Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups
Common Specs & Procedures
DTC Index- Air Bag DTCS
- Anti-Lock Brake DTCS
- Anti-Theft DTCS
- Automatic Transmission (4T80-E) DTCS
- Body Control Module DTCS
- Charging DTCS
- Cruise Control DTCS
- Engine Performance - 4.6L DTCS
- Headlight - Automatic Twilight Sentinel DTCS
- HVAC DTCS
- Instrument Panel DTCS
- Power Door Lock & Remote Keyless Entry DTCS
- Power Mirror DTCS
- Power Seat DTCS
- Power Window DTCS
- Starter DTCS
- Steering Column/Switch DTCS
- Steering, Electronic (MAGNASTEER) DTCS
- Suspension, Electronic Automatic Level Control (With CVRS) DTCS
Electrical Component Locations
Fluids
Technical Bulletins
Tire Fitment
Wiring Diagrams- Electronic Power Steering System - Wiring Diagrams
- System Wiring Diagrams
- Using lemon2025'S Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Body Control Modules
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Electronic Power Steering
- Electronic Suspension
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Memory Systems
- Navigation
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Top/Sunroof
- Power Windows
- Radio
- Shift Interlock
- Starting/Charging
- Supplemental Restraints
- Transmission
- Trunk, Tailgate, Fuel Door
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- Accessories & Equipment
- Anti-Theft Systems
- Anti-Theft System
- Description & Operation
- Component Locations
- Anti-Theft System Arming & Disarming
- Programming
- Trouble Shooting
- Self-Diagnostic System
- Diagnostic Tests
- Notes
- DTC B2734: Coded Key Controller Memory Failure
- DTC B2947: Antenna Power Short To Ground
- DTC B2948: Antenna Power Short To Battery Voltage
- DTC B2955: Key Code Input Short To Battery Voltage
- DTC B2960: Invalid Coded Key Is Present
- DTC B3031: Key Decoder In Assembly Learn Mode
- DTC B3055: Key Is Not Present
- DTC P1630: Password Learning Mode Required
- DTC P1631: Pcm Detected Incorrect Password From Vehicle Theft Deterrent Control Module
- Symptom Tests
- Removal & Installation
- Wiring Diagrams
- Power Door Locks & Remote Keyless Entry Systems
- Description & Operation (Power Door Locks)
- Description & Operation (Remote Keyless Entry)
- Component Locations
- Programming
- Trouble Shooting
- Self-Diagnostic System
- Diagnostic Tests
- System Tests
- Removal & Installation
- Wiring Diagrams
- Power Trunk & Fuel Door Release
- Anti-Theft System
- Collision/Avoidance
- Parking Assist Systems - Wiring Diagrams
- Rear Parking Assist System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Description and Operation
- Communication Devices
- Body Control Modules
- Description & Operation
- Component Locations
- Programming
- Notes
- Continuously Variable Road Sensing Suspension Module Calibration
- Dash Integration Module
- Powertrain Control Module
- Rear Integration Module
- Remote Keyless Entry Transmitter
- Steering Column Control Module
- Theft Deterrent Module
- Tire Pressure Monitoring Sensor
- Window Motor Programming - Express Mode
- Vehicle Communication Unit/Vehicle Interface Unit (ONSTAR(R))
- Trouble Shooting
- INTERMITTENTS
- Self-Diagnostic System
- Body Control System Diagnostic System Check
- Air Bag System Diagnostic System Check
- Air Conditioning System Diagnostic System Check
- Anti-Lock Brake Diagnostic System Check
- Audible Warnings Diagnostic System Check
- Automatic Transmission Shift Lock Control Diagnostic System Check
- Body Rear End Diagnostic System Check
- Cellular Communication Diagnostic System Check
- Cruise Control System Diagnostic System Check
- Defogger Diagnostic System Check
- Disc Brakes Diagnostic System Check
- Door Systems Diagnostic System Check
- Engine Controls Diagnostic System Check
- Engine Cooling Diagnostic System Check
- Engine Electrical Diagnostic System Check
- Horns Diagnostic System Check
- Hydraulic Brakes Diagnostic System Check
- Instrument Cluster Diagnostic System Check
- Lighting System Diagnostic Check
- Navigation System Diagnostic System Check
- Park Brake Diagnostic System Check
- Power Seat Systems Diagnostic System Check
- Power Sun Roof Diagnostic System Check
- Radio/Audio System Diagnostic System Check
- Remote Keyless Entry Diagnostic System Check
- Retained Accessory Power Diagnostic System Check
- Road Sensing Suspension Diagnostic System Check
- Steering Wheel & Column - Tilt Diagnostic System Check
- Theft Deterrent Diagnostic System Check
- Tire Pressuring Monitoring Diagnostic System Check
- Variable Effort Steering Diagnostic System Check
- Wiper/Washer Diagnostic System Check
- Diagnostic Trouble Code Definitions
- Diagnostic Tests
- DTC B1000: Control Module Malfunction
- DTC B1004: Keep Alive Memory
- DTC B1007: EEPROM Write Error
- DTC B1009: EEPROM Checksum Error
- DTC B1245: Radio Detects Loss Of E&C Communications
- DTC B1390: Device Voltage Reference Input Circuit Malfunction
- DTC B1556: Odometer Mileage Within EEPROM Disagree
- DTC B1652: Loss Of Keep Alive Memory
- DTC B1656: EEPROM Write Error
- DTC B1658: EEPROM Checksum Error
- DTC B1805: Ignition Switch Circuit Malfunction
- DTC U1000 & U1255: Class 2 Communication Malfunction
- DTC U1001-U1254: Loss Of XXX Communications
- DTC U1161-U1163 Or U1170: Driver's Door Module Communication Malfunction
- DTC U1300: Class 2 Short To Ground
- DTC U1301: Class 2 Short To Voltage
- DTC U1305: Loss Of Class 2 Serial Data Communication
- DTC U1500: ONSTAR(R) Serial Data Circuit Failure
- DTC U1713 Or U1715: Window Sensor High Speed Communication Circuit Failure
- DTC U1714 Or U1716: Driver's Door Module Communication Failure
- DTC U2150: Loss Of Communication With Navigation Processor
- DTC U2151: Navigation Display Serial Data High/Low Circuit
- DTC U2153: Navigation Module Internal Failure
- System Tests
- Removal & Installation
- Notes
- Cellular Telephone Module
- Continuous Variable Road Sensing Suspension Module
- Dash Integration Module
- Door Module
- Electronic Brake Control Module
- Instrument Panel Cluster
- Instrument Panel Module
- Memory Seat Module
- Navigation Module
- Navigation Display Unit
- Powertrain Control Module
- Rear Compartment Trim Panel
- Rear Integration Module
- Remote Control Door Lock Receiver
- Steering Column Control Module
- Theft Deterrent Module
- Wiring Diagrams
- Body Control Modules
- Cruise Control Systems
- Description & Operation
- Component Locations
- Adjustments
- Trouble Shooting
- INTERMITTENTS
- Self-Diagnostic System
- Diagnostic Tests
- DTC P0574: Powertrain Control Module Detects High Vehicle Speed
- DTC P1554: Powertrain Control Module Detects Cruise Engaged Signal
- DTC P1560: Cruise Control Engaged With Vehicle In Neutral Or Park
- DTC P1564: Powertrain Control Module Detects Rapid Acceleration
- DTC P1566: Powertrain Control Module Detects High Engine Speed
- DTC P1567: Traction Control System Applied Brakes
- DTC P1570: Traction Control Active Cruise Disabled
- DTC P1574: Stop Light Switch Circuit Signal Failure
- DTC P1585: Cruise Control Inhibit Output Circuit
- System Tests
- Removal & Installation
- Wiring Diagrams
- Exterior Lights
- Exterior Lighting Systems - Wiring Diagrams
- ALERO
- Astro & Safari
- Aurora
- AZTEK
- Blazer, BRAVADA & Jimmy
- BONNEVILLE
- CAMARO
- CATERA
- Cavalier & SUNFIRE
- Century & Regal
- Chevy Express & SAVANA
- Corvette
- DEVILLE
- ELDORADO
- Firebird
- Grand Am
- Grand PRIX
- Impala
- Intrigue
- LESABRE
- Lumina
- MALIBU
- Metro
- MONTANA, Silhouette & Venture
- Monte CARLO
- Park Avenue
- PRIZM
- SATURN
- SEVILLE
- Sierra, SILVERADO, Suburban, TAHOE, YUKON
- SONOMA & S10 Pickup
- Tracker
- Lighting Systems
- Description and Operation
- Exterior Lighting Systems Description and Operation
- Exterior Lamps
- Headlamps
- Headlamps w/High Intensity Discharge (HID)
- Low Voltage Operation of HID Headlamps
- Electrical System Requirements (w/HID)
- Run Up Of The Lamp (w/HID)
- When To Change The HID Bulb
- Light Color (w/HID)
- Cornering Lamps
- Daytime Running Lamps (DRL)
- Daytime Running Lamps (Norway and Sweden)
- Twilight Sentinel
- Front Fog Lamps
- Rear Fog Lamps
- Park, Tail, License and Marker Lamps
- Position Lamps
- Remote Keyless Entry Exterior Lamp Illumination
- Turn Signal Lamps
- Repeater Lamps
- Stop Lamps
- Backup Lamps
- Underhood Lamp
- Battery Run Down Protection/Inadvertent Power
- Interior Lighting Systems Description and Operation
- Exterior Lighting Systems Description and Operation
- Component Locator
- Lighting Systems Component Views
- Lighting Systems Connector End Views
- Ambient Light Sensor
- Ashtray Lamp
- Backup Lamp - Left
- Backup Lamp - Right
- Center High Mounted Stop Lamp (CHMSL)
- Cornering Lamp - Left
- Cornering Lamp - Right
- Door Courtesy Lamp - LF
- Door Courtesy Lamp - LR
- Door Courtesy Lamp - RF
- Door Courtesy Lamp - RR
- Door Lock Actuator - Driver C1
- Door Lock Actuator - Front Passenger C1
- Door Lock Actuator - LR C1
- Door Lock Actuator - RR C1
- Fog Lamp - LF
- Fog Lamp - LR (Export)
- Fog Lamp - RF
- Fog Lamp - RR (Export)
- Footwell Courtesy Lamp - Left
- Footwell Courtesy Lamp - Right
- Hazard Switch
- Headlamp - High Beam- Left (Domestic)
- Headlamp - High Beam - Left (Export)
- Headlamp - High Beam - Right (Domestic)
- Headlamp - High Beam - Right (Export)
- Headlamp - Low Beam - Left (w/HID) (Generation 2.5)
- Headlamp - Low Beam - Left (w/HID) (Generation 3.0)
- Headlamp - Low Beam - Left (w/o HID)
- Headlamp - Low Beam - Right (w/HID) (Generation 2.5)
- Headlamp - Low Beam - Right (w/HID) (Generation 3.0)
- Headlamp - Low Beam - Right (w/o HID)
- Headlamp Switch (LH Drive)
- Hood Ajar Switch (Export)
- IP Compartment Lamp
- IP Compartment Lamp Switch
- IP Dimmer/Fog Lamp Switch (RH Drive)
- Ignition Key Cylinder Lamp
- License Lamp
- Marker Lamp - LF
- Marker Lamp - RF
- Park/Turn Signal Lamp - LF (Europe)
- Park/Turn Signal Lamp - LF
- Park/Turn Signal Lamp - RF (Europe)
- Park/Turn Signal Lamp -RF
- Position Lamp - Left (Export)
- Position Lamp - Right (Export)
- Reading Lamp Switch - Left
- Reading Lamp Switch - Right
- Rear Compartment Lamp
- Reading Lamp - Left
- Reading Lamp - Right
- Tail Lamp - Left (Domestic)
- Tail Lamp - Left (Export)
- Tail Lamp - Right (Domestic)
- Tail Lamp - Right (Export)
- Tail/Stop Lamp - Left (Domestic)
- Tail/Stop Lamp - Left (Export)
- Tail/Stop Lamp - Right (Domestic)
- Tail/Stop Lamp - Right (Export)
- Turn Signal Lamp - LR
- Turn Signal Lamp - RR
- Underhood Lamp
- Vanity Mirror Lamp - Left
- Vanity Mirror Lamp - Right
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Lighting Systems
- Diagnostic System Check - Lighting Systems
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- Diagnostic Trouble Code (DTC) List
- DTC B2419: Ambient Light Sensor Input Counts
- DTC B2420: Twilight Delay Input Low
- DTC B2422: Interior Lamp Rheostat Counts
- Symptoms - Lighting Systems
- Backup Lamps Always On
- Backup Lamps Inoperative
- Cornering Lamps Always On
- Cornering Lamps Inoperative
- Courtesy Lamps Always On
- Courtesy Lamps Inoperative
- Daytime Running Lamps (DRL) Always On
- Daytime Running Lamps (DRL) Inoperative (Domestic)
- Daytime Running Lamps (DRL) Inoperative (Export)
- Fog Lamp Indicator Always On
- Fog Lamp Indicator Inoperative
- Fog Lamps Always On
- Fog Lamps Inoperative
- Hazard Lamps Always On
- Hazard Lamps Inoperative
- Headlamps Always On - Low or High Beam (Domestic)
- Headlamps Always On - Low or High Beam (Export)
- Headlamps Inoperative - Low Beams (Norway/Sweden)
- Headlamps Inoperative - Low Beams (Norway/Sweden w/HID)
- Headlamps Inoperative - Low Beams (Domestic, Europe and Japan)
- Headlamps Inoperative - Low Beams (Domestic, Europe and Japan w/HID)
- Headlamps Inoperative - High Beams (Export)
- Headlamps Inoperative - High Beams (Domestic)
- Headlamps Flash to Pass Inoperative
- Headlamps Suggested Message On in Daylight Conditions
- High Beam Indicator Always On
- High Beam Indicator Inoperative
- Ignition Lock Cylinder Lamp Always On
- Ignition Lock Cylinder Lamp Inoperative
- Interior Backlighting Does Not Dim
- Interior Backlighting Inoperative
- Instrument Panel (I/P) Compartment Lamp Inoperative
- Instrument Panel (I/P) Compartment Lamp Always On
- License Lamps Inoperative
- Lights On Indicator Always On
- Lights On Indicator Inoperative
- Park Lamps Inoperative
- Park, License, and Tail Lamps Always On
- Position Lamps Inoperative
- Reading Lamp(s) Always On
- Reading Lamp(s) Inoperative
- Rear Compartment Lamp(s) Always On
- Rear Compartment Lamp(s) Inoperative
- Repeater Lamps Inoperative
- Stop Lamps Always On
- Stop Lamps Inoperative
- Turn Signal Lamps and/or Indicators Always On or Flashing
- Turn Signal Lamps and/or Indicators Inoperative
- Twilight Sentinel Inoperative
- Underhood Lamp Always On
- Underhood Lamp Inoperative
- Vacuum Fluorescent (VF) Displays Inoperative
- Vanity Mirror Lamp(s) Always On
- Vanity Mirror Lamp(s) Inoperative
- Vacuum Fluorescent Displays Inoperative
- Repair Instructions
- Headlamp Switch Replacement (LHD)
- Fog Lamp and Instrument Panel Lamp Dimmer Switch Replacement (RHD)
- Hazard Warning Switch Replacement
- Headlamp Relay Replacement
- Fog Lamp Relay Replacement
- Reverse Lamp Relay Replacement
- Park Lamp Relay Replacement
- Daytime Running Lamps (DRL) Relay Replacement
- Hazard Lamp and Turn Signal Lamp Flasher Replacement
- Headlamp Replacement (SLS, w/o TT6, TT7 or TT8)
- Headlamp Replacement (STS and SLS w/TT6, TT7 or TT8)
- High Intensity Discharge Headlamp Starter/Arc Tube Replacement (TT6, TT7, TT8)
- HID Headlamp Ballast Replacement (TT6, TT7, TT8)
- Headlamp Bulb Replacement
- Headlamp Aiming
- Front Fog Lamp Replacement
- Front Fog Lamp Bulb Replacement
- Fog Lamp Aiming
- Repeater Lamp Replacement
- Side Marker Lamp Replacement
- Park/Turn Signal Lamp Bulb Replacement
- Cornering Lamp Bulb Replacement
- High Mounted Stop Lamp Replacement
- Backup Lamp Replacement
- Rear License Plate Lamp Replacement
- Tail Lamp Replacement
- Tail/Turn Signal Lamp Replacement
- Underhood Lamp Replacement
- Door Lamp Replacement
- Instrument Panel (I/P) Storage Compartment Lamp Replacement
- Roof Rail Rear Courtesy Lamp Switch Replacement
- Roof Rail Rear Courtesy Lamp Replacement
- Sunshade Illuminated Mirror Lamp Bulb Replacement
- Trans Floor Shift Control Indicator Lamp Replacement
- Dome Lamp Replacement
- Rear Compartment Courtesy Lamp Replacement
- Specifications
- Schematic Wiring Diagrams
- Description and Operation
- Lighting Systems - Back-Up Light System - Wiring Diagrams
- ALERO & Grand Am
- Astro & Safari
- Aurora
- AZTEK
- Blazer, BRAVADA & Jimmy
- BONNEVILLE
- CAMARO & Firebird
- CATERA
- Cavalier & SUNFIRE
- Century
- Chevy Express & SAVANA
- Corvette
- DEVILLE
- ELDORADO
- Grand PRIX
- Impala
- Intrigue
- LESABRE
- Lumina
- MALIBU
- Metro
- MONTANA, Silhouette & Venture
- Monte CARLO
- Park Avenue
- PRIZM
- Regal
- SATURN
- SEVILLE
- Sierra, SILVERADO, Suburban, TAHOE, YUKON
- SONOMA & S10 Pickup
- Tracker
- Exterior Lighting Systems - Wiring Diagrams
- Gauges & Instrument Panels
- Analog Instrument Panels
- Description & Operation (Instrument Panel Cluster)
- Description & Operation (Indicator/Warning Message)
- Anti-Lock Brake System Indicator
- Air Bag Indicators
- Brake Pad Wear Indicator
- Brake System Indicators
- Cellular Telephone Indicators
- Charging System Indicators
- Cruise Control Indicator
- Door Ajar Indicators
- Driver Number Indicator
- Electrical System Indicators
- Engine Coolant Indicators
- Engine Misfire Indicator
- Engine Oil Indicators
- Engine OVERSPEED Indicator
- Fasten Safety Belt Indicator
- Fuel System Indicators
- HVAC System Indicator
- Ice Indicator
- Idle Control Indicator
- Km/H & Mph Indicators
- Lighting System Indicators
- Malfunction Indicator Light
- Reduced Engine Power Indicator
- Stability System Indicators
- Status Indicator
- Steering System Indicator
- Suspension System Indicators
- Theft System Indicators
- Tire Pressure Indicator
- Traction Control System Indicators
- Transmission Indicators
- Trunk Ajar Indicator
- Washer Fluid Indicator
- Description & Operation (Driver's Information Center)
- Driver's Information Center Switches
- Indicators & Warning Messages
- Vehicle Information Display
- Outside Air Temperature
- Fuel Range
- Average Fuel Economy
- Instantaneous Fuel Economy
- Fuel Used
- Average Vehicle Speed
- Timer
- Battery Voltage
- Tire Pressure Monitor
- Engine Oil Life
- Transmission Fluid Life
- Cellular Phone
- Personalization
- Description & Operation (Audible Warnings)
- Component Locations
- Handling Precautions
- Programming
- Trouble Shooting
- Self-Diagnostic System
- Notes
- Air Bag System Diagnostic System Check
- Anti-Lock Brake Diagnostic System Check
- Audible Warnings Diagnostic System Check
- Body Rear End Diagnostic System Check
- Cruise Control System Diagnostic System Check
- Door Systems Diagnostic System Check
- Engine Controls Diagnostic System Check
- Engine Cooling Diagnostic System Check
- Engine Electrical Diagnostic System Check
- Hydraulic Brakes Diagnostic System Check
- Instrument Cluster Diagnostic System Check
- Lighting Systems Diagnostic Check
- Theft Deterrent Diagnostic System Check
- Tire Pressure Monitoring Diagnostic System Check
- Diagnostic Trouble Code Definitions
- Diagnostic Tests
- System Tests
- Notes
- Test A: Engine Coolant Temperature Gauge Inaccurate Or Inoperative
- Test B: Fuel Gauge Inaccurate Or Inoperative
- Test C: Speedometer/Odometer Inaccurate Or Inoperative
- Test D: Tachometer Inaccurate Or Inoperative
- Test E: Anti-Lock Brake System Indicator Always On
- Test F: Anti-Lock Brake System Indicator Inoperative
- Test G: Air Bag Indicator Circuit Malfunction
- Test H: Brake Warning Indicator Always On
- Test I: Brake Warning Indicator Inoperative
- Test J: Charge Indicator Always On
- Test K: Charge Indicator Inoperative
- Test L: Cruise Control Switch Indicator Always On
- Test M: Cruise Control Indicator Inoperative
- Test N: Door Ajar Indicator Always On
- Test O: Door Ajar Indicator Inoperative
- Test P: Engine Coolant Temperature Indicator Always On
- Test Q: Engine Oil Pressure Indicator Always On
- Test R: Engine Oil Pressure Indicator Inoperative
- Test S: Fog Light Indicator Always On
- Test T: Fog Light Indicator Inoperative
- Test U: High Beam Indicator Always On
- Test V: High Beam Indicator Inoperative
- Test W: Lights On Indicator Always On
- Test X: Lights On Indicator Inoperative
- Test Y: Low Engine Coolant Indicator Always On
- Test Z: Low Engine Oil Level Indicator Always On
- Test Aa: Low Washer Fluid Indicator Malfunction
- Test Ab: Malfunction Indicator Light Always On
- Test Ac: Malfunction Indicator Light Inoperative
- Test Ad: Seat Belt Indicator Circuit Malfunction
- Test AE: Security Indicator Inoperative
- Test AF: Traction Control Indicator Always On
- Test Ag: Traction Control Indicator Inoperative
- Test Ah: Trunk Ajar Indicator Always On
- Test Ai: Trunk Ajar Indicator Inoperative
- Test AJ: Turn Signal Lights/Indicators Always On Or Flashing
- Test AK: Turn Signal Lights/Indicators Inoperative
- Test Al: Driver's Information Center Switch(Es) Inoperative
- Test Am: Chime Always On
- Test An: Chime Inoperative
- Removal & Installation
- Wiring Diagrams
- Analog Instrument Panels
- Headlights
- Exterior Lighting Systems - Wiring Diagrams
- ALERO
- Astro & Safari
- Aurora
- AZTEK
- Blazer, BRAVADA & Jimmy
- BONNEVILLE
- CAMARO
- CATERA
- Cavalier & SUNFIRE
- Century & Regal
- Chevy Express & SAVANA
- Corvette
- DEVILLE
- ELDORADO
- Firebird
- Grand Am
- Grand PRIX
- Impala
- Intrigue
- LESABRE
- Lumina
- MALIBU
- Metro
- MONTANA, Silhouette & Venture
- Monte CARLO
- Park Avenue
- PRIZM
- SATURN
- SEVILLE
- Sierra, SILVERADO, Suburban, TAHOE, YUKON
- SONOMA & S10 Pickup
- Tracker
- Headlight Systems & Daytime Running Lights Systems - Wiring Diagrams
- ALERO
- Astro & Safari
- Aurora
- AZTEK
- Blazer, Jimmy, SONOMA & S10 Pickup
- BONNEVILLE
- CAMARO
- CATERA
- Cavalier & SUNFIRE
- Century & Regal
- Chevy Express & SAVANA
- Corvette
- DEVILLE
- ELDORADO
- Firebird
- Grand Am
- Grand PRIX
- Impala & Monte CARLO
- Intrigue
- LESABRE
- Lumina
- MALIBU
- Metro
- MONTANA, Silhouette & Venture
- Park Avenue
- PRIZM
- SATURN
- SEVILLE
- Sierra, SILVERADO, Suburban, TAHOE, YUKON
- Tracker
- Headlights - Automatic Twilight Sentinel
- Lighting Systems
- Description and Operation
- Exterior Lighting Systems Description and Operation
- Exterior Lamps
- Headlamps
- Headlamps w/High Intensity Discharge (HID)
- Low Voltage Operation of HID Headlamps
- Electrical System Requirements (w/HID)
- Run Up Of The Lamp (w/HID)
- When To Change The HID Bulb
- Light Color (w/HID)
- Cornering Lamps
- Daytime Running Lamps (DRL)
- Daytime Running Lamps (Norway and Sweden)
- Twilight Sentinel
- Front Fog Lamps
- Rear Fog Lamps
- Park, Tail, License and Marker Lamps
- Position Lamps
- Remote Keyless Entry Exterior Lamp Illumination
- Turn Signal Lamps
- Repeater Lamps
- Stop Lamps
- Backup Lamps
- Underhood Lamp
- Battery Run Down Protection/Inadvertent Power
- Interior Lighting Systems Description and Operation
- Exterior Lighting Systems Description and Operation
- Component Locator
- Lighting Systems Component Views
- Lighting Systems Connector End Views
- Ambient Light Sensor
- Ashtray Lamp
- Backup Lamp - Left
- Backup Lamp - Right
- Center High Mounted Stop Lamp (CHMSL)
- Cornering Lamp - Left
- Cornering Lamp - Right
- Door Courtesy Lamp - LF
- Door Courtesy Lamp - LR
- Door Courtesy Lamp - RF
- Door Courtesy Lamp - RR
- Door Lock Actuator - Driver C1
- Door Lock Actuator - Front Passenger C1
- Door Lock Actuator - LR C1
- Door Lock Actuator - RR C1
- Fog Lamp - LF
- Fog Lamp - LR (Export)
- Fog Lamp - RF
- Fog Lamp - RR (Export)
- Footwell Courtesy Lamp - Left
- Footwell Courtesy Lamp - Right
- Hazard Switch
- Headlamp - High Beam- Left (Domestic)
- Headlamp - High Beam - Left (Export)
- Headlamp - High Beam - Right (Domestic)
- Headlamp - High Beam - Right (Export)
- Headlamp - Low Beam - Left (w/HID) (Generation 2.5)
- Headlamp - Low Beam - Left (w/HID) (Generation 3.0)
- Headlamp - Low Beam - Left (w/o HID)
- Headlamp - Low Beam - Right (w/HID) (Generation 2.5)
- Headlamp - Low Beam - Right (w/HID) (Generation 3.0)
- Headlamp - Low Beam - Right (w/o HID)
- Headlamp Switch (LH Drive)
- Hood Ajar Switch (Export)
- IP Compartment Lamp
- IP Compartment Lamp Switch
- IP Dimmer/Fog Lamp Switch (RH Drive)
- Ignition Key Cylinder Lamp
- License Lamp
- Marker Lamp - LF
- Marker Lamp - RF
- Park/Turn Signal Lamp - LF (Europe)
- Park/Turn Signal Lamp - LF
- Park/Turn Signal Lamp - RF (Europe)
- Park/Turn Signal Lamp -RF
- Position Lamp - Left (Export)
- Position Lamp - Right (Export)
- Reading Lamp Switch - Left
- Reading Lamp Switch - Right
- Rear Compartment Lamp
- Reading Lamp - Left
- Reading Lamp - Right
- Tail Lamp - Left (Domestic)
- Tail Lamp - Left (Export)
- Tail Lamp - Right (Domestic)
- Tail Lamp - Right (Export)
- Tail/Stop Lamp - Left (Domestic)
- Tail/Stop Lamp - Left (Export)
- Tail/Stop Lamp - Right (Domestic)
- Tail/Stop Lamp - Right (Export)
- Turn Signal Lamp - LR
- Turn Signal Lamp - RR
- Underhood Lamp
- Vanity Mirror Lamp - Left
- Vanity Mirror Lamp - Right
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Lighting Systems
- Diagnostic System Check - Lighting Systems
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- Diagnostic Trouble Code (DTC) List
- DTC B2419: Ambient Light Sensor Input Counts
- DTC B2420: Twilight Delay Input Low
- DTC B2422: Interior Lamp Rheostat Counts
- Symptoms - Lighting Systems
- Backup Lamps Always On
- Backup Lamps Inoperative
- Cornering Lamps Always On
- Cornering Lamps Inoperative
- Courtesy Lamps Always On
- Courtesy Lamps Inoperative
- Daytime Running Lamps (DRL) Always On
- Daytime Running Lamps (DRL) Inoperative (Domestic)
- Daytime Running Lamps (DRL) Inoperative (Export)
- Fog Lamp Indicator Always On
- Fog Lamp Indicator Inoperative
- Fog Lamps Always On
- Fog Lamps Inoperative
- Hazard Lamps Always On
- Hazard Lamps Inoperative
- Headlamps Always On - Low or High Beam (Domestic)
- Headlamps Always On - Low or High Beam (Export)
- Headlamps Inoperative - Low Beams (Norway/Sweden)
- Headlamps Inoperative - Low Beams (Norway/Sweden w/HID)
- Headlamps Inoperative - Low Beams (Domestic, Europe and Japan)
- Headlamps Inoperative - Low Beams (Domestic, Europe and Japan w/HID)
- Headlamps Inoperative - High Beams (Export)
- Headlamps Inoperative - High Beams (Domestic)
- Headlamps Flash to Pass Inoperative
- Headlamps Suggested Message On in Daylight Conditions
- High Beam Indicator Always On
- High Beam Indicator Inoperative
- Ignition Lock Cylinder Lamp Always On
- Ignition Lock Cylinder Lamp Inoperative
- Interior Backlighting Does Not Dim
- Interior Backlighting Inoperative
- Instrument Panel (I/P) Compartment Lamp Inoperative
- Instrument Panel (I/P) Compartment Lamp Always On
- License Lamps Inoperative
- Lights On Indicator Always On
- Lights On Indicator Inoperative
- Park Lamps Inoperative
- Park, License, and Tail Lamps Always On
- Position Lamps Inoperative
- Reading Lamp(s) Always On
- Reading Lamp(s) Inoperative
- Rear Compartment Lamp(s) Always On
- Rear Compartment Lamp(s) Inoperative
- Repeater Lamps Inoperative
- Stop Lamps Always On
- Stop Lamps Inoperative
- Turn Signal Lamps and/or Indicators Always On or Flashing
- Turn Signal Lamps and/or Indicators Inoperative
- Twilight Sentinel Inoperative
- Underhood Lamp Always On
- Underhood Lamp Inoperative
- Vacuum Fluorescent (VF) Displays Inoperative
- Vanity Mirror Lamp(s) Always On
- Vanity Mirror Lamp(s) Inoperative
- Vacuum Fluorescent Displays Inoperative
- Repair Instructions
- Headlamp Switch Replacement (LHD)
- Fog Lamp and Instrument Panel Lamp Dimmer Switch Replacement (RHD)
- Hazard Warning Switch Replacement
- Headlamp Relay Replacement
- Fog Lamp Relay Replacement
- Reverse Lamp Relay Replacement
- Park Lamp Relay Replacement
- Daytime Running Lamps (DRL) Relay Replacement
- Hazard Lamp and Turn Signal Lamp Flasher Replacement
- Headlamp Replacement (SLS, w/o TT6, TT7 or TT8)
- Headlamp Replacement (STS and SLS w/TT6, TT7 or TT8)
- High Intensity Discharge Headlamp Starter/Arc Tube Replacement (TT6, TT7, TT8)
- HID Headlamp Ballast Replacement (TT6, TT7, TT8)
- Headlamp Bulb Replacement
- Headlamp Aiming
- Front Fog Lamp Replacement
- Front Fog Lamp Bulb Replacement
- Fog Lamp Aiming
- Repeater Lamp Replacement
- Side Marker Lamp Replacement
- Park/Turn Signal Lamp Bulb Replacement
- Cornering Lamp Bulb Replacement
- High Mounted Stop Lamp Replacement
- Backup Lamp Replacement
- Rear License Plate Lamp Replacement
- Tail Lamp Replacement
- Tail/Turn Signal Lamp Replacement
- Underhood Lamp Replacement
- Door Lamp Replacement
- Instrument Panel (I/P) Storage Compartment Lamp Replacement
- Roof Rail Rear Courtesy Lamp Switch Replacement
- Roof Rail Rear Courtesy Lamp Replacement
- Sunshade Illuminated Mirror Lamp Bulb Replacement
- Trans Floor Shift Control Indicator Lamp Replacement
- Dome Lamp Replacement
- Rear Compartment Courtesy Lamp Replacement
- Specifications
- Schematic Wiring Diagrams
- Description and Operation
- Exterior Lighting Systems - Wiring Diagrams
- Heated Glass/Defoggers
- Rear Window Defogger & Mirror Defogger
- Description & Operation
- Component Locations
- On-Vehicle Service
- Trouble Shooting
- INTERMITTENTS
- Self-Diagnostic System
- System Tests
- Component Tests
- Removal & Installation
- Wiring Diagrams
- Rear Window Defogger & Mirror Defogger
- Ignition Switch/Steering Lock
- Steering Wheel And Steering Column
- Model Identification
- Description & Operation
- Service Precautions
- Disabling & Activating Air Bag System
- Adjustments
- Removal & Installation
- Notes
- Air Bag (Inflator) Module
- Steering Wheel
- Sir CLOCKSPRING Assembly
- Turn Signal Switch
- Lock Cylinder
- Dimmer Switch
- Ignition Switch
- Lock Housing Cover
- Automatic Transmission Shift Lock Control - Disassemble - Off Vehicle
- Automatic Transmission Shift Lock Control - Assemble - Off Vehicle
- MULTIFUNCTION Switch Lever
- Steering Wheel Rotation Sensor
- Steering Column
- Lower Bearing & Related Components
- Overhaul
- Torque Specifications
- Steering Wheel And Steering Column
- Infotainment
- Interior/Illumination Lights
- Illumination - Interior Lighting Systems Wiring Diagrams
- ALERO
- Astro & Safari
- Aurora
- AZTEK
- Blazer, BRAVADA & Jimmy
- BONNEVILLE
- CAMARO & Firebird
- CATERA
- Cavalier & SUNFIRE
- Century & Regal
- Chevy Express & SAVANA
- Corvette
- DEVILLE
- ELDORADO
- Grand Am
- Grand PRIX
- Impala & Monte CARLO
- Intrigue
- LESABRE
- Lumina
- MALIBU
- Metro
- MONTANA, Silhouette & Venture
- Park Avenue
- PRIZM
- SATURN
- SEVILLE
- Sierra & SILVERADO
- SONOMA & S10 Pickup
- Suburban, TAHOE, YUKON
- Tracker
- Lighting Systems
- Description and Operation
- Exterior Lighting Systems Description and Operation
- Exterior Lamps
- Headlamps
- Headlamps w/High Intensity Discharge (HID)
- Low Voltage Operation of HID Headlamps
- Electrical System Requirements (w/HID)
- Run Up Of The Lamp (w/HID)
- When To Change The HID Bulb
- Light Color (w/HID)
- Cornering Lamps
- Daytime Running Lamps (DRL)
- Daytime Running Lamps (Norway and Sweden)
- Twilight Sentinel
- Front Fog Lamps
- Rear Fog Lamps
- Park, Tail, License and Marker Lamps
- Position Lamps
- Remote Keyless Entry Exterior Lamp Illumination
- Turn Signal Lamps
- Repeater Lamps
- Stop Lamps
- Backup Lamps
- Underhood Lamp
- Battery Run Down Protection/Inadvertent Power
- Interior Lighting Systems Description and Operation
- Exterior Lighting Systems Description and Operation
- Component Locator
- Lighting Systems Component Views
- Lighting Systems Connector End Views
- Ambient Light Sensor
- Ashtray Lamp
- Backup Lamp - Left
- Backup Lamp - Right
- Center High Mounted Stop Lamp (CHMSL)
- Cornering Lamp - Left
- Cornering Lamp - Right
- Door Courtesy Lamp - LF
- Door Courtesy Lamp - LR
- Door Courtesy Lamp - RF
- Door Courtesy Lamp - RR
- Door Lock Actuator - Driver C1
- Door Lock Actuator - Front Passenger C1
- Door Lock Actuator - LR C1
- Door Lock Actuator - RR C1
- Fog Lamp - LF
- Fog Lamp - LR (Export)
- Fog Lamp - RF
- Fog Lamp - RR (Export)
- Footwell Courtesy Lamp - Left
- Footwell Courtesy Lamp - Right
- Hazard Switch
- Headlamp - High Beam- Left (Domestic)
- Headlamp - High Beam - Left (Export)
- Headlamp - High Beam - Right (Domestic)
- Headlamp - High Beam - Right (Export)
- Headlamp - Low Beam - Left (w/HID) (Generation 2.5)
- Headlamp - Low Beam - Left (w/HID) (Generation 3.0)
- Headlamp - Low Beam - Left (w/o HID)
- Headlamp - Low Beam - Right (w/HID) (Generation 2.5)
- Headlamp - Low Beam - Right (w/HID) (Generation 3.0)
- Headlamp - Low Beam - Right (w/o HID)
- Headlamp Switch (LH Drive)
- Hood Ajar Switch (Export)
- IP Compartment Lamp
- IP Compartment Lamp Switch
- IP Dimmer/Fog Lamp Switch (RH Drive)
- Ignition Key Cylinder Lamp
- License Lamp
- Marker Lamp - LF
- Marker Lamp - RF
- Park/Turn Signal Lamp - LF (Europe)
- Park/Turn Signal Lamp - LF
- Park/Turn Signal Lamp - RF (Europe)
- Park/Turn Signal Lamp -RF
- Position Lamp - Left (Export)
- Position Lamp - Right (Export)
- Reading Lamp Switch - Left
- Reading Lamp Switch - Right
- Rear Compartment Lamp
- Reading Lamp - Left
- Reading Lamp - Right
- Tail Lamp - Left (Domestic)
- Tail Lamp - Left (Export)
- Tail Lamp - Right (Domestic)
- Tail Lamp - Right (Export)
- Tail/Stop Lamp - Left (Domestic)
- Tail/Stop Lamp - Left (Export)
- Tail/Stop Lamp - Right (Domestic)
- Tail/Stop Lamp - Right (Export)
- Turn Signal Lamp - LR
- Turn Signal Lamp - RR
- Underhood Lamp
- Vanity Mirror Lamp - Left
- Vanity Mirror Lamp - Right
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Lighting Systems
- Diagnostic System Check - Lighting Systems
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- Diagnostic Trouble Code (DTC) List
- DTC B2419: Ambient Light Sensor Input Counts
- DTC B2420: Twilight Delay Input Low
- DTC B2422: Interior Lamp Rheostat Counts
- Symptoms - Lighting Systems
- Backup Lamps Always On
- Backup Lamps Inoperative
- Cornering Lamps Always On
- Cornering Lamps Inoperative
- Courtesy Lamps Always On
- Courtesy Lamps Inoperative
- Daytime Running Lamps (DRL) Always On
- Daytime Running Lamps (DRL) Inoperative (Domestic)
- Daytime Running Lamps (DRL) Inoperative (Export)
- Fog Lamp Indicator Always On
- Fog Lamp Indicator Inoperative
- Fog Lamps Always On
- Fog Lamps Inoperative
- Hazard Lamps Always On
- Hazard Lamps Inoperative
- Headlamps Always On - Low or High Beam (Domestic)
- Headlamps Always On - Low or High Beam (Export)
- Headlamps Inoperative - Low Beams (Norway/Sweden)
- Headlamps Inoperative - Low Beams (Norway/Sweden w/HID)
- Headlamps Inoperative - Low Beams (Domestic, Europe and Japan)
- Headlamps Inoperative - Low Beams (Domestic, Europe and Japan w/HID)
- Headlamps Inoperative - High Beams (Export)
- Headlamps Inoperative - High Beams (Domestic)
- Headlamps Flash to Pass Inoperative
- Headlamps Suggested Message On in Daylight Conditions
- High Beam Indicator Always On
- High Beam Indicator Inoperative
- Ignition Lock Cylinder Lamp Always On
- Ignition Lock Cylinder Lamp Inoperative
- Interior Backlighting Does Not Dim
- Interior Backlighting Inoperative
- Instrument Panel (I/P) Compartment Lamp Inoperative
- Instrument Panel (I/P) Compartment Lamp Always On
- License Lamps Inoperative
- Lights On Indicator Always On
- Lights On Indicator Inoperative
- Park Lamps Inoperative
- Park, License, and Tail Lamps Always On
- Position Lamps Inoperative
- Reading Lamp(s) Always On
- Reading Lamp(s) Inoperative
- Rear Compartment Lamp(s) Always On
- Rear Compartment Lamp(s) Inoperative
- Repeater Lamps Inoperative
- Stop Lamps Always On
- Stop Lamps Inoperative
- Turn Signal Lamps and/or Indicators Always On or Flashing
- Turn Signal Lamps and/or Indicators Inoperative
- Twilight Sentinel Inoperative
- Underhood Lamp Always On
- Underhood Lamp Inoperative
- Vacuum Fluorescent (VF) Displays Inoperative
- Vanity Mirror Lamp(s) Always On
- Vanity Mirror Lamp(s) Inoperative
- Vacuum Fluorescent Displays Inoperative
- Repair Instructions
- Headlamp Switch Replacement (LHD)
- Fog Lamp and Instrument Panel Lamp Dimmer Switch Replacement (RHD)
- Hazard Warning Switch Replacement
- Headlamp Relay Replacement
- Fog Lamp Relay Replacement
- Reverse Lamp Relay Replacement
- Park Lamp Relay Replacement
- Daytime Running Lamps (DRL) Relay Replacement
- Hazard Lamp and Turn Signal Lamp Flasher Replacement
- Headlamp Replacement (SLS, w/o TT6, TT7 or TT8)
- Headlamp Replacement (STS and SLS w/TT6, TT7 or TT8)
- High Intensity Discharge Headlamp Starter/Arc Tube Replacement (TT6, TT7, TT8)
- HID Headlamp Ballast Replacement (TT6, TT7, TT8)
- Headlamp Bulb Replacement
- Headlamp Aiming
- Front Fog Lamp Replacement
- Front Fog Lamp Bulb Replacement
- Fog Lamp Aiming
- Repeater Lamp Replacement
- Side Marker Lamp Replacement
- Park/Turn Signal Lamp Bulb Replacement
- Cornering Lamp Bulb Replacement
- High Mounted Stop Lamp Replacement
- Backup Lamp Replacement
- Rear License Plate Lamp Replacement
- Tail Lamp Replacement
- Tail/Turn Signal Lamp Replacement
- Underhood Lamp Replacement
- Door Lamp Replacement
- Instrument Panel (I/P) Storage Compartment Lamp Replacement
- Roof Rail Rear Courtesy Lamp Switch Replacement
- Roof Rail Rear Courtesy Lamp Replacement
- Sunshade Illuminated Mirror Lamp Bulb Replacement
- Trans Floor Shift Control Indicator Lamp Replacement
- Dome Lamp Replacement
- Rear Compartment Courtesy Lamp Replacement
- Specifications
- Schematic Wiring Diagrams
- Description and Operation
- Illumination - Interior Lighting Systems Wiring Diagrams
- Mirrors
- Auto Dimming Mirror
- Power Mirror System
- Description & Operation
- Component Locations
- Programming
- Trouble Shooting
- INTERMITTENTS
- Self-Diagnostic System
- Diagnostic Tests
- System Tests
- Removal & Installation
- Wiring Diagrams
- Seats
- Power Seat System
- Description & Operation
- Component Locations
- Programming
- Trouble Shooting
- Self-Diagnostic System
- Diagnostic Tests
- DTC B1735, B1740, B1745, B1750, B1755, B1760, B1815, B1820, B1830, B1835, B1840, B1845, B1940 Or B1945: Power Seat Switch Failure
- DTC B1825, B1850, B1860, B2355, B2365 Or B2375: Seat Position Sensor Malfunction
- DTC B1870: Power Seat Switch Circuit Malfunction
- DTC B1875: Power Seat Motor Reached End Of Travel
- DTC B1900: Positioning Sensor Voltage Out Of Range
- DTC B2757, 2762, B2767 Or B2772: Memory Recall Switch Malfunction
- DTC B3793: Memory Seat Module Voltage Malfunction
- System Tests
- Notes
- Test A: Heated Seat Inoperative - Front
- Test B: Heated Seat Always On - Front
- Test C: Heated Seat Inoperative - Rear
- Test D: Heated Seat Always On - Rear
- Test E: Heated Seat Switch Lo Indicator Inoperative - Front
- Test F: Heated Seat Switch Lo Indicator Inoperative - Rear
- Test G: Heated Seat Switch Hi Indicator Inoperative - Front
- Test H: Heated Seat Switch Hi Indicator Inoperative - Rear
- Test I: Power Seat Inoperative - Without Memory
- Test J: Power Seat Inoperative - With Memory
- Test K: Power Seat Does Not Move Forward/Rearward - Without Memory
- Test L: Power Seat Does Not Move Forward/Rearward - With Memory
- Test M: Power Seat Does Not Tilt Forward - Without Memory
- Test N: Power Seat Does Not Tilt Forward - With Memory
- Test O: Power Seat Does Not Tilt Rearward - Without Memory
- Test P: Power Seat Does Not Tilt Rearward - With Memory
- Test Q: Power Seat Does Not Recline - Without Memory
- Test R: Power Seat Does Not Recline - With Memory
- Test S: Power Headrest Does Not Move Up/Down - Without Memory
- Test T: Power Headrest Does Not Move Up/Down - With Memory
- Test U: Memory Seat Feature Inoperative
- Test V: Lumbar Support Inoperative - Without Memory
- Test W: Lumbar Support Inoperative - With Memory
- Test X: Lumbar Support Inoperative - With Auto Contour Control
- Test Y: Lumbar Support Does Not Move In/Out - Without Memory
- Test Z: Lumbar Support Does Not Move In/Out - With Memory
- Test Aa: Lumbar Support Does Not Move Up/Down - Without Memory
- Test Ab: Lumbar Support Does Not Move Up/Down - With Memory
- Removal & Installation
- Wiring Diagrams
- Power Seat System
- Steering Column Switches
- Steering Column & Steering Column Switches
- Description & Operation
- Component Locations
- Programming
- Trouble Shooting
- Self-Diagnostic System
- Diagnostic Tests
- DTC B1396: Tilt/Telescope Position Sensor Failure
- DTC B2175: Tilt/Telescope Switch Input Malfunction
- DTC B2511: Radio Steering Wheel Controls Key Stuck
- DTC B2512: Steering Wheel Controls Circuit Malfunction
- DTC B2853, B2858, B2873, B2878 Or B2904: Tilt/Telescope Switch Malfunction
- DTC B2860: Telescope Actuator Position Sensor Voltage High
- DTC B2862: Telescope Actuator Position Sensor Voltage Low
- DTC B2880: Tilt Actuator Position Sensor Voltage High
- DTC B2882: Tilt Position Sensor Voltage Low
- DTC B2891: Tilt/Telescope Motor Circuit Malfunction
- DTC 2904: Tilt/Telescope Switch Circuit Malfunction
- System Tests
- Removal & Installation
- Torque Specifications
- Wiring Diagrams
- Steering Wheel And Steering Column
- Model Identification
- Description & Operation
- Service Precautions
- Disabling & Activating Air Bag System
- Adjustments
- Removal & Installation
- Notes
- Air Bag (Inflator) Module
- Steering Wheel
- Sir CLOCKSPRING Assembly
- Turn Signal Switch
- Lock Cylinder
- Dimmer Switch
- Ignition Switch
- Lock Housing Cover
- Automatic Transmission Shift Lock Control - Disassemble - Off Vehicle
- Automatic Transmission Shift Lock Control - Assemble - Off Vehicle
- MULTIFUNCTION Switch Lever
- Steering Wheel Rotation Sensor
- Steering Column
- Lower Bearing & Related Components
- Overhaul
- Torque Specifications
- Steering Column & Steering Column Switches
- Warning Systems
- Window Motors & Regulators
- Power Window System
- Description & Operation
- Component Locations
- Programming
- Adjustments
- Trouble Shooting
- INTERMITTENTS
- Self-Diagnostic System
- Diagnostic Tests
- Notes
- DTC B3172, B3177, B3182, B3187, B3282, B3287 Or B3292: Passenger Door Module Message Failure
- DTC B3377, B3382, B3387, B3392, B3397, B3452, B3457, B3467, B3472, B3477, B3482, B3517 Or B3522: Driver Door Switch Malfunction
- DTC B3527: Power Window Lock-Out Malfunction
- DTC B3832 Or B3833: POWER WINDOW SWITCH INPUT MALFUNCTION
- Symptom Tests
- Removal & Installation
- Wiring Diagrams
- Power Window System
- Wiper/Washer Systems
- Wiper System And Washer System
- Description & Operation
- Component Locations
- Adjustments
- Trouble Shooting
- INTERMITTENTS
- Self-Diagnostic System
- System Tests
- Removal & Installation
- Torque Specifications
- Wiring Diagrams
- Wiper System And Washer System
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Data Link Connector Wiring Diagrams
- Data Link Connectors Wiring Diagram (ALERO & Grand Am)
- Data Link Connectors Wiring Diagram (Astro & Safari)
- Data Link Connectors Wiring Diagram (Aurora)
- Data Link Connectors Wiring Diagram (AZTEK)
- Data Link Connectors Wiring Diagram (Blazer, BRAVADA, Jimmy, SONOMA & S10 Pickup)
- Data Link Connectors Wiring Diagram (BONNEVILLE)
- Data Link Connectors Wiring Diagram (CAMARO & Firebird)
- Data Link Connectors Wiring Diagram (CATERA)
- Data Link Connectors Wiring Diagram (Cavalier & SUNFIRE)
- Data Link Connectors Wiring Diagram (Century & Regal)
- Data Link Connectors Wiring Diagram (Chevy Express & SAVANA)
- Data Link Connectors Wiring Diagram (Corvette)
- Data Link Connectors Wiring Diagram (DEVILLE)
- Data Link Connectors Wiring Diagram (ELDORADO)
- Data Link Connectors Wiring Diagram (Grand PRIX)
- Data Link Connectors Wiring Diagram (Impala & Monte CARLO)
- Data Link Connectors Wiring Diagram (Intrigue)
- Data Link Connectors Wiring Diagram (LESABRE)
- Data Link Connectors Wiring Diagram (Lumina)
- Data Link Connectors Wiring Diagram (MALIBU)
- Data Link Connectors Wiring Diagram (Metro)
- Data Link Connectors Wiring Diagram (MONTANA, Silhouette & Venture)
- Data Link Connectors Wiring Diagram (Park Avenue)
- Data Link Connectors Wiring Diagram (PRIZM)
- Data Link Connectors Wiring Diagram (SATURN SC1, SC2, SL, SL1, SL2 & SW2)
- Data Link Connectors Wiring Diagram (SEVILLE)
- Data Link Connectors Wiring Diagram (Sierra, SILVERADO, Suburban, TAHOE, YUKON & YUKON XL)
- Data Link Connectors Wiring Diagram (Tracker)
- Ground Distribution - Wiring Diagrams
- ALERO & Grand Am Ground Distribution Wiring Diagram
- Astro & Safari Ground Distribution Wiring Diagram
- Aurora Ground Distribution Wiring Diagram
- AZTEK Ground Distribution Wiring Diagram
- Blazer, BRAVADA, Jimmy, SONOMA & S10 Pickup Ground Distribution Wiring Diagram
- BONNEVILLE Ground Distribution Wiring Diagram
- CAMARO & Firebird Ground Distribution Wiring Diagram
- CATERA Ground Distribution Wiring Diagram
- Cavalier & SUNFIRE Ground Distribution Wiring Diagram
- Century & Regal Ground Distribution Wiring Diagram
- Chevy Express & SAVANA Ground Distribution Wiring Diagram
- Corvette Ground Distribution Wiring Diagram
- DEVILLE Ground Distribution Wiring Diagram
- ELDORADO Ground Distribution Wiring Diagram
- Grand PRIX Ground Distribution Wiring Diagram
- Impala & Monte CARLO Ground Distribution Wiring Diagram
- Intrigue Ground Distribution Wiring Diagram
- LESABRE Ground Distribution Wiring Diagram
- Lumina Ground Distribution Wiring Diagram
- MALIBU Ground Distribution Wiring Diagram
- Metro Ground Distribution Wiring Diagram
- MONTANA, Silhouette & Venture Ground Distribution Wiring Diagram
- Park Avenue Ground Distribution Wiring Diagram
- PRIZM Ground Distribution Wiring Diagram
- SATURN L SERIESGROUND Distribution Wiring Diagrams
- SATURN S Series Ground Distribution Wiring Diagram
- SEVILLE Ground Distribution Wiring Diagram
- Sierra, SILVERADO, Suburban, TAHOE, YUKON & YUKON XL Ground Distribution Wiring Diagram
- Tracker Ground Distribution Wiring Diagram
- Power Distribution - Wiring Diagrams
- ALERO & Grand Am Power Distribution Wiring Diagram
- Astro & Safari Power Distribution Wiring Diagram
- Aurora Power Distribution Wiring Diagram
- AZTEK Power Distribution Wiring Diagram
- Blazer, BRAVADA, Jimmy, SONOMA & S10 Pickup Power Distribution Wiring Diagram
- BONNEVILLE Power Distribution Wiring Diagram
- CAMARO & Firebird Power Distribution Wiring Diagram
- CATERA Power Distribution Wiring Diagram
- Cavalier & SUNFIRE Power Distribution Wiring Diagram
- Century & Regal Power Distribution Wiring Diagram
- Chevy Express & SAVANA Power Distribution Wiring Diagram
- Corvette Power Distribution Wiring Diagram
- DEVILLE Power Distribution Wiring Diagram
- ELDORADO Power Distribution Wiring Diagram
- Grand PRIX Power Distribution Wiring Diagram
- Impala & Monte CARLO Power Distribution Wiring Diagram
- Intrigue Power Distribution Wiring Diagram
- LESABRE Power Distribution Wiring Diagram
- Lumina Power Distribution Wiring Diagram
- MALIBU Power Distribution Wiring Diagram
- Metro Power Distribution Wiring Diagram
- MONTANA, Silhouette & Venture Power Distribution Wiring Diagram
- Park Avenue Power Distribution Wiring Diagram
- PRIZM Power Distribution Wiring Diagram
- SATURN L100, L200, L300, LW200 & LW300 Power Distribution Wiring Diagram
- SC1, SC2, SL, SL1, SL2 & SW2 Power Distribution Wiring Diagram
- SEVILLE Power Distribution Wiring Diagram
- Sierra, SILVERADO, Suburban, TAHOE, YUKON & YUKON XL Power Distribution Wiring Diagram
- Tracker Power Distribution Wiring Diagram
- Data Link Connector Wiring Diagrams
- Anti-Theft Systems
- Body & Frame
- Door Locks
- Anti-Theft System
- Description & Operation
- Component Locations
- Anti-Theft System Arming & Disarming
- Programming
- Trouble Shooting
- Self-Diagnostic System
- Diagnostic Tests
- Notes
- DTC B2734: Coded Key Controller Memory Failure
- DTC B2947: Antenna Power Short To Ground
- DTC B2948: Antenna Power Short To Battery Voltage
- DTC B2955: Key Code Input Short To Battery Voltage
- DTC B2960: Invalid Coded Key Is Present
- DTC B3031: Key Decoder In Assembly Learn Mode
- DTC B3055: Key Is Not Present
- DTC P1630: Password Learning Mode Required
- DTC P1631: Pcm Detected Incorrect Password From Vehicle Theft Deterrent Control Module
- Symptom Tests
- Removal & Installation
- Wiring Diagrams
- Power Door Locks & Remote Keyless Entry Systems
- Description & Operation (Power Door Locks)
- Description & Operation (Remote Keyless Entry)
- Component Locations
- Programming
- Trouble Shooting
- Self-Diagnostic System
- Diagnostic Tests
- System Tests
- Removal & Installation
- Wiring Diagrams
- Power Trunk & Fuel Door Release
- Anti-Theft System
- Ignition Switch/Steering Lock
- Steering Wheel And Steering Column
- Model Identification
- Description & Operation
- Service Precautions
- Disabling & Activating Air Bag System
- Adjustments
- Removal & Installation
- Notes
- Air Bag (Inflator) Module
- Steering Wheel
- Sir CLOCKSPRING Assembly
- Turn Signal Switch
- Lock Cylinder
- Dimmer Switch
- Ignition Switch
- Lock Housing Cover
- Automatic Transmission Shift Lock Control - Disassemble - Off Vehicle
- Automatic Transmission Shift Lock Control - Assemble - Off Vehicle
- MULTIFUNCTION Switch Lever
- Steering Wheel Rotation Sensor
- Steering Column
- Lower Bearing & Related Components
- Overhaul
- Torque Specifications
- Steering Wheel And Steering Column
- Mirrors
- Auto Dimming Mirror
- Power Mirror System
- Description & Operation
- Component Locations
- Programming
- Trouble Shooting
- INTERMITTENTS
- Self-Diagnostic System
- Diagnostic Tests
- System Tests
- Removal & Installation
- Wiring Diagrams
- Seats
- Power Seat System
- Description & Operation
- Component Locations
- Programming
- Trouble Shooting
- Self-Diagnostic System
- Diagnostic Tests
- DTC B1735, B1740, B1745, B1750, B1755, B1760, B1815, B1820, B1830, B1835, B1840, B1845, B1940 Or B1945: Power Seat Switch Failure
- DTC B1825, B1850, B1860, B2355, B2365 Or B2375: Seat Position Sensor Malfunction
- DTC B1870: Power Seat Switch Circuit Malfunction
- DTC B1875: Power Seat Motor Reached End Of Travel
- DTC B1900: Positioning Sensor Voltage Out Of Range
- DTC B2757, 2762, B2767 Or B2772: Memory Recall Switch Malfunction
- DTC B3793: Memory Seat Module Voltage Malfunction
- System Tests
- Notes
- Test A: Heated Seat Inoperative - Front
- Test B: Heated Seat Always On - Front
- Test C: Heated Seat Inoperative - Rear
- Test D: Heated Seat Always On - Rear
- Test E: Heated Seat Switch Lo Indicator Inoperative - Front
- Test F: Heated Seat Switch Lo Indicator Inoperative - Rear
- Test G: Heated Seat Switch Hi Indicator Inoperative - Front
- Test H: Heated Seat Switch Hi Indicator Inoperative - Rear
- Test I: Power Seat Inoperative - Without Memory
- Test J: Power Seat Inoperative - With Memory
- Test K: Power Seat Does Not Move Forward/Rearward - Without Memory
- Test L: Power Seat Does Not Move Forward/Rearward - With Memory
- Test M: Power Seat Does Not Tilt Forward - Without Memory
- Test N: Power Seat Does Not Tilt Forward - With Memory
- Test O: Power Seat Does Not Tilt Rearward - Without Memory
- Test P: Power Seat Does Not Tilt Rearward - With Memory
- Test Q: Power Seat Does Not Recline - Without Memory
- Test R: Power Seat Does Not Recline - With Memory
- Test S: Power Headrest Does Not Move Up/Down - Without Memory
- Test T: Power Headrest Does Not Move Up/Down - With Memory
- Test U: Memory Seat Feature Inoperative
- Test V: Lumbar Support Inoperative - Without Memory
- Test W: Lumbar Support Inoperative - With Memory
- Test X: Lumbar Support Inoperative - With Auto Contour Control
- Test Y: Lumbar Support Does Not Move In/Out - Without Memory
- Test Z: Lumbar Support Does Not Move In/Out - With Memory
- Test Aa: Lumbar Support Does Not Move Up/Down - Without Memory
- Test Ab: Lumbar Support Does Not Move Up/Down - With Memory
- Removal & Installation
- Wiring Diagrams
- Power Seat System
- Sun Roof/T-Top/Convertible Top
- Power Sun Roofs
- Description & Operation
- Component Locations
- Servicing
- Adjustments
- Trouble Shooting
- Self-Diagnostic System
- Symptom Tests
- Removal & Installation
- Torque Specifications
- Wiring Diagrams
- Power Sun Roofs
- Windows
- Power Window System
- Description & Operation
- Component Locations
- Programming
- Adjustments
- Trouble Shooting
- INTERMITTENTS
- Self-Diagnostic System
- Diagnostic Tests
- Notes
- DTC B3172, B3177, B3182, B3187, B3282, B3287 Or B3292: Passenger Door Module Message Failure
- DTC B3377, B3382, B3387, B3392, B3397, B3452, B3457, B3467, B3472, B3477, B3482, B3517 Or B3522: Driver Door Switch Malfunction
- DTC B3527: Power Window Lock-Out Malfunction
- DTC B3832 Or B3833: POWER WINDOW SWITCH INPUT MALFUNCTION
- Symptom Tests
- Removal & Installation
- Wiring Diagrams
- Power Window System
- Door Locks
- Brakes
- Anti-Lock Brakes
- Anti-Lock Brake System - Wiring Diagrams
- ALERO & Grand Am
- Astro & Safari
- Aurora
- AZTEK
- Blazer, BRAVADA, Jimmy, SONOMA & S10 Pickup
- BONNEVILLE
- CAMARO & Firebird
- CATERA
- Cavalier & SUNFIRE
- Century & Regal
- Chevy Express & SAVANA
- Corvette
- DEVILLE
- ELDORADO
- Grand PRIX
- Impala & Monte CARLO
- Intrigue
- LESABRE
- Lumina
- MALIBU
- Metro
- MONTANA, Silhouette & Venture
- Park Avenue
- PRIZM
- SATURN
- SEVILLE
- Sierra, SILVERADO, Suburban, TAHOE & YUKON
- Tracker
- Anti-Lock Brake System With Traction Control System And VSES - BOSCH 5.3
- Model Identification
- Description & Operation
- Servicing
- Service Precautions
- Bleeding Brake System
- Programming
- Diagnosis & Testing
- Symptom Tests
- Notes
- Test A: Abs Indicator Always On ("C", "G", "H" & "K" Bodies)
- Test B: Abs Indicator Inoperative ("C", "G", "H" & "K" Bodies)
- Test C: VSES Inoperative ("C", "G", "H" & "K" Bodies)
- Test D: VSES Unwanted Activation ("C", "G", "H" & "K" Bodies)
- Test E: VSES Excessive Brake Pulsation ("C", "G", "H" & "K" Bodies)
- Test F: No Communication With EBCM (2000 "C", "H" & "K" Bodies)
- Test G: Traction Off Indicator Always On (2000 "C" Body)
- Test G: Traction Off Indicator Always On (2000 "H" Body)
- Test G: Traction Off Indicator Always On (2000 "K" Body)
- Test G: Traction Off Indicator Always On (2001 "C", "G" & "H" Bodies)
- Test H: Traction Off Indicator Inoperative (2000 "C" Body)
- Test H: Traction Off Indicator Inoperative (2000 "H" Body)
- Test H: Traction Off Indicator Inoperative (2000 "K" Body)
- Test H: Traction Off Indicator Inoperative (2001 "C" & "G" Bodies)
- Test H: Traction Off Indicator Inoperative (2001 "H" Body)
- Test H: Traction Off Indicator Inoperative (2001 "K" Body)
- Test I: Traction Active Indicator Always On (BONNEVILLE & "K" Body, & 2001 "G" Body)
- Test J: Traction Active Indicator Inoperative (BONNEVILLE & "K" Body, & 2001 "G" Body)
- Test K: Traction Ready Indicator Always On (BONNEVILLE)
- Test L: Traction Ready Indicator Inoperative (BONNEVILLE)
- Diagnostic Tests
- Notes
- DTC C1211: Abs Indicator Signal Circuit High
- DTC C1214: System Relay Contact Or Coil Circuit Open
- DTC C1217: BPMV Pump Motor Control Circuit Short
- DTC C1218: Pump Motor Voltage
- DTC C1221-C1228 & C1232-C1235: Wheel Speed Sensor
- DTC C1236: Low System Supply Voltage
- DTC C1237: High System Supply Voltage
- DTC C1238: Drive Wheel Brake Rotor Excessive Temperature
- DTC C1242 Or C1243: BPMV Pump Motor Short To Ground Or BPMV Pump Motor Stalled
- DTC C1245: Tire Inflation Monitor
- DTC C1246: Brake Lining Wear Circuit Open (2000 SEVILLE)
- DTC C1248: Dynamic Rear Proportioning Control System
- DTC C1251: RSS Indicated Malfunction (CADILLAC)
- DTC C1252 Or C1253: Normal Force Malfunction (2000 CADILLAC)
- DTC C1254: Checksum Error
- DTC C1255 Or C1256: EBCM Internal Malfunction (Abs/TCS Disabled)
- DTC C1261-C1268 Or C1271-C1274: Solenoid Valve Malfunction
- DTC C1276, P1644 Or P1689: Delivered Torque Signal Circuit Malfunction Or Delivered Torque Signal Voltage Invalid
- DTC C1277 Or P1571: Requested Torque Signal Circuit Malfunction
- DTC C1278: TCS Temporarily Inhibited By Pcm
- DTC C1281, C1283 Or C1286: Steering Sensor
- DTC C1282: Yaw Rate Sensor Bias Circuit Malfunction
- DTC C1284 Or C1285: Lateral Accelerometer Self Test Malfunction Or Lateral Accelerometer Circuit Malfunction
- DTC C1287 Or C1288: Steering Sensor Rate Malfunction Or Steering Sensor Circuit Malfunction
- DTC C1291 Or C1293: Open BRAKELIGHT Switch Contacts During Deceleration Or DTC C1291 Set In Previous Ignition Cycle
- DTC C1294: BRAKELIGHT Switch Circuit Always Active
- DTC C1295: BRAKELIGHT Switch Circuit Open
- DTC C1298: Class 2 Serial Data Link Malfunction (2000 Only)
- Removal & Installation
- Adjustments
- Torque Specifications
- Wiring Diagrams
- Anti-Lock Brake System - Wiring Diagrams
- Mechanical - Hydraulic
- Disc Brakes
- Identification
- Description & Operation
- Bleeding Brake System
- Adjustments
- Testing
- Removal & Installation
- Overhaul
- Disc Brake Specifications
- Torque Specifications
- Wiring Diagrams
- Disc Brakes
- Traction Control
- Anti-Lock Brake System - Wiring Diagrams
- ALERO & Grand Am
- Astro & Safari
- Aurora
- AZTEK
- Blazer, BRAVADA, Jimmy, SONOMA & S10 Pickup
- BONNEVILLE
- CAMARO & Firebird
- CATERA
- Cavalier & SUNFIRE
- Century & Regal
- Chevy Express & SAVANA
- Corvette
- DEVILLE
- ELDORADO
- Grand PRIX
- Impala & Monte CARLO
- Intrigue
- LESABRE
- Lumina
- MALIBU
- Metro
- MONTANA, Silhouette & Venture
- Park Avenue
- PRIZM
- SATURN
- SEVILLE
- Sierra, SILVERADO, Suburban, TAHOE & YUKON
- Tracker
- Anti-Lock Brake System With Traction Control System And VSES - BOSCH 5.3
- Model Identification
- Description & Operation
- Servicing
- Service Precautions
- Bleeding Brake System
- Programming
- Diagnosis & Testing
- Symptom Tests
- Notes
- Test A: Abs Indicator Always On ("C", "G", "H" & "K" Bodies)
- Test B: Abs Indicator Inoperative ("C", "G", "H" & "K" Bodies)
- Test C: VSES Inoperative ("C", "G", "H" & "K" Bodies)
- Test D: VSES Unwanted Activation ("C", "G", "H" & "K" Bodies)
- Test E: VSES Excessive Brake Pulsation ("C", "G", "H" & "K" Bodies)
- Test F: No Communication With EBCM (2000 "C", "H" & "K" Bodies)
- Test G: Traction Off Indicator Always On (2000 "C" Body)
- Test G: Traction Off Indicator Always On (2000 "H" Body)
- Test G: Traction Off Indicator Always On (2000 "K" Body)
- Test G: Traction Off Indicator Always On (2001 "C", "G" & "H" Bodies)
- Test H: Traction Off Indicator Inoperative (2000 "C" Body)
- Test H: Traction Off Indicator Inoperative (2000 "H" Body)
- Test H: Traction Off Indicator Inoperative (2000 "K" Body)
- Test H: Traction Off Indicator Inoperative (2001 "C" & "G" Bodies)
- Test H: Traction Off Indicator Inoperative (2001 "H" Body)
- Test H: Traction Off Indicator Inoperative (2001 "K" Body)
- Test I: Traction Active Indicator Always On (BONNEVILLE & "K" Body, & 2001 "G" Body)
- Test J: Traction Active Indicator Inoperative (BONNEVILLE & "K" Body, & 2001 "G" Body)
- Test K: Traction Ready Indicator Always On (BONNEVILLE)
- Test L: Traction Ready Indicator Inoperative (BONNEVILLE)
- Diagnostic Tests
- Notes
- DTC C1211: Abs Indicator Signal Circuit High
- DTC C1214: System Relay Contact Or Coil Circuit Open
- DTC C1217: BPMV Pump Motor Control Circuit Short
- DTC C1218: Pump Motor Voltage
- DTC C1221-C1228 & C1232-C1235: Wheel Speed Sensor
- DTC C1236: Low System Supply Voltage
- DTC C1237: High System Supply Voltage
- DTC C1238: Drive Wheel Brake Rotor Excessive Temperature
- DTC C1242 Or C1243: BPMV Pump Motor Short To Ground Or BPMV Pump Motor Stalled
- DTC C1245: Tire Inflation Monitor
- DTC C1246: Brake Lining Wear Circuit Open (2000 SEVILLE)
- DTC C1248: Dynamic Rear Proportioning Control System
- DTC C1251: RSS Indicated Malfunction (CADILLAC)
- DTC C1252 Or C1253: Normal Force Malfunction (2000 CADILLAC)
- DTC C1254: Checksum Error
- DTC C1255 Or C1256: EBCM Internal Malfunction (Abs/TCS Disabled)
- DTC C1261-C1268 Or C1271-C1274: Solenoid Valve Malfunction
- DTC C1276, P1644 Or P1689: Delivered Torque Signal Circuit Malfunction Or Delivered Torque Signal Voltage Invalid
- DTC C1277 Or P1571: Requested Torque Signal Circuit Malfunction
- DTC C1278: TCS Temporarily Inhibited By Pcm
- DTC C1281, C1283 Or C1286: Steering Sensor
- DTC C1282: Yaw Rate Sensor Bias Circuit Malfunction
- DTC C1284 Or C1285: Lateral Accelerometer Self Test Malfunction Or Lateral Accelerometer Circuit Malfunction
- DTC C1287 Or C1288: Steering Sensor Rate Malfunction Or Steering Sensor Circuit Malfunction
- DTC C1291 Or C1293: Open BRAKELIGHT Switch Contacts During Deceleration Or DTC C1291 Set In Previous Ignition Cycle
- DTC C1294: BRAKELIGHT Switch Circuit Always Active
- DTC C1295: BRAKELIGHT Switch Circuit Open
- DTC C1298: Class 2 Serial Data Link Malfunction (2000 Only)
- Removal & Installation
- Adjustments
- Torque Specifications
- Wiring Diagrams
- Anti-Lock Brake System - Wiring Diagrams
- Anti-Lock Brakes
- Drivelines & Axles
- Electrical
- Body Electrical
- Testing Wiring Systems For Intermittent & Poor Connections
- Service Precautions
- Intermittent Or Poor Connections
- Inducing Intermittent Fault Conditions
- Testing for Electrical Intermittents
- Testing for Short to Ground
- Testing for Continuity
- Testing for a Short to Voltage
- Troubleshooting with a Digital Multimeter
- Troubleshooting with a Test Lamp
- Probing Electrical Connectors
- Wiring Systems (General Information)
- Specifications
- Diagnostic Information and Procedures
- Where to Find Electrical Schematics
- Passenger Car Zoning
- Electrical Symbols
- General Electrical Diagnosis Procedures
- Checking Aftermarket Accessories
- Circuit Testing
- Using Connector Test Adapters
- Probing Electrical Connectors
- Troubleshooting with a Digital Multimeter
- Troubleshooting with a Test Lamp
- Using Fused Jumper Wires
- Measuring Voltage
- Measuring Voltage Drop
- Measuring Frequency
- Testing for Continuity
- Testing for Short to Ground
- Testing for a Short to Voltage
- Testing for Intermittent and Poor Connections
- Inducing Intermittent Fault Conditions
- Testing for Electrical Intermittents
- Scan Tool Snapshot Procedure
- Wiring Repairs
- Circuit Protection - Fuses
- Circuit Protection - Circuit Breakers
- Circuit Protection - Fusible Links
- Repairing Damaged Wire Insulation
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- SIR/SRS Wiring Repairs
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- Connector Repairs
- Connector Position Assurance Locks
- Terminal Position Assurance Locks
- Push to Seat Connectors
- Pull to Seat Connectors
- Weather Pack Connectors
- Repairing Connector Terminals
- Repair Instructions
- Special Tools and Equipment
- Testing Wiring Systems For Intermittent & Poor Connections
- Charging Systems
- Description & Operation
- Component Locations
- Adjustments
- Trouble Shooting
- On-Vehicle Testing
- Self-Diagnostic System
- Diagnostic Tests
- Notes
- DTC B1327: Device Power Circuit Low
- DTC B1328: Device Power Circuit High
- DTC B1513: Charging System Volts Low
- DTC B1514: Charging System Volts High
- DTC B1982: Device Power Circuit High
- DTC B1983: Device Power Circuit Low
- DTC P0560: System Voltage
- DTC P0562: System Voltage Low
- DTC P0563: System Voltage High
- DTC P0621: Generator L-Terminal Circuit
- DTC P0622: Generator F-Terminal Circuit
- System Tests
- Removal & Installation
- Generator Specifications
- Torque Specifications
- Connector Identification
- Wiring Diagrams
- Component Locations
- Fuses & Circuit Breakers
- Gauges
- Analog Instrument Panels
- Description & Operation (Instrument Panel Cluster)
- Description & Operation (Indicator/Warning Message)
- Anti-Lock Brake System Indicator
- Air Bag Indicators
- Brake Pad Wear Indicator
- Brake System Indicators
- Cellular Telephone Indicators
- Charging System Indicators
- Cruise Control Indicator
- Door Ajar Indicators
- Driver Number Indicator
- Electrical System Indicators
- Engine Coolant Indicators
- Engine Misfire Indicator
- Engine Oil Indicators
- Engine OVERSPEED Indicator
- Fasten Safety Belt Indicator
- Fuel System Indicators
- HVAC System Indicator
- Ice Indicator
- Idle Control Indicator
- Km/H & Mph Indicators
- Lighting System Indicators
- Malfunction Indicator Light
- Reduced Engine Power Indicator
- Stability System Indicators
- Status Indicator
- Steering System Indicator
- Suspension System Indicators
- Theft System Indicators
- Tire Pressure Indicator
- Traction Control System Indicators
- Transmission Indicators
- Trunk Ajar Indicator
- Washer Fluid Indicator
- Description & Operation (Driver's Information Center)
- Driver's Information Center Switches
- Indicators & Warning Messages
- Vehicle Information Display
- Outside Air Temperature
- Fuel Range
- Average Fuel Economy
- Instantaneous Fuel Economy
- Fuel Used
- Average Vehicle Speed
- Timer
- Battery Voltage
- Tire Pressure Monitor
- Engine Oil Life
- Transmission Fluid Life
- Cellular Phone
- Personalization
- Description & Operation (Audible Warnings)
- Component Locations
- Handling Precautions
- Programming
- Trouble Shooting
- Self-Diagnostic System
- Notes
- Air Bag System Diagnostic System Check
- Anti-Lock Brake Diagnostic System Check
- Audible Warnings Diagnostic System Check
- Body Rear End Diagnostic System Check
- Cruise Control System Diagnostic System Check
- Door Systems Diagnostic System Check
- Engine Controls Diagnostic System Check
- Engine Cooling Diagnostic System Check
- Engine Electrical Diagnostic System Check
- Hydraulic Brakes Diagnostic System Check
- Instrument Cluster Diagnostic System Check
- Lighting Systems Diagnostic Check
- Theft Deterrent Diagnostic System Check
- Tire Pressure Monitoring Diagnostic System Check
- Diagnostic Trouble Code Definitions
- Diagnostic Tests
- System Tests
- Notes
- Test A: Engine Coolant Temperature Gauge Inaccurate Or Inoperative
- Test B: Fuel Gauge Inaccurate Or Inoperative
- Test C: Speedometer/Odometer Inaccurate Or Inoperative
- Test D: Tachometer Inaccurate Or Inoperative
- Test E: Anti-Lock Brake System Indicator Always On
- Test F: Anti-Lock Brake System Indicator Inoperative
- Test G: Air Bag Indicator Circuit Malfunction
- Test H: Brake Warning Indicator Always On
- Test I: Brake Warning Indicator Inoperative
- Test J: Charge Indicator Always On
- Test K: Charge Indicator Inoperative
- Test L: Cruise Control Switch Indicator Always On
- Test M: Cruise Control Indicator Inoperative
- Test N: Door Ajar Indicator Always On
- Test O: Door Ajar Indicator Inoperative
- Test P: Engine Coolant Temperature Indicator Always On
- Test Q: Engine Oil Pressure Indicator Always On
- Test R: Engine Oil Pressure Indicator Inoperative
- Test S: Fog Light Indicator Always On
- Test T: Fog Light Indicator Inoperative
- Test U: High Beam Indicator Always On
- Test V: High Beam Indicator Inoperative
- Test W: Lights On Indicator Always On
- Test X: Lights On Indicator Inoperative
- Test Y: Low Engine Coolant Indicator Always On
- Test Z: Low Engine Oil Level Indicator Always On
- Test Aa: Low Washer Fluid Indicator Malfunction
- Test Ab: Malfunction Indicator Light Always On
- Test Ac: Malfunction Indicator Light Inoperative
- Test Ad: Seat Belt Indicator Circuit Malfunction
- Test AE: Security Indicator Inoperative
- Test AF: Traction Control Indicator Always On
- Test Ag: Traction Control Indicator Inoperative
- Test Ah: Trunk Ajar Indicator Always On
- Test Ai: Trunk Ajar Indicator Inoperative
- Test AJ: Turn Signal Lights/Indicators Always On Or Flashing
- Test AK: Turn Signal Lights/Indicators Inoperative
- Test Al: Driver's Information Center Switch(Es) Inoperative
- Test Am: Chime Always On
- Test An: Chime Inoperative
- Removal & Installation
- Wiring Diagrams
- Analog Instrument Panels
- Motors, Switches, Relays
- Testing Wiring Systems For Intermittent & Poor Connections
- Service Precautions
- Intermittent Or Poor Connections
- Inducing Intermittent Fault Conditions
- Testing for Electrical Intermittents
- Testing for Short to Ground
- Testing for Continuity
- Testing for a Short to Voltage
- Troubleshooting with a Digital Multimeter
- Troubleshooting with a Test Lamp
- Probing Electrical Connectors
- Wiring Systems (General Information)
- Specifications
- Diagnostic Information and Procedures
- Where to Find Electrical Schematics
- Passenger Car Zoning
- Electrical Symbols
- General Electrical Diagnosis Procedures
- Checking Aftermarket Accessories
- Circuit Testing
- Using Connector Test Adapters
- Probing Electrical Connectors
- Troubleshooting with a Digital Multimeter
- Troubleshooting with a Test Lamp
- Using Fused Jumper Wires
- Measuring Voltage
- Measuring Voltage Drop
- Measuring Frequency
- Testing for Continuity
- Testing for Short to Ground
- Testing for a Short to Voltage
- Testing for Intermittent and Poor Connections
- Inducing Intermittent Fault Conditions
- Testing for Electrical Intermittents
- Scan Tool Snapshot Procedure
- Wiring Repairs
- Circuit Protection - Fuses
- Circuit Protection - Circuit Breakers
- Circuit Protection - Fusible Links
- Repairing Damaged Wire Insulation
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- SIR/SRS Wiring Repairs
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- Connector Repairs
- Connector Position Assurance Locks
- Terminal Position Assurance Locks
- Push to Seat Connectors
- Pull to Seat Connectors
- Weather Pack Connectors
- Repairing Connector Terminals
- Repair Instructions
- Special Tools and Equipment
- Testing Wiring Systems For Intermittent & Poor Connections
- Starter
- Wiring Diagrams
- Electronic Power Steering System - Wiring Diagrams
- System Wiring Diagrams
- Using lemon2025'S Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Body Control Modules
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Electronic Power Steering
- Electronic Suspension
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Memory Systems
- Navigation
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Top/Sunroof
- Power Windows
- Radio
- Shift Interlock
- Starting/Charging
- Supplemental Restraints
- Transmission
- Trunk, Tailgate, Fuel Door
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- Body Electrical
- Engine Mechanical
- Accessory Drive Belts
- Engine Cooling System Specifications & Drive Belt Routing
- Model Identification
- Specifications
- Notes
- Belt Adjustment
- Cooling System Specifications
- Serpentine Belt Routing & Alignment
- Notes
- Serpentine Belt Routing (1.8L Prizm)
- Serpentine Belt Routing (1.9L Saturn DOHC)
- Serpentine Belt Routing (1.9L Saturn SOHC)
- Serpentine Belt Routing (2.0L Tracker)
- Serpentine Belt Routing (2.2L "J" Body)
- Serpentine Belt Routing (2.2L "S" Series)
- Serpentine Belt Routing (2.2L Saturn)
- Serpentine Belt Routing (2.4L "J" & "N" Bodies)
- Serpentine Belt Routing (2.5L Tracker)
- Serpentine Belt Routing (3.0L Saturn)
- Serpentine Belt Routing (3.0L "V" Body)
- Serpentine Belt Routing (3.1 "W" Body)
- Serpentine Belt Routing (3.4L "N", "W" & "Z" Bodies, & "A", "B" & "U" Series)
- Serpentine Belt Routing (3.5L "N" & "W" Bodies)
- Serpentine Belt Routing (3.8L "C", "G", "H" & "W" Bodies)
- Serpentine Belt Routing (3.8L "F" Body)
- Serpentine Belt Routing (4.0L "G" Body & 4.6L "E" & "K" Bodies)
- Serpentine Belt Routing (4.3L, 5.0L, 5.7L & 7.4L, "S" & "T" Series)
- Serpentine Belt Routing (4.8L, 5.3L & 6.0L "C" & "K" Series)
- Serpentine Belt Routing (5.7L "F" Body)
- Serpentine Belt Routing (5.7L "Y" Body)
- Serpentine Belt Routing (6.5L Turbo-Diesel "C", "G" & "K" Series With Dual Generators)
- Serpentine Belt Routing (6.5L Turbo-Diesel "C", "G" & "K" Series Without Dual Generators)
- Serpentine Belt Routing (6.6L Turbo-Diesel "C" & "K" Series)
- Serpentine Belt Routing (8.1L "C", "G" &"K" Series )
- Engine Cooling System Specifications & Drive Belt Routing
- Auxiliary Emission Control Systems
- Emission Control System Visual Inspection Procedures - General Information
- * Please Read This First *
- Emission Control Labels
- Emission Control Visual Inspection
- Notes
- Positive Crankcase Ventilation (PCV)
- Thermostatic Air Cleaner (TAC)
- Fuel Evaporative System (EVAP)
- Catalytic Converters
- Fill Pipe RESTRICTOR (Fr)
- Exhaust Gas RECIRCULATION (EGR) System
- Spark Controls (SPK)
- Air Injection System (AIS)
- Oxygen Sensor (O2)
- Computerized Engine Controls (CEC)
- Early Fuel Evaporation (EFE)
- Emission Maintenance Reminder Light (EMR) (If Equipped)
- Malfunction Indicator Light (Mil)
- Emission Control System Visual Inspection Procedures - General Information
- Cooling Fan
- Engine Cooling Fan System - Troubleshooting
- Model Identification
- Description & Operation
- Trouble Shooting
- Electric Cooling Fan Circuit Diagnosis
- Notes
- 1.0L & 1.3L Metro & Firefly (CANADIAN)
- 1.8L PRIZM
- 1.9L SATURN "S" Series
- 2.2L & 2.4L Cavalier & SUNFIRE
- 2.2L & 3.0L SATURN "L" Series
- 2.4L, 3.1L & 3.4L ALERO, Grand Am & MALIBU
- 3.0L CATERA
- Description
- Cooling Fan System Check
- Cooling Fan High Speed Inoperative
- Cooling Fan Low Speed Inoperative
- Auxiliary Engine Cooling Fan No. 1 Inoperative
- Auxiliary Engine Cooling Fan No. 2 Inoperative
- Auxiliary Cooling Fans No. 1 & 2 Inoperative
- Auxiliary Cooling Fans Inoperative At Low Speed
- Auxiliary Cooling Fans Inoperative At High Speed
- Auxiliary Cooling Fan Runs Continuously
- 3.1L & 3.8L "W" Body (Century & Regal)
- 3.1L "W" Body (Lumina)
- 3.1L & 3.8L "W" Body (Grand PRIX)
- 3.4L & 3.8L "W" Body (Impala & Monte CARLO)
- 3.5L "W" Body (Intrigue)
- 3.5L & 4.0L Aurora
- 3.8L BONNEVILLE & LESABRE
- 3.8L Park Avenue
- 3.8L & 5.7L CAMARO & Firebird
- 4.6L DEVILLE & SEVILLE
- 4.6L ELDORADO
- 5.7L Corvette
- ALERO & Grand Am
- BONNEVILLE & LESABRE
- CAMARO & Firebird
- CATERA
- Cavalier & SUNFIRE
- Century & Regal
- Corvette
- DEVILLE
- ELDORADO
- Grand PRIX
- Impala & Monte CARLO
- Intrigue
- Lumina
- MALIBU
- Metro & Firefly (CANADIAN)
- Park Avenue
- PRIZM
- SATURN
- SEVILLE
- Aurora
- Engine Cooling Fan System - Wiring Diagrams
- Engine Cooling Fan System - Troubleshooting
- Cooling System (Mechanical)
- Engine Cooling System Specifications & Drive Belt Routing
- Model Identification
- Specifications
- Notes
- Belt Adjustment
- Cooling System Specifications
- Serpentine Belt Routing & Alignment
- Notes
- Serpentine Belt Routing (1.8L Prizm)
- Serpentine Belt Routing (1.9L Saturn DOHC)
- Serpentine Belt Routing (1.9L Saturn SOHC)
- Serpentine Belt Routing (2.0L Tracker)
- Serpentine Belt Routing (2.2L "J" Body)
- Serpentine Belt Routing (2.2L "S" Series)
- Serpentine Belt Routing (2.2L Saturn)
- Serpentine Belt Routing (2.4L "J" & "N" Bodies)
- Serpentine Belt Routing (2.5L Tracker)
- Serpentine Belt Routing (3.0L Saturn)
- Serpentine Belt Routing (3.0L "V" Body)
- Serpentine Belt Routing (3.1 "W" Body)
- Serpentine Belt Routing (3.4L "N", "W" & "Z" Bodies, & "A", "B" & "U" Series)
- Serpentine Belt Routing (3.5L "N" & "W" Bodies)
- Serpentine Belt Routing (3.8L "C", "G", "H" & "W" Bodies)
- Serpentine Belt Routing (3.8L "F" Body)
- Serpentine Belt Routing (4.0L "G" Body & 4.6L "E" & "K" Bodies)
- Serpentine Belt Routing (4.3L, 5.0L, 5.7L & 7.4L, "S" & "T" Series)
- Serpentine Belt Routing (4.8L, 5.3L & 6.0L "C" & "K" Series)
- Serpentine Belt Routing (5.7L "F" Body)
- Serpentine Belt Routing (5.7L "Y" Body)
- Serpentine Belt Routing (6.5L Turbo-Diesel "C", "G" & "K" Series With Dual Generators)
- Serpentine Belt Routing (6.5L Turbo-Diesel "C", "G" & "K" Series Without Dual Generators)
- Serpentine Belt Routing (6.6L Turbo-Diesel "C" & "K" Series)
- Serpentine Belt Routing (8.1L "C", "G" &"K" Series )
- Engine Cooling System Specifications & Drive Belt Routing
- Engine Mechanical - 4.6L V8
- Engine Identification
- Adjustments
- Trouble Shooting
- Removal & Installation
- Notes
- Fuel Pressure Release
- Cooling System Bleeding
- Engine
- Intake Manifold
- Exhaust Manifold
- Cylinder Head
- Front Cover
- Crankshaft Front Seal
- Secondary Timing Chain
- Timing Chain TENSIONER
- Primary Timing Chain
- Valve Lifters
- Camshaft Cover
- Camshaft
- Harmonic Balancer
- Crankshaft Main Bearings
- Crankshaft Rear Oil Seal
- Radiator
- Thermostat
- Water Pump
- Oil Pan
- Overhaul
- Engine Oiling
- Torque Specifications
- Engine Specifications
- General Specifications
- Camshaft Specifications
- Engine Valves & Valve Springs Specifications
- Cylinder Block Specifications
- Connecting Rods Specifications
- Cylinder Head Specifications
- Crankshaft, Main Bearings & Connecting Rod Bearings Specifications
- Pistons, Piston Pins & Piston Rings Specifications
- Valve Lifters Specifications
- Starter
- Accessory Drive Belts
- Engine Performance
- Engine Adjustments
- Application
- Emissions
- EGR Function Testing - General Motors Cars
- Emission Applications
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Mode 6 - Class 2 & GMLAN
- Pin Voltage Charts
- Engine Control System - PID Value Charts
- Introduction
- PID Values
- Notes
- Scan Tool Data List Definitions
- PID Value Tables
- Notes
- PID Values (Alero & Grand Am 2.4L, & Cavalier & Sunfire)
- PID Values (Alero & Grand Am 3.4L, & Impala & Monte Carlo)
- PID Values (Aurora & Intrigue 3.5L)
- PID Values (Aurora 4.0L)
- PID Values (Bonneville, LeSabre & Park Avenue)
- PID Values (Camaro & Firebird 3.8L)
- PID Values (Camaro & Firebird 5.7L)
- PID Values (Catera)
- PID Values (Century & Malibu)
- PID Values (Corvette)
- PID Values (DeVille, Eldorado & Seville)
- PID Values (Grand Prix 3.1L)
- PID Values (Grand Prix & Regal 3.8L)
- PID Values (Lumina 3.1L)
- PID Values (Metro)
- PID Values (Prizm)
- PID Values (Saturn "L" Series 2.2L)
- PID Values (Saturn "L" Series 3.0L)
- PID Values (Saturn "S" Series)
- Engine Control System - PID Value Charts
- Remove, Overhaul & Install
- Engine Control System - Removal & Installation, Overhaul
- Model Identification
- Introduction
- Air Induction Systems
- Computerized Engine Controls
- Engine Sensors & Switches
- Crankshaft Variation Learn Procedure (Aurora, Century, Lumina, Regal)
- Gas Mass Sensor/Mixture Control Valve (2.2L - Cavalier - CNG)
- Oxygen Sensors
- Notes
- Removal (1.3L, 1.8L, 1.9L, 2.2L, 2.4L, 3.0L, 3.1L & 3.4L - Sensor 1)
- Removal (1.8L - Sensor 2)
- Removal (3.5L - Sensor 2)
- Removal (3.8L - Sensor 1)
- Removal (3.8L - Sensor 2)
- Removal (4.0L & 4.6L - Bank 1 Sensor 1)
- Removal (4.0L & 4.6L - Bank 1 Sensor 2)
- Removal (4.0L & 4.6L - Bank 2 Sensor 1)
- Removal (5.7L)
- Installation
- Cooling System
- Ignition Systems
- Camshaft Position Sensor
- Crankshaft Position Sensor (C I)
- Crankshaft Position Sensor (Dis & IDI)
- Crankshaft (7X) Position Sensor (Dis)
- Crankshaft (24X) Position Sensor (Dis)
- Ignition Coil (Dis)
- Ignition Coil (IDI)
- Ignition Coil (C I)
- Ignition Control Module (C I)
- Ignition Control Module (Dis)
- Ignition Control Module (IDI)
- Knock Sensors
- Removal & Installation (1.8L & 1.9L)
- Removal & Installation (2.2L)
- Removal & Installation (2.4L)
- Removal & Installation (3.0L - Knock Sensor 1)
- Removal & Installation (3.0L - Knock Sensor 2)
- Removal & Installation (3.1L & 3.4L)
- Removal & Installation (3.5L)
- Removal & Installation (3.8L - Knock Sensor 1)
- Removal & Installation (3.8L - Knock Sensor 2)
- Removal & Installation (4.0L, 4.6L & 5.7L)
- Fuel Systems
- Notes
- Fuel System Pressure Release
- CNG Fuel Module Assembly
- Fuel Filter Replacement
- Removal Procedure (Alero, Grand Am)
- Installation Procedure
- Removal Procedure (Bonneville)
- Removal Procedure (Catera)
- Removal Procedure (Century, Regal)
- Removal Procedure (Intrigue)
- Removal Procedure (Aurora, LeSabre, Park Avenue)
- Removal Procedure (DeVille)
- Removal Procedure (Eldorado)
- Removal Procedure (Grand Prix)
- Removal Procedure (Prizm)
- Removal Procedure (Seville)
- Removal Procedure (Camaro, Firebird)
- Removal Procedure (Cavalier, Sunfire)
- Removal Procedure (Corvette)
- Removal Procedure (Impala, Lumina, Monte Carlo)
- Removal Procedure (Malibu)
- Fuel Gauge Select Switch
- Fuel Pump
- Notes
- Removal (Aurora)
- Installation
- Removal (Bonneville, LeSabre & Park Avenue - 3.8L)
- Removal & Installation (Camaro & Firebird)
- Removal & Installation (Catera - 3.0L)
- Removal & Installation (Cavalier & Sunfire - 2.2L & 2.4L)
- Removal & Installation (Century, Grand Prix, Impala, Intrigue, Monte Carlo & Regal - 3.1L, 3.4L, 3.8L)
- Removal (Corvette - 5.7L)
- Removal & Installation (Deville & Seville - 4.6L)
- Removal & Installation (Eldorado)
- Removal & Installation (L100, L200, L300, LW200 & LW300 - 2.2L & 3.0L)
- Removal & Installation (Lumina) - 3.1L)
- Removal & Installation (Malibu) - 3.1L)
- Removal & Installation (Metro - 1.0L & 1.3L)
- Removal & Installation (Prizm - 1.8L)
- Removal & Installation (SC1, SC2, SL, SL1, SL2 & SW2 - 1.9L)
- Fuel Pressure Regulator (Gasoline)
- Fuel Rail & Injectors
- Fuel Tank Pressure Sensor
- Fuel Temperature Sensor
- Gas Mass Sensor/Mixture Control Valve (2.2L - Cavalier - CNG)
- High Pressure Fuel Regulator (2.2L - Cavalier - CNG)
- Idle Air Control Valve
- Lock-Off Solenoids (2.2L - Cavalier - CNG)
- Low Pressure Fuel Regulator (2.2L - Cavalier - CNG)
- Throttle Body
- Throttle Position Sensor
- Emission Systems & Sub-Systems
- Torque Specifications
- Engine Control System - Removal & Installation, Overhaul
- Engine Control System - Sensor Range Charts
- Specifications
- Engine Control System - Service & Adjustment Specifications
- Model Identification
- Introduction
- Capacities
- Quick-Service
- Mechanical Checks
- Ignition System
- High Tension Wire Resistance
- Spark Plugs Specifications
- Firing Order
- Notes
- Firing Order (1.3L, 1.8L, 1.9L, 2.2L & 2.4L)
- Firing Order & Spark Plug Wire Routing (3.1L & 3.4L)
- Firing Order (3.0L & 3.5L)
- Firing Order (3.8L - Except "F" Body)
- Firing Order (3.8L - "F" Body)
- Firing Order (4.0L& 4.6L)
- Firing Order (5.7L)
- Saturn 1.9L Spark Plug Wire Routing
- Saturn 1.9L Coil Pack Spark Plug Wire Routing
- Ignition Timing
- Fuel System
- Firing Order & Cylinder Identification
- Engine Control System - Service & Adjustment Specifications
- System
- Engine Control System - Basic Diagnostic Procedures
- Model Identification
- Introduction
- Preliminary Inspection & Adjustments
- No-Start Diagnosis
- Notes
- No Start - Engine Cranks Okay (1.9L)
- No Start - Engine Cranks Okay (2.2L - Cavalier & SUNFIRE)
- No Start - Engine Cranks Okay (2.2L - SATURN)
- No Start - Engine Cranks Okay (2.4L)
- No Start - Engine Cranks Okay (3.0L - CATERA)
- No Start - Engine Cranks Okay (3.0L - SATURN)
- No Start - Engine Cranks Okay (3.1L & 3.4L)
- No Start - Engine Cranks Okay (3.5L - Intrigue)
- No Start - Engine Cranks Okay (3.5L & 4.0L Aurora)
- No Start - Engine Cranks Okay (3.8L)
- No Start - Engine Cranks Okay (4.6L)
- No Start - Engine Cranks Okay (5.7L)
- Basic Fuel System Checks
- Basic Ignition System Checks
- Engine Controls Circuit Checks
- Idle Speed & Ignition Timing
- Summary
- Engine Control System - Self-Diagnostics - 4.6L
- Introduction
- Self-Diagnostic System
- Diagnostic System Checks
- Programming
- Inspection/Maintenance Procedures
- Drive Cycles
- Inspection/Maintenance System Check
- Inspection/Maintenance Complete System Set Procedure
- Inspection/Maintenance Air System Set Procedure
- Inspection/Maintenance Catalyst System Set Procedure
- Inspection/Maintenance Exhaust Gas RECIRCULATION System Set Procedure
- Inspection/Maintenance Evaporative Emission System Set Procedure
- Inspection/Maintenance Heated Oxygen Sensor/Oxygen Sensor System Set Procedure
- Inspection/Maintenance Heated Oxygen Sensor Heater System Set Procedure
- Summary
- Diagnostic Trouble Code Definitions
- System Tests
- Diagnostic Tests
- Notes
- DTC P0030: Heated Oxygen Sensor Heater Control Circuit - Bank 1 Sensor 1 - DEVILLE & SEVILLE
- DTC P0030: Heated Oxygen Sensor Heater Control Circuit - Bank 1 Sensor 1 - ELDORADO
- DTC P0036: Heated Oxygen Sensor Heater Control Circuit - Bank 1 Sensor 2 - DEVILLE & SEVILLE
- DTC P0036: Heated Oxygen Sensor Heater Control Circuit - Bank 1 Sensor 2 - ELDORADO
- DTC P0101: Mass Airflow Sensor System Performance
- DTC P0102: Mass Airflow Sensor Circuit Low Frequency
- DTC P0103: Mass Airflow Sensor Circuit High Frequency
- DTC P0106: Manifold Absolute Pressure System Performance
- DTC P0107: Manifold Absolute Pressure Sensor Circuit Low Voltage
- DTC P0108: Manifold Absolute Pressure Sensor Circuit High Voltage
- DTC P0112: Intake Air Temperature Sensor Circuit Low Voltage
- DTC P0113: Intake Air Temperature Sensor Circuit High Voltage
- DTC P0117: Engine Coolant Temperature Sensor Circuit Low Voltage
- DTC P0118: Engine Coolant Temperature Sensor Circuit High Voltage
- DTC P0121: Throttle Position Sensor Circuit Insufficient Activity
- DTC P0122: Throttle Position Sensor Circuit Voltage Low
- DTC P0123: Throttle Position Sensor Circuit High Voltage
- DTC P0125: Engine Coolant Temperature Excessive Time To Reach Closed Loop
- DTC P0130: Closed Loop Rationality - Bank 1 Sensor 1
- DTC P0131: Heated Oxygen Sensor Circuit Low Voltage - Bank 1 Sensor 1
- DTC P0132: Heated Oxygen Sensor Circuit High Voltage - Bank 1 Sensor 1
- DTC P0133: Heated Oxygen Sensor Slow Response - Bank 1 Sensor 1
- DTC P0134: Heated Oxygen Sensor Insufficient Activity - Bank 1 Sensor 1
- DTC P0135: Heated Oxygen Sensor Heater Circuit - Bank 1 Sensor 1
- DTC P0137: Heated Oxygen Sensor Circuit Low Voltage - Bank 1 Sensor 2
- DTC P0138: Heated Oxygen Sensor Circuit High Voltage - Bank 1 Sensor 2
- DTC P0140: Heated Oxygen Sensor Insufficient Activity - Bank 1 Sensor 2
- DTC P0141: Heated Oxygen Sensor Heater Circuit - Bank 1 Sensor 2
- DTC P0150: Closed Loop Rationality - Bank 2 Sensor 1
- DTC P0151: Heated Oxygen Sensor Circuit Low Voltage - Bank 2 Sensor 1
- DTC P0152: Heated Oxygen Sensor Circuit High Voltage - Bank 2 Sensor 1
- DTC P0153: Heated Oxygen Sensor Slow Response - Bank 2 Sensor 1
- DTC P0154: Heated Oxygen Sensor Circuit Insufficient Activity - Bank 2 Sensor 1
- DTC P0155: Heated Oxygen Sensor Heater Circuit - Bank 2 Sensor 1
- DTC P0171: Fuel Trim System Lean - Bank 1
- DTC P0172: Fuel Trim System Rich - Bank 1
- DTC P0174: Fuel Trim System Lean - Bank 2
- DTC P0175: Fuel Trim System Rich - Bank 2
- DTC P0201-P0208: Injector Control Circuit
- DTC P0230: Fuel Pump Control Circuit
- DTC P0300-P0308: Engine Misfire Detected
- DTC P0325: Knock Sensor Module Circuit
- DTC P0326: Knock Sensor Circuit Excessive Spark Retard
- DTC P0327: Knock Sensor Low Voltage
- DTC P0335: Crankshaft Position Sensor "A" Circuit
- DTC P0336: Crankshaft Position Sensor "A" Performance
- DTC P0340: Camshaft Position Sensor Circuit
- DTC P0341: Camshaft Position Sensor Performance
- DTC P0351: Ignition Coil No. 1 Control Circuit
- DTC P0352: Ignition Coil No. 2 Control Circuit
- DTC P0353: Ignition Coil No. 3 Control Circuit
- DTC P0354: Ignition Coil No. 4 Control Circuit
- DTC P0355: Ignition Coil No. 5 Control Circuit
- DTC P0356: Ignition Coil No. 6 Control Circuit
- DTC P0357: Ignition Coil No. 7 Control Circuit
- DTC P0358: Ignition Coil No. 8 Control Circuit
- DTC P0385: Crankshaft Position Sensor "B" Circuit
- DTC P0386: Crankshaft Position Sensor "B" Performance
- DTC P0401: Exhaust Gas RECIRCULATION Flow Insufficient
- DTC P0403: Exhaust Gas RECIRCULATION Solenoid Control Circuit
- DTC P0404: Exhaust Gas RECIRCULATION Open Position Performance
- DTC P0405: Exhaust Gas RECIRCULATION Position Sensor Circuit Low Voltage
- DTC P0410: Secondary Air Injection
- DTC P0412: Secondary Air Injection Solenoid Control Circuit
- DTC P0418: Secondary Air Injection Pump Relay Control Circuit
- DTC P0420: Catalyst System Low Efficiency
- DTC P0440: Evaporative Emission System
- DTC P0442: Evaporative Emission System Small Leak Detected
- DTC P0443: Evaporative Emission Purge Valve 1 Control Circuit
- DTC P0446: Evaporative Emission Vent Valve Control System
- DTC P0449: Evaporative Emission Vent Valve Control Circuit
- DTC P0452: Fuel Tank Pressure Sensor Circuit - Low Voltage
- DTC P0453: Fuel Tank Pressure Sensor Circuit - High Voltage
- DTC P0480: Cooling Fan Relay No. 1 Control Circuit
- DTC P0481: Cooling Fan Relay No. 2 Control Circuit
- DTC P0506: Idle Speed Low Or DTC P0507: Idle Speed High
- DTC P0560: System Voltage
- DTC P0562: System Voltage Low
- DTC P0563: System Voltage High
- DTC P0601: Control Module Read Only Memory
- DTC P0602: Control Module Not PROGRAMED
- DTC P0603: Control Module Long Term Memory Reset
- DTC P0604: Control Module Random Access Memory
- DTC P0606: Control Module Internal Performance
- DTC P0650: Malfunction Indicator Light Control Circuit
- DTC P1031: Ho2S Heater Current Monitor Control Circuit - Banks 1 & 2, Sensor 1 Or DTC P1032: Ho2S Heater Warm-Up Control Circuit - Banks 1 & 2, Sensor 1
- DTC P1106: Manifold Absolute Pressure Sensor Circuit Intermittent High Voltage
- DTC P1107: Manifold Absolute Pressure Sensor Circuit Intermittent Low Voltage
- DTC P1111: Intake Air Temperature Sensor Circuit Intermittent High Voltage
- DTC P1112: Intake Air Temperature Sensor Circuit Intermittent Low Voltage
- DTC P1114: Engine Coolant Temperature Sensor Circuit Intermittent Low Voltage
- DTC P1115: Engine Coolant Temperature Sensor Circuit Intermittent High Voltage
- DTC P1121: Throttle Position Sensor Circuit Intermittent High Voltage
- DTC P1122: Throttle Position Sensor Circuit Intermittent Low Voltage
- DTC P1133: Heated Oxygen Sensor Insufficient Switching - Bank 1 Sensor 1
- DTC P1134: Heated Oxygen Sensor Transition Time Ratio - Bank 1 Sensor 1
- DTC P1153: Heated Oxygen Sensor Insufficient Switching - Bank 2 Sensor 1
- DTC P1154: Heated Oxygen Sensor Transition Time Ratio - Bank 2 Sensor 1
- DTC P1258: Engine Coolant OVERTEMPERATURE - Protection Mode Active
- DTC P1336:Crankshaft Position System Variation Not Learned
- DTC P1359: Ignition Coil Group 1 Control Circuit
- DTC P1360: Ignition Coil Group 2 Control Circuit
- DTC P1372: Crankshaft Position Sensor "A" & "B" Correlation
- DTC P1380: Misfire Detected - Rough Road Data Not Available
- DTC P1381: Misfire Detected - No Communication With Brake Control Module
- DTC P1404: Exhaust Gas RECIRCULATION Closed System Performance
- DTC P1415: Secondary Air Injection System Bank 1
- DTC P1416: Secondary Air Injection System Bank 2
- DTC P1441: Evaporative Emission System Flow During Non-Purge
- DTC P1575: Extended Travel Brake Switch Circuit Voltage High
- DTC P1621: Powertrain Control Module Memory Performance
- DTC P1624: Customer Snapshot Requested - Data Available
- DTC P1635: 5-Volt Reference 1 Circuit
- DTC P1639: 5-Volt Reference 2 Circuit - DEVILLE & SEVILLE
- DTC P1639: 5-Volt Reference 2 Circuit - ELDORADO
- Engine Control System - System Testing & Engine Component Tests
- Model Identification
- Introduction
- Air Induction Systems
- Computerized Engine Controls
- Engine Sensors & Switches
- Motors, Relays & Solenoids
- Fuel Systems (Gasoline)
- Fuel Systems (2.2L - Cavalier CNG)
- Idle Control Systems
- Ignition Systems
- Emission Systems & Subsystems
- Miscellaneous Controls
- Component Locations
- Notes
- Component Locations (2.2L VIN 4 & 2.4L VIN T - Cavalier & SUNFIRE - Gasoline)
- Component Locations (2.2L VIN 4 & 2.4L VIN T - Cavalier & SUNFIRE - CNG)
- Component Locations (2.4L VIN T - ALERO & Grand Am)
- Component Locations (3.0L VIN R - CATERA)
- Component Locations (3.1L VIN J - Century)
- Component Locations (3.1L VIN J - MALIBU)
- Component Locations (3.1L VIN J - Lumina)
- Component Locations (3.1L VIN J - Grand PRIX)
- Component Locations (3.4L VIN E - ALERO & Grand Am)
- Component Locations (3.4L VIN E - Impala & Monte CARLO)
- Component Locations (3.5L VIN H - Aurora)
- Component Locations (3.5L VIN H - Intrigue)
- Component Locations (3.8L VIN K & 1 - BONNEVILLE, LESABRE & Park Avenue)
- Component Locations (3.8L VIN K - CAMARO & Firebird)
- Component Locations (3.8L VIN K & 1 - Grand PRIX)
- Component Locations (3.8L VIN K - Impala & Monte CARLO)
- Component Locations (3.8L VIN K & 1 - Regal)
- Component Locations (4.0L VIN C - Aurora)
- Component Locations (4.6L VIN Y & 9 - DEVILLE, ELDORADO & SEVILLE)
- Component Locations (5.7L VIN G - CAMARO & Firebird)
- Component Locations (5.7L VIN G - Corvette)
- Engine Component Locations (1.9L VIN 7 & 8 - SATURN)
- Engine Component Locations (2.2L VIN F - SATURN)
- Engine Component Locations (3.0L VIN R - SATURN)
- Transmission Component Locations (1.9L VIN 7 & 8 - SATURN A/T)
- Transmission Component Locations (1.9L VIN 7 & 8 - SATURN M/T)
- Engine Control System Troubleshooting - No Codes
- Introduction
- Preliminary Inspection
- Symptoms
- Notes
- Symptom Diagnosis
- Cuts Out, Misses
- Detonation/Spark Knock
- Engine Backfires
- Engine Dieseling/Run-On
- Excessive Exhaust Emissions Or Odors
- Hard Start
- Hesitation, Sag Or Stumble
- Lack Of Power, Sluggish Or Spongy
- Poor Fuel Economy
- Poor Fuel Fill Quality
- Rough, Unstable Or Incorrect Idle, Stalling
- Vehicle Surges Or CHUGGLES
- INTERMITTENTS
- Testing Wiring Systems For Intermittent & Poor Connections
- Service Precautions
- Intermittent Or Poor Connections
- Inducing Intermittent Fault Conditions
- Testing for Electrical Intermittents
- Testing for Short to Ground
- Testing for Continuity
- Testing for a Short to Voltage
- Troubleshooting with a Digital Multimeter
- Troubleshooting with a Test Lamp
- Probing Electrical Connectors
- Engine Control System - Basic Diagnostic Procedures
- Testing & Diagnosis
- Engine Control System - Basic Diagnostic Procedures
- Model Identification
- Introduction
- Preliminary Inspection & Adjustments
- No-Start Diagnosis
- Notes
- No Start - Engine Cranks Okay (1.9L)
- No Start - Engine Cranks Okay (2.2L - Cavalier & SUNFIRE)
- No Start - Engine Cranks Okay (2.2L - SATURN)
- No Start - Engine Cranks Okay (2.4L)
- No Start - Engine Cranks Okay (3.0L - CATERA)
- No Start - Engine Cranks Okay (3.0L - SATURN)
- No Start - Engine Cranks Okay (3.1L & 3.4L)
- No Start - Engine Cranks Okay (3.5L - Intrigue)
- No Start - Engine Cranks Okay (3.5L & 4.0L Aurora)
- No Start - Engine Cranks Okay (3.8L)
- No Start - Engine Cranks Okay (4.6L)
- No Start - Engine Cranks Okay (5.7L)
- Basic Fuel System Checks
- Basic Ignition System Checks
- Engine Controls Circuit Checks
- Idle Speed & Ignition Timing
- Summary
- Engine Control System - Self-Diagnostics - 4.6L
- Introduction
- Self-Diagnostic System
- Diagnostic System Checks
- Programming
- Inspection/Maintenance Procedures
- Drive Cycles
- Inspection/Maintenance System Check
- Inspection/Maintenance Complete System Set Procedure
- Inspection/Maintenance Air System Set Procedure
- Inspection/Maintenance Catalyst System Set Procedure
- Inspection/Maintenance Exhaust Gas RECIRCULATION System Set Procedure
- Inspection/Maintenance Evaporative Emission System Set Procedure
- Inspection/Maintenance Heated Oxygen Sensor/Oxygen Sensor System Set Procedure
- Inspection/Maintenance Heated Oxygen Sensor Heater System Set Procedure
- Summary
- Diagnostic Trouble Code Definitions
- System Tests
- Diagnostic Tests
- Notes
- DTC P0030: Heated Oxygen Sensor Heater Control Circuit - Bank 1 Sensor 1 - DEVILLE & SEVILLE
- DTC P0030: Heated Oxygen Sensor Heater Control Circuit - Bank 1 Sensor 1 - ELDORADO
- DTC P0036: Heated Oxygen Sensor Heater Control Circuit - Bank 1 Sensor 2 - DEVILLE & SEVILLE
- DTC P0036: Heated Oxygen Sensor Heater Control Circuit - Bank 1 Sensor 2 - ELDORADO
- DTC P0101: Mass Airflow Sensor System Performance
- DTC P0102: Mass Airflow Sensor Circuit Low Frequency
- DTC P0103: Mass Airflow Sensor Circuit High Frequency
- DTC P0106: Manifold Absolute Pressure System Performance
- DTC P0107: Manifold Absolute Pressure Sensor Circuit Low Voltage
- DTC P0108: Manifold Absolute Pressure Sensor Circuit High Voltage
- DTC P0112: Intake Air Temperature Sensor Circuit Low Voltage
- DTC P0113: Intake Air Temperature Sensor Circuit High Voltage
- DTC P0117: Engine Coolant Temperature Sensor Circuit Low Voltage
- DTC P0118: Engine Coolant Temperature Sensor Circuit High Voltage
- DTC P0121: Throttle Position Sensor Circuit Insufficient Activity
- DTC P0122: Throttle Position Sensor Circuit Voltage Low
- DTC P0123: Throttle Position Sensor Circuit High Voltage
- DTC P0125: Engine Coolant Temperature Excessive Time To Reach Closed Loop
- DTC P0130: Closed Loop Rationality - Bank 1 Sensor 1
- DTC P0131: Heated Oxygen Sensor Circuit Low Voltage - Bank 1 Sensor 1
- DTC P0132: Heated Oxygen Sensor Circuit High Voltage - Bank 1 Sensor 1
- DTC P0133: Heated Oxygen Sensor Slow Response - Bank 1 Sensor 1
- DTC P0134: Heated Oxygen Sensor Insufficient Activity - Bank 1 Sensor 1
- DTC P0135: Heated Oxygen Sensor Heater Circuit - Bank 1 Sensor 1
- DTC P0137: Heated Oxygen Sensor Circuit Low Voltage - Bank 1 Sensor 2
- DTC P0138: Heated Oxygen Sensor Circuit High Voltage - Bank 1 Sensor 2
- DTC P0140: Heated Oxygen Sensor Insufficient Activity - Bank 1 Sensor 2
- DTC P0141: Heated Oxygen Sensor Heater Circuit - Bank 1 Sensor 2
- DTC P0150: Closed Loop Rationality - Bank 2 Sensor 1
- DTC P0151: Heated Oxygen Sensor Circuit Low Voltage - Bank 2 Sensor 1
- DTC P0152: Heated Oxygen Sensor Circuit High Voltage - Bank 2 Sensor 1
- DTC P0153: Heated Oxygen Sensor Slow Response - Bank 2 Sensor 1
- DTC P0154: Heated Oxygen Sensor Circuit Insufficient Activity - Bank 2 Sensor 1
- DTC P0155: Heated Oxygen Sensor Heater Circuit - Bank 2 Sensor 1
- DTC P0171: Fuel Trim System Lean - Bank 1
- DTC P0172: Fuel Trim System Rich - Bank 1
- DTC P0174: Fuel Trim System Lean - Bank 2
- DTC P0175: Fuel Trim System Rich - Bank 2
- DTC P0201-P0208: Injector Control Circuit
- DTC P0230: Fuel Pump Control Circuit
- DTC P0300-P0308: Engine Misfire Detected
- DTC P0325: Knock Sensor Module Circuit
- DTC P0326: Knock Sensor Circuit Excessive Spark Retard
- DTC P0327: Knock Sensor Low Voltage
- DTC P0335: Crankshaft Position Sensor "A" Circuit
- DTC P0336: Crankshaft Position Sensor "A" Performance
- DTC P0340: Camshaft Position Sensor Circuit
- DTC P0341: Camshaft Position Sensor Performance
- DTC P0351: Ignition Coil No. 1 Control Circuit
- DTC P0352: Ignition Coil No. 2 Control Circuit
- DTC P0353: Ignition Coil No. 3 Control Circuit
- DTC P0354: Ignition Coil No. 4 Control Circuit
- DTC P0355: Ignition Coil No. 5 Control Circuit
- DTC P0356: Ignition Coil No. 6 Control Circuit
- DTC P0357: Ignition Coil No. 7 Control Circuit
- DTC P0358: Ignition Coil No. 8 Control Circuit
- DTC P0385: Crankshaft Position Sensor "B" Circuit
- DTC P0386: Crankshaft Position Sensor "B" Performance
- DTC P0401: Exhaust Gas RECIRCULATION Flow Insufficient
- DTC P0403: Exhaust Gas RECIRCULATION Solenoid Control Circuit
- DTC P0404: Exhaust Gas RECIRCULATION Open Position Performance
- DTC P0405: Exhaust Gas RECIRCULATION Position Sensor Circuit Low Voltage
- DTC P0410: Secondary Air Injection
- DTC P0412: Secondary Air Injection Solenoid Control Circuit
- DTC P0418: Secondary Air Injection Pump Relay Control Circuit
- DTC P0420: Catalyst System Low Efficiency
- DTC P0440: Evaporative Emission System
- DTC P0442: Evaporative Emission System Small Leak Detected
- DTC P0443: Evaporative Emission Purge Valve 1 Control Circuit
- DTC P0446: Evaporative Emission Vent Valve Control System
- DTC P0449: Evaporative Emission Vent Valve Control Circuit
- DTC P0452: Fuel Tank Pressure Sensor Circuit - Low Voltage
- DTC P0453: Fuel Tank Pressure Sensor Circuit - High Voltage
- DTC P0480: Cooling Fan Relay No. 1 Control Circuit
- DTC P0481: Cooling Fan Relay No. 2 Control Circuit
- DTC P0506: Idle Speed Low Or DTC P0507: Idle Speed High
- DTC P0560: System Voltage
- DTC P0562: System Voltage Low
- DTC P0563: System Voltage High
- DTC P0601: Control Module Read Only Memory
- DTC P0602: Control Module Not PROGRAMED
- DTC P0603: Control Module Long Term Memory Reset
- DTC P0604: Control Module Random Access Memory
- DTC P0606: Control Module Internal Performance
- DTC P0650: Malfunction Indicator Light Control Circuit
- DTC P1031: Ho2S Heater Current Monitor Control Circuit - Banks 1 & 2, Sensor 1 Or DTC P1032: Ho2S Heater Warm-Up Control Circuit - Banks 1 & 2, Sensor 1
- DTC P1106: Manifold Absolute Pressure Sensor Circuit Intermittent High Voltage
- DTC P1107: Manifold Absolute Pressure Sensor Circuit Intermittent Low Voltage
- DTC P1111: Intake Air Temperature Sensor Circuit Intermittent High Voltage
- DTC P1112: Intake Air Temperature Sensor Circuit Intermittent Low Voltage
- DTC P1114: Engine Coolant Temperature Sensor Circuit Intermittent Low Voltage
- DTC P1115: Engine Coolant Temperature Sensor Circuit Intermittent High Voltage
- DTC P1121: Throttle Position Sensor Circuit Intermittent High Voltage
- DTC P1122: Throttle Position Sensor Circuit Intermittent Low Voltage
- DTC P1133: Heated Oxygen Sensor Insufficient Switching - Bank 1 Sensor 1
- DTC P1134: Heated Oxygen Sensor Transition Time Ratio - Bank 1 Sensor 1
- DTC P1153: Heated Oxygen Sensor Insufficient Switching - Bank 2 Sensor 1
- DTC P1154: Heated Oxygen Sensor Transition Time Ratio - Bank 2 Sensor 1
- DTC P1258: Engine Coolant OVERTEMPERATURE - Protection Mode Active
- DTC P1336:Crankshaft Position System Variation Not Learned
- DTC P1359: Ignition Coil Group 1 Control Circuit
- DTC P1360: Ignition Coil Group 2 Control Circuit
- DTC P1372: Crankshaft Position Sensor "A" & "B" Correlation
- DTC P1380: Misfire Detected - Rough Road Data Not Available
- DTC P1381: Misfire Detected - No Communication With Brake Control Module
- DTC P1404: Exhaust Gas RECIRCULATION Closed System Performance
- DTC P1415: Secondary Air Injection System Bank 1
- DTC P1416: Secondary Air Injection System Bank 2
- DTC P1441: Evaporative Emission System Flow During Non-Purge
- DTC P1575: Extended Travel Brake Switch Circuit Voltage High
- DTC P1621: Powertrain Control Module Memory Performance
- DTC P1624: Customer Snapshot Requested - Data Available
- DTC P1635: 5-Volt Reference 1 Circuit
- DTC P1639: 5-Volt Reference 2 Circuit - DEVILLE & SEVILLE
- DTC P1639: 5-Volt Reference 2 Circuit - ELDORADO
- Engine Control System - System Testing & Engine Component Tests
- Model Identification
- Introduction
- Air Induction Systems
- Computerized Engine Controls
- Engine Sensors & Switches
- Motors, Relays & Solenoids
- Fuel Systems (Gasoline)
- Fuel Systems (2.2L - Cavalier CNG)
- Idle Control Systems
- Ignition Systems
- Emission Systems & Subsystems
- Miscellaneous Controls
- Component Locations
- Notes
- Component Locations (2.2L VIN 4 & 2.4L VIN T - Cavalier & SUNFIRE - Gasoline)
- Component Locations (2.2L VIN 4 & 2.4L VIN T - Cavalier & SUNFIRE - CNG)
- Component Locations (2.4L VIN T - ALERO & Grand Am)
- Component Locations (3.0L VIN R - CATERA)
- Component Locations (3.1L VIN J - Century)
- Component Locations (3.1L VIN J - MALIBU)
- Component Locations (3.1L VIN J - Lumina)
- Component Locations (3.1L VIN J - Grand PRIX)
- Component Locations (3.4L VIN E - ALERO & Grand Am)
- Component Locations (3.4L VIN E - Impala & Monte CARLO)
- Component Locations (3.5L VIN H - Aurora)
- Component Locations (3.5L VIN H - Intrigue)
- Component Locations (3.8L VIN K & 1 - BONNEVILLE, LESABRE & Park Avenue)
- Component Locations (3.8L VIN K - CAMARO & Firebird)
- Component Locations (3.8L VIN K & 1 - Grand PRIX)
- Component Locations (3.8L VIN K - Impala & Monte CARLO)
- Component Locations (3.8L VIN K & 1 - Regal)
- Component Locations (4.0L VIN C - Aurora)
- Component Locations (4.6L VIN Y & 9 - DEVILLE, ELDORADO & SEVILLE)
- Component Locations (5.7L VIN G - CAMARO & Firebird)
- Component Locations (5.7L VIN G - Corvette)
- Engine Component Locations (1.9L VIN 7 & 8 - SATURN)
- Engine Component Locations (2.2L VIN F - SATURN)
- Engine Component Locations (3.0L VIN R - SATURN)
- Transmission Component Locations (1.9L VIN 7 & 8 - SATURN A/T)
- Transmission Component Locations (1.9L VIN 7 & 8 - SATURN M/T)
- Engine Control System Troubleshooting - No Codes
- Introduction
- Preliminary Inspection
- Symptoms
- Notes
- Symptom Diagnosis
- Cuts Out, Misses
- Detonation/Spark Knock
- Engine Backfires
- Engine Dieseling/Run-On
- Excessive Exhaust Emissions Or Odors
- Hard Start
- Hesitation, Sag Or Stumble
- Lack Of Power, Sluggish Or Spongy
- Poor Fuel Economy
- Poor Fuel Fill Quality
- Rough, Unstable Or Incorrect Idle, Stalling
- Vehicle Surges Or CHUGGLES
- INTERMITTENTS
- Testing Wiring Systems For Intermittent & Poor Connections
- Service Precautions
- Intermittent Or Poor Connections
- Inducing Intermittent Fault Conditions
- Testing for Electrical Intermittents
- Testing for Short to Ground
- Testing for Continuity
- Testing for a Short to Voltage
- Troubleshooting with a Digital Multimeter
- Troubleshooting with a Test Lamp
- Probing Electrical Connectors
- Engine Control System - Basic Diagnostic Procedures
- Theory and Operation
- Engine Control System - Theory & Operation
- Introduction
- Air Induction System
- Computerized Engine Controls
- Notes
- Powertrain Control Module
- Input Devices
- Notes
- A/C Request Signal
- A/C Pressure Sensor
- A/C Pressure Switches
- A/C Temperature Sensors
- Accelerator Pedal Position Sensor
- Battery Voltage
- Brake Switch Feedback
- Camshaft Position Sensor (2.2L & 2.4L)
- Camshaft Position Sensor (3.1L & 3.4L)
- Camshaft Position Sensor (3.5L & 4.0L)
- Camshaft Position Sensor (3.8L)
- Camshaft Position Sensor (4.6L)
- Camshaft Position Sensor (5.7L)
- Crankshaft (7X) Sensor (2.2L & 2.4L)
- Crankshaft (3X/7X) Sensor (3.1L)
- Crankshaft (24X) Sensor (3.1L & 3.4L)
- Crankshaft (3X/18X) Sensor (3.8L)
- Crankshaft (4X/24X) Sensor (5.7L)
- Crankshaft Position Sensor
- Engine Coolant Temperature Sensor
- Engine Coolant Level Switch
- Engine Oil Level Switch
- Engine Oil Pressure Sensor/Switch
- Fuel Level Sensor
- Fuel Tank Vapor Pressure Sensor
- Gear Switches
- Generator "L" Light Circuit
- Generator "F" Field Circuit
- Ignition/Crank Signal
- Intake Air Temperature Sensor
- Knock Sensor
- Manifold Absolute Pressure Sensor
- Mass Airflow Sensor
- Oxygen Sensor
- Park/Neutral Position Switch
- RPM Reference Signal
- Throttle Position Sensor
- Transmission Fluid Temperature Sensor
- Transmission Range Switch
- Vehicle Speed Sensor
- Output Signals
- Notes
- A/C Compressor Clutch
- Air Injection System
- Boost Control Solenoid (Supercharger)
- Canister Purge Control Solenoid
- Coil-Near-Plug Ignition
- Computer Controlled Coil Ignition (C I)
- Cooling Fan Relay
- Digital EGR Valve
- Direct Ignition System
- EGR Control Solenoid
- Electronic Variable Orifice Actuator
- Fuel Injectors
- Fuel Pump & Fuel Pump Relay
- HOT Light Or Coolant Temperature (TEMP) Light
- Idle Air Control Valve
- Integrated Direct Ignition
- Linear EGR Valve
- Knock Sensor Operation
- Malfunction Indicator Light
- Self-Diagnostics
- Serial Data
- Shift Light
- Shift Solenoids (Electronically-Controlled Transmission)
- Throttle Actuator
- Torque Converter Clutch
- Fuel System
- Ignition System
- Emission Systems
- Self-Diagnostic System
- Throttle Actuator Control System
- Miscellaneous Controls
- Engine Control System - Theory & Operation
- Engine Vacuum Diagrams
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- Computer Relearn Procedures
- Introduction
- CHRYSLER Corp.
- A/C Calibration Test (Caravan, Town & Country, & Voyager)
- A/C-Heater System (SEBRING Convertible, SEBRING Sedan & Stratus Sedan)
- Body Control Module (Caravan, Town & Country, & Voyager)
- Body Control Module (SEBRING Convertible, SEBRING Sedan & Stratus Sedan)
- Body Control Module (300M, CONCORDE, DAKOTA, DURANGO, Intrepid, LHS, Ram Pickup, Ram Van & Ram Wagon)
- Engine Control Module Programming (Diesel)
- Instrument Cluster (Ram Van & Ram Wagon)
- Pcm Programming & Clearing DTCS From Abs & SRS Modules (Except SEBRING & Stratus)
- Pcm Programming (SEBRING Convertible, SEBRING Sedan & Stratus Sedan)
- Pinion Factor Procedure (All Fwd Cars Except Neon, SEBRING Convertible, SEBRING Sedan & Stratus Sedan, & All Fwd Vans)
- Power Liftgate & Power Sliding Door Learn Cycle (Caravan & Town & Country)
- Sentry Key Immobilizer System Initialization Procedure (Except SEBRING Coupe, Stratus Coupe, SEBRING Convertible, SEBRING Sedan & Stratus Sedan)
- Skim Module (SEBRING Convertible, SEBRING Sedan & Stratus Sedan)
- Transaxle/Transmission Shift Quality Quick Learn Procedure (Cars Except SEBRING Coupe & Stratus Coupe, All Fwd Vans & DAKOTA 4.7L, DURANGO 4.7L & Grand CHEROKEE 4.7L)
- Transmission Control Module (SEBRING Convertible, SEBRING Sedan & Stratus Sedan)
- Vehicle DRIVEABILITY Computer Relearn Procedure
- Ford Motor Co.
- General Motors (Cars)
- Notes
- ALERO, Grand Am & MALIBU
- Notes
- Crankshaft Position (CKP) Sensor Variation Learn Procedure (2.4L)
- Crankshaft Position (CKP) Sensor Variation Learn Procedure (3.1L & 3.4L)
- Electronically Erasable Programmable Read Only Memory (EEPROM) Programming (2.4L)
- Electronically Erasable Programmable Read Only Memory (EEPROM) Programming (3.1L & 3.4L)
- Password Learn Procedure For Anti-Theft System
- Vehicle Driveability Computer Relearn Procedure (A/T Models)
- Vehicle Driveability Computer Relearn Procedure (M/T Models)
- Aurora
- BONNEVILLE & LE Sabre
- Notes
- Crankshaft Position (CKP) Sensor Variation Learn Procedure
- Dash Integration Module (DIM) Programming
- Electronically Erasable Programmable Read Only Memory (EEPROM) Programming
- PASS-Key® III System Auto Learn Procedure
- PASS-Key® III System Quick Learn Procedure
- Rear Integration Module (RIM) Programming
- Vehicle Driveability Computer Relearn Procedure
- CAMARO & Firebird
- Notes
- Crankshaft Position (CKP) Sensor Variation Learn Procedure (3.8L)
- Crankshaft Position (CKP) Sensor Variation Learn Procedure (5.7L)
- Electronically Erasable Programmable Read Only Memory (EEPROM) Programming
- Idle Learn Procedure (5.7L)
- Programming New Body Control Module (BCM)
- Vehicle Driveability Computer Relearn Procedure (All Models)
- CATERA
- Cavalier & SUNFIRE
- Century, Grand PRIX, Impala, Intrigue, Lumina, Monte CARLO & Regal
- Notes
- Crankshaft Position (CKP) Sensor Variation Learn Procedure (3.1L & 3.4L)
- Crankshaft Position (CKP) Sensor Variation Learn Procedure (3.5L & 3.8L)
- Electronically Erasable Programmable Read Only Memory (EEPROM) Programming
- PASS-Key® III Module Programming (Grand Prix)
- PASS-Key® III System Auto Learn Procedure (Grand Prix)
- PASS-Key® III System Quick Learn Procedure (Grand Prix)
- Passlock™ Theft Deterrent Relearn (Intrigue)
- PASSLOCK™ 30 Minute Relearn Procedure (Impala & Monte Carlo)
- Programming New Theft Deterrent Module (Lumina)
- Vehicle Driveability Computer Relearn Procedure
- Corvette
- DEVILLE, ELDORADO & SEVILLE
- Notes
- Crankshaft Position (CKP) Sensor Variation Learn Procedure
- Electronically Erasable Programmable Read Only Memory (EEPROM) Programming
- Engine Oil Life Interval Programming
- Idle Air Control valve relearn procedure
- Throttle Position Sensor Relearn Procedure
- Transaxle Fluid Life Interval Programming
- Vehicle Driveability Computer Relearn Procedure
- Vehicle Theft Deterrent System Auto Learn Procedure
- Metro
- Park Avenue
- PRIZM
- SATURN
- Notes
- Electronically Erasable Programmable Read Only Memory (EEPROM) Programming
- Crankshaft Learn Procedure (1.9L)
- Crankshaft Learn Procedure (2.2L)
- Throttle Position Sensor Relearn (3.0L)
- Vehicle Driveability Computer Relearn Procedure
- Passlock™ Anti-Theft Learn Procedure
- Passlock™ Anti-Theft Seed & Key Method
- Passlock™ Anti-Theft Auto Learn Method
- General Motors (Trucks & Vans)
- Notes
- Astro & Safari
- Blazer, BRAVADA, Envoy, Jimmy, Pickup & SONOMA
- Notes
- BCM Programming
- Crankshaft Position (CKP) Sensor Variation Learn Procedure (2.2L & 4.3L)
- Electronically Erasable Programmable Read Only Memory (EEPROM) Programming (2.2L)
- Electronically Erasable Programmable Read Only Memory (EEPROM) Programming (4.3L)
- Passlock® Anti-Theft Learn Procedure
- Vehicle Driveability Computer Relearn Procedure (2.2L)
- Vehicle Driveability Computer Relearn Procedure (4.3L)
- Cutaway, Express, RV Cutaway & SAVANA
- Notes
- Electronically Erasable Programmable Read Only Memory (EEPROM) Programming (4.3L, 4.8L, 5.0L, 5.3L, 5.7L & 6.0L)
- Electronically Erasable Programmable Read Only Memory (EEPROM) Programming (7.4L)
- Powertrain Control Module (PCM) Programming (6.5L Diesel)
- TDC Offset Learn Procedure (6.5L Diesel)
- Crankshaft Position (CKP) Sensor Variation Learn Procedure (4.3L, 5.0L, 5.7L & 7.4L Except Calif.)
- Password Learn Procedure For Anti-Theft System (4.3L, 5.0L & 5.7L)
- Password Learn Procedure For Anti-Theft System (6.5L Diesel)
- Password Learn Procedure For Anti-Theft System (7.4L)
- Vehicle Driveability Computer Relearn Procedure (4.3L, 5.0L, 5.7L & 7.4L)
- Vehicle Driveability Computer Relearn Procedure (6.5L Diesel)
- Escalade, Pickup, Sierra, SILVERADO, TAHOE, YUKON & YUKON XL
- Notes
- Crankshaft Position (CKP) Sensor Variation Learn Procedure (4.3L, 4.8L, 5.0L, 5.3L, 5.7L, 6.0L & 7.4L)
- Electronically Erasable Programmable Read Only Memory (EEPROM) Programming (4.3L, 5.0L & 5.7L)
- Electronically Erasable Programmable Read Only Memory (EEPROM) Programming (7.4L)
- Powertrain Control Module (PCM) Programming (4.8L, 5.3L & 6.0L)
- Powertrain Control Module (PCM) Programming (6.5L Diesel)
- Password Learn Procedure For Anti-Theft System (4.3L, 4.8L, 5.3L & 6.0L)
- Password Learn Procedure For Anti-Theft System (5.0L, 5.7L & 7.4L)
- Password Learn Procedure For Anti-Theft System (6.5L Diesel)
- TDC Offset Learn Procedure (6.5L Diesel)
- Vehicle Driveability Computer Relearn Procedure (4.8L, 5.3L & 6.0L)
- Vehicle Driveability Computer Relearn Procedure (4.3L, 5.0L, 5.7L & 7.4L)
- Vehicle Driveability Computer Relearn Procedure (6.5L Diesel)
- MONTANA, Silhouette & Venture
- Tracker
- Jeep
- OBD-II Drive Cycles - 2001-03
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- DTC Index
- Air Bag DTCS
- Anti-Lock Brake DTCS
- Anti-Theft DTCS
- Automatic Transmission (4T80-E) DTCS
- Body Control Module DTCS
- Charging DTCS
- Cruise Control DTCS
- Engine Performance - 4.6L DTCS
- Headlight - Automatic Twilight Sentinel DTCS
- HVAC DTCS
- Instrument Panel DTCS
- Power Door Lock & Remote Keyless Entry DTCS
- Power Mirror DTCS
- Power Seat DTCS
- Power Window DTCS
- Starter DTCS
- Steering Column/Switch DTCS
- Steering, Electronic (MAGNASTEER) DTCS
- Suspension, Electronic Automatic Level Control (With CVRS) DTCS
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Testing Wiring Systems For Intermittent & Poor Connections
- Service Precautions
- Intermittent Or Poor Connections
- Inducing Intermittent Fault Conditions
- Testing for Electrical Intermittents
- Testing for Short to Ground
- Testing for Continuity
- Testing for a Short to Voltage
- Troubleshooting with a Digital Multimeter
- Troubleshooting with a Test Lamp
- Probing Electrical Connectors
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Identification
- Metric Conversions
- OEM General Information
- Gm Vehicles Cautions & Notices
- Cautions & Notices
- Definition Of Caution, Notice, & Important
- Abs Component Handling Caution
- Actions To Take When Working With Fuel Caution
- Approved Equipment For Collision Repair Caution
- Assistant Driving Caution
- Batteries Produce Explosive Gases Caution
- Battery Disconnect Caution
- Brake Dust Caution
- Brake Fluid Irritant Caution
- Brake Pipe Replacement Caution
- Breathing R-134A Caution
- Cleaning Solvent Caution
- Clutch Dust Caution
- Defroster Outlet Caution
- Door Outer Panel Replacement Caution
- Electric Coolant Fan Caution
- Express Window Down Caution
- Eye Protection Caution
- Foam Sound DEADENERS Caution
- Floor Jack Caution
- Fuel & EVAP Pipe Caution
- Fuel Gage Leak Caution
- Fuel Pipe Fitting Caution
- Fuel Rail Stop Bracket Installation Caution
- Fuel Storage Caution
- Fuel Vapors In Evaporative Emission (EVAP) Components Caution
- Gasoline/Gasoline Vapors Caution
- Glass & Sheet Metal Handling Caution
- Halogen Bulb Caution
- Hood Hold-Open Device Caution
- Hot Exhaust System Caution
- Lower O-Ring Removal Caution
- Moving Parts & Hot Surfaces Caution
- Protective Goggles & Glove Caution
- Radiator Cap Removal Caution
- Relieving Fuel Pressure Caution
- Replacement Carpet Caution
- Road Test Caution
- Safety Glasses Caution
- Safety Glasses & Compressed Air Caution
- Safety Goggles & Fuel Caution
- Servicing The Sir System Caution
- Sir Caution
- Sir Deployed Inflator Modules Are Hot Caution
- Sir Handling Caution
- Sir Inflator Module Coil Caution
- Sir Inflatable Module Deployment Outside Vehicle Caution
- Sir Inflator Module Disposal Caution
- Sir Inflator Module Handling & Storage Caution
- Sir Special Tool Caution
- Tilt Spring Caution
- Valve Springs Can Be Tightly Compressed Caution
- Vehicle Lifting Caution
- Window Retention Caution
- Work Stall Test Caution
- Air In The Power Steering System Notice
- Anti-Corrosion Materials Notice
- Automatic Transmission Shift Lock Control Notice
- Belt Dressing Notice
- Brake Caliper Notice
- Brake Caliper Supporting To Prevent Hose Damage Notice
- Brake Fluid Effects On Paint & Electrical Components Notice
- Clean, Dry, Low Pressure Gas Source Notice
- CLEARCOAT/Ultraviolet Screeners Notice
- Component Fastener Tightening Notice
- Differential Housing Cover & Gasket Removal Notice
- Do Not Depress Brake Pedal With Rotors/Drums Removed Notice
- Electrical Wiring Routing Notice
- Emission Modification Notice
- Engine Emission Notice
- Engine Lifting Notice
- Engine Mounting Notice
- Excessive Force & Oxygen Sensor Notice
- Exhaust System Inspection Notice
- Exterior Trim Emblem Removal Notice
- Fastener Notice
- Flex DECOUPLER Notice
- Fuel & Evaporative Emission (EVAP) Hose/Pipe Connection Cleaning Notice
- Fuel Injector Balance Test Notice
- Fuel Pressure Notice
- Fuel System Ground Notice
- Fuel Tank Strap Fastener Notice
- Handling Bearing Inserts Notice
- Handling ESD Sensitive Parts Notice
- Handling IAC Valve Notice
- Heated Oxygen & Oxygen Sensor Notice
- Ignition Off When Disconnecting Battery Notice
- Installing Hoses Without Twists Or Bends Notice
- Instrument Panel Cluster (IPC) Servicing Notice
- Latched DTC B1018, B1024 Notice (SDM-RSD)
- Liftgate Assist Rod Notice
- Machined Surface Damage Notice
- Nylon Fuel Lines Notice
- OBDII System Description Notice
- OBDII Symbol Description Notice
- Oxygen Sensor Notice
- Pcm & ESD Notice
- Pinion Flange/Yoke Installation Notice
- Pipe Wrench Positioning Notice
- Power Steering Hose Disconnected Notice
- Properly Secured Evaporative Emission (EVAP) Pipe Notice
- Ring Gear Removal Notice
- Sealant Notice
- Service Programming System (SPS) Notice
- Servicing And Replacing Seat Belts Notice
- Servicing The Level Sensor Notice
- Silicon Contamination Of Heated Oxygen Sensors Notice
- Single Cylinder Flooding Notice
- Spark Plug Boot Removal Notice
- Special Fastener Notice
- Stabilizer Shaft Link Damage Notice
- Steering Gear Preload Adjustment Notice
- Steering Wheel In The Full Turn Position Notice
- Suspension Spring Handling Notice
- Test Lamp To Ignition Control Module Circuit Connector Notice
- Test Probe Notice
- Transfer Case Seal Removal Notice
- Valve Lifter Priming Notice
- Cautions & Notices
- Testing Wiring Systems For Intermittent & Poor Connections
- Service Precautions
- Intermittent Or Poor Connections
- Inducing Intermittent Fault Conditions
- Testing for Electrical Intermittents
- Testing for Short to Ground
- Testing for Continuity
- Testing for a Short to Voltage
- Troubleshooting with a Digital Multimeter
- Troubleshooting with a Test Lamp
- Probing Electrical Connectors
- Gm Vehicles Cautions & Notices
- Reset Procedures
- ATEQ TPMS Reset Procedure
- BARTEC TPMS Reset Procedure
- Maintenance Reminder Light (Reset Procedures)
- Engine Oil Replacement Reminder
- Notes
- Engine Oil Replacement Reminder Reset - Procedure 01
- Engine Oil Replacement Reminder Reset - Procedure 02
- Engine Oil Replacement Reminder Reset - Procedure 03
- Engine Oil Replacement Reminder Reset - Procedure 04
- Engine Oil Replacement Reminder Reset - Procedure 05
- Engine Oil Replacement Reminder Reset - Procedure 06
- Engine Oil Replacement Reminder Reset - Procedure 07
- Engine Oil Replacement Reminder Reset - Procedure 08
- Engine Oil Replacement Reminder Reset - Procedure 09
- Engine Oil Replacement Reminder Reset - Procedure 10
- Engine Oil Replacement Reminder Reset - Procedure 11
- Engine Oil Replacement Reminder Reset - Procedure 12
- Engine Oil Replacement Reminder Reset - Procedure 13
- Engine Oil Replacement Reminder Reset - Procedure 14
- Engine Oil Replacement Reminder Reset - Procedure 15
- Engine Oil Replacement Reminder Reset - Procedure 16
- Engine Oil Replacement Reminder Reset - Procedure 17
- Engine Oil Replacement Reminder Reset - Procedure 18
- Engine Oil Replacement Reminder Reset - Procedure 19
- Engine Oil Replacement Reminder Reset - Procedure 20
- Engine Oil Replacement Reminder Reset - Procedure 21
- Engine Oil Replacement Reminder Reset - Procedure 22
- Engine Oil Replacement Reminder Reset - Procedure 23
- Engine Oil Replacement Reminder Reset - Procedure 24
- Engine Oil Replacement Reminder Reset - Procedure 25
- Engine Oil Replacement Reminder Reset - Procedure 26
- Engine Oil Replacement Reminder Reset - Procedure 27
- Engine Oil Replacement Reminder Reset - Procedure 28
- Engine Oil Replacement Reminder Reset - Procedure 29
- Engine Oil Replacement Reminder Reset - Procedure 30
- Engine Oil Replacement Reminder Reset - Procedure 31
- Engine Oil Replacement Reminder Reset - Procedure 32
- Engine Oil Replacement Reminder Reset - Procedure 33
- Engine Oil Replacement Reminder Reset - Procedure 34
- Engine Oil Replacement Reminder Reset - Procedure 35
- Engine Oil Replacement Reminder Reset - Procedure 36
- Engine Oil Replacement Reminder Reset - Procedure 37
- Emissions Maintenance Reminder (Reminder Flag)
- Emissions Maintenance Reminder (Warning Light)
- Emissions Maintenance Reminder (Check Engine Light)
- Diesel Fuel Filter Replacement Reminder
- Maintenance Service Reminder
- Timing Belt Replacement Reminder
- Transmission Fluid Replacement Reminder
- Tire Pressure Monitor System Reminder
- Notes
- TPMS Reminder Reset - Procedure 01
- TPMS Reminder Reset - Procedure 02
- TPMS Reminder Reset - Procedure 03
- TPMS Reminder Reset - Procedure 04
- TPMS Reminder Reset - Procedure 05
- TPMS Reminder Reset - Procedure 06
- TPMS Reminder Reset - Procedure 07
- TPMS Reminder Reset - Procedure 08
- TPMS Reminder Reset - Procedure 09
- TPMS Reminder Reset - Procedure 10
- TPMS Reminder Reset - Procedure 11
- TPMS Reminder Reset - Procedure 12
- TPMS Reminder Reset - Procedure 13
- TPMS Reminder Reset - Procedure 14
- TPMS Reminder Reset - Procedure 15
- TPMS Reminder Reset - Procedure 16
- TPMS Reminder Reset - Procedure 17
- TPMS Reminder Reset - Procedure 18
- TPMS Reminder Reset - Procedure 19
- TPMS Reminder Reset - Procedure 20
- TPMS Reminder Reset - Procedure 21
- TPMS Reminder Reset - Procedure 22
- TPMS Reminder Reset - Procedure 23
- TPMS Reminder Reset - Procedure 24
- TPMS Reminder Reset - Procedure 25
- TPMS Reminder Reset - Procedure 26
- TPMS Reminder Reset - Procedure 27
- TPMS Reminder Reset - Procedure 28
- TPMS Reminder Reset - Procedure 29
- TPMS Reminder Reset - Procedure 30
- TPMS Reminder Reset - Procedure 31
- TPMS Reminder Reset - Procedure 32
- TPMS Reminder Reset - Procedure 33
- TPMS Reminder Reset - Procedure 34
- TPMS Reminder Reset - Procedure 35
- TPMS Reminder Reset - Procedure 36
- TPMS Reminder Reset - Procedure 37
- Engine Oil Replacement Reminder
- Tire Pressure Monitor Systems
- Restraints
- RPO Codes
- RPO Code Description (Codes 001-19F)
- RPO Code Description (Codes 19H-2EL)
- RPO Code Description (Codes 2F1-44I)
- RPO Code Description (Codes 44L-5J9)
- RPO Code Description (Codes 5K0-6FF)
- RPO Code Description (Codes 6FG-76A)
- RPO Code Description (Codes 76D-7XD)
- RPO Code Description (Codes 7XF-8M0)
- RPO Code Description (Codes 8M1-9C0)
- RPO Code Description (Codes 9C1-A0F)
- RPO Code Description (Codes A0G-Ar4)
- RPO Code Description (Codes Ar5-BCP)
- RPO Code Description (Codes BCQ-C12)
- RPO Code Description (Codes C13-Cur)
- RPO Code Description (Codes Cut-Dir)
- RPO Code Description (Codes Dr7-EHE)
- RPO Code Description (Codes EHF-F5P)
- RPO Code Description (Codes F5Q-G1V)
- RPO Code Description (Codes G1W-HFN)
- RPO Code Description (Codes HFO-JRG)
- RPO Code Description (Codes JRH-KLY)
- RPO Code Description (Codes KLZ-LQX)
- RPO Code Description (Codes LQY-MW9)
- RPO Code Description (Codes MWE-ODK)
- RPO Code Description (Codes ODL-Ora)
- RPO Code Description (Codes Orb-PDE)
- RPO Code Description (Codes PDF-QH6)
- RPO Code Description (Codes QH7-R8D)
- RPO Code Description (Codes R8E-T07)
- RPO Code Description (Codes T08-TJ0)
- RPO Code Description (Codes TJ1-U10)
- RPO Code Description (Codes U11-Us9)
- RPO Code Description (Codes USB-VG9)
- RPO Code Description (Codes VGA-W5Y)
- RPO Code Description (Codes W5Z-XE3)
- RPO Code Description (Codes XE4-Y9Z)
- RPO Code Description (Codes Ya2-ZD9)
- RPO Code Description (Codes ZDE-ZZZ)
- Specifications Index
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Traction Control Disable Procedures
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- A/C Compressor
- HVAC System - Compressor Clutch Controls
- Model Identification
- Description & Operation
- A/C Clutch Circuit Diagnosis (Cars)
- Notes
- 2.2L & 2.4L: Cavalier & SUNFIRE (2000)
- 2.2L & 2.4L: Cavalier & SUNFIRE (2001)
- 2.4L, 3.1L & 3.4L: ALERO, Grand Am & MALIBU
- 3.0L: CATERA
- 3.1L, 3.5L & 3.8L: Century, Intrigue & Regal
- 3.1L & 3.8L: Grand PRIX
- 3.1L: Lumina
- 3.4L & 3.8L: Impala & Monte CARLO
- 3.5L & 4.0L: Aurora
- 3.8L: BONNEVILLE & LESABRE
- 3.8L: Park Avenue
- 3.8L & 5.7L: CAMARO & Firebird
- 4.6L: DEVILLE & SEVILLE
- 4.6L: ELDORADO
- 5.7L: Corvette
- A/C Clutch Circuit Diagnosis (Light Trucks & Vans)
- Notes
- 2.2L: "S" & "T" Series
- 3.4L: "A" & "B" Series
- 3.4L: "U" Series (2000)
- 3.4L: "U" Series (2001)
- 4.3L: "M" & "L" Series
- 4.3L: "S" & "T" Series (Automatic A/C)
- 4.3L: "S" & "T" Series (Manual A/C)
- 4.3L & 7.4L: "C" & "K" Series (2000) Or 4.3L, 5.0L & 5.7L: "G" Series (2000)
- 4.8L, 5.3L & 6.0L: "C" & "K" Series (2000)
- 5.0L & 5.7L: "C" & "K" Series (2000) Or 7.4L: "G" Series (2000)
- 6.5L: "C" & "K" Series (2000)
- 4.3L, 4.8L, 5.3L, 6.0L, 6.6L & 8.1L: "C" & "K" Series (Automatic A/C 2001)
- 4.3L, 4.8L, 5.3L, 6.0L, 6.6L & 8.1L: "C" & "K" Series (Manual A/C 2001)
- 4.3L, 5.0L, 5.7L, 6.5L & 8.1L: "G" Series (2001)
- Wiring Diagrams
- ALERO & Grand Am
- Astro & Safari
- Aurora
- AZTEK
- Blazer, BRAVADA, Envoy & Jimmy
- BONNEVILLE & LESABRE
- "C" & "K" Pickup
- CAMARO & Firebird
- CATERA
- Cavalier & SUNFIRE
- Century & Regal
- Corvette
- DEVILLE
- ELDORADO
- Express & SAVANA
- Grand PRIX
- Impala & Monte CARLO
- Intrigue
- Lumina
- MALIBU
- MONTANA, Silhouette & Venture
- Park Avenue
- SEVILLE
- Sierra, SILVERADO, Suburban, TAHOE, YUKON
- SONOMA & S10 Pickup
- HVAC System - Compressor Clutch Controls
- General Servicing
- Cabin Air Filter
- HVAC System - Compressor Applications & Body Designations
- HVAC System - Compressor Refrigerant Oil Checking
- Refrigerant Oils
- Servicing Precautions
- Checking Compressor Oil
- DELPHI-Thermal (HARRISON) Hd6/Ht6/HU6 & Hd6/Hr-6HE 6-CYL., V5 5-CYL. & V7 7-CYL.
- Ford FS-10 10-Cylinder
- Ford SC90V Variable Scroll
- Ford SC115 Fixed Scroll
- NIPPONDENSO 10-Cylinder
- NIPPONDENSO 10S15/10S17/10S20
- NIPPONDENSO 10PA17/10PA17C 10-CYL.
- SANDEN Scroll
- SANDEN MSC90-C Scroll
- SANDEN SD-7H15 7-Cylinder
- SANDEN TRS-90 & Tr-105 Scroll
- ZEXEL Rotary Vane
- HVAC System - Compressor Servicing
- DELPHI-Thermal (HARRISON) Hd6/Ht6/HU6 & Hd6/Hr-6HE 6-CYL., V5 5-CYL. & V7 7-CYL.
- Ford FS-10 10-Cylinder
- Ford SC90V Scroll
- Ford SC115 Scroll
- NIPPONDENSO 10-Cylinder
- NIPPONDENSO 10S15/10S17/10S20
- NIPPONDENSO 10PA17/10PA17C 10-Cylinder
- SANDEN Scroll
- SANDEN MSC90-C Scroll
- SANDEN SD-7H15 7-Cylinder
- SANDEN TRS-90 Scroll
- SANDEN TRS-105 Scroll
- ZEXEL Rotary Vane
- HVAC System - General Servicing Procedures
- USING R-134a REFRIGERANT
- System Service Valves
- Service Equipment
- Manifold Gauge Set
- Pressure-Temperature Relationship
- Pressure Gauge Readings
- Orifice Tube Replacement
- Refrigerant Recovery/Recycling
- Flushing A/C System
- Evacuating A/C System
- Charging A/C System
- Leak Testing
- HVAC System - Refrigerant Oil & Refrigerant Specifications
- HVAC Control Systems
- HVAC System - Automatic
- Specifications
- Description
- Operation
- Trouble Shooting
- Symptom Tests
- Blower Has High Speed Only
- Blower Motor Inoperative In All Speeds
- Auxiliary Blower Motor Inoperative At Any Speed
- Compressor Clutch Does Not Engage
- Compressor Clutch Does Not Disengage
- Improper Air Delivery
- Auxiliary Air Delivery Inoperative
- Air Temperature Control Inoperative
- Air Temperature Display Inaccurate
- Self-Diagnostics
- Diagnostic Tests
- DTC B1310: Outside (Ambient) Air Temperature Sensor
- DTC B1317: Inside Air Temperature Sensor
- DTC B1318: Left Sun Load Sensor DTC B1328: Right Sun Load Sensor
- DTC B1321: A/C Refrigerant Low-Side Temperature Sensor
- DTC B1324: A/C Refrigerant Pressure
- DTC B1330: Left A/C Temperature Sensor
- DTC B1331: Right A/C Temperature Sensor
- DTC B1332: Left Heater Temperature Sensor
- DTC B1333: Right Heater Temperature Sensor
- DTC B1340: Left Air Mix Actuator
- DTC B1341: Right Air Mix Actuator
- DTC B1343: Air Inlet Actuator
- DTC B1344: HTR/Def/Ac Air Inlet Actuator
- DTC B1399: Loss Of KDD Communications
- DTC B2510: Steering Wheel Switches
- System Tests
- Component Tests
- Removal & Installation
- Notes
- A/C Compressor
- Accumulator
- Actuators
- Auxiliary Blower/Mode Assembly
- Blower Motor
- Blower Control Module
- HVAC Control Panel
- Condenser
- Dash Integration Module (Dim)
- Evaporator Core
- Heater Core
- HVAC Air Filters
- HVAC Module Assembly
- Instrument Panel
- Sensors
- Removal & Installation (A/C Refrigerant Pressure Sensor)
- Removal & Installation (A/C Refrigerant Low Temperature Sensor)
- Removal & Installation (A/C Temperature)
- Removal & Installation (Ambient Temperature)
- Removal & Installation (Heater Temperature)
- Removal & Installation (In-Vehicle Temperature)
- Removal & Installation (Sun Load)
- Steering Wheel Control Switches
- Torque Specifications
- Wiring Diagrams
- HVAC System - Automatic
- A/C Compressor
- Restraints
- Air Bag, SRS
- Air Bag Restraint Systems
- Description & Operation
- Component Locations
- System Operation Check
- Air Bag Safety Precautions
- Adjustments
- Disabling & Activating Air Bag System
- Disposal Procedures
- Post-Collision Inspection
- Removal & Installation
- Diagnostics
- Diagnostic Tests
- Notes
- Connector Identification
- Sir Diagnostic System Check
- Air Bag Warning Light Circuit Malfunction
- DTC B0016: Passenger-Side Deployment Loop Resistance Low
- DTC B0017: Passenger-Side Deployment Loop Open
- DTC B0018: Passenger-Side Deployment Loop Voltage Out Of Range
- DTC B0022: Driver-Side Deployment Loop Resistance Low
- DTC B0024: Driver-Side Deployment Loop Voltage Out Of Range
- DTC B0026: Driver-Side Deployment Loop Open
- DTC B0028: Passenger Side Impact Deployment Loop Resistance Low
- DTC B0029: Passenger Side Impact Deployment Loop Open
- DTC B0030: Passenger Side Impact Deployment Loop Voltage Out Of Range
- DTC B0040: Driver Side Impact Deployment Loop Resistance Low
- DTC B0041: Driver Side Impact Deployment Loop Open
- DTC B0045: Driver Side Impact Deployment Loop Voltage Out Of Range
- DTC B0051: Deployment Commanded
- DTC B0053: Deployment Commanded With Loop Malfunction
- DTC B0057: Passenger-Side PRETENSIONER Deployment Loop Resistance Low
- DTC B0058: Passenger-Side PRETENSIONER Deployment Loop Open
- DTC B0059: Passenger-Side PRETENSIONER Deployment Loop Voltage Out Of Range
- DTC B0064: Driver-Side PRETENSIONER Deployment Loop Resistance Low
- DTC B0065: Driver-Side PRETENSIONER Deployment Loop Open
- DTC B0066: Driver-Side PRETENSIONER Deployment Loop Voltage Out Of Range
- DTC B0077: Driver-Side Sis Circuit Malfunction
- DTC B0078: Passenger-Side Sis Circuit Malfunction
- DTC B0079: Incorrect Driver-Side Sis Installed
- DTC B0080: Driver-Side Sis Malfunction
- DTC B0081: Incorrect Passenger-Side Sis Installed
- DTC B0082: Passenger-Side Sis Malfunction
- DTC B1000: Internal SDM Failure
- DTC B1001: Option Configuration Error
- Wire Repair
- Torque Specifications
- Wiring Diagrams
- Supplemental Inflatable Restraint System - Air Bag Deactivation Procedures
- Special Care During Mechanical Repairs
- DAIMLERCHRYSLER
- Ford Motor Co.
- System Operation Check
- Service Precautions
- Disabling & Activating Air Bag System
- Notes
- Disabling System (Continental)
- Activating System (Continental)
- Disabling System (Cougar)
- Activating System (Cougar)
- Disabling System (Crown Victoria & Grand Marquis)
- Activating System (Crown Victoria & Grand Marquis)
- Disabling System (Econoline)
- Activating System (Econoline)
- Disabling System (Escape)
- Activating System (Escape)
- Disabling System (Escort & Escort Coupe)
- Activating System (Escort & Escort Coupe)
- Disabling System (Excursion & F250/350 Super Duty)
- Activating System (Excursion & F250/350 Super Duty)
- Disabling System (Expedition & Navigator)
- Activating System (Expedition & Navigator)
- Disabling System (Explorer & Mountaineer)
- Activating System (Explorer & Mountaineer)
- Disabling System (Explorer Sport & Explorer Sport Trac)
- Activating System (Explorer Sport & Explorer Sport Trac)
- Disabling System (Focus)
- Activating System (Focus)
- Disabling System (F150)
- Activating System (F150)
- Disabling System (LS)
- Activating System (LS)
- Disabling System (Mustang)
- Activating System (Mustang)
- Disabling System (Ranger)
- Activating System (Ranger)
- Disabling System (Sable & Taurus)
- Activating System (Sable & Taurus)
- Disabling System (Town Car)
- Activating System (Town Car)
- Disabling System (Villager)
- Activating System (Villager)
- Disabling System (Windstar)
- Activating System (Windstar)
- Air Bag Simulator
- Driver Air Bag Module
- Passenger Air Bag Module
- Notes
- Removal & Installation (Cougar)
- Removal & Installation (Crown Victoria & Grand Marquis)
- Removal & Installation (Escort & Escort Coupe)
- Removal & Installation (Expedition & Navigator)
- Removal & Installation (Explorer Sport, Explorer Sport Trac & Ranger)
- Removal & Installation (Sable & Taurus)
- Removal & Installation (Town Car)
- Torque Specifications
- General Motors
- Notes
- System Operation Check
- Service Precautions
- Disabling & Activating Air Bag System
- Notes
- Disabling System (Alero, Grand Am & Malibu)
- Activating System (Alero, Grand Am & Malibu)
- Disabling System (Astro & Safari)
- Activating System (Astro & Safari)
- Disabling System (Aurora, Bonneville, LeSabre & Park Avenue)
- Activating System (Aurora, Bonneville, LeSabre & Park Avenue)
- Disabling System (Aztek)
- Activating System (Aztek)
- Disabling System (Blazer, Bravada, Envoy, Jimmy, Sonoma & S10)
- Activating System (Blazer, Bravada, Envoy, Jimmy, Sonoma & S10)
- Disabling System (Camaro & Firebird)
- Activating System (Camaro & Firebird)
- Disabling System (Catera)
- Activating System (Catera)
- Disabling System (Cavalier & Sunfire)
- Activating System (Cavalier & Sunfire)
- Disabling System (Century, Grand Prix, Intrigue & Regal)
- Activating System (Century, Grand Prix, Intrigue & Regal)
- Disabling System (Corvette)
- Activating System (Corvette)
- Disabling System (DeVille & Seville)
- Activating System (DeVille & Seville)
- Disabling System (Eldorado)
- Activating System (Eldorado)
- Disabling System (Express Van & Savana Van)
- Activating System (Express Van & Savana Van)
- Disabling System (Impala & Monte Carlo)
- Activating System (Impala & Monte Carlo)
- Disabling System (Lumina)
- Activating System (Lumina)
- Disabling System (Metro)
- Activating System (Metro)
- Disabling System (Montana, Silhouette & Venture)
- Activating System (Montana, Silhouette & Venture)
- Disabling System (Prizm)
- Activating System (Prizm)
- Disabling System (Saturn, L Series)
- Activating System (Saturn, L Series)
- Disabling System (Saturn, S Series)
- Activating System (Saturn, S Series)
- Disabling System (Sierra, Silverado, Suburban, Tahoe, Yukon & Yukon XL)
- Activating System (Sierra, Silverado, Suburban, Tahoe, Yukon & Yukon XL)
- Disabling System (Tracker)
- Activating System (Tracker)
- Jeep
- Air Bag Restraint Systems
- Restraints Control Systems
- Supplemental Inflatable Restraint System - Air Bag Deactivation Procedures
- Special Care During Mechanical Repairs
- DAIMLERCHRYSLER
- Ford Motor Co.
- System Operation Check
- Service Precautions
- Disabling & Activating Air Bag System
- Notes
- Disabling System (Continental)
- Activating System (Continental)
- Disabling System (Cougar)
- Activating System (Cougar)
- Disabling System (Crown Victoria & Grand Marquis)
- Activating System (Crown Victoria & Grand Marquis)
- Disabling System (Econoline)
- Activating System (Econoline)
- Disabling System (Escape)
- Activating System (Escape)
- Disabling System (Escort & Escort Coupe)
- Activating System (Escort & Escort Coupe)
- Disabling System (Excursion & F250/350 Super Duty)
- Activating System (Excursion & F250/350 Super Duty)
- Disabling System (Expedition & Navigator)
- Activating System (Expedition & Navigator)
- Disabling System (Explorer & Mountaineer)
- Activating System (Explorer & Mountaineer)
- Disabling System (Explorer Sport & Explorer Sport Trac)
- Activating System (Explorer Sport & Explorer Sport Trac)
- Disabling System (Focus)
- Activating System (Focus)
- Disabling System (F150)
- Activating System (F150)
- Disabling System (LS)
- Activating System (LS)
- Disabling System (Mustang)
- Activating System (Mustang)
- Disabling System (Ranger)
- Activating System (Ranger)
- Disabling System (Sable & Taurus)
- Activating System (Sable & Taurus)
- Disabling System (Town Car)
- Activating System (Town Car)
- Disabling System (Villager)
- Activating System (Villager)
- Disabling System (Windstar)
- Activating System (Windstar)
- Air Bag Simulator
- Driver Air Bag Module
- Passenger Air Bag Module
- Notes
- Removal & Installation (Cougar)
- Removal & Installation (Crown Victoria & Grand Marquis)
- Removal & Installation (Escort & Escort Coupe)
- Removal & Installation (Expedition & Navigator)
- Removal & Installation (Explorer Sport, Explorer Sport Trac & Ranger)
- Removal & Installation (Sable & Taurus)
- Removal & Installation (Town Car)
- Torque Specifications
- General Motors
- Notes
- System Operation Check
- Service Precautions
- Disabling & Activating Air Bag System
- Notes
- Disabling System (Alero, Grand Am & Malibu)
- Activating System (Alero, Grand Am & Malibu)
- Disabling System (Astro & Safari)
- Activating System (Astro & Safari)
- Disabling System (Aurora, Bonneville, LeSabre & Park Avenue)
- Activating System (Aurora, Bonneville, LeSabre & Park Avenue)
- Disabling System (Aztek)
- Activating System (Aztek)
- Disabling System (Blazer, Bravada, Envoy, Jimmy, Sonoma & S10)
- Activating System (Blazer, Bravada, Envoy, Jimmy, Sonoma & S10)
- Disabling System (Camaro & Firebird)
- Activating System (Camaro & Firebird)
- Disabling System (Catera)
- Activating System (Catera)
- Disabling System (Cavalier & Sunfire)
- Activating System (Cavalier & Sunfire)
- Disabling System (Century, Grand Prix, Intrigue & Regal)
- Activating System (Century, Grand Prix, Intrigue & Regal)
- Disabling System (Corvette)
- Activating System (Corvette)
- Disabling System (DeVille & Seville)
- Activating System (DeVille & Seville)
- Disabling System (Eldorado)
- Activating System (Eldorado)
- Disabling System (Express Van & Savana Van)
- Activating System (Express Van & Savana Van)
- Disabling System (Impala & Monte Carlo)
- Activating System (Impala & Monte Carlo)
- Disabling System (Lumina)
- Activating System (Lumina)
- Disabling System (Metro)
- Activating System (Metro)
- Disabling System (Montana, Silhouette & Venture)
- Activating System (Montana, Silhouette & Venture)
- Disabling System (Prizm)
- Activating System (Prizm)
- Disabling System (Saturn, L Series)
- Activating System (Saturn, L Series)
- Disabling System (Saturn, S Series)
- Activating System (Saturn, S Series)
- Disabling System (Sierra, Silverado, Suburban, Tahoe, Yukon & Yukon XL)
- Activating System (Sierra, Silverado, Suburban, Tahoe, Yukon & Yukon XL)
- Disabling System (Tracker)
- Activating System (Tracker)
- Jeep
- Supplemental Inflatable Restraint System - Air Bag Deactivation Procedures
- Seat Belts
- Supplemental Inflatable Restraint System - Air Bag Deactivation Procedures
- Special Care During Mechanical Repairs
- DAIMLERCHRYSLER
- Ford Motor Co.
- System Operation Check
- Service Precautions
- Disabling & Activating Air Bag System
- Notes
- Disabling System (Continental)
- Activating System (Continental)
- Disabling System (Cougar)
- Activating System (Cougar)
- Disabling System (Crown Victoria & Grand Marquis)
- Activating System (Crown Victoria & Grand Marquis)
- Disabling System (Econoline)
- Activating System (Econoline)
- Disabling System (Escape)
- Activating System (Escape)
- Disabling System (Escort & Escort Coupe)
- Activating System (Escort & Escort Coupe)
- Disabling System (Excursion & F250/350 Super Duty)
- Activating System (Excursion & F250/350 Super Duty)
- Disabling System (Expedition & Navigator)
- Activating System (Expedition & Navigator)
- Disabling System (Explorer & Mountaineer)
- Activating System (Explorer & Mountaineer)
- Disabling System (Explorer Sport & Explorer Sport Trac)
- Activating System (Explorer Sport & Explorer Sport Trac)
- Disabling System (Focus)
- Activating System (Focus)
- Disabling System (F150)
- Activating System (F150)
- Disabling System (LS)
- Activating System (LS)
- Disabling System (Mustang)
- Activating System (Mustang)
- Disabling System (Ranger)
- Activating System (Ranger)
- Disabling System (Sable & Taurus)
- Activating System (Sable & Taurus)
- Disabling System (Town Car)
- Activating System (Town Car)
- Disabling System (Villager)
- Activating System (Villager)
- Disabling System (Windstar)
- Activating System (Windstar)
- Air Bag Simulator
- Driver Air Bag Module
- Passenger Air Bag Module
- Notes
- Removal & Installation (Cougar)
- Removal & Installation (Crown Victoria & Grand Marquis)
- Removal & Installation (Escort & Escort Coupe)
- Removal & Installation (Expedition & Navigator)
- Removal & Installation (Explorer Sport, Explorer Sport Trac & Ranger)
- Removal & Installation (Sable & Taurus)
- Removal & Installation (Town Car)
- Torque Specifications
- General Motors
- Notes
- System Operation Check
- Service Precautions
- Disabling & Activating Air Bag System
- Notes
- Disabling System (Alero, Grand Am & Malibu)
- Activating System (Alero, Grand Am & Malibu)
- Disabling System (Astro & Safari)
- Activating System (Astro & Safari)
- Disabling System (Aurora, Bonneville, LeSabre & Park Avenue)
- Activating System (Aurora, Bonneville, LeSabre & Park Avenue)
- Disabling System (Aztek)
- Activating System (Aztek)
- Disabling System (Blazer, Bravada, Envoy, Jimmy, Sonoma & S10)
- Activating System (Blazer, Bravada, Envoy, Jimmy, Sonoma & S10)
- Disabling System (Camaro & Firebird)
- Activating System (Camaro & Firebird)
- Disabling System (Catera)
- Activating System (Catera)
- Disabling System (Cavalier & Sunfire)
- Activating System (Cavalier & Sunfire)
- Disabling System (Century, Grand Prix, Intrigue & Regal)
- Activating System (Century, Grand Prix, Intrigue & Regal)
- Disabling System (Corvette)
- Activating System (Corvette)
- Disabling System (DeVille & Seville)
- Activating System (DeVille & Seville)
- Disabling System (Eldorado)
- Activating System (Eldorado)
- Disabling System (Express Van & Savana Van)
- Activating System (Express Van & Savana Van)
- Disabling System (Impala & Monte Carlo)
- Activating System (Impala & Monte Carlo)
- Disabling System (Lumina)
- Activating System (Lumina)
- Disabling System (Metro)
- Activating System (Metro)
- Disabling System (Montana, Silhouette & Venture)
- Activating System (Montana, Silhouette & Venture)
- Disabling System (Prizm)
- Activating System (Prizm)
- Disabling System (Saturn, L Series)
- Activating System (Saturn, L Series)
- Disabling System (Saturn, S Series)
- Activating System (Saturn, S Series)
- Disabling System (Sierra, Silverado, Suburban, Tahoe, Yukon & Yukon XL)
- Activating System (Sierra, Silverado, Suburban, Tahoe, Yukon & Yukon XL)
- Disabling System (Tracker)
- Activating System (Tracker)
- Jeep
- Supplemental Inflatable Restraint System - Air Bag Deactivation Procedures
- Air Bag, SRS
- Steering
- Electronic Steering
- Manual Steering
- Power Rack & Pinion Steering
- Model Identification
- Description & Operation
- Lubrication
- Adjustments
- System Tests
- Removal & Installation
- Notes
- Outer Tie Rod
- Power Steering Pressure Hose Replacement (Aurora, 4.0L)
- Power Steering Return Hose Replacement (Aurora, 4.0L)
- Power Steering Gear Heat Shield Replacement (Aurora, 4.0L)
- Power Steering Cooler Pipe/Hose
- Power Steering Pump Pulley
- Power Steering Pump
- Pump Flow Control Valve Assembly
- Pump Shaft Seal
- Rack & Pinion Assembly
- Rack & Pinion Boots
- Overhaul
- Torque Specifications
- Power Rack & Pinion Steering
- Power Steering
- Power Rack & Pinion Steering
- Model Identification
- Description & Operation
- Lubrication
- Adjustments
- System Tests
- Removal & Installation
- Notes
- Outer Tie Rod
- Power Steering Pressure Hose Replacement (Aurora, 4.0L)
- Power Steering Return Hose Replacement (Aurora, 4.0L)
- Power Steering Gear Heat Shield Replacement (Aurora, 4.0L)
- Power Steering Cooler Pipe/Hose
- Power Steering Pump Pulley
- Power Steering Pump
- Pump Flow Control Valve Assembly
- Pump Shaft Seal
- Rack & Pinion Assembly
- Rack & Pinion Boots
- Overhaul
- Torque Specifications
- Power Rack & Pinion Steering
- Steering Column
- Steering Column & Steering Column Switches
- Description & Operation
- Component Locations
- Programming
- Trouble Shooting
- Self-Diagnostic System
- Diagnostic Tests
- DTC B1396: Tilt/Telescope Position Sensor Failure
- DTC B2175: Tilt/Telescope Switch Input Malfunction
- DTC B2511: Radio Steering Wheel Controls Key Stuck
- DTC B2512: Steering Wheel Controls Circuit Malfunction
- DTC B2853, B2858, B2873, B2878 Or B2904: Tilt/Telescope Switch Malfunction
- DTC B2860: Telescope Actuator Position Sensor Voltage High
- DTC B2862: Telescope Actuator Position Sensor Voltage Low
- DTC B2880: Tilt Actuator Position Sensor Voltage High
- DTC B2882: Tilt Position Sensor Voltage Low
- DTC B2891: Tilt/Telescope Motor Circuit Malfunction
- DTC 2904: Tilt/Telescope Switch Circuit Malfunction
- System Tests
- Removal & Installation
- Torque Specifications
- Wiring Diagrams
- Steering Wheel And Steering Column
- Model Identification
- Description & Operation
- Service Precautions
- Disabling & Activating Air Bag System
- Adjustments
- Removal & Installation
- Notes
- Air Bag (Inflator) Module
- Steering Wheel
- Sir CLOCKSPRING Assembly
- Turn Signal Switch
- Lock Cylinder
- Dimmer Switch
- Ignition Switch
- Lock Housing Cover
- Automatic Transmission Shift Lock Control - Disassemble - Off Vehicle
- Automatic Transmission Shift Lock Control - Assemble - Off Vehicle
- MULTIFUNCTION Switch Lever
- Steering Wheel Rotation Sensor
- Steering Column
- Lower Bearing & Related Components
- Overhaul
- Torque Specifications
- Steering Column & Steering Column Switches
- Suspension
- Electronic Suspension
- Electronic Suspension - Automatic Level Control - W/CVRSS
- Electronic Suspension - CV Road Sensing
- Description & Operation
- Adjustments
- Diagnosis & Testing
- Diagnostic Tests
- Notes
- Test A: No RSS Data, Loss Of Serial Communication Or Power (2000 Models)
- DTC C0550: Control Module Malfunction
- DTC C0563: Calibration ROM Checksum Error
- DTC C0577, C0578, C0579, C0582, C0583, C0584, C0587, C0588, C0589, C0592, C0593 Or Co594: Actuator Solenoid Circuit Malfunction
- DTC C0615, C0620, C0625 Or C0630: Position Sensor Malfunction
- DTC C0635 Orc0640: Normal Force Circuit Malfunction (2000 Models)
- DTC C0638 Or C0643: Normal Force Circuit High (2000 Models)
- DTC C0635, C0638, C0640, Co643, C1252 Or C1253: Normal Force Circuit Malfunction (2001 Models)
- DTC C0657 Or C0658: Level Control Compressor Circuit Malfunction
- DTC C0662 Or C0663: Level Control Exhaust Valve Circuit Malfunction
- DTC C0665: Chassis Pitch Signal Circuit Malfunction
- DTC C0690, C0691 Or C0693: Damper Control Relay Circuit Malfunction
- DTC C0695 Or C0696: Position Sensor OVERCURRENT
- DTC C0710: Steering Position Signal Malfunction
- DTC C0896: Device Voltage Range/Performance
- Removal & Installation
- Wiring Diagrams
- Electronic Suspension Control System - Wiring Diagrams
- Front Suspension
- Rear Suspension
- Wheel Alignment Specifications & Adjustment Procedures
- Electronic Suspension
- Transmission
- Automatic Trans
- Automatic Transaxle Diagnosis - 4T80-E
- Identification
- Description & Operation
- Introduction
- Adapt Function
- Transaxle Components & Systems
- Electronic Components
- Notes
- Torque Converter Clutch Pulse Width Modulation Solenoid Valve
- Pressure Control Solenoid Valve
- 1-2 & 2-3 Shift Solenoid Valves
- Transmission Fluid Pressure Manual Valve Position Switch
- Vehicle Speed Sensor
- Input Speed Sensor
- Transmission Fluid Temperature Sensor
- Internal Mode Switch
- Transaxle Electrical Connector
- Powertrain Control Module
- Limp-In Mode
- Electronic Control System
- Shift Interlock System
- Trouble Shooting
- Performance Tests
- Road Test
- Introduction
- Electrical Function Check
- Upshift Control & Torque Converter Clutch Apply
- Part Throttle Detent Downshift
- Full Throttle Detent Downshift
- Manual Downshifts
- Manual 4-3 Downshift
- Manual 4-2 Downshift
- Manual 4-1 Downshift
- Coasting Downshifts
- Manual Gear Range Selection (Reverse)
- Manual Gear Range Selection (1st)
- Manual Gear Range Selection (2nd)
- Manual Gear Range Selection (3rd)
- Shift Speed Specifications
- Torque Converter Diagnosis
- Hydraulic Pressure Tests
- Clutch & Servo Air Checks
- Road Test
- Self-Diagnostic System
- Diagnostic Tests
- DTC P0218: Transaxle Fluid OVERTEMPERATURE
- DTC P0502: Vehicle Speed Sensor Circuit (Low Input)
- DTC P0503: Vehicle Speed Sensor Circuit Performance
- DTC P0711: Transmission Fluid Temperature Sensor Circuit Performance
- DTC P0712: Transmission Fluid Temperature Sensor Circuit (Low Input)
- DTC P0713: Transmission Fluid Temperature Sensor Circuit (High Input)
- DTC P0716: Input Speed Sensor Circuit Performance
- DTC P0717: Input Speed Sensor Circuit (No Signal)
- DTC P0719: TCC Brake Switch Circuit Low Input (Switch Stuck On)
- DTC P0724: TCC Brake Switch Circuit High Input (Switch Stuck Off)
- DTC P0731: Incorrect 1ST Gear Ratio
- DTC P0732: Incorrect 2ND Gear Ratio
- DTC P0733: Incorrect 3RD Gear Ratio
- DTC P0734: Incorrect 4TH Gear Ratio
- DTC P0741: TCC System Stuck Off
- DTC P0742: TCC System Stuck On
- DTC P0748: Pressure Control Solenoid Circuit Electrical Malfunction
- DTC P0751: 1-2 Shift Solenoid Valve Performance
- DTC P0752: 1-2 Shift Solenoid Valve Performance
- DTC P0756: 2-3 Shift Solenoid Valve Performance
- DTC P0757: 2-3 Shift Solenoid Valve Performance
- DTC P1811: Maximum Adapt & Long Shift
- DTC P1814: Torque Converter Overstress
- DTC P1820: Internal Mode Switch Circuit "A" Low
- DTC P1822: Internal Mode Switch Circuit "B" High
- DTC P1823: Internal Mode Switch Circuit "P" Low
- DTC P1825: Internal Mode Switch - Invalid Range
- DTC P1842: 1-2 Shift Solenoid Circuit Low Voltage
- DTC P1843: 1-2 Shift Solenoid Circuit High Voltage
- DTC P1845: 2-3 Shift Solenoid Circuit Low Voltage
- DTC P1847: 2-3 Shift Solenoid Circuit High Voltage
- DTC P1860: TCC PWM Solenoid Circuit - Electrical Malfunction
- DTC P1868: Transmission Fluid Life
- Symptom Tests
- Component Tests
- Removal & Installation
- Torque Specifications
- Electronic Component Specifications
- Connector Identification
- Wiring Diagrams
- Automatic Transaxle Hydraulic Diagrams - 4T80-E
- Automatic Transaxle Overhaul & Testing - 4T80-E
- Application
- Identification
- Description & Operation
- Lubrication
- Trouble Shooting
- Component Tests
- Transaxle Disassembly
- Component Disassembly & Reassembly
- Transaxle Reassembly
- Torque Specifications
- Transaxle Specifications
- Automatic Transaxle Removal & Installation
- Automatic Transmission Servicing
- Application
- Identification
- Lubrication
- On-Vehicle Repairs
- Adjustments
- Removal & Installation
- Notes
- Case Extension Housing
- Detent Lever & Roller Assembly
- Differential Carrier
- Final Drive Assembly
- Fluid Level Indicator
- Lower Valve Assembly
- Manual Shaft & Seal
- Oil Cooler Pipe
- Oil Pressure Test Plug
- Output Shaft
- Parking Gear
- Parking Pawl
- Scavenge Screens & Seals
- Shift Cable (Console Shift)
- Shift Cable (Column Shift)
- Transaxle Brace
- Vehicle Speed Sensor
- Torque Specifications
- Shift Interlock Systems
- Automatic Transaxle Diagnosis - 4T80-E
- Automatic Transaxle Hydraulic Diagrams - 4T80-E
- Automatic Trans
- External Pages