LEMON Manuals
: Even more car manuals for everyone: 1960-2025
Home
>>
Mitsubishi
>>
2005
>>
Lancer Evolution
>>
Repair and Diagnosis
>>
External Pages
>>
Different variant/trim
>>
Section 10 (On-Vehicle Service - Except Evolution)
April 5, 2026:
LEMON Manuals is launched!
Read the announcement.
Section 10 (On-Vehicle Service - Except Evolution)
WARNING:
This page is about a different variant/trim than selected.
Expand All (for easy ctrl-f)
Collapse All
General Description
Manual Transaxle Diagnosis
Introduction
Troubleshooting Strategy
Symptom Chart
Symptom Procedures
INSPECTION PROCEDURE 1: Noise, Vibration
Diagnosis
INSPECTION PROCEDURE 2: Oil Leaks
Diagnosis
INSPECTION PROCEDURE 3: Hard Shifting
Diagnosis
INSPECTION PROCEDURE 4: Jumps Out of Gear
Diagnosis
Special Tools
On-Vehicle Service
Transmission Oil Level Check
Transmission Oil Replacement
Transaxle Control
Removal And Installation
Notes
Removal Service Point
<< A >> Gearshift Link Clip/Select Cable Connection (Transaxle Side) /Shift Cable Connection (Transaxle Side) Removal
Installation Service Point
>> A << Shift Cable Connection (Transaxle Side) /Select Cable CONECTION (Transaxle Side) /Gearshift Link Clip Installation
>> B << Shift Cable Connection/Shift Cable Clip (Gearshift Lever Side) Installation
Shift Lever Assembly
Disassembly And Assembly
Transaxle Assembly
Removal And Installation
Notes
Removal Service Points
<< A >> Drive Shaft Nut Removal
<< B >> Tie Rod End Disconnection
<< C >> Drive Shaft/Drive Shaft And Inner Shaft Assembly Removal
<< D >> Starter Motor Removal
<< E >> Transaxle Mount Assembly Removal
<< F >> Clutch Release Bearing Separation
<< G >> Engine Assembly Supporting
Installation Service Points
>> A << Transaxle Mount Stopper Installation
>> B << Stabilizer Bar Installation
>> C << Drive Shaft Nut Installation
Specifications
Fastener Tightening Specifications
Service Specification
Lubricant