEDS INCORRECT
- Symptom: *EBL STATUS INDICATOR FLASHING
- Symptom: *HVAC SYSTEM TEST
- Ignition, Power, Accessory
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT OPEN
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT SHORT TO GROUND
- Symptom: BCM - IGNITION MUX SWITCH INPUT MISMATCH
- Symptom: BCM - IGNITION MUX SWITCH INPUT OPEN
- Symptom: BCM - IGNITION MUX SWITCH INPUT SHORT
- Symptom: BCM - IGNITION RUN 1 SHORT
- Symptom: BCM - IGNITION RUN 2 SHORT
- Symptom: BCM - IOD OUTPUT CIRCUIT SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT OPEN / SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT SHORT TO VOLTAGE
- Symptom: BCM - RUN/START HARDWIRE INPUT MISMATCH
- Symptom: HORN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: HORN RELAY COIL SHORT TO BATTERY
- Symptom: HORN SWITCH STUCK
- Symptom: *HORNS INOPERATIVE
- Instrument Cluster
- Symptom List: ABS LAMP CIRCUIT OPEN; ABS LAMP CIRCUIT SHORTED; AIRBAG LAMP CIRCUIT OPEN; AIRBAG LAMP CIRCUIT SHORTED
- Symptom: ABS MESSAGES NOT RECEIVED
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT OPEN / SHORTED TO VOLTAGE
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT SHORT TO GROUND
- Symptom: BCM - PWM DIMMING OUTPUT SHORT
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: ORC MESSAGES NOT RECEIVED
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *GAUGE CLUSTER DIAGNOSTIC TEST
- Symptom: *INSTRUMENT CLUSTER DIAGNOSTIC TEST
- Interior Lighting
- Power Door Locks/RKE
- Symptom: DECKLID RELEASE OUTPUT OPEN
- Symptom: DECKLID RELEASE OUTPUT SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH OPEN OR SHORT TO VOLTAGE
- Symptom: DRIVER CYLINDER UNLOCK SWITCH SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH STUCK
- Symptom: DRIVER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: DRIVER DOOR LOCK SWITCH STUCK
- Symptom: DRIVER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: DRIVER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: DRIVER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER DOOR LOCK SWITCH STUCK
- Symptom: PASSENGER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER/DRIVER DOOR UNLATCH RETURN SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT OPEN/SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT SHORT TO BATTERY
- Symptom: *ALL DOOR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR UNLATCH INOPERATIVE
- Symptom: *PASSENGER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *PASSENGER DOOR UNLATCH INOPERATIVE
- Symptom: *REMOTE KEYLESS ENTRY PROBLEM
- Power Windows
- Symptom: DRIVER WINDOW DOWN OUTPUT SHORT TO GROUND
- Symptom: DRIVER WINDOW HALL EFFECT FAILURE
- Symptom: DRIVER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: DRIVER WINDOW SWITCH SHORT TO GROUND
- Symptom: DRIVER WINDOW SWITCH STUCK DOWN
- Symptom: DRIVER WINDOW SWITCH STUCK UP
- Symptom: DRIVER WINDOW UP OUTPUT SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL SHORT TO BATTERY
- Symptom: PASSENGER WINDOW HALL EFFECT FAILURE
- Symptom: PASSENGER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: PASSENGER WINDOW SWITCH SHORT TO GROUND
- Symptom: PASSENGER WINDOW SWITCH STUCK DOWN
- Symptom: PASSENGER WINDOW SWITCH STUCK UP
- Symptom: PASSENGER WINDOW UP SHORT TO GROUND
- Symptom: *DRIVER WINDOW INOPERATIVE
- Symptom: *PASSENGER WINDOW INOPERATIVE
- Tire Pressure Monitoring
- Symptom: CRITICAL TIRE PRESSURE - BCM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM; LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM; RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM; RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM
- Symptom: TIRE PRESSURE LOW - BCM
- Symptom: TIRE PRESSURE MONITOR MODULE FAILURE - TPM
- Symptom: TPM DIAGNOSTIC - BCM
- Symptom: TPM MODULE INITIALIZED - BCM
- Symptom: *LO TIRE LCD MESSAGE FLASHING
- Symptom: VTSS INDICATOR OUTPUT OPEN
- Symptom: VTSS INDICATOR OUTPUT SHORT
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *DECKLID DOES NOT TRIP VTSS
- Symptom: *DRIVER DOOR DOES NOT TRIP VTSS
- Symptom: *EXTERIOR LAMPS FAIL TO FLASH WHEN ALARM IS TRIPPED
- Symptom: *HOOD DOES NOT TRIP VTSS
- Symptom: *HORN FAILS TO SOUND WHEN ALARM IS TRIPPED
- Symptom: *PASSENGER DOOR DOES NOT TRIP VTSS
- Symptom: *VTSS LAMP ON STEADY DURING ARMING
- Symptom: *VTSS WILL NOT ARM
- Verification Tests
- Air Bag
- Component Locations
- Connector PINOUTS
- A/C-Heater Control C1 - Black 10 Way
- A/C-Heater Control C2 - Black 16 Way
- Airbag Control Module C1 (Orc) - Yellow 32 Way
- Airbag Control Module C2 (Orc) Yellow 32 Way
- Airbag On/Off Switch-Passenger - Yellow 6 Way
- Airbag Squib 1-Driver - Yellow/Black 2 Way
- Airbag Squib 2-Driver - Yellow/Gray 2 Way
- Airbag Squib-Passenger - Yellow 4 Way
- Ajar Switch-DECKLID - Black 3 Way
- Ajar Switch-Driver Door - Black 4 Way
- Ajar Switch-Hood - Natural 3 Way
- Ajar Switch-Passenger Door - Black 4 Way
- Blend Door Actuator - Gray 2 Way
- Blower Motor - Orange 2 Way
- Blower Motor Resistor Block - Black 4 Way
- Body Control Module C1 - Black 6 Way
- Body Control Module C2 - Black/Green 34 Way
- Body Control Module C3 - Black/White 34 Way
- Body Control Module C4 - Black/Gray 34 Way
- Body Control Module C5 - Black/Black 34 Way
- Brake Fluid Level Switch - Black 2 Way
- C200 - Black (Body Side)
- C200 - Black (Instrument Panel Side)
- C201 - Yellow (Body Side)
- C201 - Yellow (Instrument Panel Side)
- C204 - (HVAC Jumper Side)
- C204 - (Instrument Panel Side)
- C206 - Red (Console Jumper Side)
- C206 - Red (Instrument Panel Side)
- CLOCKSPRING - White 8 Way
- Controller Antilock Brake - Black 24 Way
- Cylinder Unlock Switch-Driver - Black 2 Way
- Data Link Connector - Black 16 Way
- DECKLID Release Motor - Black 2 Way
- Door Latch Motor-Driver - 2 Way
- Door Latch Motor-Passenger - 2 Way
- Door Lock Switch-Driver - Black 3 Way
- Door Lock Switch-Passenger - Black 3 Way
- Exterior Door Handle Switch-Driver - Black 2 Way
- Exterior Door Handle Switch-Passenger Black 2 Way
- Fog Lamp-Left - Black 2 Way
- Gauge Cluster C1 - White 3 Way
- Gauge Cluster C2 - Black 20 Way
- Hid Lamp-Left - Gray 2 Way
- High Beam Headlamp-Left - Black 2 Way
- Horn-High Note - Black 2 Way
- Horn-Low Note - Black 2 Way
- Ignition Switch - Black 5 Way
- Instrument Cluster C1 - Black 16 Way
- Instrument Cluster C12 - Black 20 Way
- Interior Door Handle Switch-Driver - Black 2 Way
- Interior Door Handle Switch-Passenger - Black 2 Way
- Marker Lamp-Left Front - DK.Gray 2 Way
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way
- Multi-Function Switch - Gray 20 Way
- Park/Turn Lamp-Left - Black 3 Way
- Power Amplifier C1 - DK.Gray 14 Way
- Power Amplifier C2 - Green 16 Way
- Fuses (PDC)
- Power Window Motor-Driver - 6 Way
- Power Window Motor-Passenger - 6 Way
- Power Window Switch-Driver - Gray 3 Way
- Power Window Switch-Passenger - Gray 3 Way
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Radio - Gray 22 Way
- RECIRCULATION Door Actuator - Gray 2 Way
- Remote Keyless Entry Module - Black 6 Way
- Seat Belt Switch-Driver - White 2 Way
- Seat Belt Switch-Passenger - White 2 Way
- Seat Belt TENSIONER-Driver - Yellow 2 Way
- Seat Belt TENSIONER-Passenger - Yellow 2 Way
- Speaker-Left Door - Black 2 Way
- Speaker-Left Instrument Panel - White 2 Way
- Speaker-Left Rear - White 3 Way
- Speaker-Rear Woofer - Gray 4 Way
- Speaker-Right Door - Black 2 Way
- Speaker-Right Instrument Panel - White 2 Way
- Speaker-Right Rear - White 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Window Down Relay-Passenger - Black 5 Way
- Window Up Relay-Passenger - Black 5 Way
- Schematic Diagrams
- Airbag System
- Audio System
- Chime System
- Communication
- Door Ajar System
- Electrically Heated Systems
- Exterior Lighting
- Heating & A/C System
- Ignition, Power, Accessory
- Instrument Cluster/Gauge Cluster
- Interior Lighting
- Power Door Locks/RKE
- Power Window System
- Tire Pressure Monitor Module (TPM)
- Vehicle Theft Security System
- Chime/Buzzer
- Chime/Buzzer
- Description
- Operation
- Airbag Warning
- Antilock Brake Warning
- Critical Coolant Temperature Warning
- Critical Oil Temperature Warning
- Deck Lid Ajar Reminder
- Dome Lamps On Reminder
- Door Ajar Warning
- Enhanced Seat Belt Reminder
- Fasten Seat Belt Reminder
- Headlamps Reminder
- Key In Ignition Reminder
- Low Fuel Reminder
- Park Brake/Low Brake Fluid Warning
- Service Engine Soon Warning
- Tire Pressure System Warning
- Under/Over Voltage Warning
- Warning Lamp Announcement
- Diagnosis And Testing - Chime Conditions
- Chime/Buzzer
- Horn System
- Tires & Wheels & Tire Pressure Monitoring System
- Body Diagnostic Procedures
- Window Motors & Regulators
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Body Control Module
- Chime Warning System
- Communication
- Door Ajar System
- Exterior Lighting System
- Relays Controlled By The BCM
- Heating & A/C System
- Instrument Cluster / Gauge Cluster
- Interior Lighting
- Tire Pressure Monitoring System (TPMS)
- Power Door Entry System
- Power Windows
- Electrically Heated Systems
- Vehicle Theft Security System
- Using The DRBIII®
- DRBIII® Error Messages
- DRBIII® Does Not Power Up (Blank Screen)
- Display Is Not Visible
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Air Bag
- Symptom List: ACCELEROMETER 1; ACCELEROMETER 2; INTERNAL 1; OUTPUT DRIVER 1; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: DRIVER SQUIB 2 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 2 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 2 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 2 SHORT TO GROUND
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH OPEN
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO BATTERY
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO GROUND
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO BATTERY
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: PASSENGER SQUIB 2 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 2 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 2 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 2 SHORT TO GROUND
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: All OUTPUTS SHORT
- Symptom List; CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH BCM
- Chime
- Communication
- Symptom: ACM MESSAGES NOT RECEIVED
- Symptom: AUDIO MESSAGES NOT RECEIVED
- Symptom: COUNTRY CODE NOT PROGRAMMED
- Symptom: INTERNAL BCM FAILURE
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom List: PCI BUS SHORTED TO BATTERY; PCI BUS SHORTED TO GROUND
- Symptom: PCI INTERNAL FAULT
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *NO RESPONSE FROM ACM
- Symptom: *NO RESPONSE FROM BODY CONTROL MODULE
- Symptom: *NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE
- Symptom: *NO RESPONSE FROM HVAC
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM PCM (PCI BUS)
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY)
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM TIRE PRESSURE MONITOR MODULE
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Door Ajar
- Symptom: *DECKLID AJAR CIRCUIT OPEN
- Symptom: *DECKLID AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *DRIVER DOOR AJAR CIRCUIT OPEN
- Symptom: *DRIVER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *HOOD AJAR CIRCUIT OPEN
- Symptom: *HOOD AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *PASSENGER DOOR AJAR CIRCUIT OPEN
- Symptom: *PASSENGER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Electrically Heated Systems
- Exterior Lighting
- Symptom: LEFT FOG LAMP OUTPUT OPEN
- Symptom: LEFT FOG LAMP OUTPUT SHORTED
- Symptom: LEFT HIGH BEAM OUTPUT OPEN
- Symptom: LEFT HIGH BEAM OUTPUT SHORT
- Symptom: LOW BEAM RELAY COIL OUTPUT OPEN/SHORT TO GROUND
- Symptom: LOW BEAM RELAY COIL SHORT TO VOLTAGE
- Symptom: PARK LAMP OUTPUT SHORT
- Symptom: RIGHT FOG LAMP OUTPUT OPEN
- Symptom: RIGHT FOG LAMP OUTPUT SHORTED
- Symptom: RIGHT HIGH BEAM OUTPUT OPEN
- Symptom: RIGHT HIGH BEAM OUTPUT SHORT
- Heating & A/C
- Symptom List: A/C SWITCH FAULT (ACTIVE); CHECKSUM FAILURE (ACTIVE); DEFOG SWITCH FAULT (ACTIVE)
- Symptom List: A/C SWITCH FAULT (STORED); BACKLIGHT DIMMING RX FAILURE (STORED); BLEND OVERCURRENT (STORED); CHECKSUM FAILURE (STORED); DEFOG SWITCH FAULT (STORED); LOOPBACK TEST FAILURE (STORED); MODE 1 OVERCURRENT (STORED); MODE 2 OVERCURRENT (STORED); RECIRC OVERCURRENT (STORED); REFRIGERANT PRESS RX FAILURE (STORED); TX FAILURE (STORED); VIN RX FAILURE (STORED)
- Notes
- When Monitored and Set Condition:
- A/C Switch Fault (Stored)
- Backlight Dimming RX Failure (Stored)
- Blend OVERCURRENT (Stored)
- Checksum Failure (Stored)
- Defog Switch Fault (Stored)
- LOOPBACK Test Failure (Stored)
- Mode 1 OVERCURRENT (Stored)
- Mode 2 OVERCURRENT (Stored)
- RECIRC OVERCURRENT (Stored)
- Refrigerant Press RX Failure (Stored)
- TX Failure (Stored)
- VIN RX Failure (Stored)
- Possible Causes
- Diagnostic Procedure
- Symptom List: ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE; BLEND CIRCUIT SHORTED TO GROUND; BLEND CIRCUIT SHORTED TO IGN OR BATT; COMMON DRIVER SHORTED TO GROUND; COMMON DRIVER SHORTED TO IGN OR BATT; MODE 1 CIRCUIT SHORTED TO GROUND; MODE 1 CIRCUIT SHORTED TO IGN OR BATT; MODE 2 CIRCUIT SHORTED TO GROUND; MODE 2 CIRCUIT SHORTED TO IGN OR BATT; RECIRC CIRCUIT SHORTED TO GROUND; RECIRC CIRCUIT SHORTED TO IGN OR BATT; SHORT TOO COMPLEX
- Notes
- When Monitored and Set Condition:
- Act CKT Test Passed, OVERCURRENT DTCS Active
- Blend Circuit Shorted To Ground
- Blend Circuit Shorted To IGN Or Batt
- Common Driver Shorted To Ground
- Common Driver Shorted To IGN Or Batt
- Mode 1 Circuit Shorted To Ground
- Mode 1 Circuit Shorted To IGN Or Batt
- Mode 2 Circuit Shorted To Ground
- Mode 2 Circuit Shorted To IGN Or Batt
- RECIRC Circuit Shorted To Ground
- RECIRC Circuit Shorted To IGN Or Batt
- Short Too Complex
- Possible Causes
- Diagnostic Procedure
- Symptom: BACKLIGHT DIMMING RX FAILURE (ACTIVE)
- Symptom List: BLEND CALIBRATION FAULT; MODE 1 CALIBRATION FAULT; MODE 2 CALIBRATION FAULT; RECIRCULATION CALIBRATION FAULT
- Symptom List: BLEND OVERCURRENT (ACTIVE); MODE 1 OVERCURRENT (ACTIVE); MODE 2 OVERCURRENT (ACTIVE); RECIRC OVERCURRENT (ACTIVE)
- Symptom: DEFOG RELAY CONTROL CKT SHORTED TO BATT
- Symptom: LOOPBACK TEST FAILURE (ACTIVE)
- Symptom List: REFRIGERANT PRESSURE RX FAILURE (ACTIVE); VIN RX FAILURE (ACTIVE)
- Symptom: TX FAILURE (ACTIVE)
- Symptom: *A/C - HEATER CONTROL ILLUMINATION INOPERATIVE
- Symptom: *BLEND/MODE/RECIRC DOOR OPERATION IMPROPER
- Symptom: *BLOWER MOTOR INOPERATIVE
- Symptom: *BLOWER MOTOR SPEEDS INCORRECT
- Symptom: *EBL STATUS INDICATOR FLASHING
- Symptom: *HVAC SYSTEM TEST
- Ignition, Power, Accessory
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT OPEN
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT SHORT TO GROUND
- Symptom: BCM - IGNITION MUX SWITCH INPUT MISMATCH
- Symptom: BCM - IGNITION MUX SWITCH INPUT OPEN
- Symptom: BCM - IGNITION MUX SWITCH INPUT SHORT
- Symptom: BCM - IGNITION RUN 1 SHORT
- Symptom: BCM - IGNITION RUN 2 SHORT
- Symptom: BCM - IOD OUTPUT CIRCUIT SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT OPEN / SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT SHORT TO VOLTAGE
- Symptom: BCM - RUN/START HARDWIRE INPUT MISMATCH
- Symptom: HORN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: HORN RELAY COIL SHORT TO BATTERY
- Symptom: HORN SWITCH STUCK
- Symptom: *HORNS INOPERATIVE
- Instrument Cluster
- Symptom List: ABS LAMP CIRCUIT OPEN; ABS LAMP CIRCUIT SHORTED; AIRBAG LAMP CIRCUIT OPEN; AIRBAG LAMP CIRCUIT SHORTED
- Symptom: ABS MESSAGES NOT RECEIVED
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT OPEN / SHORTED TO VOLTAGE
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT SHORT TO GROUND
- Symptom: BCM - PWM DIMMING OUTPUT SHORT
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: ORC MESSAGES NOT RECEIVED
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *GAUGE CLUSTER DIAGNOSTIC TEST
- Symptom: *INSTRUMENT CLUSTER DIAGNOSTIC TEST
- Interior Lighting
- Power Door Locks/RKE
- Symptom: DECKLID RELEASE OUTPUT OPEN
- Symptom: DECKLID RELEASE OUTPUT SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH OPEN OR SHORT TO VOLTAGE
- Symptom: DRIVER CYLINDER UNLOCK SWITCH SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH STUCK
- Symptom: DRIVER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: DRIVER DOOR LOCK SWITCH STUCK
- Symptom: DRIVER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: DRIVER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: DRIVER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER DOOR LOCK SWITCH STUCK
- Symptom: PASSENGER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER/DRIVER DOOR UNLATCH RETURN SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT OPEN/SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT SHORT TO BATTERY
- Symptom: *ALL DOOR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR UNLATCH INOPERATIVE
- Symptom: *PASSENGER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *PASSENGER DOOR UNLATCH INOPERATIVE
- Symptom: *REMOTE KEYLESS ENTRY PROBLEM
- Power Windows
- Symptom: DRIVER WINDOW DOWN OUTPUT SHORT TO GROUND
- Symptom: DRIVER WINDOW HALL EFFECT FAILURE
- Symptom: DRIVER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: DRIVER WINDOW SWITCH SHORT TO GROUND
- Symptom: DRIVER WINDOW SWITCH STUCK DOWN
- Symptom: DRIVER WINDOW SWITCH STUCK UP
- Symptom: DRIVER WINDOW UP OUTPUT SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL SHORT TO BATTERY
- Symptom: PASSENGER WINDOW HALL EFFECT FAILURE
- Symptom: PASSENGER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: PASSENGER WINDOW SWITCH SHORT TO GROUND
- Symptom: PASSENGER WINDOW SWITCH STUCK DOWN
- Symptom: PASSENGER WINDOW SWITCH STUCK UP
- Symptom: PASSENGER WINDOW UP SHORT TO GROUND
- Symptom: *DRIVER WINDOW INOPERATIVE
- Symptom: *PASSENGER WINDOW INOPERATIVE
- Tire Pressure Monitoring
- Symptom: CRITICAL TIRE PRESSURE - BCM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM; LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM; RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM; RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM
- Symptom: TIRE PRESSURE LOW - BCM
- Symptom: TIRE PRESSURE MONITOR MODULE FAILURE - TPM
- Symptom: TPM DIAGNOSTIC - BCM
- Symptom: TPM MODULE INITIALIZED - BCM
- Symptom: *LO TIRE LCD MESSAGE FLASHING
- Symptom: VTSS INDICATOR OUTPUT OPEN
- Symptom: VTSS INDICATOR OUTPUT SHORT
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *DECKLID DOES NOT TRIP VTSS
- Symptom: *DRIVER DOOR DOES NOT TRIP VTSS
- Symptom: *EXTERIOR LAMPS FAIL TO FLASH WHEN ALARM IS TRIPPED
- Symptom: *HOOD DOES NOT TRIP VTSS
- Symptom: *HORN FAILS TO SOUND WHEN ALARM IS TRIPPED
- Symptom: *PASSENGER DOOR DOES NOT TRIP VTSS
- Symptom: *VTSS LAMP ON STEADY DURING ARMING
- Symptom: *VTSS WILL NOT ARM
- Verification Tests
- Air Bag
- Component Locations
- Connector PINOUTS
- A/C-Heater Control C1 - Black 10 Way
- A/C-Heater Control C2 - Black 16 Way
- Airbag Control Module C1 (Orc) - Yellow 32 Way
- Airbag Control Module C2 (Orc) Yellow 32 Way
- Airbag On/Off Switch-Passenger - Yellow 6 Way
- Airbag Squib 1-Driver - Yellow/Black 2 Way
- Airbag Squib 2-Driver - Yellow/Gray 2 Way
- Airbag Squib-Passenger - Yellow 4 Way
- Ajar Switch-DECKLID - Black 3 Way
- Ajar Switch-Driver Door - Black 4 Way
- Ajar Switch-Hood - Natural 3 Way
- Ajar Switch-Passenger Door - Black 4 Way
- Blend Door Actuator - Gray 2 Way
- Blower Motor - Orange 2 Way
- Blower Motor Resistor Block - Black 4 Way
- Body Control Module C1 - Black 6 Way
- Body Control Module C2 - Black/Green 34 Way
- Body Control Module C3 - Black/White 34 Way
- Body Control Module C4 - Black/Gray 34 Way
- Body Control Module C5 - Black/Black 34 Way
- Brake Fluid Level Switch - Black 2 Way
- C200 - Black (Body Side)
- C200 - Black (Instrument Panel Side)
- C201 - Yellow (Body Side)
- C201 - Yellow (Instrument Panel Side)
- C204 - (HVAC Jumper Side)
- C204 - (Instrument Panel Side)
- C206 - Red (Console Jumper Side)
- C206 - Red (Instrument Panel Side)
- CLOCKSPRING - White 8 Way
- Controller Antilock Brake - Black 24 Way
- Cylinder Unlock Switch-Driver - Black 2 Way
- Data Link Connector - Black 16 Way
- DECKLID Release Motor - Black 2 Way
- Door Latch Motor-Driver - 2 Way
- Door Latch Motor-Passenger - 2 Way
- Door Lock Switch-Driver - Black 3 Way
- Door Lock Switch-Passenger - Black 3 Way
- Exterior Door Handle Switch-Driver - Black 2 Way
- Exterior Door Handle Switch-Passenger Black 2 Way
- Fog Lamp-Left - Black 2 Way
- Gauge Cluster C1 - White 3 Way
- Gauge Cluster C2 - Black 20 Way
- Hid Lamp-Left - Gray 2 Way
- High Beam Headlamp-Left - Black 2 Way
- Horn-High Note - Black 2 Way
- Horn-Low Note - Black 2 Way
- Ignition Switch - Black 5 Way
- Instrument Cluster C1 - Black 16 Way
- Instrument Cluster C12 - Black 20 Way
- Interior Door Handle Switch-Driver - Black 2 Way
- Interior Door Handle Switch-Passenger - Black 2 Way
- Marker Lamp-Left Front - DK.Gray 2 Way
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way
- Multi-Function Switch - Gray 20 Way
- Park/Turn Lamp-Left - Black 3 Way
- Power Amplifier C1 - DK.Gray 14 Way
- Power Amplifier C2 - Green 16 Way
- Fuses (PDC)
- Power Window Motor-Driver - 6 Way
- Power Window Motor-Passenger - 6 Way
- Power Window Switch-Driver - Gray 3 Way
- Power Window Switch-Passenger - Gray 3 Way
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Radio - Gray 22 Way
- RECIRCULATION Door Actuator - Gray 2 Way
- Remote Keyless Entry Module - Black 6 Way
- Seat Belt Switch-Driver - White 2 Way
- Seat Belt Switch-Passenger - White 2 Way
- Seat Belt TENSIONER-Driver - Yellow 2 Way
- Seat Belt TENSIONER-Passenger - Yellow 2 Way
- Speaker-Left Door - Black 2 Way
- Speaker-Left Instrument Panel - White 2 Way
- Speaker-Left Rear - White 3 Way
- Speaker-Rear Woofer - Gray 4 Way
- Speaker-Right Door - Black 2 Way
- Speaker-Right Instrument Panel - White 2 Way
- Speaker-Right Rear - White 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Window Down Relay-Passenger - Black 5 Way
- Window Up Relay-Passenger - Black 5 Way
- Schematic Diagrams
- Airbag System
- Audio System
- Chime System
- Communication
- Door Ajar System
- Electrically Heated Systems
- Exterior Lighting
- Heating & A/C System
- Ignition, Power, Accessory
- Instrument Cluster/Gauge Cluster
- Interior Lighting
- Power Door Locks/RKE
- Power Window System
- Tire Pressure Monitor Module (TPM)
- Vehicle Theft Security System
- Door - Front
- Power Window System
- Stationary Glass
- Body Diagnostic Procedures
- Wiper/Washer Systems
- Wiper System & Washer System (Service Information)
- Wipers/Washers
- Description
- Operation
- Diagnosis And Testing - Wipers/ Washers
- Notes
- Motor Will Not Operate All Switch Positions
- Motor Operates Slowly At All Speeds
- Wipers Run At High Speed With Switch In Low Speed Position Or Wipers Run At Low Speed With Switch In High Speed Position.
- Wipers Will Operate Continuously With The Switch In The Intermittent Position - When Wiper Switch Is Turned Off, Wipers Stop Wherever They Are Without Returning To Park Position.
- Wipers Do Not Operate When Washer Motor Is Engaged (Pulse Wipe) Or Wipers Do Operate In Intermittent Position.
- WASHE R System Diagnosis
- Washer Hoses / Tubes
- Washer Nozzle
- Washer Pump Motor
- Washer Reservoir
- Wiper Arms
- Wiper Blades
- Wiper Module
- Wiper Motor
- Wiper/Washer Switch
- Wipers/Washers
- Wiper System & Washer System (Service Information)
- Anti-Theft Systems
- Body & Frame
- Body, Cab Control Systems
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Body Control Module
- Chime Warning System
- Communication
- Door Ajar System
- Exterior Lighting System
- Relays Controlled By The BCM
- Heating & A/C System
- Instrument Cluster / Gauge Cluster
- Interior Lighting
- Tire Pressure Monitoring System (TPMS)
- Power Door Entry System
- Power Windows
- Electrically Heated Systems
- Vehicle Theft Security System
- Using The DRBIII®
- DRBIII® Error Messages
- DRBIII® Does Not Power Up (Blank Screen)
- Display Is Not Visible
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Air Bag
- Symptom List: ACCELEROMETER 1; ACCELEROMETER 2; INTERNAL 1; OUTPUT DRIVER 1; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: DRIVER SQUIB 2 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 2 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 2 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 2 SHORT TO GROUND
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH OPEN
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO BATTERY
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO GROUND
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO BATTERY
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: PASSENGER SQUIB 2 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 2 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 2 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 2 SHORT TO GROUND
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: All OUTPUTS SHORT
- Symptom List; CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH BCM
- Chime
- Communication
- Symptom: ACM MESSAGES NOT RECEIVED
- Symptom: AUDIO MESSAGES NOT RECEIVED
- Symptom: COUNTRY CODE NOT PROGRAMMED
- Symptom: INTERNAL BCM FAILURE
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom List: PCI BUS SHORTED TO BATTERY; PCI BUS SHORTED TO GROUND
- Symptom: PCI INTERNAL FAULT
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *NO RESPONSE FROM ACM
- Symptom: *NO RESPONSE FROM BODY CONTROL MODULE
- Symptom: *NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE
- Symptom: *NO RESPONSE FROM HVAC
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM PCM (PCI BUS)
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY)
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM TIRE PRESSURE MONITOR MODULE
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Door Ajar
- Symptom: *DECKLID AJAR CIRCUIT OPEN
- Symptom: *DECKLID AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *DRIVER DOOR AJAR CIRCUIT OPEN
- Symptom: *DRIVER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *HOOD AJAR CIRCUIT OPEN
- Symptom: *HOOD AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *PASSENGER DOOR AJAR CIRCUIT OPEN
- Symptom: *PASSENGER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Electrically Heated Systems
- Exterior Lighting
- Symptom: LEFT FOG LAMP OUTPUT OPEN
- Symptom: LEFT FOG LAMP OUTPUT SHORTED
- Symptom: LEFT HIGH BEAM OUTPUT OPEN
- Symptom: LEFT HIGH BEAM OUTPUT SHORT
- Symptom: LOW BEAM RELAY COIL OUTPUT OPEN/SHORT TO GROUND
- Symptom: LOW BEAM RELAY COIL SHORT TO VOLTAGE
- Symptom: PARK LAMP OUTPUT SHORT
- Symptom: RIGHT FOG LAMP OUTPUT OPEN
- Symptom: RIGHT FOG LAMP OUTPUT SHORTED
- Symptom: RIGHT HIGH BEAM OUTPUT OPEN
- Symptom: RIGHT HIGH BEAM OUTPUT SHORT
- Heating & A/C
- Symptom List: A/C SWITCH FAULT (ACTIVE); CHECKSUM FAILURE (ACTIVE); DEFOG SWITCH FAULT (ACTIVE)
- Symptom List: A/C SWITCH FAULT (STORED); BACKLIGHT DIMMING RX FAILURE (STORED); BLEND OVERCURRENT (STORED); CHECKSUM FAILURE (STORED); DEFOG SWITCH FAULT (STORED); LOOPBACK TEST FAILURE (STORED); MODE 1 OVERCURRENT (STORED); MODE 2 OVERCURRENT (STORED); RECIRC OVERCURRENT (STORED); REFRIGERANT PRESS RX FAILURE (STORED); TX FAILURE (STORED); VIN RX FAILURE (STORED)
- Notes
- When Monitored and Set Condition:
- A/C Switch Fault (Stored)
- Backlight Dimming RX Failure (Stored)
- Blend OVERCURRENT (Stored)
- Checksum Failure (Stored)
- Defog Switch Fault (Stored)
- LOOPBACK Test Failure (Stored)
- Mode 1 OVERCURRENT (Stored)
- Mode 2 OVERCURRENT (Stored)
- RECIRC OVERCURRENT (Stored)
- Refrigerant Press RX Failure (Stored)
- TX Failure (Stored)
- VIN RX Failure (Stored)
- Possible Causes
- Diagnostic Procedure
- Symptom List: ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE; BLEND CIRCUIT SHORTED TO GROUND; BLEND CIRCUIT SHORTED TO IGN OR BATT; COMMON DRIVER SHORTED TO GROUND; COMMON DRIVER SHORTED TO IGN OR BATT; MODE 1 CIRCUIT SHORTED TO GROUND; MODE 1 CIRCUIT SHORTED TO IGN OR BATT; MODE 2 CIRCUIT SHORTED TO GROUND; MODE 2 CIRCUIT SHORTED TO IGN OR BATT; RECIRC CIRCUIT SHORTED TO GROUND; RECIRC CIRCUIT SHORTED TO IGN OR BATT; SHORT TOO COMPLEX
- Notes
- When Monitored and Set Condition:
- Act CKT Test Passed, OVERCURRENT DTCS Active
- Blend Circuit Shorted To Ground
- Blend Circuit Shorted To IGN Or Batt
- Common Driver Shorted To Ground
- Common Driver Shorted To IGN Or Batt
- Mode 1 Circuit Shorted To Ground
- Mode 1 Circuit Shorted To IGN Or Batt
- Mode 2 Circuit Shorted To Ground
- Mode 2 Circuit Shorted To IGN Or Batt
- RECIRC Circuit Shorted To Ground
- RECIRC Circuit Shorted To IGN Or Batt
- Short Too Complex
- Possible Causes
- Diagnostic Procedure
- Symptom: BACKLIGHT DIMMING RX FAILURE (ACTIVE)
- Symptom List: BLEND CALIBRATION FAULT; MODE 1 CALIBRATION FAULT; MODE 2 CALIBRATION FAULT; RECIRCULATION CALIBRATION FAULT
- Symptom List: BLEND OVERCURRENT (ACTIVE); MODE 1 OVERCURRENT (ACTIVE); MODE 2 OVERCURRENT (ACTIVE); RECIRC OVERCURRENT (ACTIVE)
- Symptom: DEFOG RELAY CONTROL CKT SHORTED TO BATT
- Symptom: LOOPBACK TEST FAILURE (ACTIVE)
- Symptom List: REFRIGERANT PRESSURE RX FAILURE (ACTIVE); VIN RX FAILURE (ACTIVE)
- Symptom: TX FAILURE (ACTIVE)
- Symptom: *A/C - HEATER CONTROL ILLUMINATION INOPERATIVE
- Symptom: *BLEND/MODE/RECIRC DOOR OPERATION IMPROPER
- Symptom: *BLOWER MOTOR INOPERATIVE
- Symptom: *BLOWER MOTOR SPEEDS INCORRECT
- Symptom: *EBL STATUS INDICATOR FLASHING
- Symptom: *HVAC SYSTEM TEST
- Ignition, Power, Accessory
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT OPEN
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT SHORT TO GROUND
- Symptom: BCM - IGNITION MUX SWITCH INPUT MISMATCH
- Symptom: BCM - IGNITION MUX SWITCH INPUT OPEN
- Symptom: BCM - IGNITION MUX SWITCH INPUT SHORT
- Symptom: BCM - IGNITION RUN 1 SHORT
- Symptom: BCM - IGNITION RUN 2 SHORT
- Symptom: BCM - IOD OUTPUT CIRCUIT SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT OPEN / SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT SHORT TO VOLTAGE
- Symptom: BCM - RUN/START HARDWIRE INPUT MISMATCH
- Symptom: HORN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: HORN RELAY COIL SHORT TO BATTERY
- Symptom: HORN SWITCH STUCK
- Symptom: *HORNS INOPERATIVE
- Instrument Cluster
- Symptom List: ABS LAMP CIRCUIT OPEN; ABS LAMP CIRCUIT SHORTED; AIRBAG LAMP CIRCUIT OPEN; AIRBAG LAMP CIRCUIT SHORTED
- Symptom: ABS MESSAGES NOT RECEIVED
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT OPEN / SHORTED TO VOLTAGE
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT SHORT TO GROUND
- Symptom: BCM - PWM DIMMING OUTPUT SHORT
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: ORC MESSAGES NOT RECEIVED
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *GAUGE CLUSTER DIAGNOSTIC TEST
- Symptom: *INSTRUMENT CLUSTER DIAGNOSTIC TEST
- Interior Lighting
- Power Door Locks/RKE
- Symptom: DECKLID RELEASE OUTPUT OPEN
- Symptom: DECKLID RELEASE OUTPUT SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH OPEN OR SHORT TO VOLTAGE
- Symptom: DRIVER CYLINDER UNLOCK SWITCH SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH STUCK
- Symptom: DRIVER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: DRIVER DOOR LOCK SWITCH STUCK
- Symptom: DRIVER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: DRIVER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: DRIVER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER DOOR LOCK SWITCH STUCK
- Symptom: PASSENGER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER/DRIVER DOOR UNLATCH RETURN SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT OPEN/SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT SHORT TO BATTERY
- Symptom: *ALL DOOR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR UNLATCH INOPERATIVE
- Symptom: *PASSENGER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *PASSENGER DOOR UNLATCH INOPERATIVE
- Symptom: *REMOTE KEYLESS ENTRY PROBLEM
- Power Windows
- Symptom: DRIVER WINDOW DOWN OUTPUT SHORT TO GROUND
- Symptom: DRIVER WINDOW HALL EFFECT FAILURE
- Symptom: DRIVER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: DRIVER WINDOW SWITCH SHORT TO GROUND
- Symptom: DRIVER WINDOW SWITCH STUCK DOWN
- Symptom: DRIVER WINDOW SWITCH STUCK UP
- Symptom: DRIVER WINDOW UP OUTPUT SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL SHORT TO BATTERY
- Symptom: PASSENGER WINDOW HALL EFFECT FAILURE
- Symptom: PASSENGER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: PASSENGER WINDOW SWITCH SHORT TO GROUND
- Symptom: PASSENGER WINDOW SWITCH STUCK DOWN
- Symptom: PASSENGER WINDOW SWITCH STUCK UP
- Symptom: PASSENGER WINDOW UP SHORT TO GROUND
- Symptom: *DRIVER WINDOW INOPERATIVE
- Symptom: *PASSENGER WINDOW INOPERATIVE
- Tire Pressure Monitoring
- Symptom: CRITICAL TIRE PRESSURE - BCM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM; LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM; RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM; RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM
- Symptom: TIRE PRESSURE LOW - BCM
- Symptom: TIRE PRESSURE MONITOR MODULE FAILURE - TPM
- Symptom: TPM DIAGNOSTIC - BCM
- Symptom: TPM MODULE INITIALIZED - BCM
- Symptom: *LO TIRE LCD MESSAGE FLASHING
- Symptom: VTSS INDICATOR OUTPUT OPEN
- Symptom: VTSS INDICATOR OUTPUT SHORT
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *DECKLID DOES NOT TRIP VTSS
- Symptom: *DRIVER DOOR DOES NOT TRIP VTSS
- Symptom: *EXTERIOR LAMPS FAIL TO FLASH WHEN ALARM IS TRIPPED
- Symptom: *HOOD DOES NOT TRIP VTSS
- Symptom: *HORN FAILS TO SOUND WHEN ALARM IS TRIPPED
- Symptom: *PASSENGER DOOR DOES NOT TRIP VTSS
- Symptom: *VTSS LAMP ON STEADY DURING ARMING
- Symptom: *VTSS WILL NOT ARM
- Verification Tests
- Air Bag
- Component Locations
- Connector PINOUTS
- A/C-Heater Control C1 - Black 10 Way
- A/C-Heater Control C2 - Black 16 Way
- Airbag Control Module C1 (Orc) - Yellow 32 Way
- Airbag Control Module C2 (Orc) Yellow 32 Way
- Airbag On/Off Switch-Passenger - Yellow 6 Way
- Airbag Squib 1-Driver - Yellow/Black 2 Way
- Airbag Squib 2-Driver - Yellow/Gray 2 Way
- Airbag Squib-Passenger - Yellow 4 Way
- Ajar Switch-DECKLID - Black 3 Way
- Ajar Switch-Driver Door - Black 4 Way
- Ajar Switch-Hood - Natural 3 Way
- Ajar Switch-Passenger Door - Black 4 Way
- Blend Door Actuator - Gray 2 Way
- Blower Motor - Orange 2 Way
- Blower Motor Resistor Block - Black 4 Way
- Body Control Module C1 - Black 6 Way
- Body Control Module C2 - Black/Green 34 Way
- Body Control Module C3 - Black/White 34 Way
- Body Control Module C4 - Black/Gray 34 Way
- Body Control Module C5 - Black/Black 34 Way
- Brake Fluid Level Switch - Black 2 Way
- C200 - Black (Body Side)
- C200 - Black (Instrument Panel Side)
- C201 - Yellow (Body Side)
- C201 - Yellow (Instrument Panel Side)
- C204 - (HVAC Jumper Side)
- C204 - (Instrument Panel Side)
- C206 - Red (Console Jumper Side)
- C206 - Red (Instrument Panel Side)
- CLOCKSPRING - White 8 Way
- Controller Antilock Brake - Black 24 Way
- Cylinder Unlock Switch-Driver - Black 2 Way
- Data Link Connector - Black 16 Way
- DECKLID Release Motor - Black 2 Way
- Door Latch Motor-Driver - 2 Way
- Door Latch Motor-Passenger - 2 Way
- Door Lock Switch-Driver - Black 3 Way
- Door Lock Switch-Passenger - Black 3 Way
- Exterior Door Handle Switch-Driver - Black 2 Way
- Exterior Door Handle Switch-Passenger Black 2 Way
- Fog Lamp-Left - Black 2 Way
- Gauge Cluster C1 - White 3 Way
- Gauge Cluster C2 - Black 20 Way
- Hid Lamp-Left - Gray 2 Way
- High Beam Headlamp-Left - Black 2 Way
- Horn-High Note - Black 2 Way
- Horn-Low Note - Black 2 Way
- Ignition Switch - Black 5 Way
- Instrument Cluster C1 - Black 16 Way
- Instrument Cluster C12 - Black 20 Way
- Interior Door Handle Switch-Driver - Black 2 Way
- Interior Door Handle Switch-Passenger - Black 2 Way
- Marker Lamp-Left Front - DK.Gray 2 Way
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way
- Multi-Function Switch - Gray 20 Way
- Park/Turn Lamp-Left - Black 3 Way
- Power Amplifier C1 - DK.Gray 14 Way
- Power Amplifier C2 - Green 16 Way
- Fuses (PDC)
- Power Window Motor-Driver - 6 Way
- Power Window Motor-Passenger - 6 Way
- Power Window Switch-Driver - Gray 3 Way
- Power Window Switch-Passenger - Gray 3 Way
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Radio - Gray 22 Way
- RECIRCULATION Door Actuator - Gray 2 Way
- Remote Keyless Entry Module - Black 6 Way
- Seat Belt Switch-Driver - White 2 Way
- Seat Belt Switch-Passenger - White 2 Way
- Seat Belt TENSIONER-Driver - Yellow 2 Way
- Seat Belt TENSIONER-Passenger - Yellow 2 Way
- Speaker-Left Door - Black 2 Way
- Speaker-Left Instrument Panel - White 2 Way
- Speaker-Left Rear - White 3 Way
- Speaker-Rear Woofer - Gray 4 Way
- Speaker-Right Door - Black 2 Way
- Speaker-Right Instrument Panel - White 2 Way
- Speaker-Right Rear - White 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Window Down Relay-Passenger - Black 5 Way
- Window Up Relay-Passenger - Black 5 Way
- Schematic Diagrams
- Airbag System
- Audio System
- Chime System
- Communication
- Door Ajar System
- Electrically Heated Systems
- Exterior Lighting
- Heating & A/C System
- Ignition, Power, Accessory
- Instrument Cluster/Gauge Cluster
- Interior Lighting
- Power Door Locks/RKE
- Power Window System
- Tire Pressure Monitor Module (TPM)
- Vehicle Theft Security System
- Electronic Control Modules
- Body Diagnostic Procedures
- Door Locks
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Body Control Module
- Chime Warning System
- Communication
- Door Ajar System
- Exterior Lighting System
- Relays Controlled By The BCM
- Heating & A/C System
- Instrument Cluster / Gauge Cluster
- Interior Lighting
- Tire Pressure Monitoring System (TPMS)
- Power Door Entry System
- Power Windows
- Electrically Heated Systems
- Vehicle Theft Security System
- Using The DRBIII®
- DRBIII® Error Messages
- DRBIII® Does Not Power Up (Blank Screen)
- Display Is Not Visible
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Air Bag
- Symptom List: ACCELEROMETER 1; ACCELEROMETER 2; INTERNAL 1; OUTPUT DRIVER 1; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: DRIVER SQUIB 2 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 2 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 2 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 2 SHORT TO GROUND
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH OPEN
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO BATTERY
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO GROUND
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO BATTERY
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: PASSENGER SQUIB 2 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 2 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 2 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 2 SHORT TO GROUND
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: All OUTPUTS SHORT
- Symptom List; CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH BCM
- Chime
- Communication
- Symptom: ACM MESSAGES NOT RECEIVED
- Symptom: AUDIO MESSAGES NOT RECEIVED
- Symptom: COUNTRY CODE NOT PROGRAMMED
- Symptom: INTERNAL BCM FAILURE
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom List: PCI BUS SHORTED TO BATTERY; PCI BUS SHORTED TO GROUND
- Symptom: PCI INTERNAL FAULT
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *NO RESPONSE FROM ACM
- Symptom: *NO RESPONSE FROM BODY CONTROL MODULE
- Symptom: *NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE
- Symptom: *NO RESPONSE FROM HVAC
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM PCM (PCI BUS)
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY)
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM TIRE PRESSURE MONITOR MODULE
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Door Ajar
- Symptom: *DECKLID AJAR CIRCUIT OPEN
- Symptom: *DECKLID AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *DRIVER DOOR AJAR CIRCUIT OPEN
- Symptom: *DRIVER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *HOOD AJAR CIRCUIT OPEN
- Symptom: *HOOD AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *PASSENGER DOOR AJAR CIRCUIT OPEN
- Symptom: *PASSENGER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Electrically Heated Systems
- Exterior Lighting
- Symptom: LEFT FOG LAMP OUTPUT OPEN
- Symptom: LEFT FOG LAMP OUTPUT SHORTED
- Symptom: LEFT HIGH BEAM OUTPUT OPEN
- Symptom: LEFT HIGH BEAM OUTPUT SHORT
- Symptom: LOW BEAM RELAY COIL OUTPUT OPEN/SHORT TO GROUND
- Symptom: LOW BEAM RELAY COIL SHORT TO VOLTAGE
- Symptom: PARK LAMP OUTPUT SHORT
- Symptom: RIGHT FOG LAMP OUTPUT OPEN
- Symptom: RIGHT FOG LAMP OUTPUT SHORTED
- Symptom: RIGHT HIGH BEAM OUTPUT OPEN
- Symptom: RIGHT HIGH BEAM OUTPUT SHORT
- Heating & A/C
- Symptom List: A/C SWITCH FAULT (ACTIVE); CHECKSUM FAILURE (ACTIVE); DEFOG SWITCH FAULT (ACTIVE)
- Symptom List: A/C SWITCH FAULT (STORED); BACKLIGHT DIMMING RX FAILURE (STORED); BLEND OVERCURRENT (STORED); CHECKSUM FAILURE (STORED); DEFOG SWITCH FAULT (STORED); LOOPBACK TEST FAILURE (STORED); MODE 1 OVERCURRENT (STORED); MODE 2 OVERCURRENT (STORED); RECIRC OVERCURRENT (STORED); REFRIGERANT PRESS RX FAILURE (STORED); TX FAILURE (STORED); VIN RX FAILURE (STORED)
- Notes
- When Monitored and Set Condition:
- A/C Switch Fault (Stored)
- Backlight Dimming RX Failure (Stored)
- Blend OVERCURRENT (Stored)
- Checksum Failure (Stored)
- Defog Switch Fault (Stored)
- LOOPBACK Test Failure (Stored)
- Mode 1 OVERCURRENT (Stored)
- Mode 2 OVERCURRENT (Stored)
- RECIRC OVERCURRENT (Stored)
- Refrigerant Press RX Failure (Stored)
- TX Failure (Stored)
- VIN RX Failure (Stored)
- Possible Causes
- Diagnostic Procedure
- Symptom List: ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE; BLEND CIRCUIT SHORTED TO GROUND; BLEND CIRCUIT SHORTED TO IGN OR BATT; COMMON DRIVER SHORTED TO GROUND; COMMON DRIVER SHORTED TO IGN OR BATT; MODE 1 CIRCUIT SHORTED TO GROUND; MODE 1 CIRCUIT SHORTED TO IGN OR BATT; MODE 2 CIRCUIT SHORTED TO GROUND; MODE 2 CIRCUIT SHORTED TO IGN OR BATT; RECIRC CIRCUIT SHORTED TO GROUND; RECIRC CIRCUIT SHORTED TO IGN OR BATT; SHORT TOO COMPLEX
- Notes
- When Monitored and Set Condition:
- Act CKT Test Passed, OVERCURRENT DTCS Active
- Blend Circuit Shorted To Ground
- Blend Circuit Shorted To IGN Or Batt
- Common Driver Shorted To Ground
- Common Driver Shorted To IGN Or Batt
- Mode 1 Circuit Shorted To Ground
- Mode 1 Circuit Shorted To IGN Or Batt
- Mode 2 Circuit Shorted To Ground
- Mode 2 Circuit Shorted To IGN Or Batt
- RECIRC Circuit Shorted To Ground
- RECIRC Circuit Shorted To IGN Or Batt
- Short Too Complex
- Possible Causes
- Diagnostic Procedure
- Symptom: BACKLIGHT DIMMING RX FAILURE (ACTIVE)
- Symptom List: BLEND CALIBRATION FAULT; MODE 1 CALIBRATION FAULT; MODE 2 CALIBRATION FAULT; RECIRCULATION CALIBRATION FAULT
- Symptom List: BLEND OVERCURRENT (ACTIVE); MODE 1 OVERCURRENT (ACTIVE); MODE 2 OVERCURRENT (ACTIVE); RECIRC OVERCURRENT (ACTIVE)
- Symptom: DEFOG RELAY CONTROL CKT SHORTED TO BATT
- Symptom: LOOPBACK TEST FAILURE (ACTIVE)
- Symptom List: REFRIGERANT PRESSURE RX FAILURE (ACTIVE); VIN RX FAILURE (ACTIVE)
- Symptom: TX FAILURE (ACTIVE)
- Symptom: *A/C - HEATER CONTROL ILLUMINATION INOPERATIVE
- Symptom: *BLEND/MODE/RECIRC DOOR OPERATION IMPROPER
- Symptom: *BLOWER MOTOR INOPERATIVE
- Symptom: *BLOWER MOTOR SPEEDS INCORRECT
- Symptom: *EBL STATUS INDICATOR FLASHING
- Symptom: *HVAC SYSTEM TEST
- Ignition, Power, Accessory
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT OPEN
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT SHORT TO GROUND
- Symptom: BCM - IGNITION MUX SWITCH INPUT MISMATCH
- Symptom: BCM - IGNITION MUX SWITCH INPUT OPEN
- Symptom: BCM - IGNITION MUX SWITCH INPUT SHORT
- Symptom: BCM - IGNITION RUN 1 SHORT
- Symptom: BCM - IGNITION RUN 2 SHORT
- Symptom: BCM - IOD OUTPUT CIRCUIT SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT OPEN / SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT SHORT TO VOLTAGE
- Symptom: BCM - RUN/START HARDWIRE INPUT MISMATCH
- Symptom: HORN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: HORN RELAY COIL SHORT TO BATTERY
- Symptom: HORN SWITCH STUCK
- Symptom: *HORNS INOPERATIVE
- Instrument Cluster
- Symptom List: ABS LAMP CIRCUIT OPEN; ABS LAMP CIRCUIT SHORTED; AIRBAG LAMP CIRCUIT OPEN; AIRBAG LAMP CIRCUIT SHORTED
- Symptom: ABS MESSAGES NOT RECEIVED
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT OPEN / SHORTED TO VOLTAGE
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT SHORT TO GROUND
- Symptom: BCM - PWM DIMMING OUTPUT SHORT
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: ORC MESSAGES NOT RECEIVED
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *GAUGE CLUSTER DIAGNOSTIC TEST
- Symptom: *INSTRUMENT CLUSTER DIAGNOSTIC TEST
- Interior Lighting
- Power Door Locks/RKE
- Symptom: DECKLID RELEASE OUTPUT OPEN
- Symptom: DECKLID RELEASE OUTPUT SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH OPEN OR SHORT TO VOLTAGE
- Symptom: DRIVER CYLINDER UNLOCK SWITCH SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH STUCK
- Symptom: DRIVER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: DRIVER DOOR LOCK SWITCH STUCK
- Symptom: DRIVER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: DRIVER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: DRIVER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER DOOR LOCK SWITCH STUCK
- Symptom: PASSENGER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER/DRIVER DOOR UNLATCH RETURN SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT OPEN/SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT SHORT TO BATTERY
- Symptom: *ALL DOOR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR UNLATCH INOPERATIVE
- Symptom: *PASSENGER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *PASSENGER DOOR UNLATCH INOPERATIVE
- Symptom: *REMOTE KEYLESS ENTRY PROBLEM
- Power Windows
- Symptom: DRIVER WINDOW DOWN OUTPUT SHORT TO GROUND
- Symptom: DRIVER WINDOW HALL EFFECT FAILURE
- Symptom: DRIVER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: DRIVER WINDOW SWITCH SHORT TO GROUND
- Symptom: DRIVER WINDOW SWITCH STUCK DOWN
- Symptom: DRIVER WINDOW SWITCH STUCK UP
- Symptom: DRIVER WINDOW UP OUTPUT SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL SHORT TO BATTERY
- Symptom: PASSENGER WINDOW HALL EFFECT FAILURE
- Symptom: PASSENGER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: PASSENGER WINDOW SWITCH SHORT TO GROUND
- Symptom: PASSENGER WINDOW SWITCH STUCK DOWN
- Symptom: PASSENGER WINDOW SWITCH STUCK UP
- Symptom: PASSENGER WINDOW UP SHORT TO GROUND
- Symptom: *DRIVER WINDOW INOPERATIVE
- Symptom: *PASSENGER WINDOW INOPERATIVE
- Tire Pressure Monitoring
- Symptom: CRITICAL TIRE PRESSURE - BCM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM; LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM; RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM; RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM
- Symptom: TIRE PRESSURE LOW - BCM
- Symptom: TIRE PRESSURE MONITOR MODULE FAILURE - TPM
- Symptom: TPM DIAGNOSTIC - BCM
- Symptom: TPM MODULE INITIALIZED - BCM
- Symptom: *LO TIRE LCD MESSAGE FLASHING
- Symptom: VTSS INDICATOR OUTPUT OPEN
- Symptom: VTSS INDICATOR OUTPUT SHORT
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *DECKLID DOES NOT TRIP VTSS
- Symptom: *DRIVER DOOR DOES NOT TRIP VTSS
- Symptom: *EXTERIOR LAMPS FAIL TO FLASH WHEN ALARM IS TRIPPED
- Symptom: *HOOD DOES NOT TRIP VTSS
- Symptom: *HORN FAILS TO SOUND WHEN ALARM IS TRIPPED
- Symptom: *PASSENGER DOOR DOES NOT TRIP VTSS
- Symptom: *VTSS LAMP ON STEADY DURING ARMING
- Symptom: *VTSS WILL NOT ARM
- Verification Tests
- Air Bag
- Component Locations
- Connector PINOUTS
- A/C-Heater Control C1 - Black 10 Way
- A/C-Heater Control C2 - Black 16 Way
- Airbag Control Module C1 (Orc) - Yellow 32 Way
- Airbag Control Module C2 (Orc) Yellow 32 Way
- Airbag On/Off Switch-Passenger - Yellow 6 Way
- Airbag Squib 1-Driver - Yellow/Black 2 Way
- Airbag Squib 2-Driver - Yellow/Gray 2 Way
- Airbag Squib-Passenger - Yellow 4 Way
- Ajar Switch-DECKLID - Black 3 Way
- Ajar Switch-Driver Door - Black 4 Way
- Ajar Switch-Hood - Natural 3 Way
- Ajar Switch-Passenger Door - Black 4 Way
- Blend Door Actuator - Gray 2 Way
- Blower Motor - Orange 2 Way
- Blower Motor Resistor Block - Black 4 Way
- Body Control Module C1 - Black 6 Way
- Body Control Module C2 - Black/Green 34 Way
- Body Control Module C3 - Black/White 34 Way
- Body Control Module C4 - Black/Gray 34 Way
- Body Control Module C5 - Black/Black 34 Way
- Brake Fluid Level Switch - Black 2 Way
- C200 - Black (Body Side)
- C200 - Black (Instrument Panel Side)
- C201 - Yellow (Body Side)
- C201 - Yellow (Instrument Panel Side)
- C204 - (HVAC Jumper Side)
- C204 - (Instrument Panel Side)
- C206 - Red (Console Jumper Side)
- C206 - Red (Instrument Panel Side)
- CLOCKSPRING - White 8 Way
- Controller Antilock Brake - Black 24 Way
- Cylinder Unlock Switch-Driver - Black 2 Way
- Data Link Connector - Black 16 Way
- DECKLID Release Motor - Black 2 Way
- Door Latch Motor-Driver - 2 Way
- Door Latch Motor-Passenger - 2 Way
- Door Lock Switch-Driver - Black 3 Way
- Door Lock Switch-Passenger - Black 3 Way
- Exterior Door Handle Switch-Driver - Black 2 Way
- Exterior Door Handle Switch-Passenger Black 2 Way
- Fog Lamp-Left - Black 2 Way
- Gauge Cluster C1 - White 3 Way
- Gauge Cluster C2 - Black 20 Way
- Hid Lamp-Left - Gray 2 Way
- High Beam Headlamp-Left - Black 2 Way
- Horn-High Note - Black 2 Way
- Horn-Low Note - Black 2 Way
- Ignition Switch - Black 5 Way
- Instrument Cluster C1 - Black 16 Way
- Instrument Cluster C12 - Black 20 Way
- Interior Door Handle Switch-Driver - Black 2 Way
- Interior Door Handle Switch-Passenger - Black 2 Way
- Marker Lamp-Left Front - DK.Gray 2 Way
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way
- Multi-Function Switch - Gray 20 Way
- Park/Turn Lamp-Left - Black 3 Way
- Power Amplifier C1 - DK.Gray 14 Way
- Power Amplifier C2 - Green 16 Way
- Fuses (PDC)
- Power Window Motor-Driver - 6 Way
- Power Window Motor-Passenger - 6 Way
- Power Window Switch-Driver - Gray 3 Way
- Power Window Switch-Passenger - Gray 3 Way
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Radio - Gray 22 Way
- RECIRCULATION Door Actuator - Gray 2 Way
- Remote Keyless Entry Module - Black 6 Way
- Seat Belt Switch-Driver - White 2 Way
- Seat Belt Switch-Passenger - White 2 Way
- Seat Belt TENSIONER-Driver - Yellow 2 Way
- Seat Belt TENSIONER-Passenger - Yellow 2 Way
- Speaker-Left Door - Black 2 Way
- Speaker-Left Instrument Panel - White 2 Way
- Speaker-Left Rear - White 3 Way
- Speaker-Rear Woofer - Gray 4 Way
- Speaker-Right Door - Black 2 Way
- Speaker-Right Instrument Panel - White 2 Way
- Speaker-Right Rear - White 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Window Down Relay-Passenger - Black 5 Way
- Window Up Relay-Passenger - Black 5 Way
- Schematic Diagrams
- Airbag System
- Audio System
- Chime System
- Communication
- Door Ajar System
- Electrically Heated Systems
- Exterior Lighting
- Heating & A/C System
- Ignition, Power, Accessory
- Instrument Cluster/Gauge Cluster
- Interior Lighting
- Power Door Locks/RKE
- Power Window System
- Tire Pressure Monitor Module (TPM)
- Vehicle Theft Security System
- Door - Front
- Power Door Locks (Service Information)
- Power Locks
- Door Cylinder Unlock Switch
- Exterior Door Handle Switch
- Interior Door Handle Switch
- Power Lock Switch
- Remote Keyless Entry Module
- Remote Keyless Entry Transmitter
- Diagnosis And Testing - Remote Keyless Entry Transmitter
- Standard Procedure
- Specifications - Remote Keyless Entry Transmitter
- Vehicle Theft Security
- Body Diagnostic Procedures
- Exterior Body Panels
- Body Panel Repair
- Warning
- Diagnosis And Testing
- Standard Procedure
- Standard Procedure - Plastic Body Panel Repair
- Notes
- Rigid Plastics:
- Semi-Rigid Plastics:
- Flexible Plastics:
- Repair Procedure:
- Adhesion Promoter/Surface Modifier:
- Safety Precaution And Warnings
- Rigid, Semi-Rigid, And Flexible Plastic Parts Types
- Panel Sectioning
- Panel Reinforcement
- Visual Inspection
- Panel Surface Preparation
- Patching Panels
- Panel Patch Fabrications
- Panel Patch Installation
- Patched Panel Surfacing
- Standard Procedure - Heat Staking
- Standard Procedure - Plastic Body Panel Repair
- Specifications
- Special Tools
- Body Structure
- Gap And Flush
- Opening Dimensions
- Sealer Locations
- Structural Adhesive Locations
- Weld Locations
- Specifications
- Weld Locations
- Front Frame Structure (1 Of 4)
- Front Frame Structure (2 Of 4)
- Front Frame Structure (3 Of 4)
- Front Frame Structure (4 Of 4)
- Floor Pan (1 Of 5)
- Floor Pan (2 Of 5)
- Floor Pan (3 Of 5)
- Floor Pan (4 Of 5)
- Floor Pan (5 Of 5)
- Rear Frame (1 Of 5)
- Rear Frame (2 Of 5)
- Rear Frame (3 Of 5)
- Rear Frame (4 Of 5)
- Rear Frame (5 Of 5)
- Weld Locations
- Specifications
- DECKLID
- Exterior Trim
- Frame & Bumpers
- Frame & Bumpers
- Front Fascia
- Front Bumper Reinforcement
- Rear Fascia
- Rear Bumper Foam
- Rear Bumper
- Frame
- Warning
- Standard Procedure - Frame Damage Repair
- Specifications
- Frame Dimensions
- Notes
- Vehicle Preparation
- Notes
- X, Y, And Z Planes
- Frame Side View - Front Section - Z Dimensions
- Frame Side View - Rear Section - Z Dimensions
- Frame Side View - Front Section - X Dimensions
- Frame Side View - Rear Section - X Dimensions
- Frame Top View - Front Section - X And Y Dimensions
- Frame Top View - Rear Section - X And Y Dimensions
- Front Suspension Mounting Angles
- Rear Suspension Mounting Angles
- Specifications - Welding
- Frame Dimensions
- Rear Transmission CROSSMEMBER
- Hood
- Paint & Body (Service Information)
- Weatherstrip/Seals
- Body Panel Repair
- Exterior/Interior Trim
- Body Panel Repair
- Warning
- Diagnosis And Testing
- Standard Procedure
- Standard Procedure - Plastic Body Panel Repair
- Notes
- Rigid Plastics:
- Semi-Rigid Plastics:
- Flexible Plastics:
- Repair Procedure:
- Adhesion Promoter/Surface Modifier:
- Safety Precaution And Warnings
- Rigid, Semi-Rigid, And Flexible Plastic Parts Types
- Panel Sectioning
- Panel Reinforcement
- Visual Inspection
- Panel Surface Preparation
- Patching Panels
- Panel Patch Fabrications
- Panel Patch Installation
- Patched Panel Surfacing
- Standard Procedure - Heat Staking
- Standard Procedure - Plastic Body Panel Repair
- Specifications
- Special Tools
- DECKLID
- Door - Front
- Instrument Panel
- Interior
- Body Panel Repair
- Frames, Subframes & Crossmembers
- Frame & Bumpers
- Frame & Bumpers
- Front Fascia
- Front Bumper Reinforcement
- Rear Fascia
- Rear Bumper Foam
- Rear Bumper
- Frame
- Warning
- Standard Procedure - Frame Damage Repair
- Specifications
- Frame Dimensions
- Notes
- Vehicle Preparation
- Notes
- X, Y, And Z Planes
- Frame Side View - Front Section - Z Dimensions
- Frame Side View - Rear Section - Z Dimensions
- Frame Side View - Front Section - X Dimensions
- Frame Side View - Rear Section - X Dimensions
- Frame Top View - Front Section - X And Y Dimensions
- Frame Top View - Rear Section - X And Y Dimensions
- Front Suspension Mounting Angles
- Rear Suspension Mounting Angles
- Specifications - Welding
- Frame Dimensions
- Rear Transmission CROSSMEMBER
- Frame & Bumpers
- Mirrors
- Exterior Trim
- Interior
- Power Mirrors
- Seats
- Sun Roof/T-Top/Convertible Top
- Windows
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Body Control Module
- Chime Warning System
- Communication
- Door Ajar System
- Exterior Lighting System
- Relays Controlled By The BCM
- Heating & A/C System
- Instrument Cluster / Gauge Cluster
- Interior Lighting
- Tire Pressure Monitoring System (TPMS)
- Power Door Entry System
- Power Windows
- Electrically Heated Systems
- Vehicle Theft Security System
- Using The DRBIII®
- DRBIII® Error Messages
- DRBIII® Does Not Power Up (Blank Screen)
- Display Is Not Visible
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Air Bag
- Symptom List: ACCELEROMETER 1; ACCELEROMETER 2; INTERNAL 1; OUTPUT DRIVER 1; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: DRIVER SQUIB 2 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 2 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 2 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 2 SHORT TO GROUND
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH OPEN
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO BATTERY
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO GROUND
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO BATTERY
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: PASSENGER SQUIB 2 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 2 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 2 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 2 SHORT TO GROUND
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: All OUTPUTS SHORT
- Symptom List; CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH BCM
- Chime
- Communication
- Symptom: ACM MESSAGES NOT RECEIVED
- Symptom: AUDIO MESSAGES NOT RECEIVED
- Symptom: COUNTRY CODE NOT PROGRAMMED
- Symptom: INTERNAL BCM FAILURE
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom List: PCI BUS SHORTED TO BATTERY; PCI BUS SHORTED TO GROUND
- Symptom: PCI INTERNAL FAULT
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *NO RESPONSE FROM ACM
- Symptom: *NO RESPONSE FROM BODY CONTROL MODULE
- Symptom: *NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE
- Symptom: *NO RESPONSE FROM HVAC
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM PCM (PCI BUS)
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY)
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM TIRE PRESSURE MONITOR MODULE
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Door Ajar
- Symptom: *DECKLID AJAR CIRCUIT OPEN
- Symptom: *DECKLID AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *DRIVER DOOR AJAR CIRCUIT OPEN
- Symptom: *DRIVER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *HOOD AJAR CIRCUIT OPEN
- Symptom: *HOOD AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *PASSENGER DOOR AJAR CIRCUIT OPEN
- Symptom: *PASSENGER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Electrically Heated Systems
- Exterior Lighting
- Symptom: LEFT FOG LAMP OUTPUT OPEN
- Symptom: LEFT FOG LAMP OUTPUT SHORTED
- Symptom: LEFT HIGH BEAM OUTPUT OPEN
- Symptom: LEFT HIGH BEAM OUTPUT SHORT
- Symptom: LOW BEAM RELAY COIL OUTPUT OPEN/SHORT TO GROUND
- Symptom: LOW BEAM RELAY COIL SHORT TO VOLTAGE
- Symptom: PARK LAMP OUTPUT SHORT
- Symptom: RIGHT FOG LAMP OUTPUT OPEN
- Symptom: RIGHT FOG LAMP OUTPUT SHORTED
- Symptom: RIGHT HIGH BEAM OUTPUT OPEN
- Symptom: RIGHT HIGH BEAM OUTPUT SHORT
- Heating & A/C
- Symptom List: A/C SWITCH FAULT (ACTIVE); CHECKSUM FAILURE (ACTIVE); DEFOG SWITCH FAULT (ACTIVE)
- Symptom List: A/C SWITCH FAULT (STORED); BACKLIGHT DIMMING RX FAILURE (STORED); BLEND OVERCURRENT (STORED); CHECKSUM FAILURE (STORED); DEFOG SWITCH FAULT (STORED); LOOPBACK TEST FAILURE (STORED); MODE 1 OVERCURRENT (STORED); MODE 2 OVERCURRENT (STORED); RECIRC OVERCURRENT (STORED); REFRIGERANT PRESS RX FAILURE (STORED); TX FAILURE (STORED); VIN RX FAILURE (STORED)
- Notes
- When Monitored and Set Condition:
- A/C Switch Fault (Stored)
- Backlight Dimming RX Failure (Stored)
- Blend OVERCURRENT (Stored)
- Checksum Failure (Stored)
- Defog Switch Fault (Stored)
- LOOPBACK Test Failure (Stored)
- Mode 1 OVERCURRENT (Stored)
- Mode 2 OVERCURRENT (Stored)
- RECIRC OVERCURRENT (Stored)
- Refrigerant Press RX Failure (Stored)
- TX Failure (Stored)
- VIN RX Failure (Stored)
- Possible Causes
- Diagnostic Procedure
- Symptom List: ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE; BLEND CIRCUIT SHORTED TO GROUND; BLEND CIRCUIT SHORTED TO IGN OR BATT; COMMON DRIVER SHORTED TO GROUND; COMMON DRIVER SHORTED TO IGN OR BATT; MODE 1 CIRCUIT SHORTED TO GROUND; MODE 1 CIRCUIT SHORTED TO IGN OR BATT; MODE 2 CIRCUIT SHORTED TO GROUND; MODE 2 CIRCUIT SHORTED TO IGN OR BATT; RECIRC CIRCUIT SHORTED TO GROUND; RECIRC CIRCUIT SHORTED TO IGN OR BATT; SHORT TOO COMPLEX
- Notes
- When Monitored and Set Condition:
- Act CKT Test Passed, OVERCURRENT DTCS Active
- Blend Circuit Shorted To Ground
- Blend Circuit Shorted To IGN Or Batt
- Common Driver Shorted To Ground
- Common Driver Shorted To IGN Or Batt
- Mode 1 Circuit Shorted To Ground
- Mode 1 Circuit Shorted To IGN Or Batt
- Mode 2 Circuit Shorted To Ground
- Mode 2 Circuit Shorted To IGN Or Batt
- RECIRC Circuit Shorted To Ground
- RECIRC Circuit Shorted To IGN Or Batt
- Short Too Complex
- Possible Causes
- Diagnostic Procedure
- Symptom: BACKLIGHT DIMMING RX FAILURE (ACTIVE)
- Symptom List: BLEND CALIBRATION FAULT; MODE 1 CALIBRATION FAULT; MODE 2 CALIBRATION FAULT; RECIRCULATION CALIBRATION FAULT
- Symptom List: BLEND OVERCURRENT (ACTIVE); MODE 1 OVERCURRENT (ACTIVE); MODE 2 OVERCURRENT (ACTIVE); RECIRC OVERCURRENT (ACTIVE)
- Symptom: DEFOG RELAY CONTROL CKT SHORTED TO BATT
- Symptom: LOOPBACK TEST FAILURE (ACTIVE)
- Symptom List: REFRIGERANT PRESSURE RX FAILURE (ACTIVE); VIN RX FAILURE (ACTIVE)
- Symptom: TX FAILURE (ACTIVE)
- Symptom: *A/C - HEATER CONTROL ILLUMINATION INOPERATIVE
- Symptom: *BLEND/MODE/RECIRC DOOR OPERATION IMPROPER
- Symptom: *BLOWER MOTOR INOPERATIVE
- Symptom: *BLOWER MOTOR SPEEDS INCORRECT
- Symptom: *EBL STATUS INDICATOR FLASHING
- Symptom: *HVAC SYSTEM TEST
- Ignition, Power, Accessory
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT OPEN
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT SHORT TO GROUND
- Symptom: BCM - IGNITION MUX SWITCH INPUT MISMATCH
- Symptom: BCM - IGNITION MUX SWITCH INPUT OPEN
- Symptom: BCM - IGNITION MUX SWITCH INPUT SHORT
- Symptom: BCM - IGNITION RUN 1 SHORT
- Symptom: BCM - IGNITION RUN 2 SHORT
- Symptom: BCM - IOD OUTPUT CIRCUIT SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT OPEN / SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT SHORT TO VOLTAGE
- Symptom: BCM - RUN/START HARDWIRE INPUT MISMATCH
- Symptom: HORN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: HORN RELAY COIL SHORT TO BATTERY
- Symptom: HORN SWITCH STUCK
- Symptom: *HORNS INOPERATIVE
- Instrument Cluster
- Symptom List: ABS LAMP CIRCUIT OPEN; ABS LAMP CIRCUIT SHORTED; AIRBAG LAMP CIRCUIT OPEN; AIRBAG LAMP CIRCUIT SHORTED
- Symptom: ABS MESSAGES NOT RECEIVED
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT OPEN / SHORTED TO VOLTAGE
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT SHORT TO GROUND
- Symptom: BCM - PWM DIMMING OUTPUT SHORT
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: ORC MESSAGES NOT RECEIVED
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *GAUGE CLUSTER DIAGNOSTIC TEST
- Symptom: *INSTRUMENT CLUSTER DIAGNOSTIC TEST
- Interior Lighting
- Power Door Locks/RKE
- Symptom: DECKLID RELEASE OUTPUT OPEN
- Symptom: DECKLID RELEASE OUTPUT SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH OPEN OR SHORT TO VOLTAGE
- Symptom: DRIVER CYLINDER UNLOCK SWITCH SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH STUCK
- Symptom: DRIVER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: DRIVER DOOR LOCK SWITCH STUCK
- Symptom: DRIVER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: DRIVER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: DRIVER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER DOOR LOCK SWITCH STUCK
- Symptom: PASSENGER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER/DRIVER DOOR UNLATCH RETURN SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT OPEN/SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT SHORT TO BATTERY
- Symptom: *ALL DOOR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR UNLATCH INOPERATIVE
- Symptom: *PASSENGER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *PASSENGER DOOR UNLATCH INOPERATIVE
- Symptom: *REMOTE KEYLESS ENTRY PROBLEM
- Power Windows
- Symptom: DRIVER WINDOW DOWN OUTPUT SHORT TO GROUND
- Symptom: DRIVER WINDOW HALL EFFECT FAILURE
- Symptom: DRIVER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: DRIVER WINDOW SWITCH SHORT TO GROUND
- Symptom: DRIVER WINDOW SWITCH STUCK DOWN
- Symptom: DRIVER WINDOW SWITCH STUCK UP
- Symptom: DRIVER WINDOW UP OUTPUT SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL SHORT TO BATTERY
- Symptom: PASSENGER WINDOW HALL EFFECT FAILURE
- Symptom: PASSENGER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: PASSENGER WINDOW SWITCH SHORT TO GROUND
- Symptom: PASSENGER WINDOW SWITCH STUCK DOWN
- Symptom: PASSENGER WINDOW SWITCH STUCK UP
- Symptom: PASSENGER WINDOW UP SHORT TO GROUND
- Symptom: *DRIVER WINDOW INOPERATIVE
- Symptom: *PASSENGER WINDOW INOPERATIVE
- Tire Pressure Monitoring
- Symptom: CRITICAL TIRE PRESSURE - BCM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM; LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM; RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM; RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM
- Symptom: TIRE PRESSURE LOW - BCM
- Symptom: TIRE PRESSURE MONITOR MODULE FAILURE - TPM
- Symptom: TPM DIAGNOSTIC - BCM
- Symptom: TPM MODULE INITIALIZED - BCM
- Symptom: *LO TIRE LCD MESSAGE FLASHING
- Symptom: VTSS INDICATOR OUTPUT OPEN
- Symptom: VTSS INDICATOR OUTPUT SHORT
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *DECKLID DOES NOT TRIP VTSS
- Symptom: *DRIVER DOOR DOES NOT TRIP VTSS
- Symptom: *EXTERIOR LAMPS FAIL TO FLASH WHEN ALARM IS TRIPPED
- Symptom: *HOOD DOES NOT TRIP VTSS
- Symptom: *HORN FAILS TO SOUND WHEN ALARM IS TRIPPED
- Symptom: *PASSENGER DOOR DOES NOT TRIP VTSS
- Symptom: *VTSS LAMP ON STEADY DURING ARMING
- Symptom: *VTSS WILL NOT ARM
- Verification Tests
- Air Bag
- Component Locations
- Connector PINOUTS
- A/C-Heater Control C1 - Black 10 Way
- A/C-Heater Control C2 - Black 16 Way
- Airbag Control Module C1 (Orc) - Yellow 32 Way
- Airbag Control Module C2 (Orc) Yellow 32 Way
- Airbag On/Off Switch-Passenger - Yellow 6 Way
- Airbag Squib 1-Driver - Yellow/Black 2 Way
- Airbag Squib 2-Driver - Yellow/Gray 2 Way
- Airbag Squib-Passenger - Yellow 4 Way
- Ajar Switch-DECKLID - Black 3 Way
- Ajar Switch-Driver Door - Black 4 Way
- Ajar Switch-Hood - Natural 3 Way
- Ajar Switch-Passenger Door - Black 4 Way
- Blend Door Actuator - Gray 2 Way
- Blower Motor - Orange 2 Way
- Blower Motor Resistor Block - Black 4 Way
- Body Control Module C1 - Black 6 Way
- Body Control Module C2 - Black/Green 34 Way
- Body Control Module C3 - Black/White 34 Way
- Body Control Module C4 - Black/Gray 34 Way
- Body Control Module C5 - Black/Black 34 Way
- Brake Fluid Level Switch - Black 2 Way
- C200 - Black (Body Side)
- C200 - Black (Instrument Panel Side)
- C201 - Yellow (Body Side)
- C201 - Yellow (Instrument Panel Side)
- C204 - (HVAC Jumper Side)
- C204 - (Instrument Panel Side)
- C206 - Red (Console Jumper Side)
- C206 - Red (Instrument Panel Side)
- CLOCKSPRING - White 8 Way
- Controller Antilock Brake - Black 24 Way
- Cylinder Unlock Switch-Driver - Black 2 Way
- Data Link Connector - Black 16 Way
- DECKLID Release Motor - Black 2 Way
- Door Latch Motor-Driver - 2 Way
- Door Latch Motor-Passenger - 2 Way
- Door Lock Switch-Driver - Black 3 Way
- Door Lock Switch-Passenger - Black 3 Way
- Exterior Door Handle Switch-Driver - Black 2 Way
- Exterior Door Handle Switch-Passenger Black 2 Way
- Fog Lamp-Left - Black 2 Way
- Gauge Cluster C1 - White 3 Way
- Gauge Cluster C2 - Black 20 Way
- Hid Lamp-Left - Gray 2 Way
- High Beam Headlamp-Left - Black 2 Way
- Horn-High Note - Black 2 Way
- Horn-Low Note - Black 2 Way
- Ignition Switch - Black 5 Way
- Instrument Cluster C1 - Black 16 Way
- Instrument Cluster C12 - Black 20 Way
- Interior Door Handle Switch-Driver - Black 2 Way
- Interior Door Handle Switch-Passenger - Black 2 Way
- Marker Lamp-Left Front - DK.Gray 2 Way
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way
- Multi-Function Switch - Gray 20 Way
- Park/Turn Lamp-Left - Black 3 Way
- Power Amplifier C1 - DK.Gray 14 Way
- Power Amplifier C2 - Green 16 Way
- Fuses (PDC)
- Power Window Motor-Driver - 6 Way
- Power Window Motor-Passenger - 6 Way
- Power Window Switch-Driver - Gray 3 Way
- Power Window Switch-Passenger - Gray 3 Way
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Radio - Gray 22 Way
- RECIRCULATION Door Actuator - Gray 2 Way
- Remote Keyless Entry Module - Black 6 Way
- Seat Belt Switch-Driver - White 2 Way
- Seat Belt Switch-Passenger - White 2 Way
- Seat Belt TENSIONER-Driver - Yellow 2 Way
- Seat Belt TENSIONER-Passenger - Yellow 2 Way
- Speaker-Left Door - Black 2 Way
- Speaker-Left Instrument Panel - White 2 Way
- Speaker-Left Rear - White 3 Way
- Speaker-Rear Woofer - Gray 4 Way
- Speaker-Right Door - Black 2 Way
- Speaker-Right Instrument Panel - White 2 Way
- Speaker-Right Rear - White 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Window Down Relay-Passenger - Black 5 Way
- Window Up Relay-Passenger - Black 5 Way
- Schematic Diagrams
- Airbag System
- Audio System
- Chime System
- Communication
- Door Ajar System
- Electrically Heated Systems
- Exterior Lighting
- Heating & A/C System
- Ignition, Power, Accessory
- Instrument Cluster/Gauge Cluster
- Interior Lighting
- Power Door Locks/RKE
- Power Window System
- Tire Pressure Monitor Module (TPM)
- Vehicle Theft Security System
- Door - Front
- Power Window System
- Stationary Glass
- Body Diagnostic Procedures
- Body, Cab Control Systems
- Brakes
- Anti-Lock Brakes
- Brake System - Abs
- Chassis Diagnostic Procedures - Anti-Lock Brake System
- Introduction
- Identification Of System
- System Description And Functional Operation
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Notes
- Brakes (Cab) - Symptoms
- Symptom: BUS SYSTEM COMMUNICATION
- Symptom: CAB INTERNAL FAILURE
- Symptom: CLUSTER LAMP FAILURE
- Symptom: INCORRECT TONE WHEEL FAILURE
- Symptom List: LEFT FRONT SENSOR CIRCUIT FAILURE; LEFT REAR SENSOR CIRCUIT FAILURE; RIGHT FRONT SENSOR CIRCUIT FAILURE; RIGHT REAR SENSOR CIRCUIT FAILURE
- Symptom List: LEFT FRONT WHEEL SPEED SIGNAL FAILURE; LEFT REAR WHEEL SPEED SIGNAL FAILURE; RIGHT FRONT WHEEL SPEED SIGNAL FAILURE; RIGHT REAR WHEEL SPEED SIGNAL FAILURE
- Symptom: PUMP CIRCUIT FAILURE
- Symptom: SYSTEM OVER VOLTAGE
- Symptom: SYSTEM UNDER VOLTAGE
- Symptom: VALVE POWER FEED FAILURE
- Symptom: *BRAKE LAMP SWITCH INOPERATIVE
- Communication - Symptoms
- Verification Tests
- Component Locations
- Schematic Diagrams
- Electronic Control Modules
- Mechanical - Hydraulic
- Disc Brakes
- Description & Operation
- Bleeding Brake System
- Adjustments
- Symptom Diagnosis
- Removal & Installation
- Adjustable Pedals Switch
- Front Brake Calipers
- Rear Brake Calipers
- Disc Brake Caliper Adapter
- Disc Brake Caliper Guide
- Brake Pads/Shoes - Front/Rear
- Brake Rotors
- Brake Fluid Level Switch
- Master Cylinder
- Fluid Reservoir
- Brake Booster
- Pedal Assembly (Adjustable)
- Parking Brake Cable
- Parking Brake Caliper
- Parking Brake Lever
- Parking Brake Pads/Shoes
- Overhaul
- Brake System Specifications
- Torque Specifications
- Disc Brakes
- Parking Brake System
- Disc Brakes
- Description & Operation
- Bleeding Brake System
- Adjustments
- Symptom Diagnosis
- Removal & Installation
- Adjustable Pedals Switch
- Front Brake Calipers
- Rear Brake Calipers
- Disc Brake Caliper Adapter
- Disc Brake Caliper Guide
- Brake Pads/Shoes - Front/Rear
- Brake Rotors
- Brake Fluid Level Switch
- Master Cylinder
- Fluid Reservoir
- Brake Booster
- Pedal Assembly (Adjustable)
- Parking Brake Cable
- Parking Brake Caliper
- Parking Brake Lever
- Parking Brake Pads/Shoes
- Overhaul
- Brake System Specifications
- Torque Specifications
- Disc Brakes
- Traction Control
- Brake System - Abs
- Chassis Diagnostic Procedures - Anti-Lock Brake System
- Introduction
- Identification Of System
- System Description And Functional Operation
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Notes
- Brakes (Cab) - Symptoms
- Symptom: BUS SYSTEM COMMUNICATION
- Symptom: CAB INTERNAL FAILURE
- Symptom: CLUSTER LAMP FAILURE
- Symptom: INCORRECT TONE WHEEL FAILURE
- Symptom List: LEFT FRONT SENSOR CIRCUIT FAILURE; LEFT REAR SENSOR CIRCUIT FAILURE; RIGHT FRONT SENSOR CIRCUIT FAILURE; RIGHT REAR SENSOR CIRCUIT FAILURE
- Symptom List: LEFT FRONT WHEEL SPEED SIGNAL FAILURE; LEFT REAR WHEEL SPEED SIGNAL FAILURE; RIGHT FRONT WHEEL SPEED SIGNAL FAILURE; RIGHT REAR WHEEL SPEED SIGNAL FAILURE
- Symptom: PUMP CIRCUIT FAILURE
- Symptom: SYSTEM OVER VOLTAGE
- Symptom: SYSTEM UNDER VOLTAGE
- Symptom: VALVE POWER FEED FAILURE
- Symptom: *BRAKE LAMP SWITCH INOPERATIVE
- Communication - Symptoms
- Verification Tests
- Component Locations
- Schematic Diagrams
- Electronic Control Modules
- Anti-Lock Brakes
- Drivelines & Axles
- Electrical
- Body Electrical
- Connector End Views
- Connector End Views
- A/C Compressor Clutch - Black 2 Way Connector End View
- A/C Low Pressure Switch - DK. Green 2 Way Connector End View
- A/C Pressure Transducer - Black 4 Way Connector End View
- A/C-Heater Control C1 - Black 10 Way Connector End View
- A/C-Heater Control C2 - Black 16 Way Connector End View
- Adjustable Pedals Motor - White 2 Way Connector End View
- Adjustable Pedals Switch - White 6 Way Connector End View
- Airbag Control Module C1 (Orc) - Yellow 32 Way Connector End View
- Airbag Control Module C2 (Orc) - Yellow 32 Way Connector End View
- Airbag On/Off Switch-Passenger - Yellow 6 Way Connector End View
- Airbag Squib 1-Driver - Yellow/Black 2 Way Connector End View
- Airbag Squib 2-Driver - Yellow/Gray 2 Way Connector End View
- Airbag Squib-Passenger - Yellow 4 Way Connector End View
- Ajar Switch-DECKLID - Black 3 Way Connector End View
- Ajar Switch-Driver Door - Black 4 Way Connector End View
- Ajar Switch-Hood - Natural 3 Way Connector End View
- Ajar Switch-Passenger Door - Black 4 Way Connector End View
- Back-Up Lamp Switch - Brown 2 Way Connector End View
- Back-Up Lamp-Left - Gray 3 Way Connector End View
- Back-Up Lamp-Right - Gray 3 Way Connector End View
- Battery Temperature Sensor - 2 Way Connector End View
- Blend Door Actuator - Gray 2 Way Connector End View
- Blower Motor - Orange 2 Way Connector End View
- Blower Motor Resistor Block - Black 4 Way Connector End View
- Body Control Module C1 - Black 6 Way Connector End View
- Body Control Module C2 - Black/Green 34 Way Connector End View
- Body Control Module C3 - Black/White 34 Way Connector End View
- Body Control Module C4 - Black/Gray 34 Way Connector End View
- Body Control Module C5 - Black/Black 34 Way Connector End View
- Brake Fluid Level Switch - Black 2 Way Connector End View
- Brake Lamp Switch - Black 6 Way Connector End View
- C100 - (Headlamp And Dash Side) Connector End View
- C100 - (Instrument Panel Side) Connector End View
- C101 - (Headlamp And Dash Side) Connector End View
- C101 - (Instrument Panel Side) Connector End View
- C102 - Black (Body Side) Connector End View
- C102 - Black (Headlamp And Dash Side) Connector End View
- C103 - Gray (Body Side) Connector End View
- C103 - Gray (Headlamp And Dash Side) Connector End View
- C104 - Black (Engine Side) Connector End View
- C104 - Black (Headlamp And Dash Side) Connector End View
- C106 - Black (Headlamp And Dash Side) Connector End View
- C106 - Black (Headlamp Jumper Side) Connector End View
- C107 - Black (Headlamp And Dash Side) Connector End View
- C107 - Black (Headlamp Jumper Side) Connector End View
- C200 - Black (Body Side) Connector End View
- C200 - Black (Instrument Panel Side) Connector End View
- C201 - Yellow (Body Side) Connector End View
- C201 - Yellow (Instrument Panel Side) Connector End View
- C202 - White (Instrument Panel Side) Connector End View
- C202 - White (Left Door Side) Connector End View
- C203 - White (Instrument Panel Side) Connector End View
- C203 - White (Right Door Side) Connector End View
- C204 - (HVAC Jumper Side) Connector End View
- C204 - (Instrument Panel Side) Connector End View
- C205 - Black (Instrument Panel Side) Connector End View
- C205 - Black (Mirror Jumper Side) 2 Way Connector End View
- C206 - Red (Console Jumper Side) Connector End View
- C206 - Red (Instrument Panel Side) Connector End View
- C207 - White (Instrument Panel Side) Connector End View
- C207 - White (Right Door Side) Connector End View
- C300 - Black (Body Side) Connector End View
- C300 - Black (Transmission Side) Connector End View
- C301 - Black (Body Side) Connector End View
- C301 - Black (Left Tail Lamp Side) Connector End View
- C302 - Black (Body Side) Connector End View
- C302 - Black (Right Tail Lamp Side) Connector End View
- C303 - Black (Body Side) Connector End View
- C303 - Black (DECKLID Jumper Side) Connector End View
- Camshaft Position Sensor - Gray 3 Way Connector End View
- Center High Mounted Stop Lamp - Gray 2 Way Connector End View
- Cigar Lighter Outlet - Gray 3 Way Connector End View
- CLOCKSPRING - White 8 Way Connector End View
- Clutch Interlock Switch - DK. Green 2 Way Connector End View
- Controller Antilock Brake - Black 24 Way Connector End View
- Crankshaft Position Sensor - Black 3 Way Connector End View
- Cylinder Unlock Switch-Driver - Black 2 Way Connector End View
- Data Link Connector - Black 16 Way Connector End View
- DECKLID Release Motor - Black 2 Way Connector End View
- Door Latch Motor-Driver - 2 Way Connector End View
- Door Latch Motor-Passenger - 2 Way -. Connector End View
- Door Lock Switch-Driver - Black 3 Way Connector End View
- Door Lock Switch-Passenger - Black 3 Way Connector End View
- Engine Coolant Temperature Sensor - Black 2 Way Connector End View
- Engine Oil Pressure Sensor - Black 3 Way Connector End View
- Engine Oil Temperature Sensor - Black 2 Way Connector End View
- EVAP/Purge Solenoid - Black 2 Way Connector End View
- Exterior Door Handle Switch-Driver - Black 2 Way Connector End View
- Exterior Door Handle Switch-Passenger - Black 2 Way Connector End View
- Fog Lamp-Left - Black 2 Way Connector End View
- Fog Lamp-Right - Black 2 Way Connector End View
- FOOTWELL Lamp-Left - Black 2 Way Connector End View
- FOOTWELL Lamp-Right - Black 2 Way Connector End View
- Fuel Injector No. 1 - Black 2 Way Connector End View
- Fuel Injector No. 2 - Black 2 Way Connector End View
- Fuel Injector No. 3 - Black 2 Way Connector End View
- Fuel Injector No. 4 - Black 2 Way Connector End View
- Fuel Injector No. 5 - Black 2 Way Connector End View
- Fuel Injector No. 6 - Black 2 Way Connector End View
- Fuel Injector No. 7 - Black 2 Way Connector End View
- Fuel Injector No. 8 - Black 2 Way Connector End View
- Fuel Injector No. 9 - Black 2 Way Connector End View
- Fuel Injector No. 10 - Black 2 Way Connector End View
- Fuel Tank Module - Gray 4 Way Connector End View
- Gauge Cluster C1 - White 3 Way Connector End View
- Gauge Cluster C2 - Black 20 Way Connector End View
- Generator - Gray 2 Way Connector End View
- Glove Box Lamp - Black 2 Way Connector End View
- Hid Lamp-Left - Gray 2 Way Connector End View
- Hid Lamp-Right - Gray 2 Way Connector End View
- High Beam Headlamp-Left - Black 2 Way Connector End View
- High Beam Headlamp-Right - Black 2 Way Connector End View
- Horn-High Note - Black 2 Way Connector End View
- Horn-Low Note - Black 2 Way Connector End View
- Hydraulic Cooling Module - Black 3 Way Connector End View
- Idle Air Control Motor - Black 4 Way Connector End View
- Ignition Coil Pack-Left - Black 4 Way Connector End View
- Ignition Coil Pack-Right - Black 3 Way Connector End View
- Ignition Switch - Black 5 Way Connector End View
- Illuminated Rearview Mirror - Black 7 Way Connector End View
- Instrument Cluster C1 - Black 16 Way Connector End View
- Instrument Cluster C2 - Black 20 Way Connector End View
- Intake Air Temperature Sensor - Black 2 Way Connector End View
- Interior Door Handle Switch-Driver - Black 2 Way Connector End View
- Interior Door Handle Switch-Passenger - Black 2 Way Connector End View
- Key-In Switch/Halo Lamp - White 2 Way Connector End View
- Leak Detection Pump - Black 4 Way Connector End View
- License Lamp-Left - Natural 2 Way Connector End View
- License Lamp-Right - Natural 2 Way Connector End View
- Manifold Absolute Pressure Sensor - Black 3 Way Connector End View
- Marker Lamp-Left Front - DK. Gray 2 Way Connector End View
- Marker Lamp-Left Rear - LT Gray 2 Way Connector End View
- Marker Lamp-Right Front - DK. Gray 2 Way Connector End View
- Marker Lamp-Right Rear - LT. Gray 2 Way Connector End View
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way Connector End View
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way Connector End View
- Multi-Function Switch - Gray 20 Way Connector End View
- Oxygen Sensor 1/1 Left Bank Up - Black 4 Way Connector End View
- Oxygen Sensor 1/2 Left Bank Down - Black 4 Way Connector End View
- Oxygen Sensor 2/1 Right Bank Up - Black 4 Way Connector End View
- Oxygen Sensor 2/2 Right Bank Down - Black 4 Way Connector End View
- Park/Turn Lamp-Left - Black 3 Way Connector End View
- Park/Turn Lamp-Right - Black 3 Way Connector End View
- Power Amplifier C1 - DK. Gray 14 Way Connector End View
- Power Amplifier C2 - Green 16 Way Connector End View
- Power Mirror Switch - Black 10 Way Connector End View
- Power Mirror-Driver - White 3 Way Connector End View
- Power Mirror-Passenger - White 3 Way Connector End View
- Power Outlet - Black 2 Way Connector End View
- Power Window Motor-Driver - 6 Way Connector End View
- Power Window Motor-Passenger - 6 Way Connector End View
- Power Window Switch-Driver - Gray 3 Way Connector End View
- Power Window Switch-Passenger - Gray 3 Way Connector End View
- Powertrain Control Module C1 - Black/Black 32 Way Connector End View
- Powertrain Control Module C2 - Black/White 32 Way Connector End View
- Powertrain Control Module C3 - Black/Gray 32 Way Connector End View
- Push-Button Starter Switch - Natural 6 Way Connector End View
- Radio - Gray 22 Way Connector End View
- RECIRCULATION Door Actuator - Gray 2 Way Connector End View
- Remote Keyless Entry Module - Black 6 Way Connector End View
- Remote Radio Switch-Left Provision - Black 2 Way Connector End View
- Remote Radio Switch-Right Provision - Black 2 Way Connector End View
- Reverse Lock-Out Solenoid - White 2 Way Connector End View
- Seat Belt Switch-Driver - White 2 Way Connector End View
- Seat Belt Switch-Passenger - White 2 Way Connector End View
- Seat Belt TENSIONER-Driver - Yellow 2 Way Connector End View
- Seat Belt TENSIONER-Passenger - Yellow 2 Way Connector End View
- Shutter Motor-Left - White 2 Way Connector End View
- Shutter Motor-Right - White 2 Way Connector End View
- Skip Shift Solenoid - White 2 Way Connector End View
- Speaker-Left Door - Black 2 Way Connector End View
- Speaker-Left Instrument Panel - White 2 Way Connector End View
- Speaker-Left Rear - White 3 Way Connector End View
- Speaker-Rear Woofer - Gray 4 Way Connector End View
- Speaker-Right Door - Black 2 Way Connector End View
- Speaker-Right Instrument Panel - White 2 Way Connector End View
- Speaker-Right Rear - White 3 Way Connector End View
- Tail Lamp-Left - LT. Gray 2 Way Connector End View
- Tail Lamp-Right - LT. Gray 2 Way Connector End View
- Tail/Stop Lamp-Left - DK. Gray 3 Way Connector End View
- Tail/Stop Lamp-Right - DK. Gray 3 Way Connector End View
- Throttle Position Sensor - Black 3 Way Connector End View
- Tire Pressure Monitor Module - Blue 6 Way Connector End View
- Turn Signal Lamp-Left Rear - Black 3 Way Connector End View
- Turn Signal Lamp-Right Rear - Black 3 Way Connector End View
- VTSS Led - Black 2 Way Connector End View
- Washer Pump Motor - Black 2 Way Connector End View
- Wheel Speed Sensor-Left Front - LT. Gray 2 Way Connector End View
- Wheel Speed Sensor-Left Rear - Gray 2 Way Connector End View
- Wheel Speed Sensor-Right Front - LT. Gray 2 Way Connector End View
- Wheel Speed Sensor-Right Rear - Gray 2 Way Connector End View
- Window Down Relay-Passenger - Black 5 Way Connector End View
- Window Up Relay-Passenger - Black 5 Way Connector End View
- Wiper Control Module - Gray 7 Way Connector End View
- Wiper Motor - Black 6 Way Connector End View
- Connector End Views
- Connector/Ground/Splice Location
- Power Distribution (Component Locations)
- Power Distribution (Removal & Installation)
- Connector End Views
- Charging Systems
- Battery System
- Charging System - Generators & Regulators
- Identification
- Description & Operation
- Programming
- Adjustments
- Trouble Shooting
- On-Vehicle Testing
- Self-Diagnostic System
- System Testing
- Diagnostic Tests
- Verification Tests
- Removal & Installation
- Overhaul
- Torque Specifications
- Wiring Diagrams
- Component Locations
- Fuses & Circuit Breakers
- Gauges
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Body Control Module
- Chime Warning System
- Communication
- Door Ajar System
- Exterior Lighting System
- Relays Controlled By The BCM
- Heating & A/C System
- Instrument Cluster / Gauge Cluster
- Interior Lighting
- Tire Pressure Monitoring System (TPMS)
- Power Door Entry System
- Power Windows
- Electrically Heated Systems
- Vehicle Theft Security System
- Using The DRBIII®
- DRBIII® Error Messages
- DRBIII® Does Not Power Up (Blank Screen)
- Display Is Not Visible
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Air Bag
- Symptom List: ACCELEROMETER 1; ACCELEROMETER 2; INTERNAL 1; OUTPUT DRIVER 1; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: DRIVER SQUIB 2 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 2 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 2 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 2 SHORT TO GROUND
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH OPEN
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO BATTERY
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO GROUND
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO BATTERY
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: PASSENGER SQUIB 2 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 2 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 2 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 2 SHORT TO GROUND
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: All OUTPUTS SHORT
- Symptom List; CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH BCM
- Chime
- Communication
- Symptom: ACM MESSAGES NOT RECEIVED
- Symptom: AUDIO MESSAGES NOT RECEIVED
- Symptom: COUNTRY CODE NOT PROGRAMMED
- Symptom: INTERNAL BCM FAILURE
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom List: PCI BUS SHORTED TO BATTERY; PCI BUS SHORTED TO GROUND
- Symptom: PCI INTERNAL FAULT
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *NO RESPONSE FROM ACM
- Symptom: *NO RESPONSE FROM BODY CONTROL MODULE
- Symptom: *NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE
- Symptom: *NO RESPONSE FROM HVAC
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM PCM (PCI BUS)
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY)
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM TIRE PRESSURE MONITOR MODULE
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Door Ajar
- Symptom: *DECKLID AJAR CIRCUIT OPEN
- Symptom: *DECKLID AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *DRIVER DOOR AJAR CIRCUIT OPEN
- Symptom: *DRIVER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *HOOD AJAR CIRCUIT OPEN
- Symptom: *HOOD AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *PASSENGER DOOR AJAR CIRCUIT OPEN
- Symptom: *PASSENGER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Electrically Heated Systems
- Exterior Lighting
- Symptom: LEFT FOG LAMP OUTPUT OPEN
- Symptom: LEFT FOG LAMP OUTPUT SHORTED
- Symptom: LEFT HIGH BEAM OUTPUT OPEN
- Symptom: LEFT HIGH BEAM OUTPUT SHORT
- Symptom: LOW BEAM RELAY COIL OUTPUT OPEN/SHORT TO GROUND
- Symptom: LOW BEAM RELAY COIL SHORT TO VOLTAGE
- Symptom: PARK LAMP OUTPUT SHORT
- Symptom: RIGHT FOG LAMP OUTPUT OPEN
- Symptom: RIGHT FOG LAMP OUTPUT SHORTED
- Symptom: RIGHT HIGH BEAM OUTPUT OPEN
- Symptom: RIGHT HIGH BEAM OUTPUT SHORT
- Heating & A/C
- Symptom List: A/C SWITCH FAULT (ACTIVE); CHECKSUM FAILURE (ACTIVE); DEFOG SWITCH FAULT (ACTIVE)
- Symptom List: A/C SWITCH FAULT (STORED); BACKLIGHT DIMMING RX FAILURE (STORED); BLEND OVERCURRENT (STORED); CHECKSUM FAILURE (STORED); DEFOG SWITCH FAULT (STORED); LOOPBACK TEST FAILURE (STORED); MODE 1 OVERCURRENT (STORED); MODE 2 OVERCURRENT (STORED); RECIRC OVERCURRENT (STORED); REFRIGERANT PRESS RX FAILURE (STORED); TX FAILURE (STORED); VIN RX FAILURE (STORED)
- Notes
- When Monitored and Set Condition:
- A/C Switch Fault (Stored)
- Backlight Dimming RX Failure (Stored)
- Blend OVERCURRENT (Stored)
- Checksum Failure (Stored)
- Defog Switch Fault (Stored)
- LOOPBACK Test Failure (Stored)
- Mode 1 OVERCURRENT (Stored)
- Mode 2 OVERCURRENT (Stored)
- RECIRC OVERCURRENT (Stored)
- Refrigerant Press RX Failure (Stored)
- TX Failure (Stored)
- VIN RX Failure (Stored)
- Possible Causes
- Diagnostic Procedure
- Symptom List: ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE; BLEND CIRCUIT SHORTED TO GROUND; BLEND CIRCUIT SHORTED TO IGN OR BATT; COMMON DRIVER SHORTED TO GROUND; COMMON DRIVER SHORTED TO IGN OR BATT; MODE 1 CIRCUIT SHORTED TO GROUND; MODE 1 CIRCUIT SHORTED TO IGN OR BATT; MODE 2 CIRCUIT SHORTED TO GROUND; MODE 2 CIRCUIT SHORTED TO IGN OR BATT; RECIRC CIRCUIT SHORTED TO GROUND; RECIRC CIRCUIT SHORTED TO IGN OR BATT; SHORT TOO COMPLEX
- Notes
- When Monitored and Set Condition:
- Act CKT Test Passed, OVERCURRENT DTCS Active
- Blend Circuit Shorted To Ground
- Blend Circuit Shorted To IGN Or Batt
- Common Driver Shorted To Ground
- Common Driver Shorted To IGN Or Batt
- Mode 1 Circuit Shorted To Ground
- Mode 1 Circuit Shorted To IGN Or Batt
- Mode 2 Circuit Shorted To Ground
- Mode 2 Circuit Shorted To IGN Or Batt
- RECIRC Circuit Shorted To Ground
- RECIRC Circuit Shorted To IGN Or Batt
- Short Too Complex
- Possible Causes
- Diagnostic Procedure
- Symptom: BACKLIGHT DIMMING RX FAILURE (ACTIVE)
- Symptom List: BLEND CALIBRATION FAULT; MODE 1 CALIBRATION FAULT; MODE 2 CALIBRATION FAULT; RECIRCULATION CALIBRATION FAULT
- Symptom List: BLEND OVERCURRENT (ACTIVE); MODE 1 OVERCURRENT (ACTIVE); MODE 2 OVERCURRENT (ACTIVE); RECIRC OVERCURRENT (ACTIVE)
- Symptom: DEFOG RELAY CONTROL CKT SHORTED TO BATT
- Symptom: LOOPBACK TEST FAILURE (ACTIVE)
- Symptom List: REFRIGERANT PRESSURE RX FAILURE (ACTIVE); VIN RX FAILURE (ACTIVE)
- Symptom: TX FAILURE (ACTIVE)
- Symptom: *A/C - HEATER CONTROL ILLUMINATION INOPERATIVE
- Symptom: *BLEND/MODE/RECIRC DOOR OPERATION IMPROPER
- Symptom: *BLOWER MOTOR INOPERATIVE
- Symptom: *BLOWER MOTOR SPEEDS INCORRECT
- Symptom: *EBL STATUS INDICATOR FLASHING
- Symptom: *HVAC SYSTEM TEST
- Ignition, Power, Accessory
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT OPEN
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT SHORT TO GROUND
- Symptom: BCM - IGNITION MUX SWITCH INPUT MISMATCH
- Symptom: BCM - IGNITION MUX SWITCH INPUT OPEN
- Symptom: BCM - IGNITION MUX SWITCH INPUT SHORT
- Symptom: BCM - IGNITION RUN 1 SHORT
- Symptom: BCM - IGNITION RUN 2 SHORT
- Symptom: BCM - IOD OUTPUT CIRCUIT SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT OPEN / SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT SHORT TO VOLTAGE
- Symptom: BCM - RUN/START HARDWIRE INPUT MISMATCH
- Symptom: HORN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: HORN RELAY COIL SHORT TO BATTERY
- Symptom: HORN SWITCH STUCK
- Symptom: *HORNS INOPERATIVE
- Instrument Cluster
- Symptom List: ABS LAMP CIRCUIT OPEN; ABS LAMP CIRCUIT SHORTED; AIRBAG LAMP CIRCUIT OPEN; AIRBAG LAMP CIRCUIT SHORTED
- Symptom: ABS MESSAGES NOT RECEIVED
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT OPEN / SHORTED TO VOLTAGE
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT SHORT TO GROUND
- Symptom: BCM - PWM DIMMING OUTPUT SHORT
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: ORC MESSAGES NOT RECEIVED
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *GAUGE CLUSTER DIAGNOSTIC TEST
- Symptom: *INSTRUMENT CLUSTER DIAGNOSTIC TEST
- Interior Lighting
- Power Door Locks/RKE
- Symptom: DECKLID RELEASE OUTPUT OPEN
- Symptom: DECKLID RELEASE OUTPUT SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH OPEN OR SHORT TO VOLTAGE
- Symptom: DRIVER CYLINDER UNLOCK SWITCH SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH STUCK
- Symptom: DRIVER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: DRIVER DOOR LOCK SWITCH STUCK
- Symptom: DRIVER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: DRIVER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: DRIVER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER DOOR LOCK SWITCH STUCK
- Symptom: PASSENGER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER/DRIVER DOOR UNLATCH RETURN SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT OPEN/SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT SHORT TO BATTERY
- Symptom: *ALL DOOR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR UNLATCH INOPERATIVE
- Symptom: *PASSENGER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *PASSENGER DOOR UNLATCH INOPERATIVE
- Symptom: *REMOTE KEYLESS ENTRY PROBLEM
- Power Windows
- Symptom: DRIVER WINDOW DOWN OUTPUT SHORT TO GROUND
- Symptom: DRIVER WINDOW HALL EFFECT FAILURE
- Symptom: DRIVER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: DRIVER WINDOW SWITCH SHORT TO GROUND
- Symptom: DRIVER WINDOW SWITCH STUCK DOWN
- Symptom: DRIVER WINDOW SWITCH STUCK UP
- Symptom: DRIVER WINDOW UP OUTPUT SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL SHORT TO BATTERY
- Symptom: PASSENGER WINDOW HALL EFFECT FAILURE
- Symptom: PASSENGER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: PASSENGER WINDOW SWITCH SHORT TO GROUND
- Symptom: PASSENGER WINDOW SWITCH STUCK DOWN
- Symptom: PASSENGER WINDOW SWITCH STUCK UP
- Symptom: PASSENGER WINDOW UP SHORT TO GROUND
- Symptom: *DRIVER WINDOW INOPERATIVE
- Symptom: *PASSENGER WINDOW INOPERATIVE
- Tire Pressure Monitoring
- Symptom: CRITICAL TIRE PRESSURE - BCM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM; LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM; RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM; RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM
- Symptom: TIRE PRESSURE LOW - BCM
- Symptom: TIRE PRESSURE MONITOR MODULE FAILURE - TPM
- Symptom: TPM DIAGNOSTIC - BCM
- Symptom: TPM MODULE INITIALIZED - BCM
- Symptom: *LO TIRE LCD MESSAGE FLASHING
- Symptom: VTSS INDICATOR OUTPUT OPEN
- Symptom: VTSS INDICATOR OUTPUT SHORT
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *DECKLID DOES NOT TRIP VTSS
- Symptom: *DRIVER DOOR DOES NOT TRIP VTSS
- Symptom: *EXTERIOR LAMPS FAIL TO FLASH WHEN ALARM IS TRIPPED
- Symptom: *HOOD DOES NOT TRIP VTSS
- Symptom: *HORN FAILS TO SOUND WHEN ALARM IS TRIPPED
- Symptom: *PASSENGER DOOR DOES NOT TRIP VTSS
- Symptom: *VTSS LAMP ON STEADY DURING ARMING
- Symptom: *VTSS WILL NOT ARM
- Verification Tests
- Air Bag
- Component Locations
- Connector PINOUTS
- A/C-Heater Control C1 - Black 10 Way
- A/C-Heater Control C2 - Black 16 Way
- Airbag Control Module C1 (Orc) - Yellow 32 Way
- Airbag Control Module C2 (Orc) Yellow 32 Way
- Airbag On/Off Switch-Passenger - Yellow 6 Way
- Airbag Squib 1-Driver - Yellow/Black 2 Way
- Airbag Squib 2-Driver - Yellow/Gray 2 Way
- Airbag Squib-Passenger - Yellow 4 Way
- Ajar Switch-DECKLID - Black 3 Way
- Ajar Switch-Driver Door - Black 4 Way
- Ajar Switch-Hood - Natural 3 Way
- Ajar Switch-Passenger Door - Black 4 Way
- Blend Door Actuator - Gray 2 Way
- Blower Motor - Orange 2 Way
- Blower Motor Resistor Block - Black 4 Way
- Body Control Module C1 - Black 6 Way
- Body Control Module C2 - Black/Green 34 Way
- Body Control Module C3 - Black/White 34 Way
- Body Control Module C4 - Black/Gray 34 Way
- Body Control Module C5 - Black/Black 34 Way
- Brake Fluid Level Switch - Black 2 Way
- C200 - Black (Body Side)
- C200 - Black (Instrument Panel Side)
- C201 - Yellow (Body Side)
- C201 - Yellow (Instrument Panel Side)
- C204 - (HVAC Jumper Side)
- C204 - (Instrument Panel Side)
- C206 - Red (Console Jumper Side)
- C206 - Red (Instrument Panel Side)
- CLOCKSPRING - White 8 Way
- Controller Antilock Brake - Black 24 Way
- Cylinder Unlock Switch-Driver - Black 2 Way
- Data Link Connector - Black 16 Way
- DECKLID Release Motor - Black 2 Way
- Door Latch Motor-Driver - 2 Way
- Door Latch Motor-Passenger - 2 Way
- Door Lock Switch-Driver - Black 3 Way
- Door Lock Switch-Passenger - Black 3 Way
- Exterior Door Handle Switch-Driver - Black 2 Way
- Exterior Door Handle Switch-Passenger Black 2 Way
- Fog Lamp-Left - Black 2 Way
- Gauge Cluster C1 - White 3 Way
- Gauge Cluster C2 - Black 20 Way
- Hid Lamp-Left - Gray 2 Way
- High Beam Headlamp-Left - Black 2 Way
- Horn-High Note - Black 2 Way
- Horn-Low Note - Black 2 Way
- Ignition Switch - Black 5 Way
- Instrument Cluster C1 - Black 16 Way
- Instrument Cluster C12 - Black 20 Way
- Interior Door Handle Switch-Driver - Black 2 Way
- Interior Door Handle Switch-Passenger - Black 2 Way
- Marker Lamp-Left Front - DK.Gray 2 Way
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way
- Multi-Function Switch - Gray 20 Way
- Park/Turn Lamp-Left - Black 3 Way
- Power Amplifier C1 - DK.Gray 14 Way
- Power Amplifier C2 - Green 16 Way
- Fuses (PDC)
- Power Window Motor-Driver - 6 Way
- Power Window Motor-Passenger - 6 Way
- Power Window Switch-Driver - Gray 3 Way
- Power Window Switch-Passenger - Gray 3 Way
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Radio - Gray 22 Way
- RECIRCULATION Door Actuator - Gray 2 Way
- Remote Keyless Entry Module - Black 6 Way
- Seat Belt Switch-Driver - White 2 Way
- Seat Belt Switch-Passenger - White 2 Way
- Seat Belt TENSIONER-Driver - Yellow 2 Way
- Seat Belt TENSIONER-Passenger - Yellow 2 Way
- Speaker-Left Door - Black 2 Way
- Speaker-Left Instrument Panel - White 2 Way
- Speaker-Left Rear - White 3 Way
- Speaker-Rear Woofer - Gray 4 Way
- Speaker-Right Door - Black 2 Way
- Speaker-Right Instrument Panel - White 2 Way
- Speaker-Right Rear - White 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Window Down Relay-Passenger - Black 5 Way
- Window Up Relay-Passenger - Black 5 Way
- Schematic Diagrams
- Airbag System
- Audio System
- Chime System
- Communication
- Door Ajar System
- Electrically Heated Systems
- Exterior Lighting
- Heating & A/C System
- Ignition, Power, Accessory
- Instrument Cluster/Gauge Cluster
- Interior Lighting
- Power Door Locks/RKE
- Power Window System
- Tire Pressure Monitor Module (TPM)
- Vehicle Theft Security System
- Instrument Cluster
- Instrument Panel
- Body Diagnostic Procedures
- Horns
- Motors, Switches, Relays
- Connector End Views
- Connector End Views
- A/C Compressor Clutch - Black 2 Way Connector End View
- A/C Low Pressure Switch - DK. Green 2 Way Connector End View
- A/C Pressure Transducer - Black 4 Way Connector End View
- A/C-Heater Control C1 - Black 10 Way Connector End View
- A/C-Heater Control C2 - Black 16 Way Connector End View
- Adjustable Pedals Motor - White 2 Way Connector End View
- Adjustable Pedals Switch - White 6 Way Connector End View
- Airbag Control Module C1 (Orc) - Yellow 32 Way Connector End View
- Airbag Control Module C2 (Orc) - Yellow 32 Way Connector End View
- Airbag On/Off Switch-Passenger - Yellow 6 Way Connector End View
- Airbag Squib 1-Driver - Yellow/Black 2 Way Connector End View
- Airbag Squib 2-Driver - Yellow/Gray 2 Way Connector End View
- Airbag Squib-Passenger - Yellow 4 Way Connector End View
- Ajar Switch-DECKLID - Black 3 Way Connector End View
- Ajar Switch-Driver Door - Black 4 Way Connector End View
- Ajar Switch-Hood - Natural 3 Way Connector End View
- Ajar Switch-Passenger Door - Black 4 Way Connector End View
- Back-Up Lamp Switch - Brown 2 Way Connector End View
- Back-Up Lamp-Left - Gray 3 Way Connector End View
- Back-Up Lamp-Right - Gray 3 Way Connector End View
- Battery Temperature Sensor - 2 Way Connector End View
- Blend Door Actuator - Gray 2 Way Connector End View
- Blower Motor - Orange 2 Way Connector End View
- Blower Motor Resistor Block - Black 4 Way Connector End View
- Body Control Module C1 - Black 6 Way Connector End View
- Body Control Module C2 - Black/Green 34 Way Connector End View
- Body Control Module C3 - Black/White 34 Way Connector End View
- Body Control Module C4 - Black/Gray 34 Way Connector End View
- Body Control Module C5 - Black/Black 34 Way Connector End View
- Brake Fluid Level Switch - Black 2 Way Connector End View
- Brake Lamp Switch - Black 6 Way Connector End View
- C100 - (Headlamp And Dash Side) Connector End View
- C100 - (Instrument Panel Side) Connector End View
- C101 - (Headlamp And Dash Side) Connector End View
- C101 - (Instrument Panel Side) Connector End View
- C102 - Black (Body Side) Connector End View
- C102 - Black (Headlamp And Dash Side) Connector End View
- C103 - Gray (Body Side) Connector End View
- C103 - Gray (Headlamp And Dash Side) Connector End View
- C104 - Black (Engine Side) Connector End View
- C104 - Black (Headlamp And Dash Side) Connector End View
- C106 - Black (Headlamp And Dash Side) Connector End View
- C106 - Black (Headlamp Jumper Side) Connector End View
- C107 - Black (Headlamp And Dash Side) Connector End View
- C107 - Black (Headlamp Jumper Side) Connector End View
- C200 - Black (Body Side) Connector End View
- C200 - Black (Instrument Panel Side) Connector End View
- C201 - Yellow (Body Side) Connector End View
- C201 - Yellow (Instrument Panel Side) Connector End View
- C202 - White (Instrument Panel Side) Connector End View
- C202 - White (Left Door Side) Connector End View
- C203 - White (Instrument Panel Side) Connector End View
- C203 - White (Right Door Side) Connector End View
- C204 - (HVAC Jumper Side) Connector End View
- C204 - (Instrument Panel Side) Connector End View
- C205 - Black (Instrument Panel Side) Connector End View
- C205 - Black (Mirror Jumper Side) 2 Way Connector End View
- C206 - Red (Console Jumper Side) Connector End View
- C206 - Red (Instrument Panel Side) Connector End View
- C207 - White (Instrument Panel Side) Connector End View
- C207 - White (Right Door Side) Connector End View
- C300 - Black (Body Side) Connector End View
- C300 - Black (Transmission Side) Connector End View
- C301 - Black (Body Side) Connector End View
- C301 - Black (Left Tail Lamp Side) Connector End View
- C302 - Black (Body Side) Connector End View
- C302 - Black (Right Tail Lamp Side) Connector End View
- C303 - Black (Body Side) Connector End View
- C303 - Black (DECKLID Jumper Side) Connector End View
- Camshaft Position Sensor - Gray 3 Way Connector End View
- Center High Mounted Stop Lamp - Gray 2 Way Connector End View
- Cigar Lighter Outlet - Gray 3 Way Connector End View
- CLOCKSPRING - White 8 Way Connector End View
- Clutch Interlock Switch - DK. Green 2 Way Connector End View
- Controller Antilock Brake - Black 24 Way Connector End View
- Crankshaft Position Sensor - Black 3 Way Connector End View
- Cylinder Unlock Switch-Driver - Black 2 Way Connector End View
- Data Link Connector - Black 16 Way Connector End View
- DECKLID Release Motor - Black 2 Way Connector End View
- Door Latch Motor-Driver - 2 Way Connector End View
- Door Latch Motor-Passenger - 2 Way -. Connector End View
- Door Lock Switch-Driver - Black 3 Way Connector End View
- Door Lock Switch-Passenger - Black 3 Way Connector End View
- Engine Coolant Temperature Sensor - Black 2 Way Connector End View
- Engine Oil Pressure Sensor - Black 3 Way Connector End View
- Engine Oil Temperature Sensor - Black 2 Way Connector End View
- EVAP/Purge Solenoid - Black 2 Way Connector End View
- Exterior Door Handle Switch-Driver - Black 2 Way Connector End View
- Exterior Door Handle Switch-Passenger - Black 2 Way Connector End View
- Fog Lamp-Left - Black 2 Way Connector End View
- Fog Lamp-Right - Black 2 Way Connector End View
- FOOTWELL Lamp-Left - Black 2 Way Connector End View
- FOOTWELL Lamp-Right - Black 2 Way Connector End View
- Fuel Injector No. 1 - Black 2 Way Connector End View
- Fuel Injector No. 2 - Black 2 Way Connector End View
- Fuel Injector No. 3 - Black 2 Way Connector End View
- Fuel Injector No. 4 - Black 2 Way Connector End View
- Fuel Injector No. 5 - Black 2 Way Connector End View
- Fuel Injector No. 6 - Black 2 Way Connector End View
- Fuel Injector No. 7 - Black 2 Way Connector End View
- Fuel Injector No. 8 - Black 2 Way Connector End View
- Fuel Injector No. 9 - Black 2 Way Connector End View
- Fuel Injector No. 10 - Black 2 Way Connector End View
- Fuel Tank Module - Gray 4 Way Connector End View
- Gauge Cluster C1 - White 3 Way Connector End View
- Gauge Cluster C2 - Black 20 Way Connector End View
- Generator - Gray 2 Way Connector End View
- Glove Box Lamp - Black 2 Way Connector End View
- Hid Lamp-Left - Gray 2 Way Connector End View
- Hid Lamp-Right - Gray 2 Way Connector End View
- High Beam Headlamp-Left - Black 2 Way Connector End View
- High Beam Headlamp-Right - Black 2 Way Connector End View
- Horn-High Note - Black 2 Way Connector End View
- Horn-Low Note - Black 2 Way Connector End View
- Hydraulic Cooling Module - Black 3 Way Connector End View
- Idle Air Control Motor - Black 4 Way Connector End View
- Ignition Coil Pack-Left - Black 4 Way Connector End View
- Ignition Coil Pack-Right - Black 3 Way Connector End View
- Ignition Switch - Black 5 Way Connector End View
- Illuminated Rearview Mirror - Black 7 Way Connector End View
- Instrument Cluster C1 - Black 16 Way Connector End View
- Instrument Cluster C2 - Black 20 Way Connector End View
- Intake Air Temperature Sensor - Black 2 Way Connector End View
- Interior Door Handle Switch-Driver - Black 2 Way Connector End View
- Interior Door Handle Switch-Passenger - Black 2 Way Connector End View
- Key-In Switch/Halo Lamp - White 2 Way Connector End View
- Leak Detection Pump - Black 4 Way Connector End View
- License Lamp-Left - Natural 2 Way Connector End View
- License Lamp-Right - Natural 2 Way Connector End View
- Manifold Absolute Pressure Sensor - Black 3 Way Connector End View
- Marker Lamp-Left Front - DK. Gray 2 Way Connector End View
- Marker Lamp-Left Rear - LT Gray 2 Way Connector End View
- Marker Lamp-Right Front - DK. Gray 2 Way Connector End View
- Marker Lamp-Right Rear - LT. Gray 2 Way Connector End View
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way Connector End View
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way Connector End View
- Multi-Function Switch - Gray 20 Way Connector End View
- Oxygen Sensor 1/1 Left Bank Up - Black 4 Way Connector End View
- Oxygen Sensor 1/2 Left Bank Down - Black 4 Way Connector End View
- Oxygen Sensor 2/1 Right Bank Up - Black 4 Way Connector End View
- Oxygen Sensor 2/2 Right Bank Down - Black 4 Way Connector End View
- Park/Turn Lamp-Left - Black 3 Way Connector End View
- Park/Turn Lamp-Right - Black 3 Way Connector End View
- Power Amplifier C1 - DK. Gray 14 Way Connector End View
- Power Amplifier C2 - Green 16 Way Connector End View
- Power Mirror Switch - Black 10 Way Connector End View
- Power Mirror-Driver - White 3 Way Connector End View
- Power Mirror-Passenger - White 3 Way Connector End View
- Power Outlet - Black 2 Way Connector End View
- Power Window Motor-Driver - 6 Way Connector End View
- Power Window Motor-Passenger - 6 Way Connector End View
- Power Window Switch-Driver - Gray 3 Way Connector End View
- Power Window Switch-Passenger - Gray 3 Way Connector End View
- Powertrain Control Module C1 - Black/Black 32 Way Connector End View
- Powertrain Control Module C2 - Black/White 32 Way Connector End View
- Powertrain Control Module C3 - Black/Gray 32 Way Connector End View
- Push-Button Starter Switch - Natural 6 Way Connector End View
- Radio - Gray 22 Way Connector End View
- RECIRCULATION Door Actuator - Gray 2 Way Connector End View
- Remote Keyless Entry Module - Black 6 Way Connector End View
- Remote Radio Switch-Left Provision - Black 2 Way Connector End View
- Remote Radio Switch-Right Provision - Black 2 Way Connector End View
- Reverse Lock-Out Solenoid - White 2 Way Connector End View
- Seat Belt Switch-Driver - White 2 Way Connector End View
- Seat Belt Switch-Passenger - White 2 Way Connector End View
- Seat Belt TENSIONER-Driver - Yellow 2 Way Connector End View
- Seat Belt TENSIONER-Passenger - Yellow 2 Way Connector End View
- Shutter Motor-Left - White 2 Way Connector End View
- Shutter Motor-Right - White 2 Way Connector End View
- Skip Shift Solenoid - White 2 Way Connector End View
- Speaker-Left Door - Black 2 Way Connector End View
- Speaker-Left Instrument Panel - White 2 Way Connector End View
- Speaker-Left Rear - White 3 Way Connector End View
- Speaker-Rear Woofer - Gray 4 Way Connector End View
- Speaker-Right Door - Black 2 Way Connector End View
- Speaker-Right Instrument Panel - White 2 Way Connector End View
- Speaker-Right Rear - White 3 Way Connector End View
- Tail Lamp-Left - LT. Gray 2 Way Connector End View
- Tail Lamp-Right - LT. Gray 2 Way Connector End View
- Tail/Stop Lamp-Left - DK. Gray 3 Way Connector End View
- Tail/Stop Lamp-Right - DK. Gray 3 Way Connector End View
- Throttle Position Sensor - Black 3 Way Connector End View
- Tire Pressure Monitor Module - Blue 6 Way Connector End View
- Turn Signal Lamp-Left Rear - Black 3 Way Connector End View
- Turn Signal Lamp-Right Rear - Black 3 Way Connector End View
- VTSS Led - Black 2 Way Connector End View
- Washer Pump Motor - Black 2 Way Connector End View
- Wheel Speed Sensor-Left Front - LT. Gray 2 Way Connector End View
- Wheel Speed Sensor-Left Rear - Gray 2 Way Connector End View
- Wheel Speed Sensor-Right Front - LT. Gray 2 Way Connector End View
- Wheel Speed Sensor-Right Rear - Gray 2 Way Connector End View
- Window Down Relay-Passenger - Black 5 Way Connector End View
- Window Up Relay-Passenger - Black 5 Way Connector End View
- Wiper Control Module - Gray 7 Way Connector End View
- Wiper Motor - Black 6 Way Connector End View
- Connector End Views
- Connector/Ground/Splice Location
- Power Distribution (Component Locations)
- Power Distribution (Removal & Installation)
- Connector End Views
- Starter
- Powertrain Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- General Description
- Function Operation
- Fuel Control
- On-Board Diagnostics
- JTEC Controlled Rear Wheel Drive Vehicles
- Other Controls
- Charging System
- Leak Detection Pump System
- EVAP Leak Detection System Components
- Leak Detection Pump (LDP) Components
- LDP At Rest (Not Powered)
- Diaphragm Upward Movement
- Diaphragm Downward Movement
- Pumping Action
- Enabling Conditions To Run EVAP Leak Detection Test
- Section 1
- Section 2
- Section 3
- Section 4
- Section 5
- Diagnostic Tips
- Test Equipment
- Important
- Non-Monitored Circuits
- Diagnostic Trouble Codes
- Using The DRBIII®
- DRBIII® Error Messages And Blank Screen
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Acronyms
- Diagnostic Information And Procedures
- DTC Index
- Communication - Symptoms
- DRIVEABILITY - Gas - Symptoms
- Symptom: INTERMITTENT CONDITION
- Symptom: *BRAKE SWITCH SENSE STATUS DOES NOT CHANGE ON DRBIII™
- Symptom: *CANNOT SHIFT INTO 2ND AND 3RD GEARS
- Symptom: *CANNOT SHIFT INTO REVERSE
- Symptom: *CHECKING A/C SYSTEM OPERATION WITH NO DTCS
- Symptom: CHECKING CHARGING SYSTEM OPERATION WITH NO DTCS
- Symptom: CHECKING RADIATOR FAN OPERATION
- Symptom: CHECKING THE PCM POWER AND GROUNDS
- DRIVEABILITY - Gas - Diagnostic Tests
- P0031-O2 Sensor 1/1 Heater Circuit Low, P0032-O2 Sensor 1/1 Heater Circuit High, P0051-O2 Sensor 2/1 Heater Circuit Low, P0052-O2 Sensor 2/1 Heater Circuit High
- P0071-Ambient/Battery Temp Sensor Performance
- P0107-Map Sensor Voltage Too Low
- P0108-Map Sensor Voltage Too High
- P0111-Intake Air Temp Performance
- P0112-Intake Air Temp Sensor Voltage Too Low
- P0113-Intake Air Temp Sensor Voltage Too High
- P0117-Engine Coolant Temp Sensor Voltage Too Low
- P0118-Engine Coolant Temp Sensor Voltage Too High
- P0121-TP Sensor Voltage Does Not Agree With Map
- P0122-Throttle Position Sensor #1 Voltage Too Low
- P0123-Throttle Position Sensor #1 Voltage Too High
- P0125-Closed Loop Temp Not Reached
- P0131-O2 Sensor 1/1 Circuit Voltage Too Low, P0137-O2 Sensor 1/2 Circuit Voltage Too Low, P0151-O2 Sensor 2/1 Circuit Voltage Too Low, P0157-O2 Sensor 2/2 Circuit Voltage Too Low
- P0132-O2 Sensor 1/1 Circuit Voltage Too High, P0138-O2 Sensor 1/2 Circuit Voltage Too High, P0152-O2 Sensor 2/1 Circuit Voltage Too High, P0158-O2 Sensor 2/2 Circuit Voltage Too High
- P0133-O2 Sensor 1/1 Slow Response, P0139-O2 Sensor 1/2 Slow Response, P0153-O2 Sensor 2/1 Slow Response, P0159-O2 Sensor 2/2 Slow Response
- P0135-O2 Sensor 1/1 Heater Failure, P0141-O2 Sensor 1/2 Heater Failure, P0155-O2 Sensor 2/1 Heater Failure, P0161-O2 Sensor 2/2 Heater Failure
- P0136-O2 Sensor 1/2 Heater Circuit Malfunction
- P0171-1/1 Fuel System Lean, P0174-2/1 Fuel System Lean
- P0172-1/1 Fuel System Rich, P0175-2/1 Fuel System Rich
- P0197-Engine Oil Temperature Sensor Voltage Too Low
- P0198-Engine Oil Temperature Sensor Voltage Too High
- P0201-Injector #1 Control Circuit, P0202-Injector #2 Control Circuit, P0203-Injector #3 Control Circuit, P0204-Injector #4 Control Circuit, P0205-Injector #5 Control Circuit, P0206-Injector #6 Control Circuit, P0207-Injector #7 Control Circuit, P0208-Injector #8 Control Circuit, P0209-Injector #9 Control Circuit, P0210-Injector #10 Control Circuit
- P0300-Multiple Cylinder Mis-Fire, P0301-Cylinder #1 Misfire, P0302-Cylinder #2 Misfire, P0303-Cylinder #3 Misfire, P0304-Cylinder #4 Misfire, P0305-Cylinder #5 Misfire, P0306-Cylinder #6 Misfire, P0307-Cylinder #7 Misfire, P0308-Cylinder #8 Misfire, P0309-Cylinder #9 Misfire, P0310-Cylinder #10 Misfire
- P0320-No Crank Reference Signal At Pcm
- P0340-No Cam Reference Signal At Pcm
- P0351-Ignition Coil #1 Primary Circuit, P0352-Ignition Coil #2 Primary Circuit, P0353-Ignition Coil #3 Primary Circuit, P0354-Ignition Coil #4 Primary Circuit, P0355-Ignition Coil #5 Primary Circuit
- P0420-1/1 Catalytic Converter Efficiency, P0432-2/1 Catalytic Converter Efficiency
- P0441-EVAP Purge Flow Monitor
- P0442-EVAP Leak Monitor Medium (0.040) Leak Detected, P0445-EVAP Leak Monitor Large Leak Detected
- P0443-EVAP Purge Solenoid Circuit
- P0460-Fuel Level Sending Unit No Change Over Miles
- P0462-Fuel Level Sending Unit Volts Too Low
- P0463-Fuel Level Sending Unit Volts Too High
- P0500-No Vehicle Speed Signal
- P0505-Idle Air Control Motor Circuits
- P0522-Oil Pressure Circuit Low
- P0523-Oil Pressure Circuit High
- P0601-Pcm Internal Controller Failure
- P0622-Generator Field Not Switching Properly
- P0645-A/C Clutch Relay Circuit
- P0801-Reverse Gear Lockout Circuit Open Or Shorted
- P1195-O2 Sensor 1/1 Slow During Catalyst Monitor, P1196-O2 Sensor 2/1 Slow During Catalyst Monitor
- P1281-Engine Is Cold Too Long
- P1282-Fuel Pump/System Relay Control Circuit
- P1294-Target Idle Not Reached
- P1296-No 5-Volts To Map Sensor
- P1297-No Change In Map From Start To Run
- P1388-Auto Shutdown Relay Control Circuit
- P1389-No ASD Relay Output Voltage At Pcm
- P1391-Intermittent Loss Of CMP Or CKP
- P1398-Mis-Fire Adaptive Numerator At Limit
- P1486-EVAP Leak Monitor Pinched Hose Found
- P1492-Ambient/Battery Temperature Sensor Voltage Too High
- P1493-Ambient/Battery Temperature Sensor Voltage Too Low
- P1494-Leak Detection Pump Switch Or Mechanical Fault
- P1495-Leak Detection Pump Solenoid Circuit
- P1499-Hydraulic Fan Solenoid Circuit
- P1594-Charging System Voltage Too High
- P1598-A/C Pressure Sensor Voltage Too High
- P1599-A/C Pressure Sensor Voltage Too Low
- P1682-Charging System Voltage Too Low
- P1687-No Cluster Bus Message
- P1695-Bus Message From Body Control Module
- P1696-Pcm Failure EEPROM Write Denied
- P1719-Skip Shift Solenoid Circuit Open Or Shorted
- Starting - Symptoms
- Verification Tests
- Component Locations
- Control Modules And PDC
- Data Link Connector Location
- Sensors And Solenoids
- Battery Temperature Sensor Location
- Cam Position Sensor Location
- Crank Position Sensor Location
- MAP Sensor, ECT Sensor And Fuel Injector Locations
- IAT Sensor Location
- Engine Oil Pressure And Engine Oil Temperature Sensor Locations
- Oxygen Sensor Locations
- Throttle Position Sensor And IAC Motor Locations
- Ignition Coil Location
- Skip Shift Solenoid, Reverse Lockout Solenoid And Vehicle Speed Sensor Locations
- Fuel System
- Connector End Views
- A/C Compressor Clutch - Black 2 Way
- A/C Compressor Switch - DK. Green 2 Way
- A/C Pressure Transducer - Black 4 Way
- Battery Temperature Sensor - Way
- Brake Lamp Switch - Black 6 Way
- Camshaft Position Sensor - Gray 3 Way
- CLOCKSPRING - White 8 Way
- Clutch Interlock Switch - DK.Green 2 Way
- Crankshaft Position Sensor - Black 3 Way
- Data Link Connector - Black 2 Way
- Engine Coolant Temperature Sensor - Black 2 Way
- Engine Oil Pressure Sensor - Black 3 Way
- Engine Oil Temperature Sensor - Black 2 Way
- EVAP/Purge Solenoid - Black 2 Way
- Fuel Injector No. 1 - Black 2 Way
- Fuel Injector No. 2 - Black 2 Way
- Fuel Injector No. 3 - Black 2 Way
- Fuel Injector No. 4 - Black 2 Way
- Fuel Injector No. 5 - Black 2 Way
- Fuel Injector No. 6 - Black 2 Way
- Fuel Injector No. 7 - Black 2 Way
- Fuel Injector No. 8 - Black 2 Way
- Fuel Injector No. 9 - Black 2 Way
- Fuel Injector No. 10 - Black 2 Way
- Fuel Tank Module - Gray 2 Way
- Generator - Gray 2 Way
- Hydraulic Cooling Module - Black 3 Way
- Idle Air Control Motor-Black 4 Way
- Ignition Coil Pack-Left-Black 4 Way
- Ignition Coil Pack-Right-Black 3 Way
- Ignition Switch-Black 5 Way
- Intake Air Temperature Sensor-Black 2 Way
- Leak Detection Pump-Black 4 Way
- Manifold Absolute Pressure Sensor-Black 3 Way
- Multi-Function Switch-Gray 2 Way
- Oxygen Sensor 1/1 Left Bank Up-Black 4 Way
- Oxygen Sensor 1/2 Left Bank Down-Black 4 Way
- Oxygen Sensor 2/1 Right Bank Up-Black 4 Way
- Oxygen Sensor 2/2 Right Bank Down-Black 4 Way
- Power Distribution Center
- Fuses (PDC)
- A/C Compressor Clutch Relay
- Auto Shut Down Relay
- Fuel Pump Relay
- Oxygen Sensor Heater Relay
- Run/Acc Relay
- Starter Motor Relay
- Powertrain Control Module C1-Black/Black 32 Way
- Powertrain Control Module C2-Black/White 32 Way
- Powertrain Control Module C3-Black/Gray 32 Way
- Push-Button Starter Switch-Natural 6 Way
- Reverse Lock-Out Solenoid-White 2 Way
- Skip Shift Solenoid-White 2 Way
- Throttle Position Sensor-Black 3 Way
- Tire Pressure Monitor Module-Blue 6 Way
- VTSS Led-Black 2 Way
- Schematic Diagrams
- Charts And Graphs
- Starting System
- Starting
- Starter Motor
- Starter Motor Relay
- Starter Solenoid
- Powertrain Diagnostic Procedures
- Wiring Diagrams
- Connector End Views
- Connector End Views
- A/C Compressor Clutch - Black 2 Way Connector End View
- A/C Low Pressure Switch - DK. Green 2 Way Connector End View
- A/C Pressure Transducer - Black 4 Way Connector End View
- A/C-Heater Control C1 - Black 10 Way Connector End View
- A/C-Heater Control C2 - Black 16 Way Connector End View
- Adjustable Pedals Motor - White 2 Way Connector End View
- Adjustable Pedals Switch - White 6 Way Connector End View
- Airbag Control Module C1 (Orc) - Yellow 32 Way Connector End View
- Airbag Control Module C2 (Orc) - Yellow 32 Way Connector End View
- Airbag On/Off Switch-Passenger - Yellow 6 Way Connector End View
- Airbag Squib 1-Driver - Yellow/Black 2 Way Connector End View
- Airbag Squib 2-Driver - Yellow/Gray 2 Way Connector End View
- Airbag Squib-Passenger - Yellow 4 Way Connector End View
- Ajar Switch-DECKLID - Black 3 Way Connector End View
- Ajar Switch-Driver Door - Black 4 Way Connector End View
- Ajar Switch-Hood - Natural 3 Way Connector End View
- Ajar Switch-Passenger Door - Black 4 Way Connector End View
- Back-Up Lamp Switch - Brown 2 Way Connector End View
- Back-Up Lamp-Left - Gray 3 Way Connector End View
- Back-Up Lamp-Right - Gray 3 Way Connector End View
- Battery Temperature Sensor - 2 Way Connector End View
- Blend Door Actuator - Gray 2 Way Connector End View
- Blower Motor - Orange 2 Way Connector End View
- Blower Motor Resistor Block - Black 4 Way Connector End View
- Body Control Module C1 - Black 6 Way Connector End View
- Body Control Module C2 - Black/Green 34 Way Connector End View
- Body Control Module C3 - Black/White 34 Way Connector End View
- Body Control Module C4 - Black/Gray 34 Way Connector End View
- Body Control Module C5 - Black/Black 34 Way Connector End View
- Brake Fluid Level Switch - Black 2 Way Connector End View
- Brake Lamp Switch - Black 6 Way Connector End View
- C100 - (Headlamp And Dash Side) Connector End View
- C100 - (Instrument Panel Side) Connector End View
- C101 - (Headlamp And Dash Side) Connector End View
- C101 - (Instrument Panel Side) Connector End View
- C102 - Black (Body Side) Connector End View
- C102 - Black (Headlamp And Dash Side) Connector End View
- C103 - Gray (Body Side) Connector End View
- C103 - Gray (Headlamp And Dash Side) Connector End View
- C104 - Black (Engine Side) Connector End View
- C104 - Black (Headlamp And Dash Side) Connector End View
- C106 - Black (Headlamp And Dash Side) Connector End View
- C106 - Black (Headlamp Jumper Side) Connector End View
- C107 - Black (Headlamp And Dash Side) Connector End View
- C107 - Black (Headlamp Jumper Side) Connector End View
- C200 - Black (Body Side) Connector End View
- C200 - Black (Instrument Panel Side) Connector End View
- C201 - Yellow (Body Side) Connector End View
- C201 - Yellow (Instrument Panel Side) Connector End View
- C202 - White (Instrument Panel Side) Connector End View
- C202 - White (Left Door Side) Connector End View
- C203 - White (Instrument Panel Side) Connector End View
- C203 - White (Right Door Side) Connector End View
- C204 - (HVAC Jumper Side) Connector End View
- C204 - (Instrument Panel Side) Connector End View
- C205 - Black (Instrument Panel Side) Connector End View
- C205 - Black (Mirror Jumper Side) 2 Way Connector End View
- C206 - Red (Console Jumper Side) Connector End View
- C206 - Red (Instrument Panel Side) Connector End View
- C207 - White (Instrument Panel Side) Connector End View
- C207 - White (Right Door Side) Connector End View
- C300 - Black (Body Side) Connector End View
- C300 - Black (Transmission Side) Connector End View
- C301 - Black (Body Side) Connector End View
- C301 - Black (Left Tail Lamp Side) Connector End View
- C302 - Black (Body Side) Connector End View
- C302 - Black (Right Tail Lamp Side) Connector End View
- C303 - Black (Body Side) Connector End View
- C303 - Black (DECKLID Jumper Side) Connector End View
- Camshaft Position Sensor - Gray 3 Way Connector End View
- Center High Mounted Stop Lamp - Gray 2 Way Connector End View
- Cigar Lighter Outlet - Gray 3 Way Connector End View
- CLOCKSPRING - White 8 Way Connector End View
- Clutch Interlock Switch - DK. Green 2 Way Connector End View
- Controller Antilock Brake - Black 24 Way Connector End View
- Crankshaft Position Sensor - Black 3 Way Connector End View
- Cylinder Unlock Switch-Driver - Black 2 Way Connector End View
- Data Link Connector - Black 16 Way Connector End View
- DECKLID Release Motor - Black 2 Way Connector End View
- Door Latch Motor-Driver - 2 Way Connector End View
- Door Latch Motor-Passenger - 2 Way -. Connector End View
- Door Lock Switch-Driver - Black 3 Way Connector End View
- Door Lock Switch-Passenger - Black 3 Way Connector End View
- Engine Coolant Temperature Sensor - Black 2 Way Connector End View
- Engine Oil Pressure Sensor - Black 3 Way Connector End View
- Engine Oil Temperature Sensor - Black 2 Way Connector End View
- EVAP/Purge Solenoid - Black 2 Way Connector End View
- Exterior Door Handle Switch-Driver - Black 2 Way Connector End View
- Exterior Door Handle Switch-Passenger - Black 2 Way Connector End View
- Fog Lamp-Left - Black 2 Way Connector End View
- Fog Lamp-Right - Black 2 Way Connector End View
- FOOTWELL Lamp-Left - Black 2 Way Connector End View
- FOOTWELL Lamp-Right - Black 2 Way Connector End View
- Fuel Injector No. 1 - Black 2 Way Connector End View
- Fuel Injector No. 2 - Black 2 Way Connector End View
- Fuel Injector No. 3 - Black 2 Way Connector End View
- Fuel Injector No. 4 - Black 2 Way Connector End View
- Fuel Injector No. 5 - Black 2 Way Connector End View
- Fuel Injector No. 6 - Black 2 Way Connector End View
- Fuel Injector No. 7 - Black 2 Way Connector End View
- Fuel Injector No. 8 - Black 2 Way Connector End View
- Fuel Injector No. 9 - Black 2 Way Connector End View
- Fuel Injector No. 10 - Black 2 Way Connector End View
- Fuel Tank Module - Gray 4 Way Connector End View
- Gauge Cluster C1 - White 3 Way Connector End View
- Gauge Cluster C2 - Black 20 Way Connector End View
- Generator - Gray 2 Way Connector End View
- Glove Box Lamp - Black 2 Way Connector End View
- Hid Lamp-Left - Gray 2 Way Connector End View
- Hid Lamp-Right - Gray 2 Way Connector End View
- High Beam Headlamp-Left - Black 2 Way Connector End View
- High Beam Headlamp-Right - Black 2 Way Connector End View
- Horn-High Note - Black 2 Way Connector End View
- Horn-Low Note - Black 2 Way Connector End View
- Hydraulic Cooling Module - Black 3 Way Connector End View
- Idle Air Control Motor - Black 4 Way Connector End View
- Ignition Coil Pack-Left - Black 4 Way Connector End View
- Ignition Coil Pack-Right - Black 3 Way Connector End View
- Ignition Switch - Black 5 Way Connector End View
- Illuminated Rearview Mirror - Black 7 Way Connector End View
- Instrument Cluster C1 - Black 16 Way Connector End View
- Instrument Cluster C2 - Black 20 Way Connector End View
- Intake Air Temperature Sensor - Black 2 Way Connector End View
- Interior Door Handle Switch-Driver - Black 2 Way Connector End View
- Interior Door Handle Switch-Passenger - Black 2 Way Connector End View
- Key-In Switch/Halo Lamp - White 2 Way Connector End View
- Leak Detection Pump - Black 4 Way Connector End View
- License Lamp-Left - Natural 2 Way Connector End View
- License Lamp-Right - Natural 2 Way Connector End View
- Manifold Absolute Pressure Sensor - Black 3 Way Connector End View
- Marker Lamp-Left Front - DK. Gray 2 Way Connector End View
- Marker Lamp-Left Rear - LT Gray 2 Way Connector End View
- Marker Lamp-Right Front - DK. Gray 2 Way Connector End View
- Marker Lamp-Right Rear - LT. Gray 2 Way Connector End View
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way Connector End View
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way Connector End View
- Multi-Function Switch - Gray 20 Way Connector End View
- Oxygen Sensor 1/1 Left Bank Up - Black 4 Way Connector End View
- Oxygen Sensor 1/2 Left Bank Down - Black 4 Way Connector End View
- Oxygen Sensor 2/1 Right Bank Up - Black 4 Way Connector End View
- Oxygen Sensor 2/2 Right Bank Down - Black 4 Way Connector End View
- Park/Turn Lamp-Left - Black 3 Way Connector End View
- Park/Turn Lamp-Right - Black 3 Way Connector End View
- Power Amplifier C1 - DK. Gray 14 Way Connector End View
- Power Amplifier C2 - Green 16 Way Connector End View
- Power Mirror Switch - Black 10 Way Connector End View
- Power Mirror-Driver - White 3 Way Connector End View
- Power Mirror-Passenger - White 3 Way Connector End View
- Power Outlet - Black 2 Way Connector End View
- Power Window Motor-Driver - 6 Way Connector End View
- Power Window Motor-Passenger - 6 Way Connector End View
- Power Window Switch-Driver - Gray 3 Way Connector End View
- Power Window Switch-Passenger - Gray 3 Way Connector End View
- Powertrain Control Module C1 - Black/Black 32 Way Connector End View
- Powertrain Control Module C2 - Black/White 32 Way Connector End View
- Powertrain Control Module C3 - Black/Gray 32 Way Connector End View
- Push-Button Starter Switch - Natural 6 Way Connector End View
- Radio - Gray 22 Way Connector End View
- RECIRCULATION Door Actuator - Gray 2 Way Connector End View
- Remote Keyless Entry Module - Black 6 Way Connector End View
- Remote Radio Switch-Left Provision - Black 2 Way Connector End View
- Remote Radio Switch-Right Provision - Black 2 Way Connector End View
- Reverse Lock-Out Solenoid - White 2 Way Connector End View
- Seat Belt Switch-Driver - White 2 Way Connector End View
- Seat Belt Switch-Passenger - White 2 Way Connector End View
- Seat Belt TENSIONER-Driver - Yellow 2 Way Connector End View
- Seat Belt TENSIONER-Passenger - Yellow 2 Way Connector End View
- Shutter Motor-Left - White 2 Way Connector End View
- Shutter Motor-Right - White 2 Way Connector End View
- Skip Shift Solenoid - White 2 Way Connector End View
- Speaker-Left Door - Black 2 Way Connector End View
- Speaker-Left Instrument Panel - White 2 Way Connector End View
- Speaker-Left Rear - White 3 Way Connector End View
- Speaker-Rear Woofer - Gray 4 Way Connector End View
- Speaker-Right Door - Black 2 Way Connector End View
- Speaker-Right Instrument Panel - White 2 Way Connector End View
- Speaker-Right Rear - White 3 Way Connector End View
- Tail Lamp-Left - LT. Gray 2 Way Connector End View
- Tail Lamp-Right - LT. Gray 2 Way Connector End View
- Tail/Stop Lamp-Left - DK. Gray 3 Way Connector End View
- Tail/Stop Lamp-Right - DK. Gray 3 Way Connector End View
- Throttle Position Sensor - Black 3 Way Connector End View
- Tire Pressure Monitor Module - Blue 6 Way Connector End View
- Turn Signal Lamp-Left Rear - Black 3 Way Connector End View
- Turn Signal Lamp-Right Rear - Black 3 Way Connector End View
- VTSS Led - Black 2 Way Connector End View
- Washer Pump Motor - Black 2 Way Connector End View
- Wheel Speed Sensor-Left Front - LT. Gray 2 Way Connector End View
- Wheel Speed Sensor-Left Rear - Gray 2 Way Connector End View
- Wheel Speed Sensor-Right Front - LT. Gray 2 Way Connector End View
- Wheel Speed Sensor-Right Rear - Gray 2 Way Connector End View
- Window Down Relay-Passenger - Black 5 Way Connector End View
- Window Up Relay-Passenger - Black 5 Way Connector End View
- Wiper Control Module - Gray 7 Way Connector End View
- Wiper Motor - Black 6 Way Connector End View
- Connector End Views
- Using lemon2025'S System Wiring Diagrams
- Connector End Views
- Body Electrical
- Engine Mechanical
- Auxiliary Emission Control Systems
- Electronically-Controlled Hydraulic Cooling Fans
- Cooling System (Mechanical)
- Accessory Drive Belt
- Cooling System Specifications & Drive Belt Routing
- Engine Cooling System - Diagnosis, Removal & Installation
- Engine Cooling System - Torque Specifications & Special Tools
- Exhaust System
- Fuel System
- Mechanical
- 8.3L Engine (Service Information)
- Engine - 8.3L
- Description
- Diagnosis And Testing
- Engine Diagnosis - Introduction
- Engine Diagnosis - Performance
- Engine Diagnosis - Mechanical
- Diagnosis And Testing - Cylinder Compression Pressure Test
- Cylinder Combustion Pressure Leakage Test
- Cylinder Head Gasket Failure Diagnosis
- Diagnosis And Testing - Intake Manifold Leaks
- Hydraulic Tappet Noise Diagnosis
- Diagnosis And Testing - Engine Oil Leak Inspection
- Standard Procedure
- Removal - Engine Assembly
- Installation - Engine Assembly
- Specifications
- Special Tools
- Air Cleaner Element
- Air Cleaner Housing
- Engine Mounts
- Intake Manifold
- Exhaust Manifold
- Cylinder Head(S)
- Cylinder Head Cover(S)
- Rocker Arms
- Valve Springs/Seals
- Intake/Exhaust - Valves/Seats/Guides
- Timing Chain Cover
- Timing Chain And Sprockets
- Lubrication
- Oil
- Oil Cooler & Lines
- Oil Pan
- Oil Pump
- Oil Pressure Sensor
- Oil Temperature Sensor
- Engine Block
- Hydraulic Tappets
- Camshaft
- Piston & Connecting Rod
- Piston Rings
- Connecting Rod Bearings
- Crankshaft Damper
- Crankshaft Oil Seal Front
- Crankshaft Oil Seal And Retainer - Rear
- Crankshaft Main Bearings
- Crankshaft
- Crankshaft Pilot Bearing
- Engine - 8.3L
- 8.3L Engine (Service Information)
- Starter
- Powertrain Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- General Description
- Function Operation
- Fuel Control
- On-Board Diagnostics
- JTEC Controlled Rear Wheel Drive Vehicles
- Other Controls
- Charging System
- Leak Detection Pump System
- EVAP Leak Detection System Components
- Leak Detection Pump (LDP) Components
- LDP At Rest (Not Powered)
- Diaphragm Upward Movement
- Diaphragm Downward Movement
- Pumping Action
- Enabling Conditions To Run EVAP Leak Detection Test
- Section 1
- Section 2
- Section 3
- Section 4
- Section 5
- Diagnostic Tips
- Test Equipment
- Important
- Non-Monitored Circuits
- Diagnostic Trouble Codes
- Using The DRBIII®
- DRBIII® Error Messages And Blank Screen
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Acronyms
- Diagnostic Information And Procedures
- DTC Index
- Communication - Symptoms
- DRIVEABILITY - Gas - Symptoms
- Symptom: INTERMITTENT CONDITION
- Symptom: *BRAKE SWITCH SENSE STATUS DOES NOT CHANGE ON DRBIII™
- Symptom: *CANNOT SHIFT INTO 2ND AND 3RD GEARS
- Symptom: *CANNOT SHIFT INTO REVERSE
- Symptom: *CHECKING A/C SYSTEM OPERATION WITH NO DTCS
- Symptom: CHECKING CHARGING SYSTEM OPERATION WITH NO DTCS
- Symptom: CHECKING RADIATOR FAN OPERATION
- Symptom: CHECKING THE PCM POWER AND GROUNDS
- DRIVEABILITY - Gas - Diagnostic Tests
- P0031-O2 Sensor 1/1 Heater Circuit Low, P0032-O2 Sensor 1/1 Heater Circuit High, P0051-O2 Sensor 2/1 Heater Circuit Low, P0052-O2 Sensor 2/1 Heater Circuit High
- P0071-Ambient/Battery Temp Sensor Performance
- P0107-Map Sensor Voltage Too Low
- P0108-Map Sensor Voltage Too High
- P0111-Intake Air Temp Performance
- P0112-Intake Air Temp Sensor Voltage Too Low
- P0113-Intake Air Temp Sensor Voltage Too High
- P0117-Engine Coolant Temp Sensor Voltage Too Low
- P0118-Engine Coolant Temp Sensor Voltage Too High
- P0121-TP Sensor Voltage Does Not Agree With Map
- P0122-Throttle Position Sensor #1 Voltage Too Low
- P0123-Throttle Position Sensor #1 Voltage Too High
- P0125-Closed Loop Temp Not Reached
- P0131-O2 Sensor 1/1 Circuit Voltage Too Low, P0137-O2 Sensor 1/2 Circuit Voltage Too Low, P0151-O2 Sensor 2/1 Circuit Voltage Too Low, P0157-O2 Sensor 2/2 Circuit Voltage Too Low
- P0132-O2 Sensor 1/1 Circuit Voltage Too High, P0138-O2 Sensor 1/2 Circuit Voltage Too High, P0152-O2 Sensor 2/1 Circuit Voltage Too High, P0158-O2 Sensor 2/2 Circuit Voltage Too High
- P0133-O2 Sensor 1/1 Slow Response, P0139-O2 Sensor 1/2 Slow Response, P0153-O2 Sensor 2/1 Slow Response, P0159-O2 Sensor 2/2 Slow Response
- P0135-O2 Sensor 1/1 Heater Failure, P0141-O2 Sensor 1/2 Heater Failure, P0155-O2 Sensor 2/1 Heater Failure, P0161-O2 Sensor 2/2 Heater Failure
- P0136-O2 Sensor 1/2 Heater Circuit Malfunction
- P0171-1/1 Fuel System Lean, P0174-2/1 Fuel System Lean
- P0172-1/1 Fuel System Rich, P0175-2/1 Fuel System Rich
- P0197-Engine Oil Temperature Sensor Voltage Too Low
- P0198-Engine Oil Temperature Sensor Voltage Too High
- P0201-Injector #1 Control Circuit, P0202-Injector #2 Control Circuit, P0203-Injector #3 Control Circuit, P0204-Injector #4 Control Circuit, P0205-Injector #5 Control Circuit, P0206-Injector #6 Control Circuit, P0207-Injector #7 Control Circuit, P0208-Injector #8 Control Circuit, P0209-Injector #9 Control Circuit, P0210-Injector #10 Control Circuit
- P0300-Multiple Cylinder Mis-Fire, P0301-Cylinder #1 Misfire, P0302-Cylinder #2 Misfire, P0303-Cylinder #3 Misfire, P0304-Cylinder #4 Misfire, P0305-Cylinder #5 Misfire, P0306-Cylinder #6 Misfire, P0307-Cylinder #7 Misfire, P0308-Cylinder #8 Misfire, P0309-Cylinder #9 Misfire, P0310-Cylinder #10 Misfire
- P0320-No Crank Reference Signal At Pcm
- P0340-No Cam Reference Signal At Pcm
- P0351-Ignition Coil #1 Primary Circuit, P0352-Ignition Coil #2 Primary Circuit, P0353-Ignition Coil #3 Primary Circuit, P0354-Ignition Coil #4 Primary Circuit, P0355-Ignition Coil #5 Primary Circuit
- P0420-1/1 Catalytic Converter Efficiency, P0432-2/1 Catalytic Converter Efficiency
- P0441-EVAP Purge Flow Monitor
- P0442-EVAP Leak Monitor Medium (0.040) Leak Detected, P0445-EVAP Leak Monitor Large Leak Detected
- P0443-EVAP Purge Solenoid Circuit
- P0460-Fuel Level Sending Unit No Change Over Miles
- P0462-Fuel Level Sending Unit Volts Too Low
- P0463-Fuel Level Sending Unit Volts Too High
- P0500-No Vehicle Speed Signal
- P0505-Idle Air Control Motor Circuits
- P0522-Oil Pressure Circuit Low
- P0523-Oil Pressure Circuit High
- P0601-Pcm Internal Controller Failure
- P0622-Generator Field Not Switching Properly
- P0645-A/C Clutch Relay Circuit
- P0801-Reverse Gear Lockout Circuit Open Or Shorted
- P1195-O2 Sensor 1/1 Slow During Catalyst Monitor, P1196-O2 Sensor 2/1 Slow During Catalyst Monitor
- P1281-Engine Is Cold Too Long
- P1282-Fuel Pump/System Relay Control Circuit
- P1294-Target Idle Not Reached
- P1296-No 5-Volts To Map Sensor
- P1297-No Change In Map From Start To Run
- P1388-Auto Shutdown Relay Control Circuit
- P1389-No ASD Relay Output Voltage At Pcm
- P1391-Intermittent Loss Of CMP Or CKP
- P1398-Mis-Fire Adaptive Numerator At Limit
- P1486-EVAP Leak Monitor Pinched Hose Found
- P1492-Ambient/Battery Temperature Sensor Voltage Too High
- P1493-Ambient/Battery Temperature Sensor Voltage Too Low
- P1494-Leak Detection Pump Switch Or Mechanical Fault
- P1495-Leak Detection Pump Solenoid Circuit
- P1499-Hydraulic Fan Solenoid Circuit
- P1594-Charging System Voltage Too High
- P1598-A/C Pressure Sensor Voltage Too High
- P1599-A/C Pressure Sensor Voltage Too Low
- P1682-Charging System Voltage Too Low
- P1687-No Cluster Bus Message
- P1695-Bus Message From Body Control Module
- P1696-Pcm Failure EEPROM Write Denied
- P1719-Skip Shift Solenoid Circuit Open Or Shorted
- Starting - Symptoms
- Verification Tests
- Component Locations
- Control Modules And PDC
- Data Link Connector Location
- Sensors And Solenoids
- Battery Temperature Sensor Location
- Cam Position Sensor Location
- Crank Position Sensor Location
- MAP Sensor, ECT Sensor And Fuel Injector Locations
- IAT Sensor Location
- Engine Oil Pressure And Engine Oil Temperature Sensor Locations
- Oxygen Sensor Locations
- Throttle Position Sensor And IAC Motor Locations
- Ignition Coil Location
- Skip Shift Solenoid, Reverse Lockout Solenoid And Vehicle Speed Sensor Locations
- Fuel System
- Connector End Views
- A/C Compressor Clutch - Black 2 Way
- A/C Compressor Switch - DK. Green 2 Way
- A/C Pressure Transducer - Black 4 Way
- Battery Temperature Sensor - Way
- Brake Lamp Switch - Black 6 Way
- Camshaft Position Sensor - Gray 3 Way
- CLOCKSPRING - White 8 Way
- Clutch Interlock Switch - DK.Green 2 Way
- Crankshaft Position Sensor - Black 3 Way
- Data Link Connector - Black 2 Way
- Engine Coolant Temperature Sensor - Black 2 Way
- Engine Oil Pressure Sensor - Black 3 Way
- Engine Oil Temperature Sensor - Black 2 Way
- EVAP/Purge Solenoid - Black 2 Way
- Fuel Injector No. 1 - Black 2 Way
- Fuel Injector No. 2 - Black 2 Way
- Fuel Injector No. 3 - Black 2 Way
- Fuel Injector No. 4 - Black 2 Way
- Fuel Injector No. 5 - Black 2 Way
- Fuel Injector No. 6 - Black 2 Way
- Fuel Injector No. 7 - Black 2 Way
- Fuel Injector No. 8 - Black 2 Way
- Fuel Injector No. 9 - Black 2 Way
- Fuel Injector No. 10 - Black 2 Way
- Fuel Tank Module - Gray 2 Way
- Generator - Gray 2 Way
- Hydraulic Cooling Module - Black 3 Way
- Idle Air Control Motor-Black 4 Way
- Ignition Coil Pack-Left-Black 4 Way
- Ignition Coil Pack-Right-Black 3 Way
- Ignition Switch-Black 5 Way
- Intake Air Temperature Sensor-Black 2 Way
- Leak Detection Pump-Black 4 Way
- Manifold Absolute Pressure Sensor-Black 3 Way
- Multi-Function Switch-Gray 2 Way
- Oxygen Sensor 1/1 Left Bank Up-Black 4 Way
- Oxygen Sensor 1/2 Left Bank Down-Black 4 Way
- Oxygen Sensor 2/1 Right Bank Up-Black 4 Way
- Oxygen Sensor 2/2 Right Bank Down-Black 4 Way
- Power Distribution Center
- Fuses (PDC)
- A/C Compressor Clutch Relay
- Auto Shut Down Relay
- Fuel Pump Relay
- Oxygen Sensor Heater Relay
- Run/Acc Relay
- Starter Motor Relay
- Powertrain Control Module C1-Black/Black 32 Way
- Powertrain Control Module C2-Black/White 32 Way
- Powertrain Control Module C3-Black/Gray 32 Way
- Push-Button Starter Switch-Natural 6 Way
- Reverse Lock-Out Solenoid-White 2 Way
- Skip Shift Solenoid-White 2 Way
- Throttle Position Sensor-Black 3 Way
- Tire Pressure Monitor Module-Blue 6 Way
- VTSS Led-Black 2 Way
- Schematic Diagrams
- Charts And Graphs
- Starting System
- Starting
- Starter Motor
- Starter Motor Relay
- Starter Solenoid
- Powertrain Diagnostic Procedures
- Engine Performance
- Emissions
- Emission Applications
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Fuel Delivery
- Ignition System
- Mode 6 - CHRYSLER
- Introduction
- 1996
- 1997-1998
- 1999
- 2000
- 2001
- 2002
- 2003-2004
- 2005
- 2006
- 2007
- 2007-09 Diesel Engines
- 2008
- 2008-10 Viper
- 2009-10 Pt Cruiser
- 2009 - All Vehicles With V6 Or V8 Engines
- 2009 Vehicles With The "World I4" 4 Cylinder Engine
- 2010 Vehicles
- 2011 Vehicles
- 2012 Vehicles
- Remove, Overhaul & Install
- Fuel Delivery
- Fuel Injection
- Fuel Injection
- Accelerator Pedal
- Crankshaft Position Sensor
- Fuel Injectors
- Fuel Pump Relay
- Idle Air Control Motor
- Inlet Air Temperature Sensor
- Map Sensor
- O2 Sensor
- Throttle Body
- Throttle Cable
- Throttle Position Sensor
- Ignition Control
- Specifications
- System
- Electronic Control Modules
- Emissions Control
- On-Board Diagnostics
- Powertrain Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- General Description
- Function Operation
- Fuel Control
- On-Board Diagnostics
- JTEC Controlled Rear Wheel Drive Vehicles
- Other Controls
- Charging System
- Leak Detection Pump System
- EVAP Leak Detection System Components
- Leak Detection Pump (LDP) Components
- LDP At Rest (Not Powered)
- Diaphragm Upward Movement
- Diaphragm Downward Movement
- Pumping Action
- Enabling Conditions To Run EVAP Leak Detection Test
- Section 1
- Section 2
- Section 3
- Section 4
- Section 5
- Diagnostic Tips
- Test Equipment
- Important
- Non-Monitored Circuits
- Diagnostic Trouble Codes
- Using The DRBIII®
- DRBIII® Error Messages And Blank Screen
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Acronyms
- Diagnostic Information And Procedures
- DTC Index
- Communication - Symptoms
- DRIVEABILITY - Gas - Symptoms
- Symptom: INTERMITTENT CONDITION
- Symptom: *BRAKE SWITCH SENSE STATUS DOES NOT CHANGE ON DRBIII™
- Symptom: *CANNOT SHIFT INTO 2ND AND 3RD GEARS
- Symptom: *CANNOT SHIFT INTO REVERSE
- Symptom: *CHECKING A/C SYSTEM OPERATION WITH NO DTCS
- Symptom: CHECKING CHARGING SYSTEM OPERATION WITH NO DTCS
- Symptom: CHECKING RADIATOR FAN OPERATION
- Symptom: CHECKING THE PCM POWER AND GROUNDS
- DRIVEABILITY - Gas - Diagnostic Tests
- P0031-O2 Sensor 1/1 Heater Circuit Low, P0032-O2 Sensor 1/1 Heater Circuit High, P0051-O2 Sensor 2/1 Heater Circuit Low, P0052-O2 Sensor 2/1 Heater Circuit High
- P0071-Ambient/Battery Temp Sensor Performance
- P0107-Map Sensor Voltage Too Low
- P0108-Map Sensor Voltage Too High
- P0111-Intake Air Temp Performance
- P0112-Intake Air Temp Sensor Voltage Too Low
- P0113-Intake Air Temp Sensor Voltage Too High
- P0117-Engine Coolant Temp Sensor Voltage Too Low
- P0118-Engine Coolant Temp Sensor Voltage Too High
- P0121-TP Sensor Voltage Does Not Agree With Map
- P0122-Throttle Position Sensor #1 Voltage Too Low
- P0123-Throttle Position Sensor #1 Voltage Too High
- P0125-Closed Loop Temp Not Reached
- P0131-O2 Sensor 1/1 Circuit Voltage Too Low, P0137-O2 Sensor 1/2 Circuit Voltage Too Low, P0151-O2 Sensor 2/1 Circuit Voltage Too Low, P0157-O2 Sensor 2/2 Circuit Voltage Too Low
- P0132-O2 Sensor 1/1 Circuit Voltage Too High, P0138-O2 Sensor 1/2 Circuit Voltage Too High, P0152-O2 Sensor 2/1 Circuit Voltage Too High, P0158-O2 Sensor 2/2 Circuit Voltage Too High
- P0133-O2 Sensor 1/1 Slow Response, P0139-O2 Sensor 1/2 Slow Response, P0153-O2 Sensor 2/1 Slow Response, P0159-O2 Sensor 2/2 Slow Response
- P0135-O2 Sensor 1/1 Heater Failure, P0141-O2 Sensor 1/2 Heater Failure, P0155-O2 Sensor 2/1 Heater Failure, P0161-O2 Sensor 2/2 Heater Failure
- P0136-O2 Sensor 1/2 Heater Circuit Malfunction
- P0171-1/1 Fuel System Lean, P0174-2/1 Fuel System Lean
- P0172-1/1 Fuel System Rich, P0175-2/1 Fuel System Rich
- P0197-Engine Oil Temperature Sensor Voltage Too Low
- P0198-Engine Oil Temperature Sensor Voltage Too High
- P0201-Injector #1 Control Circuit, P0202-Injector #2 Control Circuit, P0203-Injector #3 Control Circuit, P0204-Injector #4 Control Circuit, P0205-Injector #5 Control Circuit, P0206-Injector #6 Control Circuit, P0207-Injector #7 Control Circuit, P0208-Injector #8 Control Circuit, P0209-Injector #9 Control Circuit, P0210-Injector #10 Control Circuit
- P0300-Multiple Cylinder Mis-Fire, P0301-Cylinder #1 Misfire, P0302-Cylinder #2 Misfire, P0303-Cylinder #3 Misfire, P0304-Cylinder #4 Misfire, P0305-Cylinder #5 Misfire, P0306-Cylinder #6 Misfire, P0307-Cylinder #7 Misfire, P0308-Cylinder #8 Misfire, P0309-Cylinder #9 Misfire, P0310-Cylinder #10 Misfire
- P0320-No Crank Reference Signal At Pcm
- P0340-No Cam Reference Signal At Pcm
- P0351-Ignition Coil #1 Primary Circuit, P0352-Ignition Coil #2 Primary Circuit, P0353-Ignition Coil #3 Primary Circuit, P0354-Ignition Coil #4 Primary Circuit, P0355-Ignition Coil #5 Primary Circuit
- P0420-1/1 Catalytic Converter Efficiency, P0432-2/1 Catalytic Converter Efficiency
- P0441-EVAP Purge Flow Monitor
- P0442-EVAP Leak Monitor Medium (0.040) Leak Detected, P0445-EVAP Leak Monitor Large Leak Detected
- P0443-EVAP Purge Solenoid Circuit
- P0460-Fuel Level Sending Unit No Change Over Miles
- P0462-Fuel Level Sending Unit Volts Too Low
- P0463-Fuel Level Sending Unit Volts Too High
- P0500-No Vehicle Speed Signal
- P0505-Idle Air Control Motor Circuits
- P0522-Oil Pressure Circuit Low
- P0523-Oil Pressure Circuit High
- P0601-Pcm Internal Controller Failure
- P0622-Generator Field Not Switching Properly
- P0645-A/C Clutch Relay Circuit
- P0801-Reverse Gear Lockout Circuit Open Or Shorted
- P1195-O2 Sensor 1/1 Slow During Catalyst Monitor, P1196-O2 Sensor 2/1 Slow During Catalyst Monitor
- P1281-Engine Is Cold Too Long
- P1282-Fuel Pump/System Relay Control Circuit
- P1294-Target Idle Not Reached
- P1296-No 5-Volts To Map Sensor
- P1297-No Change In Map From Start To Run
- P1388-Auto Shutdown Relay Control Circuit
- P1389-No ASD Relay Output Voltage At Pcm
- P1391-Intermittent Loss Of CMP Or CKP
- P1398-Mis-Fire Adaptive Numerator At Limit
- P1486-EVAP Leak Monitor Pinched Hose Found
- P1492-Ambient/Battery Temperature Sensor Voltage Too High
- P1493-Ambient/Battery Temperature Sensor Voltage Too Low
- P1494-Leak Detection Pump Switch Or Mechanical Fault
- P1495-Leak Detection Pump Solenoid Circuit
- P1499-Hydraulic Fan Solenoid Circuit
- P1594-Charging System Voltage Too High
- P1598-A/C Pressure Sensor Voltage Too High
- P1599-A/C Pressure Sensor Voltage Too Low
- P1682-Charging System Voltage Too Low
- P1687-No Cluster Bus Message
- P1695-Bus Message From Body Control Module
- P1696-Pcm Failure EEPROM Write Denied
- P1719-Skip Shift Solenoid Circuit Open Or Shorted
- Starting - Symptoms
- Verification Tests
- Component Locations
- Control Modules And PDC
- Data Link Connector Location
- Sensors And Solenoids
- Battery Temperature Sensor Location
- Cam Position Sensor Location
- Crank Position Sensor Location
- MAP Sensor, ECT Sensor And Fuel Injector Locations
- IAT Sensor Location
- Engine Oil Pressure And Engine Oil Temperature Sensor Locations
- Oxygen Sensor Locations
- Throttle Position Sensor And IAC Motor Locations
- Ignition Coil Location
- Skip Shift Solenoid, Reverse Lockout Solenoid And Vehicle Speed Sensor Locations
- Fuel System
- Connector End Views
- A/C Compressor Clutch - Black 2 Way
- A/C Compressor Switch - DK. Green 2 Way
- A/C Pressure Transducer - Black 4 Way
- Battery Temperature Sensor - Way
- Brake Lamp Switch - Black 6 Way
- Camshaft Position Sensor - Gray 3 Way
- CLOCKSPRING - White 8 Way
- Clutch Interlock Switch - DK.Green 2 Way
- Crankshaft Position Sensor - Black 3 Way
- Data Link Connector - Black 2 Way
- Engine Coolant Temperature Sensor - Black 2 Way
- Engine Oil Pressure Sensor - Black 3 Way
- Engine Oil Temperature Sensor - Black 2 Way
- EVAP/Purge Solenoid - Black 2 Way
- Fuel Injector No. 1 - Black 2 Way
- Fuel Injector No. 2 - Black 2 Way
- Fuel Injector No. 3 - Black 2 Way
- Fuel Injector No. 4 - Black 2 Way
- Fuel Injector No. 5 - Black 2 Way
- Fuel Injector No. 6 - Black 2 Way
- Fuel Injector No. 7 - Black 2 Way
- Fuel Injector No. 8 - Black 2 Way
- Fuel Injector No. 9 - Black 2 Way
- Fuel Injector No. 10 - Black 2 Way
- Fuel Tank Module - Gray 2 Way
- Generator - Gray 2 Way
- Hydraulic Cooling Module - Black 3 Way
- Idle Air Control Motor-Black 4 Way
- Ignition Coil Pack-Left-Black 4 Way
- Ignition Coil Pack-Right-Black 3 Way
- Ignition Switch-Black 5 Way
- Intake Air Temperature Sensor-Black 2 Way
- Leak Detection Pump-Black 4 Way
- Manifold Absolute Pressure Sensor-Black 3 Way
- Multi-Function Switch-Gray 2 Way
- Oxygen Sensor 1/1 Left Bank Up-Black 4 Way
- Oxygen Sensor 1/2 Left Bank Down-Black 4 Way
- Oxygen Sensor 2/1 Right Bank Up-Black 4 Way
- Oxygen Sensor 2/2 Right Bank Down-Black 4 Way
- Power Distribution Center
- Fuses (PDC)
- A/C Compressor Clutch Relay
- Auto Shut Down Relay
- Fuel Pump Relay
- Oxygen Sensor Heater Relay
- Run/Acc Relay
- Starter Motor Relay
- Powertrain Control Module C1-Black/Black 32 Way
- Powertrain Control Module C2-Black/White 32 Way
- Powertrain Control Module C3-Black/Gray 32 Way
- Push-Button Starter Switch-Natural 6 Way
- Reverse Lock-Out Solenoid-White 2 Way
- Skip Shift Solenoid-White 2 Way
- Throttle Position Sensor-Black 3 Way
- Tire Pressure Monitor Module-Blue 6 Way
- VTSS Led-Black 2 Way
- Schematic Diagrams
- Charts And Graphs
- Testing & Diagnosis
- Electronic Control Modules
- Emissions Control
- On-Board Diagnostics
- Powertrain Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- General Description
- Function Operation
- Fuel Control
- On-Board Diagnostics
- JTEC Controlled Rear Wheel Drive Vehicles
- Other Controls
- Charging System
- Leak Detection Pump System
- EVAP Leak Detection System Components
- Leak Detection Pump (LDP) Components
- LDP At Rest (Not Powered)
- Diaphragm Upward Movement
- Diaphragm Downward Movement
- Pumping Action
- Enabling Conditions To Run EVAP Leak Detection Test
- Section 1
- Section 2
- Section 3
- Section 4
- Section 5
- Diagnostic Tips
- Test Equipment
- Important
- Non-Monitored Circuits
- Diagnostic Trouble Codes
- Using The DRBIII®
- DRBIII® Error Messages And Blank Screen
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Acronyms
- Diagnostic Information And Procedures
- DTC Index
- Communication - Symptoms
- DRIVEABILITY - Gas - Symptoms
- Symptom: INTERMITTENT CONDITION
- Symptom: *BRAKE SWITCH SENSE STATUS DOES NOT CHANGE ON DRBIII™
- Symptom: *CANNOT SHIFT INTO 2ND AND 3RD GEARS
- Symptom: *CANNOT SHIFT INTO REVERSE
- Symptom: *CHECKING A/C SYSTEM OPERATION WITH NO DTCS
- Symptom: CHECKING CHARGING SYSTEM OPERATION WITH NO DTCS
- Symptom: CHECKING RADIATOR FAN OPERATION
- Symptom: CHECKING THE PCM POWER AND GROUNDS
- DRIVEABILITY - Gas - Diagnostic Tests
- P0031-O2 Sensor 1/1 Heater Circuit Low, P0032-O2 Sensor 1/1 Heater Circuit High, P0051-O2 Sensor 2/1 Heater Circuit Low, P0052-O2 Sensor 2/1 Heater Circuit High
- P0071-Ambient/Battery Temp Sensor Performance
- P0107-Map Sensor Voltage Too Low
- P0108-Map Sensor Voltage Too High
- P0111-Intake Air Temp Performance
- P0112-Intake Air Temp Sensor Voltage Too Low
- P0113-Intake Air Temp Sensor Voltage Too High
- P0117-Engine Coolant Temp Sensor Voltage Too Low
- P0118-Engine Coolant Temp Sensor Voltage Too High
- P0121-TP Sensor Voltage Does Not Agree With Map
- P0122-Throttle Position Sensor #1 Voltage Too Low
- P0123-Throttle Position Sensor #1 Voltage Too High
- P0125-Closed Loop Temp Not Reached
- P0131-O2 Sensor 1/1 Circuit Voltage Too Low, P0137-O2 Sensor 1/2 Circuit Voltage Too Low, P0151-O2 Sensor 2/1 Circuit Voltage Too Low, P0157-O2 Sensor 2/2 Circuit Voltage Too Low
- P0132-O2 Sensor 1/1 Circuit Voltage Too High, P0138-O2 Sensor 1/2 Circuit Voltage Too High, P0152-O2 Sensor 2/1 Circuit Voltage Too High, P0158-O2 Sensor 2/2 Circuit Voltage Too High
- P0133-O2 Sensor 1/1 Slow Response, P0139-O2 Sensor 1/2 Slow Response, P0153-O2 Sensor 2/1 Slow Response, P0159-O2 Sensor 2/2 Slow Response
- P0135-O2 Sensor 1/1 Heater Failure, P0141-O2 Sensor 1/2 Heater Failure, P0155-O2 Sensor 2/1 Heater Failure, P0161-O2 Sensor 2/2 Heater Failure
- P0136-O2 Sensor 1/2 Heater Circuit Malfunction
- P0171-1/1 Fuel System Lean, P0174-2/1 Fuel System Lean
- P0172-1/1 Fuel System Rich, P0175-2/1 Fuel System Rich
- P0197-Engine Oil Temperature Sensor Voltage Too Low
- P0198-Engine Oil Temperature Sensor Voltage Too High
- P0201-Injector #1 Control Circuit, P0202-Injector #2 Control Circuit, P0203-Injector #3 Control Circuit, P0204-Injector #4 Control Circuit, P0205-Injector #5 Control Circuit, P0206-Injector #6 Control Circuit, P0207-Injector #7 Control Circuit, P0208-Injector #8 Control Circuit, P0209-Injector #9 Control Circuit, P0210-Injector #10 Control Circuit
- P0300-Multiple Cylinder Mis-Fire, P0301-Cylinder #1 Misfire, P0302-Cylinder #2 Misfire, P0303-Cylinder #3 Misfire, P0304-Cylinder #4 Misfire, P0305-Cylinder #5 Misfire, P0306-Cylinder #6 Misfire, P0307-Cylinder #7 Misfire, P0308-Cylinder #8 Misfire, P0309-Cylinder #9 Misfire, P0310-Cylinder #10 Misfire
- P0320-No Crank Reference Signal At Pcm
- P0340-No Cam Reference Signal At Pcm
- P0351-Ignition Coil #1 Primary Circuit, P0352-Ignition Coil #2 Primary Circuit, P0353-Ignition Coil #3 Primary Circuit, P0354-Ignition Coil #4 Primary Circuit, P0355-Ignition Coil #5 Primary Circuit
- P0420-1/1 Catalytic Converter Efficiency, P0432-2/1 Catalytic Converter Efficiency
- P0441-EVAP Purge Flow Monitor
- P0442-EVAP Leak Monitor Medium (0.040) Leak Detected, P0445-EVAP Leak Monitor Large Leak Detected
- P0443-EVAP Purge Solenoid Circuit
- P0460-Fuel Level Sending Unit No Change Over Miles
- P0462-Fuel Level Sending Unit Volts Too Low
- P0463-Fuel Level Sending Unit Volts Too High
- P0500-No Vehicle Speed Signal
- P0505-Idle Air Control Motor Circuits
- P0522-Oil Pressure Circuit Low
- P0523-Oil Pressure Circuit High
- P0601-Pcm Internal Controller Failure
- P0622-Generator Field Not Switching Properly
- P0645-A/C Clutch Relay Circuit
- P0801-Reverse Gear Lockout Circuit Open Or Shorted
- P1195-O2 Sensor 1/1 Slow During Catalyst Monitor, P1196-O2 Sensor 2/1 Slow During Catalyst Monitor
- P1281-Engine Is Cold Too Long
- P1282-Fuel Pump/System Relay Control Circuit
- P1294-Target Idle Not Reached
- P1296-No 5-Volts To Map Sensor
- P1297-No Change In Map From Start To Run
- P1388-Auto Shutdown Relay Control Circuit
- P1389-No ASD Relay Output Voltage At Pcm
- P1391-Intermittent Loss Of CMP Or CKP
- P1398-Mis-Fire Adaptive Numerator At Limit
- P1486-EVAP Leak Monitor Pinched Hose Found
- P1492-Ambient/Battery Temperature Sensor Voltage Too High
- P1493-Ambient/Battery Temperature Sensor Voltage Too Low
- P1494-Leak Detection Pump Switch Or Mechanical Fault
- P1495-Leak Detection Pump Solenoid Circuit
- P1499-Hydraulic Fan Solenoid Circuit
- P1594-Charging System Voltage Too High
- P1598-A/C Pressure Sensor Voltage Too High
- P1599-A/C Pressure Sensor Voltage Too Low
- P1682-Charging System Voltage Too Low
- P1687-No Cluster Bus Message
- P1695-Bus Message From Body Control Module
- P1696-Pcm Failure EEPROM Write Denied
- P1719-Skip Shift Solenoid Circuit Open Or Shorted
- Starting - Symptoms
- Verification Tests
- Component Locations
- Control Modules And PDC
- Data Link Connector Location
- Sensors And Solenoids
- Battery Temperature Sensor Location
- Cam Position Sensor Location
- Crank Position Sensor Location
- MAP Sensor, ECT Sensor And Fuel Injector Locations
- IAT Sensor Location
- Engine Oil Pressure And Engine Oil Temperature Sensor Locations
- Oxygen Sensor Locations
- Throttle Position Sensor And IAC Motor Locations
- Ignition Coil Location
- Skip Shift Solenoid, Reverse Lockout Solenoid And Vehicle Speed Sensor Locations
- Fuel System
- Connector End Views
- A/C Compressor Clutch - Black 2 Way
- A/C Compressor Switch - DK. Green 2 Way
- A/C Pressure Transducer - Black 4 Way
- Battery Temperature Sensor - Way
- Brake Lamp Switch - Black 6 Way
- Camshaft Position Sensor - Gray 3 Way
- CLOCKSPRING - White 8 Way
- Clutch Interlock Switch - DK.Green 2 Way
- Crankshaft Position Sensor - Black 3 Way
- Data Link Connector - Black 2 Way
- Engine Coolant Temperature Sensor - Black 2 Way
- Engine Oil Pressure Sensor - Black 3 Way
- Engine Oil Temperature Sensor - Black 2 Way
- EVAP/Purge Solenoid - Black 2 Way
- Fuel Injector No. 1 - Black 2 Way
- Fuel Injector No. 2 - Black 2 Way
- Fuel Injector No. 3 - Black 2 Way
- Fuel Injector No. 4 - Black 2 Way
- Fuel Injector No. 5 - Black 2 Way
- Fuel Injector No. 6 - Black 2 Way
- Fuel Injector No. 7 - Black 2 Way
- Fuel Injector No. 8 - Black 2 Way
- Fuel Injector No. 9 - Black 2 Way
- Fuel Injector No. 10 - Black 2 Way
- Fuel Tank Module - Gray 2 Way
- Generator - Gray 2 Way
- Hydraulic Cooling Module - Black 3 Way
- Idle Air Control Motor-Black 4 Way
- Ignition Coil Pack-Left-Black 4 Way
- Ignition Coil Pack-Right-Black 3 Way
- Ignition Switch-Black 5 Way
- Intake Air Temperature Sensor-Black 2 Way
- Leak Detection Pump-Black 4 Way
- Manifold Absolute Pressure Sensor-Black 3 Way
- Multi-Function Switch-Gray 2 Way
- Oxygen Sensor 1/1 Left Bank Up-Black 4 Way
- Oxygen Sensor 1/2 Left Bank Down-Black 4 Way
- Oxygen Sensor 2/1 Right Bank Up-Black 4 Way
- Oxygen Sensor 2/2 Right Bank Down-Black 4 Way
- Power Distribution Center
- Fuses (PDC)
- A/C Compressor Clutch Relay
- Auto Shut Down Relay
- Fuel Pump Relay
- Oxygen Sensor Heater Relay
- Run/Acc Relay
- Starter Motor Relay
- Powertrain Control Module C1-Black/Black 32 Way
- Powertrain Control Module C2-Black/White 32 Way
- Powertrain Control Module C3-Black/Gray 32 Way
- Push-Button Starter Switch-Natural 6 Way
- Reverse Lock-Out Solenoid-White 2 Way
- Skip Shift Solenoid-White 2 Way
- Throttle Position Sensor-Black 3 Way
- Tire Pressure Monitor Module-Blue 6 Way
- VTSS Led-Black 2 Way
- Schematic Diagrams
- Charts And Graphs
- Theory and Operation
- Electronic Control Modules
- Emissions Control
- Fuel Injection
- Fuel Injection
- Accelerator Pedal
- Crankshaft Position Sensor
- Fuel Injectors
- Fuel Pump Relay
- Idle Air Control Motor
- Inlet Air Temperature Sensor
- Map Sensor
- O2 Sensor
- Throttle Body
- Throttle Cable
- Throttle Position Sensor
- Ignition Control
- On-Board Diagnostics
- Tune-Up
- Vacuum Diagrams
- Emissions
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- OBD-II Drive Cycles
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- DTC Index
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Identification
- Metric Conversions
- Reset Procedures
- BARTEC TPMS Reset Procedure (No COMS)
- Maintenance Reminder Light (Reset Procedures)
- Emissions Maintenance Reminder (EGR)
- Emissions Maintenance Reminder (EMR Mileage)
- Emissions Maintenance Reminder (MAINT REQD Or Check EGR)
- Emissions Maintenance Reminder (Sri)
- Engine Oil Replacement Reminder
- Maintenance Service Reminder (ASSYST Maintenance Computer)
- Maintenance Service Reminder (Perform Service)
- Maintenance Service Reminder (Service Reminder Indicator)
- Maintenance Service Reminder (Service Reminder Message)
- Tire Pressure Monitor System Reminder
- Restraints
- Specifications Index
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Suspension
- Traction Control Disable Procedures
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- General Servicing
- HVAC Control Systems
- Air Conditioning Controls
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Body Control Module
- Chime Warning System
- Communication
- Door Ajar System
- Exterior Lighting System
- Relays Controlled By The BCM
- Heating & A/C System
- Instrument Cluster / Gauge Cluster
- Interior Lighting
- Tire Pressure Monitoring System (TPMS)
- Power Door Entry System
- Power Windows
- Electrically Heated Systems
- Vehicle Theft Security System
- Using The DRBIII®
- DRBIII® Error Messages
- DRBIII® Does Not Power Up (Blank Screen)
- Display Is Not Visible
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Air Bag
- Symptom List: ACCELEROMETER 1; ACCELEROMETER 2; INTERNAL 1; OUTPUT DRIVER 1; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: DRIVER SQUIB 2 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 2 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 2 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 2 SHORT TO GROUND
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH OPEN
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO BATTERY
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO GROUND
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO BATTERY
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: PASSENGER SQUIB 2 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 2 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 2 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 2 SHORT TO GROUND
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: All OUTPUTS SHORT
- Symptom List; CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH BCM
- Chime
- Communication
- Symptom: ACM MESSAGES NOT RECEIVED
- Symptom: AUDIO MESSAGES NOT RECEIVED
- Symptom: COUNTRY CODE NOT PROGRAMMED
- Symptom: INTERNAL BCM FAILURE
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom List: PCI BUS SHORTED TO BATTERY; PCI BUS SHORTED TO GROUND
- Symptom: PCI INTERNAL FAULT
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *NO RESPONSE FROM ACM
- Symptom: *NO RESPONSE FROM BODY CONTROL MODULE
- Symptom: *NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE
- Symptom: *NO RESPONSE FROM HVAC
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM PCM (PCI BUS)
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY)
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM TIRE PRESSURE MONITOR MODULE
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Door Ajar
- Symptom: *DECKLID AJAR CIRCUIT OPEN
- Symptom: *DECKLID AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *DRIVER DOOR AJAR CIRCUIT OPEN
- Symptom: *DRIVER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *HOOD AJAR CIRCUIT OPEN
- Symptom: *HOOD AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *PASSENGER DOOR AJAR CIRCUIT OPEN
- Symptom: *PASSENGER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Electrically Heated Systems
- Exterior Lighting
- Symptom: LEFT FOG LAMP OUTPUT OPEN
- Symptom: LEFT FOG LAMP OUTPUT SHORTED
- Symptom: LEFT HIGH BEAM OUTPUT OPEN
- Symptom: LEFT HIGH BEAM OUTPUT SHORT
- Symptom: LOW BEAM RELAY COIL OUTPUT OPEN/SHORT TO GROUND
- Symptom: LOW BEAM RELAY COIL SHORT TO VOLTAGE
- Symptom: PARK LAMP OUTPUT SHORT
- Symptom: RIGHT FOG LAMP OUTPUT OPEN
- Symptom: RIGHT FOG LAMP OUTPUT SHORTED
- Symptom: RIGHT HIGH BEAM OUTPUT OPEN
- Symptom: RIGHT HIGH BEAM OUTPUT SHORT
- Heating & A/C
- Symptom List: A/C SWITCH FAULT (ACTIVE); CHECKSUM FAILURE (ACTIVE); DEFOG SWITCH FAULT (ACTIVE)
- Symptom List: A/C SWITCH FAULT (STORED); BACKLIGHT DIMMING RX FAILURE (STORED); BLEND OVERCURRENT (STORED); CHECKSUM FAILURE (STORED); DEFOG SWITCH FAULT (STORED); LOOPBACK TEST FAILURE (STORED); MODE 1 OVERCURRENT (STORED); MODE 2 OVERCURRENT (STORED); RECIRC OVERCURRENT (STORED); REFRIGERANT PRESS RX FAILURE (STORED); TX FAILURE (STORED); VIN RX FAILURE (STORED)
- Notes
- When Monitored and Set Condition:
- A/C Switch Fault (Stored)
- Backlight Dimming RX Failure (Stored)
- Blend OVERCURRENT (Stored)
- Checksum Failure (Stored)
- Defog Switch Fault (Stored)
- LOOPBACK Test Failure (Stored)
- Mode 1 OVERCURRENT (Stored)
- Mode 2 OVERCURRENT (Stored)
- RECIRC OVERCURRENT (Stored)
- Refrigerant Press RX Failure (Stored)
- TX Failure (Stored)
- VIN RX Failure (Stored)
- Possible Causes
- Diagnostic Procedure
- Symptom List: ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE; BLEND CIRCUIT SHORTED TO GROUND; BLEND CIRCUIT SHORTED TO IGN OR BATT; COMMON DRIVER SHORTED TO GROUND; COMMON DRIVER SHORTED TO IGN OR BATT; MODE 1 CIRCUIT SHORTED TO GROUND; MODE 1 CIRCUIT SHORTED TO IGN OR BATT; MODE 2 CIRCUIT SHORTED TO GROUND; MODE 2 CIRCUIT SHORTED TO IGN OR BATT; RECIRC CIRCUIT SHORTED TO GROUND; RECIRC CIRCUIT SHORTED TO IGN OR BATT; SHORT TOO COMPLEX
- Notes
- When Monitored and Set Condition:
- Act CKT Test Passed, OVERCURRENT DTCS Active
- Blend Circuit Shorted To Ground
- Blend Circuit Shorted To IGN Or Batt
- Common Driver Shorted To Ground
- Common Driver Shorted To IGN Or Batt
- Mode 1 Circuit Shorted To Ground
- Mode 1 Circuit Shorted To IGN Or Batt
- Mode 2 Circuit Shorted To Ground
- Mode 2 Circuit Shorted To IGN Or Batt
- RECIRC Circuit Shorted To Ground
- RECIRC Circuit Shorted To IGN Or Batt
- Short Too Complex
- Possible Causes
- Diagnostic Procedure
- Symptom: BACKLIGHT DIMMING RX FAILURE (ACTIVE)
- Symptom List: BLEND CALIBRATION FAULT; MODE 1 CALIBRATION FAULT; MODE 2 CALIBRATION FAULT; RECIRCULATION CALIBRATION FAULT
- Symptom List: BLEND OVERCURRENT (ACTIVE); MODE 1 OVERCURRENT (ACTIVE); MODE 2 OVERCURRENT (ACTIVE); RECIRC OVERCURRENT (ACTIVE)
- Symptom: DEFOG RELAY CONTROL CKT SHORTED TO BATT
- Symptom: LOOPBACK TEST FAILURE (ACTIVE)
- Symptom List: REFRIGERANT PRESSURE RX FAILURE (ACTIVE); VIN RX FAILURE (ACTIVE)
- Symptom: TX FAILURE (ACTIVE)
- Symptom: *A/C - HEATER CONTROL ILLUMINATION INOPERATIVE
- Symptom: *BLEND/MODE/RECIRC DOOR OPERATION IMPROPER
- Symptom: *BLOWER MOTOR INOPERATIVE
- Symptom: *BLOWER MOTOR SPEEDS INCORRECT
- Symptom: *EBL STATUS INDICATOR FLASHING
- Symptom: *HVAC SYSTEM TEST
- Ignition, Power, Accessory
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT OPEN
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT SHORT TO GROUND
- Symptom: BCM - IGNITION MUX SWITCH INPUT MISMATCH
- Symptom: BCM - IGNITION MUX SWITCH INPUT OPEN
- Symptom: BCM - IGNITION MUX SWITCH INPUT SHORT
- Symptom: BCM - IGNITION RUN 1 SHORT
- Symptom: BCM - IGNITION RUN 2 SHORT
- Symptom: BCM - IOD OUTPUT CIRCUIT SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT OPEN / SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT SHORT TO VOLTAGE
- Symptom: BCM - RUN/START HARDWIRE INPUT MISMATCH
- Symptom: HORN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: HORN RELAY COIL SHORT TO BATTERY
- Symptom: HORN SWITCH STUCK
- Symptom: *HORNS INOPERATIVE
- Instrument Cluster
- Symptom List: ABS LAMP CIRCUIT OPEN; ABS LAMP CIRCUIT SHORTED; AIRBAG LAMP CIRCUIT OPEN; AIRBAG LAMP CIRCUIT SHORTED
- Symptom: ABS MESSAGES NOT RECEIVED
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT OPEN / SHORTED TO VOLTAGE
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT SHORT TO GROUND
- Symptom: BCM - PWM DIMMING OUTPUT SHORT
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: ORC MESSAGES NOT RECEIVED
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *GAUGE CLUSTER DIAGNOSTIC TEST
- Symptom: *INSTRUMENT CLUSTER DIAGNOSTIC TEST
- Interior Lighting
- Power Door Locks/RKE
- Symptom: DECKLID RELEASE OUTPUT OPEN
- Symptom: DECKLID RELEASE OUTPUT SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH OPEN OR SHORT TO VOLTAGE
- Symptom: DRIVER CYLINDER UNLOCK SWITCH SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH STUCK
- Symptom: DRIVER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: DRIVER DOOR LOCK SWITCH STUCK
- Symptom: DRIVER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: DRIVER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: DRIVER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER DOOR LOCK SWITCH STUCK
- Symptom: PASSENGER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER/DRIVER DOOR UNLATCH RETURN SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT OPEN/SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT SHORT TO BATTERY
- Symptom: *ALL DOOR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR UNLATCH INOPERATIVE
- Symptom: *PASSENGER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *PASSENGER DOOR UNLATCH INOPERATIVE
- Symptom: *REMOTE KEYLESS ENTRY PROBLEM
- Power Windows
- Symptom: DRIVER WINDOW DOWN OUTPUT SHORT TO GROUND
- Symptom: DRIVER WINDOW HALL EFFECT FAILURE
- Symptom: DRIVER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: DRIVER WINDOW SWITCH SHORT TO GROUND
- Symptom: DRIVER WINDOW SWITCH STUCK DOWN
- Symptom: DRIVER WINDOW SWITCH STUCK UP
- Symptom: DRIVER WINDOW UP OUTPUT SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL SHORT TO BATTERY
- Symptom: PASSENGER WINDOW HALL EFFECT FAILURE
- Symptom: PASSENGER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: PASSENGER WINDOW SWITCH SHORT TO GROUND
- Symptom: PASSENGER WINDOW SWITCH STUCK DOWN
- Symptom: PASSENGER WINDOW SWITCH STUCK UP
- Symptom: PASSENGER WINDOW UP SHORT TO GROUND
- Symptom: *DRIVER WINDOW INOPERATIVE
- Symptom: *PASSENGER WINDOW INOPERATIVE
- Tire Pressure Monitoring
- Symptom: CRITICAL TIRE PRESSURE - BCM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM; LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM; RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM; RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM
- Symptom: TIRE PRESSURE LOW - BCM
- Symptom: TIRE PRESSURE MONITOR MODULE FAILURE - TPM
- Symptom: TPM DIAGNOSTIC - BCM
- Symptom: TPM MODULE INITIALIZED - BCM
- Symptom: *LO TIRE LCD MESSAGE FLASHING
- Symptom: VTSS INDICATOR OUTPUT OPEN
- Symptom: VTSS INDICATOR OUTPUT SHORT
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *DECKLID DOES NOT TRIP VTSS
- Symptom: *DRIVER DOOR DOES NOT TRIP VTSS
- Symptom: *EXTERIOR LAMPS FAIL TO FLASH WHEN ALARM IS TRIPPED
- Symptom: *HOOD DOES NOT TRIP VTSS
- Symptom: *HORN FAILS TO SOUND WHEN ALARM IS TRIPPED
- Symptom: *PASSENGER DOOR DOES NOT TRIP VTSS
- Symptom: *VTSS LAMP ON STEADY DURING ARMING
- Symptom: *VTSS WILL NOT ARM
- Verification Tests
- Air Bag
- Component Locations
- Connector PINOUTS
- A/C-Heater Control C1 - Black 10 Way
- A/C-Heater Control C2 - Black 16 Way
- Airbag Control Module C1 (Orc) - Yellow 32 Way
- Airbag Control Module C2 (Orc) Yellow 32 Way
- Airbag On/Off Switch-Passenger - Yellow 6 Way
- Airbag Squib 1-Driver - Yellow/Black 2 Way
- Airbag Squib 2-Driver - Yellow/Gray 2 Way
- Airbag Squib-Passenger - Yellow 4 Way
- Ajar Switch-DECKLID - Black 3 Way
- Ajar Switch-Driver Door - Black 4 Way
- Ajar Switch-Hood - Natural 3 Way
- Ajar Switch-Passenger Door - Black 4 Way
- Blend Door Actuator - Gray 2 Way
- Blower Motor - Orange 2 Way
- Blower Motor Resistor Block - Black 4 Way
- Body Control Module C1 - Black 6 Way
- Body Control Module C2 - Black/Green 34 Way
- Body Control Module C3 - Black/White 34 Way
- Body Control Module C4 - Black/Gray 34 Way
- Body Control Module C5 - Black/Black 34 Way
- Brake Fluid Level Switch - Black 2 Way
- C200 - Black (Body Side)
- C200 - Black (Instrument Panel Side)
- C201 - Yellow (Body Side)
- C201 - Yellow (Instrument Panel Side)
- C204 - (HVAC Jumper Side)
- C204 - (Instrument Panel Side)
- C206 - Red (Console Jumper Side)
- C206 - Red (Instrument Panel Side)
- CLOCKSPRING - White 8 Way
- Controller Antilock Brake - Black 24 Way
- Cylinder Unlock Switch-Driver - Black 2 Way
- Data Link Connector - Black 16 Way
- DECKLID Release Motor - Black 2 Way
- Door Latch Motor-Driver - 2 Way
- Door Latch Motor-Passenger - 2 Way
- Door Lock Switch-Driver - Black 3 Way
- Door Lock Switch-Passenger - Black 3 Way
- Exterior Door Handle Switch-Driver - Black 2 Way
- Exterior Door Handle Switch-Passenger Black 2 Way
- Fog Lamp-Left - Black 2 Way
- Gauge Cluster C1 - White 3 Way
- Gauge Cluster C2 - Black 20 Way
- Hid Lamp-Left - Gray 2 Way
- High Beam Headlamp-Left - Black 2 Way
- Horn-High Note - Black 2 Way
- Horn-Low Note - Black 2 Way
- Ignition Switch - Black 5 Way
- Instrument Cluster C1 - Black 16 Way
- Instrument Cluster C12 - Black 20 Way
- Interior Door Handle Switch-Driver - Black 2 Way
- Interior Door Handle Switch-Passenger - Black 2 Way
- Marker Lamp-Left Front - DK.Gray 2 Way
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way
- Multi-Function Switch - Gray 20 Way
- Park/Turn Lamp-Left - Black 3 Way
- Power Amplifier C1 - DK.Gray 14 Way
- Power Amplifier C2 - Green 16 Way
- Fuses (PDC)
- Power Window Motor-Driver - 6 Way
- Power Window Motor-Passenger - 6 Way
- Power Window Switch-Driver - Gray 3 Way
- Power Window Switch-Passenger - Gray 3 Way
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Radio - Gray 22 Way
- RECIRCULATION Door Actuator - Gray 2 Way
- Remote Keyless Entry Module - Black 6 Way
- Seat Belt Switch-Driver - White 2 Way
- Seat Belt Switch-Passenger - White 2 Way
- Seat Belt TENSIONER-Driver - Yellow 2 Way
- Seat Belt TENSIONER-Passenger - Yellow 2 Way
- Speaker-Left Door - Black 2 Way
- Speaker-Left Instrument Panel - White 2 Way
- Speaker-Left Rear - White 3 Way
- Speaker-Rear Woofer - Gray 4 Way
- Speaker-Right Door - Black 2 Way
- Speaker-Right Instrument Panel - White 2 Way
- Speaker-Right Rear - White 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Window Down Relay-Passenger - Black 5 Way
- Window Up Relay-Passenger - Black 5 Way
- Schematic Diagrams
- Airbag System
- Audio System
- Chime System
- Communication
- Door Ajar System
- Electrically Heated Systems
- Exterior Lighting
- Heating & A/C System
- Ignition, Power, Accessory
- Instrument Cluster/Gauge Cluster
- Interior Lighting
- Power Door Locks/RKE
- Power Window System
- Tire Pressure Monitor Module (TPM)
- Vehicle Theft Security System
- HVAC - Airflow Distribution
- HVAC - Plumbing
- Plumbing
- A/C Compressor
- A/C Condenser
- A/C Discharge Line
- A/C Evaporator
- A/C Variable ORFICE Tube
- Accumulator
- Heater Core
- Heater Inlet Hose
- Heater Return Hose
- Liquid Line
- Refrigerant
- Refrigerant Oil
- Service Port Valve Core
- Suction Line
- HVAC Systems
- Maintenance
- Procedures
- Lubrication
- Maintenance Reminder Light (Reset Procedures)
- Emissions Maintenance Reminder (EGR)
- Emissions Maintenance Reminder (EMR Mileage)
- Emissions Maintenance Reminder (MAINT REQD Or Check EGR)
- Emissions Maintenance Reminder (Sri)
- Engine Oil Replacement Reminder
- Maintenance Service Reminder (ASSYST Maintenance Computer)
- Maintenance Service Reminder (Perform Service)
- Maintenance Service Reminder (Service Reminder Indicator)
- Maintenance Service Reminder (Service Reminder Message)
- Tire Pressure Monitor System Reminder
- Procedures
- Restraints
- Steering
- Manual Steering
- Power Steering Gear
- Power Steering Pump
- Power Steering System
- Power Steering
- Power Steering Gear
- Power Steering Pump
- Power Steering System
- Steering Wheel & Steering Column
- Power Steering Gear
- Manual Steering
- Suspension
- Front Suspension
- Rear Suspension
- Wheel Alignment Specifications & Adjustment Procedures
- Wheels & Tire System
- Body Diagnostic Procedures
- Introduction
- Identification Of System
- System Description And Functional Operation
- Notes
- Airbag System
- Audio System
- Body Control Module
- Chime Warning System
- Communication
- Door Ajar System
- Exterior Lighting System
- Relays Controlled By The BCM
- Heating & A/C System
- Instrument Cluster / Gauge Cluster
- Interior Lighting
- Tire Pressure Monitoring System (TPMS)
- Power Door Entry System
- Power Windows
- Electrically Heated Systems
- Vehicle Theft Security System
- Using The DRBIII®
- DRBIII® Error Messages
- DRBIII® Does Not Power Up (Blank Screen)
- Display Is Not Visible
- Disclaimers, Safety, Warnings
- Required Tools And Equipment
- Glossary Of Terms
- Diagnostic Information And Procedures
- Air Bag
- Symptom List: ACCELEROMETER 1; ACCELEROMETER 2; INTERNAL 1; OUTPUT DRIVER 1; STORED ENERGY FIRING 1
- Symptom List: AIRBAG WARNING INDICATOR OPEN; AIRBAG WARNING INDICATOR SHORT
- Symptom: CLUSTER MESSAGE MISMATCH
- Symptom: DRIVER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: DRIVER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: DRIVER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: DRIVER SQUIB 1 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 1 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 1 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 1 SHORT TO GROUND
- Symptom: DRIVER SQUIB 2 CIRCUIT OPEN
- Symptom: DRIVER SQUIB 2 CIRCUIT SHORT
- Symptom: DRIVER SQUIB 2 SHORT TO BATTERY
- Symptom: DRIVER SQUIB 2 SHORT TO GROUND
- Symptom: LOSS OF IGNITION RUN - START
- Symptom: LOSS OF IGNITION RUN ONLY
- Symptom: NO CLUSTER MESSAGE
- Symptom: NO PCI TRANSMISSION
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH OPEN
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO BATTERY
- Symptom: PASSENGER AIRBAG ON - OFF SWITCH SHORT TO GROUND
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO BATTERY
- Symptom: PASSENGER OFF INDICATOR CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT SWITCH CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT SWITCH SHORT TO GROUND
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT OPEN
- Symptom: PASSENGER SEAT BELT TENSIONER CIRCUIT SHORT
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO BATTERY
- Symptom: PASSENGER SEAT BELT TENSIONER SHORT TO GROUND
- Symptom: PASSENGER SQUIB 1 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 1 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 1 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 1 SHORT TO GROUND
- Symptom: PASSENGER SQUIB 2 CIRCUIT OPEN
- Symptom: PASSENGER SQUIB 2 CIRCUIT SHORT
- Symptom: PASSENGER SQUIB 2 SHORT TO BATTERY
- Symptom: PASSENGER SQUIB 2 SHORT TO GROUND
- Symptom: *AIRBAG INDICATOR ON WITHOUT ACTIVE TROUBLE CODES
- Audio
- Symptom: All OUTPUTS SHORT
- Symptom List; CD MECHANICAL FAILURE; NO PCI TRANSMISSION; *AM/FM SWITCH INOPERATIVE; *ANY STATION PRESET SWITCH INOPERATIVE; *BALANCE INOPERATIVE; *CD EJECT SWITCH INOPERATIVE; *EQUALIZER INOPERATIVE; *FADER INOPERATIVE; *FF/RW SWITCH INOPERATIVE; *HOUR/MINUTE SWITCHES INOPERATIVE; *PAUSE/PLAY SWITCH INOPERATIVE; *PWR SWITCH INOPERATIVE; *SCAN SWITCH INOPERATIVE; *SEEK SWITCH INOPERATIVE; *SET SWITCH INOPERATIVE; *TAPE EJECT SWITCH INOPERATIVE; *TIME SWITCH INOPERATIVE; *TUNE SWITCH INOPERATIVE
- Symptom: CD PLAY FAILURE
- Symptom: CD READ FAILURE
- Symptom: CD TEMPERATURE HIGH
- symptom: LOW VOLTAGE LEVEL
- Symptom: NO ANTENNA CONNECTION
- Symptom: NO COMMUNICATION WITH BCM
- Chime
- Communication
- Symptom: ACM MESSAGES NOT RECEIVED
- Symptom: AUDIO MESSAGES NOT RECEIVED
- Symptom: COUNTRY CODE NOT PROGRAMMED
- Symptom: INTERNAL BCM FAILURE
- Symptom: MIC MESSAGES NOT RECEIVED
- Symptom List: PCI BUS SHORTED TO BATTERY; PCI BUS SHORTED TO GROUND
- Symptom: PCI INTERNAL FAULT
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *NO RESPONSE FROM ACM
- Symptom: *NO RESPONSE FROM BODY CONTROL MODULE
- Symptom: *NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE
- Symptom: *NO RESPONSE FROM HVAC
- Symptom: *NO RESPONSE FROM INSTRUMENT CLUSTER
- Symptom: *NO RESPONSE FROM PCM (PCI BUS)
- Symptom: *NO RESPONSE FROM PCM (SCI ONLY)
- Symptom: *NO RESPONSE FROM RADIO
- Symptom: *NO RESPONSE FROM TIRE PRESSURE MONITOR MODULE
- Symptom: *PCI BUS COMMUNICATION FAILURE
- Door Ajar
- Symptom: *DECKLID AJAR CIRCUIT OPEN
- Symptom: *DECKLID AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *DRIVER DOOR AJAR CIRCUIT OPEN
- Symptom: *DRIVER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *HOOD AJAR CIRCUIT OPEN
- Symptom: *HOOD AJAR CIRCUIT SHORTED TO GROUND
- Symptom: *PASSENGER DOOR AJAR CIRCUIT OPEN
- Symptom: *PASSENGER DOOR AJAR CIRCUIT SHORTED TO GROUND
- Electrically Heated Systems
- Exterior Lighting
- Symptom: LEFT FOG LAMP OUTPUT OPEN
- Symptom: LEFT FOG LAMP OUTPUT SHORTED
- Symptom: LEFT HIGH BEAM OUTPUT OPEN
- Symptom: LEFT HIGH BEAM OUTPUT SHORT
- Symptom: LOW BEAM RELAY COIL OUTPUT OPEN/SHORT TO GROUND
- Symptom: LOW BEAM RELAY COIL SHORT TO VOLTAGE
- Symptom: PARK LAMP OUTPUT SHORT
- Symptom: RIGHT FOG LAMP OUTPUT OPEN
- Symptom: RIGHT FOG LAMP OUTPUT SHORTED
- Symptom: RIGHT HIGH BEAM OUTPUT OPEN
- Symptom: RIGHT HIGH BEAM OUTPUT SHORT
- Heating & A/C
- Symptom List: A/C SWITCH FAULT (ACTIVE); CHECKSUM FAILURE (ACTIVE); DEFOG SWITCH FAULT (ACTIVE)
- Symptom List: A/C SWITCH FAULT (STORED); BACKLIGHT DIMMING RX FAILURE (STORED); BLEND OVERCURRENT (STORED); CHECKSUM FAILURE (STORED); DEFOG SWITCH FAULT (STORED); LOOPBACK TEST FAILURE (STORED); MODE 1 OVERCURRENT (STORED); MODE 2 OVERCURRENT (STORED); RECIRC OVERCURRENT (STORED); REFRIGERANT PRESS RX FAILURE (STORED); TX FAILURE (STORED); VIN RX FAILURE (STORED)
- Notes
- When Monitored and Set Condition:
- A/C Switch Fault (Stored)
- Backlight Dimming RX Failure (Stored)
- Blend OVERCURRENT (Stored)
- Checksum Failure (Stored)
- Defog Switch Fault (Stored)
- LOOPBACK Test Failure (Stored)
- Mode 1 OVERCURRENT (Stored)
- Mode 2 OVERCURRENT (Stored)
- RECIRC OVERCURRENT (Stored)
- Refrigerant Press RX Failure (Stored)
- TX Failure (Stored)
- VIN RX Failure (Stored)
- Possible Causes
- Diagnostic Procedure
- Symptom List: ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE; BLEND CIRCUIT SHORTED TO GROUND; BLEND CIRCUIT SHORTED TO IGN OR BATT; COMMON DRIVER SHORTED TO GROUND; COMMON DRIVER SHORTED TO IGN OR BATT; MODE 1 CIRCUIT SHORTED TO GROUND; MODE 1 CIRCUIT SHORTED TO IGN OR BATT; MODE 2 CIRCUIT SHORTED TO GROUND; MODE 2 CIRCUIT SHORTED TO IGN OR BATT; RECIRC CIRCUIT SHORTED TO GROUND; RECIRC CIRCUIT SHORTED TO IGN OR BATT; SHORT TOO COMPLEX
- Notes
- When Monitored and Set Condition:
- Act CKT Test Passed, OVERCURRENT DTCS Active
- Blend Circuit Shorted To Ground
- Blend Circuit Shorted To IGN Or Batt
- Common Driver Shorted To Ground
- Common Driver Shorted To IGN Or Batt
- Mode 1 Circuit Shorted To Ground
- Mode 1 Circuit Shorted To IGN Or Batt
- Mode 2 Circuit Shorted To Ground
- Mode 2 Circuit Shorted To IGN Or Batt
- RECIRC Circuit Shorted To Ground
- RECIRC Circuit Shorted To IGN Or Batt
- Short Too Complex
- Possible Causes
- Diagnostic Procedure
- Symptom: BACKLIGHT DIMMING RX FAILURE (ACTIVE)
- Symptom List: BLEND CALIBRATION FAULT; MODE 1 CALIBRATION FAULT; MODE 2 CALIBRATION FAULT; RECIRCULATION CALIBRATION FAULT
- Symptom List: BLEND OVERCURRENT (ACTIVE); MODE 1 OVERCURRENT (ACTIVE); MODE 2 OVERCURRENT (ACTIVE); RECIRC OVERCURRENT (ACTIVE)
- Symptom: DEFOG RELAY CONTROL CKT SHORTED TO BATT
- Symptom: LOOPBACK TEST FAILURE (ACTIVE)
- Symptom List: REFRIGERANT PRESSURE RX FAILURE (ACTIVE); VIN RX FAILURE (ACTIVE)
- Symptom: TX FAILURE (ACTIVE)
- Symptom: *A/C - HEATER CONTROL ILLUMINATION INOPERATIVE
- Symptom: *BLEND/MODE/RECIRC DOOR OPERATION IMPROPER
- Symptom: *BLOWER MOTOR INOPERATIVE
- Symptom: *BLOWER MOTOR SPEEDS INCORRECT
- Symptom: *EBL STATUS INDICATOR FLASHING
- Symptom: *HVAC SYSTEM TEST
- Ignition, Power, Accessory
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT OPEN
- Symptom: BCM - ACCESSORY RELAY CONTROL CIRCUIT SHORT TO GROUND
- Symptom: BCM - IGNITION MUX SWITCH INPUT MISMATCH
- Symptom: BCM - IGNITION MUX SWITCH INPUT OPEN
- Symptom: BCM - IGNITION MUX SWITCH INPUT SHORT
- Symptom: BCM - IGNITION RUN 1 SHORT
- Symptom: BCM - IGNITION RUN 2 SHORT
- Symptom: BCM - IOD OUTPUT CIRCUIT SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT OPEN / SHORT TO GROUND
- Symptom: BCM - IOD WAKE UP CLUSTER OUTPUT SHORT TO VOLTAGE
- Symptom: BCM - RUN/START HARDWIRE INPUT MISMATCH
- Symptom: HORN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: HORN RELAY COIL SHORT TO BATTERY
- Symptom: HORN SWITCH STUCK
- Symptom: *HORNS INOPERATIVE
- Instrument Cluster
- Symptom List: ABS LAMP CIRCUIT OPEN; ABS LAMP CIRCUIT SHORTED; AIRBAG LAMP CIRCUIT OPEN; AIRBAG LAMP CIRCUIT SHORTED
- Symptom: ABS MESSAGES NOT RECEIVED
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT OPEN / SHORTED TO VOLTAGE
- Symptom: BCM - FUEL LEVEL SENDING UNIT INPUT SHORT TO GROUND
- Symptom: BCM - PWM DIMMING OUTPUT SHORT
- Symptom: BCM MESSAGES NOT RECEIVED
- Symptom: EEPROM CHECKSUM FAILURE
- Symptom: ORC MESSAGES NOT RECEIVED
- Symptom: PCM MESSAGES NOT RECEIVED
- Symptom: *GAUGE CLUSTER DIAGNOSTIC TEST
- Symptom: *INSTRUMENT CLUSTER DIAGNOSTIC TEST
- Interior Lighting
- Power Door Locks/RKE
- Symptom: DECKLID RELEASE OUTPUT OPEN
- Symptom: DECKLID RELEASE OUTPUT SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH OPEN OR SHORT TO VOLTAGE
- Symptom: DRIVER CYLINDER UNLOCK SWITCH SHORT TO GROUND
- Symptom: DRIVER CYLINDER UNLOCK SWITCH STUCK
- Symptom: DRIVER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: DRIVER DOOR LOCK SWITCH STUCK
- Symptom: DRIVER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: DRIVER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: DRIVER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER DOOR LOCK CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER DOOR LOCK SWITCH STUCK
- Symptom: PASSENGER DOOR UNLATCH CIRCUIT SHORT TO GROUND
- Symptom: PASSENGER EXTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER INTERIOR DOOR HANDLE SWITCH STUCK
- Symptom: PASSENGER/DRIVER DOOR UNLATCH RETURN SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT OPEN/SHORT TO GROUND
- Symptom: RKE PROGRAM LINE OUTPUT SHORT TO BATTERY
- Symptom: *ALL DOOR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *DRIVER DOOR UNLATCH INOPERATIVE
- Symptom: *PASSENGER DOOR SWITCH OR SWITCHES INOPERATIVE
- Symptom: *PASSENGER DOOR UNLATCH INOPERATIVE
- Symptom: *REMOTE KEYLESS ENTRY PROBLEM
- Power Windows
- Symptom: DRIVER WINDOW DOWN OUTPUT SHORT TO GROUND
- Symptom: DRIVER WINDOW HALL EFFECT FAILURE
- Symptom: DRIVER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: DRIVER WINDOW SWITCH SHORT TO GROUND
- Symptom: DRIVER WINDOW SWITCH STUCK DOWN
- Symptom: DRIVER WINDOW SWITCH STUCK UP
- Symptom: DRIVER WINDOW UP OUTPUT SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL OPEN/SHORT TO GROUND
- Symptom: PASSENGER WINDOW DOWN RELAY COIL SHORT TO BATTERY
- Symptom: PASSENGER WINDOW HALL EFFECT FAILURE
- Symptom: PASSENGER WINDOW SWITCH OPEN/SHORT TO VOLTAGE
- Symptom: PASSENGER WINDOW SWITCH SHORT TO GROUND
- Symptom: PASSENGER WINDOW SWITCH STUCK DOWN
- Symptom: PASSENGER WINDOW SWITCH STUCK UP
- Symptom: PASSENGER WINDOW UP SHORT TO GROUND
- Symptom: *DRIVER WINDOW INOPERATIVE
- Symptom: *PASSENGER WINDOW INOPERATIVE
- Tire Pressure Monitoring
- Symptom: CRITICAL TIRE PRESSURE - BCM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM; LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM; RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER - TPM; RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER - TPM
- Symptom List: LEFT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; LEFT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; RIGHT FRONT TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM; RIGHT REAR TIRE PRESSURE SENSOR/TRANSMITTER LOW BATTERY - TPM
- Symptom: TIRE PRESSURE LOW - BCM
- Symptom: TIRE PRESSURE MONITOR MODULE FAILURE - TPM
- Symptom: TPM DIAGNOSTIC - BCM
- Symptom: TPM MODULE INITIALIZED - BCM
- Symptom: *LO TIRE LCD MESSAGE FLASHING
- Symptom: VTSS INDICATOR OUTPUT OPEN
- Symptom: VTSS INDICATOR OUTPUT SHORT
- Symptom: *ALARM TRIPS ON ITS OWN
- Symptom: *DECKLID DOES NOT TRIP VTSS
- Symptom: *DRIVER DOOR DOES NOT TRIP VTSS
- Symptom: *EXTERIOR LAMPS FAIL TO FLASH WHEN ALARM IS TRIPPED
- Symptom: *HOOD DOES NOT TRIP VTSS
- Symptom: *HORN FAILS TO SOUND WHEN ALARM IS TRIPPED
- Symptom: *PASSENGER DOOR DOES NOT TRIP VTSS
- Symptom: *VTSS LAMP ON STEADY DURING ARMING
- Symptom: *VTSS WILL NOT ARM
- Verification Tests
- Air Bag
- Component Locations
- Connector PINOUTS
- A/C-Heater Control C1 - Black 10 Way
- A/C-Heater Control C2 - Black 16 Way
- Airbag Control Module C1 (Orc) - Yellow 32 Way
- Airbag Control Module C2 (Orc) Yellow 32 Way
- Airbag On/Off Switch-Passenger - Yellow 6 Way
- Airbag Squib 1-Driver - Yellow/Black 2 Way
- Airbag Squib 2-Driver - Yellow/Gray 2 Way
- Airbag Squib-Passenger - Yellow 4 Way
- Ajar Switch-DECKLID - Black 3 Way
- Ajar Switch-Driver Door - Black 4 Way
- Ajar Switch-Hood - Natural 3 Way
- Ajar Switch-Passenger Door - Black 4 Way
- Blend Door Actuator - Gray 2 Way
- Blower Motor - Orange 2 Way
- Blower Motor Resistor Block - Black 4 Way
- Body Control Module C1 - Black 6 Way
- Body Control Module C2 - Black/Green 34 Way
- Body Control Module C3 - Black/White 34 Way
- Body Control Module C4 - Black/Gray 34 Way
- Body Control Module C5 - Black/Black 34 Way
- Brake Fluid Level Switch - Black 2 Way
- C200 - Black (Body Side)
- C200 - Black (Instrument Panel Side)
- C201 - Yellow (Body Side)
- C201 - Yellow (Instrument Panel Side)
- C204 - (HVAC Jumper Side)
- C204 - (Instrument Panel Side)
- C206 - Red (Console Jumper Side)
- C206 - Red (Instrument Panel Side)
- CLOCKSPRING - White 8 Way
- Controller Antilock Brake - Black 24 Way
- Cylinder Unlock Switch-Driver - Black 2 Way
- Data Link Connector - Black 16 Way
- DECKLID Release Motor - Black 2 Way
- Door Latch Motor-Driver - 2 Way
- Door Latch Motor-Passenger - 2 Way
- Door Lock Switch-Driver - Black 3 Way
- Door Lock Switch-Passenger - Black 3 Way
- Exterior Door Handle Switch-Driver - Black 2 Way
- Exterior Door Handle Switch-Passenger Black 2 Way
- Fog Lamp-Left - Black 2 Way
- Gauge Cluster C1 - White 3 Way
- Gauge Cluster C2 - Black 20 Way
- Hid Lamp-Left - Gray 2 Way
- High Beam Headlamp-Left - Black 2 Way
- Horn-High Note - Black 2 Way
- Horn-Low Note - Black 2 Way
- Ignition Switch - Black 5 Way
- Instrument Cluster C1 - Black 16 Way
- Instrument Cluster C12 - Black 20 Way
- Interior Door Handle Switch-Driver - Black 2 Way
- Interior Door Handle Switch-Passenger - Black 2 Way
- Marker Lamp-Left Front - DK.Gray 2 Way
- Mode Door Actuator 1 (Defrost To Floor) - Gray 2 Way
- Mode Door Actuator 2 (Panel To Floor) - Gray 2 Way
- Multi-Function Switch - Gray 20 Way
- Park/Turn Lamp-Left - Black 3 Way
- Power Amplifier C1 - DK.Gray 14 Way
- Power Amplifier C2 - Green 16 Way
- Fuses (PDC)
- Power Window Motor-Driver - 6 Way
- Power Window Motor-Passenger - 6 Way
- Power Window Switch-Driver - Gray 3 Way
- Power Window Switch-Passenger - Gray 3 Way
- Powertrain Control Module C1 - Black/Black 32 Way
- Powertrain Control Module C2 - Black/White 32 Way
- Powertrain Control Module C3 - Black/Gray 32 Way
- Radio - Gray 22 Way
- RECIRCULATION Door Actuator - Gray 2 Way
- Remote Keyless Entry Module - Black 6 Way
- Seat Belt Switch-Driver - White 2 Way
- Seat Belt Switch-Passenger - White 2 Way
- Seat Belt TENSIONER-Driver - Yellow 2 Way
- Seat Belt TENSIONER-Passenger - Yellow 2 Way
- Speaker-Left Door - Black 2 Way
- Speaker-Left Instrument Panel - White 2 Way
- Speaker-Left Rear - White 3 Way
- Speaker-Rear Woofer - Gray 4 Way
- Speaker-Right Door - Black 2 Way
- Speaker-Right Instrument Panel - White 2 Way
- Speaker-Right Rear - White 3 Way
- Tire Pressure Monitor Module - Blue 6 Way
- VTSS Led - Black 2 Way
- Window Down Relay-Passenger - Black 5 Way
- Window Up Relay-Passenger - Black 5 Way
- Schematic Diagrams
- Airbag System
- Audio System
- Chime System
- Communication
- Door Ajar System
- Electrically Heated Systems
- Exterior Lighting
- Heating & A/C System
- Ignition, Power, Accessory
- Instrument Cluster/Gauge Cluster
- Interior Lighting
- Power Door Locks/RKE
- Power Window System
- Tire Pressure Monitor Module (TPM)
- Vehicle Theft Security System
- Tires & Wheels & Tire Pressure Monitoring System
- Body Diagnostic Procedures
- Transmission
- Clutch System (Service Information)
- Manual Transmission Removal & Installation