Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups
Common Specs & Procedures
DTC Index
Electrical Component Locations
Fluids
Technical Bulletins
Tire Fitment
Wiring Diagrams- OEM Connector End Views
- Connector End Views
- A/C-Heater Control Unit Connector End Views
- Air Quality Sensor Connector End View
- Audio Unit Connector End Views (H250)
- Audio Unit Connector End Views (H260)
- Audio Unit Connector End Views (H290)
- Auto Light Sensor Connector End View
- Data Link Connector End View
- Door Switch Connector End View
- DRL Module Connector End View
- Engine Control Module Connector End View (2.0L)
- Engine Control Module Connector End Views (2.7L)
- Engine Control Relay 5-Pin Connector End View (Component Side)
- Engine Control Relay 8-Pin Connector End View (Component Side)
- Fog Lamp Switch Connector End View
- Front Power Door Lock Actuator Connector End View
- Front Wiper Motor Connector End View
- Fuel Pump Check Connector End View
- Fuel Pump Relay Connector End View
- Hazard Switch Connector End View
- Head Lamp Relay End View
- HECU Connector End View
- HO2S Connector End View (Front & Rear)
- Ignition Coil Connector End View (2.7L)
- Ignition Switch Connector & Door Warning Switch Connector End Views & Locations
- Instrument Cluster Harness Connector End Views
- Map Lamp Switch Connector End View
- PCM/ECM Harness Connector End View (2.0L)
- PCM/ECM Harness Connector End Views (2.7L)
- Power Door Mirror Actuator Connector End View
- Power Door Mirror Switch Connector End View
- Power Window Main Switch Connector End View
- Power Window Sub Switch Connector End View
- Rear Washer Switch Connector End View
- Rear Wiper Motor Connector End View
- Rheostat Connector End View
- Solenoid Connector End View
- Stop Lamp Switch Connector End View
- Sun Roof Switch Connector End View
- Supplemental Restraint System Control Module Connector End View
- Throttle Position Sensor 3-Pin Connector End View (Component Side)
- Transaxle Control Module (TCM) 26-Pin Connector End View (2.0L)
- Transaxle Control Module (TCM) 22-pin Connector End View (2.7L)
- Transaxle Range Switch Harness Connector End View
- Vehicle Speed Sensor (VSS) Connector End Views
- Washer Motor Connector End View (Front & Rear)
- Connector Locations
- Brake Fluid Level Sensor Connector Location
- Data Link Connector Location
- Fog Lamp Connector Location
- Front Wheel Speed Sensor Connector Location
- Fuel Injector Harness Connector Location (2.7L)
- Glove Box Lamp & Connector Location
- HECU Double Lock Connector Location
- Radiator Fan Motor Connector Location (2.0L)
- Rear Wheel Speed Sensor Connector Location
- Rear Window Defogger Connector Location
- Sun Roof Controller & Motor Side Connector Locations
- Connector End Views
- System Wiring Diagrams
- Using lemon2025'S Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Top/Sunroof
- Power Windows
- Radio
- Starting/Charging
- Supplemental Restraints
- Transmission
- Trunk, Tailgate, Fuel Door
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- OEM Connector End Views
- Accessories & Equipment
- Anti-Theft Systems
- Electronic Time & Alarm Control System
- Exterior
- General Information - Interior & Exterior
- Immobilizer Control System
- Power Door Locks
- Cruise Control Systems
- Cruise Control System
- General Specifications
- Cruise Control System Pre-Troubleshooting
- Trouble Symptom Charts
- Trouble Symptom 1: Cancellation When Not Wanted Or System Cannot Be Set After Auto Cancellation
- Trouble Symptom 2: Vehicle Speed Varies Or Surges
- Trouble Symptom 3: Cancellation Inoperative With Brake Pedal Depressed
- Trouble Symptom 4: Cancellation Inoperative When Shift Lever Is Moved To Neutral Position
- Trouble Symptom 5: Cannot Decelerate Using Set Switch
- Trouble Symptom 6: Cannot Accelerate Or Resume Speed Using The Resume Switch
- Trouble Symptom 7: Cannot Set Speed Under (25 Mph) Or There Is No Auto Cancellation At That Speed
- Trouble Symptom 8: Cruise Control Main Switch Indicator Does Not Illuminate
- Trouble Symptom 9: Malfunction Of Control Function By On/Off Switching Of Idle Switch
- Trouble Symptom 10: Overdrive Is Not Canceled During Fixed Speed Driving Or No Shift To Overdrive During Manual Driving
- System Block Diagram
- Component Locations
- Components
- Parts Inspection
- Inspection
- Cruise Control System
- Entertainment Systems
- Exterior Lights
- Gauges & Instrument Panels
- Indicators & Gauges
- Indicators & Gauges
- General Specifications
- Service Specifications
- Troubleshooting
- Instrument Cluster
- Components
- Circuit Diagram
- Removal & Installation
- Inspection Of Components
- Speedometer
- Tachometer
- Fuel Gauge
- Fuel Sender
- Low Fuel Level Sensor
- Engine Coolant Temperature Gauge
- Engine Coolant Temperature Sender
- Oil Pressure Switch
- Oil Pressure Warning Lamp
- Brake Fluid Level Warning Switch
- Brake Fluid Level Warning Lamp
- Parking Brake Switch
- Door Switch
- Seat Belt Switch
- Seat Belt Warning Lamp
- Multi Gauge
- Indicators & Gauges
- Interior
- Indicators & Gauges
- Headlights
- Heated Glass/Defoggers
- Horns
- Ignition Switch/Steering Lock
- Infotainment
- Interior/Exterior Trim
- Interior/Illumination Lights
- Mirrors
- Seats
- Steering Column Switches
- Window Motors & Regulators
- Wiper/Washer Systems
- Anti-Theft Systems
- Body & Frame
- Door Locks
- Electronic Time & Alarm Control System
- Exterior
- General Information - Interior & Exterior
- Immobilizer Control System
- Power Door Locks
- Exterior Body Panels
- Exterior/Interior Trim
- Ignition Switch/Steering Lock
- Mirrors
- Seats
- Sun Roof/T-Top/Convertible Top
- Windows
- Door Locks
- Brakes
- Anti-Lock Brakes
- Anti-Lock Brake System
- Abs (Anti-Lock Brake System)
- Troubleshooting
- System Components
- Hydraulic System Diagram
- Abs Control
- Traction Control System (TCS)
- EBD (Electronic Brake-Force Distribution)
- Warning Lamp Control
- Standard Flow Of Diagnostic Troubleshooting
- Notes With Regard To Diagnosis
- Abs Check Sheet
- Hi-Scan (Pro) Check
- Connector Check
- Inspection Chart For Diagnostic Trouble Codes
- Actuator Driving
- Current Data
- Fail-Safe Specification
- Anti-Lock Brake System Circuit Diagram
- Inspection Procedure For Diagnostic Trouble Codes
- DTC C1200, C1203, C1206 & C1209: Wheel Speed Sensor Open Or Short To Ground
- DTC C1201, C1204, C1207 & C1210: Wheel Speed Sensor Malfunction
- DTC C1202, C1205, C1208 & C1211: Wheel Speed Sensor Malfunction
- DTC C1101 & C1102: Voltage Out Of Range
- DTC C1604: ECU Hardware (EEPROM & ECU Failure)
- DTC C2112: Valve Relay (Including Fuse Failure)
- DTC C1605: CAN Hardware Error
- DTC C1611-C1613: CAN Timeout EMS, CAN Timeout TCU & CAN Wrong Matched Transmission
- DTC C1610: Bus Off Error
- DTC C2402: Motor Pump Failure
- Inspection Chart For Trouble Symptoms
- Inspection Procedure For Trouble Symptoms
- Anti-Lock Braking System Control Module
- HECU Block Diagram
- External Wiring Diagram (Abs & TCS)
- Inspection At HECU Terminals
- Component Specification
- Removal
- Installation
- Abs Operation Check
- Anti-Lock Braking System Wheel Speed Sensor
- Abs (Anti-Lock Brake System)
- Anti-Lock Brake System
- Mechanical - Hydraulic
- Disc Brakes
- Description & Operation
- Troubleshooting
- Bleeding Brake System
- Adjustments
- Component Tests
- Removal & Installation
- Overhaul
- Torque Specifications
- Disc Brake Specifications
- Disc Brakes
- Traction Control
- Anti-Lock Brake System
- Abs (Anti-Lock Brake System)
- Troubleshooting
- System Components
- Hydraulic System Diagram
- Abs Control
- Traction Control System (TCS)
- EBD (Electronic Brake-Force Distribution)
- Warning Lamp Control
- Standard Flow Of Diagnostic Troubleshooting
- Notes With Regard To Diagnosis
- Abs Check Sheet
- Hi-Scan (Pro) Check
- Connector Check
- Inspection Chart For Diagnostic Trouble Codes
- Actuator Driving
- Current Data
- Fail-Safe Specification
- Anti-Lock Brake System Circuit Diagram
- Inspection Procedure For Diagnostic Trouble Codes
- DTC C1200, C1203, C1206 & C1209: Wheel Speed Sensor Open Or Short To Ground
- DTC C1201, C1204, C1207 & C1210: Wheel Speed Sensor Malfunction
- DTC C1202, C1205, C1208 & C1211: Wheel Speed Sensor Malfunction
- DTC C1101 & C1102: Voltage Out Of Range
- DTC C1604: ECU Hardware (EEPROM & ECU Failure)
- DTC C2112: Valve Relay (Including Fuse Failure)
- DTC C1605: CAN Hardware Error
- DTC C1611-C1613: CAN Timeout EMS, CAN Timeout TCU & CAN Wrong Matched Transmission
- DTC C1610: Bus Off Error
- DTC C2402: Motor Pump Failure
- Inspection Chart For Trouble Symptoms
- Inspection Procedure For Trouble Symptoms
- Anti-Lock Braking System Control Module
- HECU Block Diagram
- External Wiring Diagram (Abs & TCS)
- Inspection At HECU Terminals
- Component Specification
- Removal
- Installation
- Abs Operation Check
- Anti-Lock Braking System Wheel Speed Sensor
- Abs (Anti-Lock Brake System)
- Anti-Lock Brake System
- Anti-Lock Brakes
- Drivelines & Axles
- Electrical
- Body Electrical
- OEM Connector End Views
- Connector End Views
- A/C-Heater Control Unit Connector End Views
- Air Quality Sensor Connector End View
- Audio Unit Connector End Views (H250)
- Audio Unit Connector End Views (H260)
- Audio Unit Connector End Views (H290)
- Auto Light Sensor Connector End View
- Data Link Connector End View
- Door Switch Connector End View
- DRL Module Connector End View
- Engine Control Module Connector End View (2.0L)
- Engine Control Module Connector End Views (2.7L)
- Engine Control Relay 5-Pin Connector End View (Component Side)
- Engine Control Relay 8-Pin Connector End View (Component Side)
- Fog Lamp Switch Connector End View
- Front Power Door Lock Actuator Connector End View
- Front Wiper Motor Connector End View
- Fuel Pump Check Connector End View
- Fuel Pump Relay Connector End View
- Hazard Switch Connector End View
- Head Lamp Relay End View
- HECU Connector End View
- HO2S Connector End View (Front & Rear)
- Ignition Coil Connector End View (2.7L)
- Ignition Switch Connector & Door Warning Switch Connector End Views & Locations
- Instrument Cluster Harness Connector End Views
- Map Lamp Switch Connector End View
- PCM/ECM Harness Connector End View (2.0L)
- PCM/ECM Harness Connector End Views (2.7L)
- Power Door Mirror Actuator Connector End View
- Power Door Mirror Switch Connector End View
- Power Window Main Switch Connector End View
- Power Window Sub Switch Connector End View
- Rear Washer Switch Connector End View
- Rear Wiper Motor Connector End View
- Rheostat Connector End View
- Solenoid Connector End View
- Stop Lamp Switch Connector End View
- Sun Roof Switch Connector End View
- Supplemental Restraint System Control Module Connector End View
- Throttle Position Sensor 3-Pin Connector End View (Component Side)
- Transaxle Control Module (TCM) 26-Pin Connector End View (2.0L)
- Transaxle Control Module (TCM) 22-pin Connector End View (2.7L)
- Transaxle Range Switch Harness Connector End View
- Vehicle Speed Sensor (VSS) Connector End Views
- Washer Motor Connector End View (Front & Rear)
- Connector Locations
- Brake Fluid Level Sensor Connector Location
- Data Link Connector Location
- Fog Lamp Connector Location
- Front Wheel Speed Sensor Connector Location
- Fuel Injector Harness Connector Location (2.7L)
- Glove Box Lamp & Connector Location
- HECU Double Lock Connector Location
- Radiator Fan Motor Connector Location (2.0L)
- Rear Wheel Speed Sensor Connector Location
- Rear Window Defogger Connector Location
- Sun Roof Controller & Motor Side Connector Locations
- Connector End Views
- OEM Connector End Views
- Charging Systems
- Generators & Regulators (2.0L)
- Description & Operation
- Component Locations
- Adjustments
- Trouble Shooting
- On-Vehicle Testing
- Bench Testing
- Removal & Installation
- Overhaul
- Generator Specifications
- Torque Specifications
- Wiring Diagrams
- Generators & Regulators (2.0L)
- Component Locations
- Fuses & Circuit Breakers
- Gauges
- Indicators & Gauges
- Indicators & Gauges
- General Specifications
- Service Specifications
- Troubleshooting
- Instrument Cluster
- Components
- Circuit Diagram
- Removal & Installation
- Inspection Of Components
- Speedometer
- Tachometer
- Fuel Gauge
- Fuel Sender
- Low Fuel Level Sensor
- Engine Coolant Temperature Gauge
- Engine Coolant Temperature Sender
- Oil Pressure Switch
- Oil Pressure Warning Lamp
- Brake Fluid Level Warning Switch
- Brake Fluid Level Warning Lamp
- Parking Brake Switch
- Door Switch
- Seat Belt Switch
- Seat Belt Warning Lamp
- Multi Gauge
- Indicators & Gauges
- Interior
- Indicators & Gauges
- Horns
- Motors, Switches, Relays
- OEM Connector End Views
- Connector End Views
- A/C-Heater Control Unit Connector End Views
- Air Quality Sensor Connector End View
- Audio Unit Connector End Views (H250)
- Audio Unit Connector End Views (H260)
- Audio Unit Connector End Views (H290)
- Auto Light Sensor Connector End View
- Data Link Connector End View
- Door Switch Connector End View
- DRL Module Connector End View
- Engine Control Module Connector End View (2.0L)
- Engine Control Module Connector End Views (2.7L)
- Engine Control Relay 5-Pin Connector End View (Component Side)
- Engine Control Relay 8-Pin Connector End View (Component Side)
- Fog Lamp Switch Connector End View
- Front Power Door Lock Actuator Connector End View
- Front Wiper Motor Connector End View
- Fuel Pump Check Connector End View
- Fuel Pump Relay Connector End View
- Hazard Switch Connector End View
- Head Lamp Relay End View
- HECU Connector End View
- HO2S Connector End View (Front & Rear)
- Ignition Coil Connector End View (2.7L)
- Ignition Switch Connector & Door Warning Switch Connector End Views & Locations
- Instrument Cluster Harness Connector End Views
- Map Lamp Switch Connector End View
- PCM/ECM Harness Connector End View (2.0L)
- PCM/ECM Harness Connector End Views (2.7L)
- Power Door Mirror Actuator Connector End View
- Power Door Mirror Switch Connector End View
- Power Window Main Switch Connector End View
- Power Window Sub Switch Connector End View
- Rear Washer Switch Connector End View
- Rear Wiper Motor Connector End View
- Rheostat Connector End View
- Solenoid Connector End View
- Stop Lamp Switch Connector End View
- Sun Roof Switch Connector End View
- Supplemental Restraint System Control Module Connector End View
- Throttle Position Sensor 3-Pin Connector End View (Component Side)
- Transaxle Control Module (TCM) 26-Pin Connector End View (2.0L)
- Transaxle Control Module (TCM) 22-pin Connector End View (2.7L)
- Transaxle Range Switch Harness Connector End View
- Vehicle Speed Sensor (VSS) Connector End Views
- Washer Motor Connector End View (Front & Rear)
- Connector Locations
- Brake Fluid Level Sensor Connector Location
- Data Link Connector Location
- Fog Lamp Connector Location
- Front Wheel Speed Sensor Connector Location
- Fuel Injector Harness Connector Location (2.7L)
- Glove Box Lamp & Connector Location
- HECU Double Lock Connector Location
- Radiator Fan Motor Connector Location (2.0L)
- Rear Wheel Speed Sensor Connector Location
- Rear Window Defogger Connector Location
- Sun Roof Controller & Motor Side Connector Locations
- Connector End Views
- OEM Connector End Views
- Starters
- Wiring Diagrams
- OEM Connector End Views
- Connector End Views
- A/C-Heater Control Unit Connector End Views
- Air Quality Sensor Connector End View
- Audio Unit Connector End Views (H250)
- Audio Unit Connector End Views (H260)
- Audio Unit Connector End Views (H290)
- Auto Light Sensor Connector End View
- Data Link Connector End View
- Door Switch Connector End View
- DRL Module Connector End View
- Engine Control Module Connector End View (2.0L)
- Engine Control Module Connector End Views (2.7L)
- Engine Control Relay 5-Pin Connector End View (Component Side)
- Engine Control Relay 8-Pin Connector End View (Component Side)
- Fog Lamp Switch Connector End View
- Front Power Door Lock Actuator Connector End View
- Front Wiper Motor Connector End View
- Fuel Pump Check Connector End View
- Fuel Pump Relay Connector End View
- Hazard Switch Connector End View
- Head Lamp Relay End View
- HECU Connector End View
- HO2S Connector End View (Front & Rear)
- Ignition Coil Connector End View (2.7L)
- Ignition Switch Connector & Door Warning Switch Connector End Views & Locations
- Instrument Cluster Harness Connector End Views
- Map Lamp Switch Connector End View
- PCM/ECM Harness Connector End View (2.0L)
- PCM/ECM Harness Connector End Views (2.7L)
- Power Door Mirror Actuator Connector End View
- Power Door Mirror Switch Connector End View
- Power Window Main Switch Connector End View
- Power Window Sub Switch Connector End View
- Rear Washer Switch Connector End View
- Rear Wiper Motor Connector End View
- Rheostat Connector End View
- Solenoid Connector End View
- Stop Lamp Switch Connector End View
- Sun Roof Switch Connector End View
- Supplemental Restraint System Control Module Connector End View
- Throttle Position Sensor 3-Pin Connector End View (Component Side)
- Transaxle Control Module (TCM) 26-Pin Connector End View (2.0L)
- Transaxle Control Module (TCM) 22-pin Connector End View (2.7L)
- Transaxle Range Switch Harness Connector End View
- Vehicle Speed Sensor (VSS) Connector End Views
- Washer Motor Connector End View (Front & Rear)
- Connector Locations
- Brake Fluid Level Sensor Connector Location
- Data Link Connector Location
- Fog Lamp Connector Location
- Front Wheel Speed Sensor Connector Location
- Fuel Injector Harness Connector Location (2.7L)
- Glove Box Lamp & Connector Location
- HECU Double Lock Connector Location
- Radiator Fan Motor Connector Location (2.0L)
- Rear Wheel Speed Sensor Connector Location
- Rear Window Defogger Connector Location
- Sun Roof Controller & Motor Side Connector Locations
- Connector End Views
- System Wiring Diagrams
- Using lemon2025'S Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Top/Sunroof
- Power Windows
- Radio
- Starting/Charging
- Supplemental Restraints
- Transmission
- Trunk, Tailgate, Fuel Door
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- OEM Connector End Views
- Body Electrical
- Engine Mechanical
- Accessory Drive Belts
- Electric Cooling Fans
- Cooling System (Mechanical)
- 2.0L 4-Cylinder Engine
- General
- Beta Engine Appearance
- Specifications
- Service Standards
- Torque Specifications
- Special Tools
- Troubleshooting
- Maintenance
- Engine Block
- Main Moving System
- Cooling System
- Lubrication System
- Intake & Exhaust System
- Cylinder Head Assembly
- Timing System
- General
- Cooling System Specifications & Drive Belt Routing
- 2.0L 4-Cylinder Engine
- Exhaust
- 2.0L 4-Cylinder Engine
- General
- Beta Engine Appearance
- Specifications
- Service Standards
- Torque Specifications
- Special Tools
- Troubleshooting
- Maintenance
- Engine Block
- Main Moving System
- Cooling System
- Lubrication System
- Intake & Exhaust System
- Cylinder Head Assembly
- Timing System
- General
- 2.0L 4-Cylinder Engine
- Fuel System
- Engine Controls - System & Component Testing
- Introduction
- Computerized Engine Controls
- Sensors & Switches
- Notes
- Sensors
- Notes
- Acceleration Sensor
- Camshaft Position (CMP) Sensor
- Crankshaft Position (CKP) Sensor
- Engine Coolant Temperature (ECT) Sensor
- Fuel Tank Pressure (FTP) Sensor
- Heated Oxygen Sensor (HO2S)
- Heated Oxygen Sensor (HO2S) Heater
- Intake Air Temperature (IAT) Sensor
- Knock Sensor (KS)
- Manifold Absolute Pressure (MAP) Sensor
- Mass Airflow (MAF) Sensor
- Throttle Position (TP) Sensor
- Vehicle Speed Sensor (VSS)
- Switches
- Relays
- Fuel System
- Idle Control System
- Ignition System
- Emission Systems & Sub-Systems
- Engine Controls - System & Component Testing
- Lubrication System
- 2.0L 4-Cylinder Engine
- General
- Beta Engine Appearance
- Specifications
- Service Standards
- Torque Specifications
- Special Tools
- Troubleshooting
- Maintenance
- Engine Block
- Main Moving System
- Cooling System
- Lubrication System
- Intake & Exhaust System
- Cylinder Head Assembly
- Timing System
- General
- 2.0L 4-Cylinder Engine
- Mechanical
- 2.0L 4-Cylinder Engine
- General
- Beta Engine Appearance
- Specifications
- Service Standards
- Torque Specifications
- Special Tools
- Troubleshooting
- Maintenance
- Engine Block
- Main Moving System
- Cooling System
- Lubrication System
- Intake & Exhaust System
- Cylinder Head Assembly
- Timing System
- General
- 2.0L 4-Cylinder Engine
- Starters
- Timing Belt
- 2.0L 4-Cylinder Engine
- General
- Beta Engine Appearance
- Specifications
- Service Standards
- Torque Specifications
- Special Tools
- Troubleshooting
- Maintenance
- Engine Block
- Main Moving System
- Cooling System
- Lubrication System
- Intake & Exhaust System
- Cylinder Head Assembly
- Timing System
- General
- 2.0L 4-Cylinder Engine
- Engine Performance
- Engine Controls - On-Vehicle Adjustments
- Application
- Emissions
- Emission Applications
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Engine Control Systems
- Engine Controls - System & Component Testing
- Introduction
- Computerized Engine Controls
- Sensors & Switches
- Notes
- Sensors
- Notes
- Acceleration Sensor
- Camshaft Position (CMP) Sensor
- Crankshaft Position (CKP) Sensor
- Engine Coolant Temperature (ECT) Sensor
- Fuel Tank Pressure (FTP) Sensor
- Heated Oxygen Sensor (HO2S)
- Heated Oxygen Sensor (HO2S) Heater
- Intake Air Temperature (IAT) Sensor
- Knock Sensor (KS)
- Manifold Absolute Pressure (MAP) Sensor
- Mass Airflow (MAF) Sensor
- Throttle Position (TP) Sensor
- Vehicle Speed Sensor (VSS)
- Switches
- Relays
- Fuel System
- Idle Control System
- Ignition System
- Emission Systems & Sub-Systems
- Engine Controls - System & Component Testing
- Fuel Delivery
- Engine Controls - System & Component Testing
- Introduction
- Computerized Engine Controls
- Sensors & Switches
- Notes
- Sensors
- Notes
- Acceleration Sensor
- Camshaft Position (CMP) Sensor
- Crankshaft Position (CKP) Sensor
- Engine Coolant Temperature (ECT) Sensor
- Fuel Tank Pressure (FTP) Sensor
- Heated Oxygen Sensor (HO2S)
- Heated Oxygen Sensor (HO2S) Heater
- Intake Air Temperature (IAT) Sensor
- Knock Sensor (KS)
- Manifold Absolute Pressure (MAP) Sensor
- Mass Airflow (MAF) Sensor
- Throttle Position (TP) Sensor
- Vehicle Speed Sensor (VSS)
- Switches
- Relays
- Fuel System
- Idle Control System
- Ignition System
- Emission Systems & Sub-Systems
- Engine Controls - System & Component Testing
- Mode 6 - 2001-2005 HYUNDAI
- Engine Controls - Pin Voltage Charts
- Remove, Overhaul & Install
- Engine Controls - Removal & Installation
- Introduction
- Air Induction System
- Computerized Engine Controls
- Sensors & Switches
- Fuel System
- Ignition System
- Emission Systems & Sub-Systems
- Torque Specifications
- Engine Controls - Removal & Installation
- Sensor Range Charts
- Specifications
- System
- Engine Controls - Basic Diagnostic Procedures
- Introduction
- Preliminary Inspection & Adjustments
- Fuel System
- Ignition Checks
- Idle Speed & Ignition Timing
- Summary
- Engine Controls - Self-Diagnostics - 2.0L
- Introduction
- Self-Diagnostic System
- Diagnostic Trouble Code Definitions
- Engine Control Module (ECM) Location
- Summary
- Drive Cycles
- Intermittent Diagnostic Trouble Codes
- Connector Terminal Identification
- Diagnostic Tests
- Notes
- DTC P0106, DTC P0107 Or DTC P0108
- DTC P0112 Or DTC P0113
- DTC P0116, DTC P0117 Or DTC P0118
- DTC P0121, DTC P0122 Or DTC P0123
- DTC P0130 Or DTC P0136
- DTC P0131 Or DTC P0137
- DTC P0132 Or DTC P0138
- DTC P0133 Or DTC P0134
- DTC P0030, DTC P0031, DTC P0032, DTC P0036, DTC P0037 Or DTC P0038
- DTC P0261, DTC P0262, DTC P0264, DTC P0265, DTC P0267, DTC P0268, DTC P0270 & DTC P0271
- DTC P0300: Random Misfire Detected
- DTC P0301, DTC P0302, DTC P0303 & DTC P0304
- DTC P0325: Knock Sensor Circuit Malfunction
- DTC P0335: Crankshaft Position (CKP) Sensor Circuit Malfunction
- DTC P0340: Camshaft Position (CMP) Sensor Circuit Malfunction
- DTC P0420: Catalytic Converter Efficiency Deterioration
- DTC P0441, DTC P0442, DTC P0455 Or DTC P0456
- DTC P0444 Or DTC P0445
- DTC P0447 Or DTC P0448
- DTC P0451, DTC P0452, DTC P0453 Or DTC P0454
- DTC P0501: Vehicle Speed Sensor (VSS) Range/Performance Problem
- DTC P0506 Or DTC P0507
- DTC P0650: Malfunction Indicator Light (Mil) Request Signal Circuit
- DTC P1505, DTC P1506, DTC P1507 Or DTC P1508
- DTC P1513 Or DTC P1553
- Engine Controls - System & Component Testing
- Introduction
- Computerized Engine Controls
- Sensors & Switches
- Notes
- Sensors
- Notes
- Acceleration Sensor
- Camshaft Position (CMP) Sensor
- Crankshaft Position (CKP) Sensor
- Engine Coolant Temperature (ECT) Sensor
- Fuel Tank Pressure (FTP) Sensor
- Heated Oxygen Sensor (HO2S)
- Heated Oxygen Sensor (HO2S) Heater
- Intake Air Temperature (IAT) Sensor
- Knock Sensor (KS)
- Manifold Absolute Pressure (MAP) Sensor
- Mass Airflow (MAF) Sensor
- Throttle Position (TP) Sensor
- Vehicle Speed Sensor (VSS)
- Switches
- Relays
- Fuel System
- Idle Control System
- Ignition System
- Emission Systems & Sub-Systems
- Engine Controls - Trouble Shooting - No Codes
- Engine Controls - Basic Diagnostic Procedures
- Testing & Diagnosis
- Engine Controls - Basic Diagnostic Procedures
- Introduction
- Preliminary Inspection & Adjustments
- Fuel System
- Ignition Checks
- Idle Speed & Ignition Timing
- Summary
- Engine Controls - Self-Diagnostics - 2.0L
- Introduction
- Self-Diagnostic System
- Diagnostic Trouble Code Definitions
- Engine Control Module (ECM) Location
- Summary
- Drive Cycles
- Intermittent Diagnostic Trouble Codes
- Connector Terminal Identification
- Diagnostic Tests
- Notes
- DTC P0106, DTC P0107 Or DTC P0108
- DTC P0112 Or DTC P0113
- DTC P0116, DTC P0117 Or DTC P0118
- DTC P0121, DTC P0122 Or DTC P0123
- DTC P0130 Or DTC P0136
- DTC P0131 Or DTC P0137
- DTC P0132 Or DTC P0138
- DTC P0133 Or DTC P0134
- DTC P0030, DTC P0031, DTC P0032, DTC P0036, DTC P0037 Or DTC P0038
- DTC P0261, DTC P0262, DTC P0264, DTC P0265, DTC P0267, DTC P0268, DTC P0270 & DTC P0271
- DTC P0300: Random Misfire Detected
- DTC P0301, DTC P0302, DTC P0303 & DTC P0304
- DTC P0325: Knock Sensor Circuit Malfunction
- DTC P0335: Crankshaft Position (CKP) Sensor Circuit Malfunction
- DTC P0340: Camshaft Position (CMP) Sensor Circuit Malfunction
- DTC P0420: Catalytic Converter Efficiency Deterioration
- DTC P0441, DTC P0442, DTC P0455 Or DTC P0456
- DTC P0444 Or DTC P0445
- DTC P0447 Or DTC P0448
- DTC P0451, DTC P0452, DTC P0453 Or DTC P0454
- DTC P0501: Vehicle Speed Sensor (VSS) Range/Performance Problem
- DTC P0506 Or DTC P0507
- DTC P0650: Malfunction Indicator Light (Mil) Request Signal Circuit
- DTC P1505, DTC P1506, DTC P1507 Or DTC P1508
- DTC P1513 Or DTC P1553
- Engine Controls - System & Component Testing
- Introduction
- Computerized Engine Controls
- Sensors & Switches
- Notes
- Sensors
- Notes
- Acceleration Sensor
- Camshaft Position (CMP) Sensor
- Crankshaft Position (CKP) Sensor
- Engine Coolant Temperature (ECT) Sensor
- Fuel Tank Pressure (FTP) Sensor
- Heated Oxygen Sensor (HO2S)
- Heated Oxygen Sensor (HO2S) Heater
- Intake Air Temperature (IAT) Sensor
- Knock Sensor (KS)
- Manifold Absolute Pressure (MAP) Sensor
- Mass Airflow (MAF) Sensor
- Throttle Position (TP) Sensor
- Vehicle Speed Sensor (VSS)
- Switches
- Relays
- Fuel System
- Idle Control System
- Ignition System
- Emission Systems & Sub-Systems
- Engine Controls - Trouble Shooting - No Codes
- Engine Controls - Basic Diagnostic Procedures
- Theory and Operation
- Engine Controls - Theory & Operation
- Introduction
- Air Induction System
- Computerized Engine Controls
- Notes
- Engine Control Module
- Input Devices
- Notes
- A/C Switch
- Acceleration Sensor (Accent)
- Camshaft Position Sensor
- Crankshaft Position Sensor
- Engine Coolant Temperature Sensor
- Fuel Tank Pressure Sensor
- Heated Oxygen Sensor
- Idle Position Switch (Sante Fe 3.5L & XG350)
- Intake Air Temperature Sensor
- Knock Sensor
- Mass Airflow Sensor
- Manifold Absolute Pressure Sensor (Accent, Elantra, Santa Fe 2.4L, Sonata 2.4L, Tiburon 2.0L & XG350)
- Power Steering Pressure Switch (Santa Fe, Sonata 2.4L, Sonata 2.7L, Tiburon 2.7L & XG350)
- Throttle Position Sensor
- Transaxle Range Switch (A/T)
- Vehicle Speed Sensor
- Output Signals
- Fuel System
- Ignition System
- Emission Systems
- Self-Diagnostic System
- Miscellaneous Controls
- Engine Controls - Theory & Operation
- Vacuum Diagrams
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- Computer Relearn Procedures
- OBD-II Drive Cycles
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- DTC Index
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Identification
- Metric Conversions
- OEM General Information
- How To Use The Engine Performance Section
- Restraints
- Specifications Index
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Traction Control Disable Procedures
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- A/C Compressor
- HVAC System
- General
- Air Conditioning System
- Instructions
- Refrigeration Cycle
- Refrigerant Line (2.0L DOHC)
- Refrigerant Line (2.7L DOHC)
- Installation Of Manifold Gauge Set
- Refrigerant Discharging Procedure
- Evacuating Refrigerant System
- Handling Refrigerant Service Tap Valve
- Charging Refrigerant System (Vapor)
- Charging The Refrigerant System (Liquid)
- Performance Test
- Checking For Refrigerant Leaks
- Amount Of Deflection Of Belt
- Blower Unit Air Filter
- Performance Test Diagnosis Using Manifold Gauge
- Manual A/C Compressor Controls
- Full Auto A/C Compressor
- Heater
- Blower Controls
- Blower & A/C Controls Schematic Diagram
- Control Panel (Auto)
- Blower & A/C Controls (Automatic)
- HVAC System
- General Servicing
- Cabin Air Filter
- HVAC System
- General
- Air Conditioning System
- Instructions
- Refrigeration Cycle
- Refrigerant Line (2.0L DOHC)
- Refrigerant Line (2.7L DOHC)
- Installation Of Manifold Gauge Set
- Refrigerant Discharging Procedure
- Evacuating Refrigerant System
- Handling Refrigerant Service Tap Valve
- Charging Refrigerant System (Vapor)
- Charging The Refrigerant System (Liquid)
- Performance Test
- Checking For Refrigerant Leaks
- Amount Of Deflection Of Belt
- Blower Unit Air Filter
- Performance Test Diagnosis Using Manifold Gauge
- Manual A/C Compressor Controls
- Full Auto A/C Compressor
- Heater
- Blower Controls
- Blower & A/C Controls Schematic Diagram
- Control Panel (Auto)
- Blower & A/C Controls (Automatic)
- HVAC Control Systems
- HVAC System
- General
- Air Conditioning System
- Instructions
- Refrigeration Cycle
- Refrigerant Line (2.0L DOHC)
- Refrigerant Line (2.7L DOHC)
- Installation Of Manifold Gauge Set
- Refrigerant Discharging Procedure
- Evacuating Refrigerant System
- Handling Refrigerant Service Tap Valve
- Charging Refrigerant System (Vapor)
- Charging The Refrigerant System (Liquid)
- Performance Test
- Checking For Refrigerant Leaks
- Amount Of Deflection Of Belt
- Blower Unit Air Filter
- Performance Test Diagnosis Using Manifold Gauge
- Manual A/C Compressor Controls
- Full Auto A/C Compressor
- Heater
- Blower Controls
- Blower & A/C Controls Schematic Diagram
- Control Panel (Auto)
- Blower & A/C Controls (Automatic)
- HVAC System
- A/C Compressor
- Restraints
- Air Bag, SRS
- Air Bag Restraint Systems
- Description & Operation
- Component Locations
- System Operation Check
- Air Bag Safety Precautions
- Disabling & Activating Air Bag System
- Disposal Procedures
- Post-Collision Inspection
- Removal & Installation
- Diagnostics
- Diagnostic Tests
- DTC B1111, B1112: Battery Voltage High Or Low
- DTC B1346, B1347: Driver-Side Air Bag Resistance High/Low
- DTC B1348, B1354, B1363, B1369, B1380, B1384, B1401, B1404: Component Shorted To Ground
- Notes
- Check Driver-side AIR Bag Squib Circuit
- Check Passenger-side AIR Bag Squib Circuit
- Check Driver-side Seat Belt Pretensioner Squib Circuit
- Check Passenger-side Seat Belt Pretensioner Squib Circuit
- Check Driver Side Impact AIR Bag Squib Circuit
- Check Passenger Side Impact AIR Bag Squib Circuit
- Check Driver-side Satellite Sensor Circuit
- Check Passenger-side Satellite Sensor Circuit
- Check SRSCM
- DTC B1349, B1355, B1364, B1370, B1381, B1385, B1402, B1405: Component Shorted To Battery
- Notes
- Check Driver-side AIR Bag Squib Circuit
- Check Passenger-side AIR Bag Squib Circuit
- Check Driver-side Seat Belt Pretensioner Squib Circuit
- Check Passenger-side Seat Belt Pretensioner Squib Circuit
- Check Driver Side Impact AIR Bag Squib Circuit
- Check Passenger Side Impact AIR Bag Squib Circuit
- Check Driver-side Satellite Sensor Circuit
- Check Passenger-side Satellite Sensor Circuit
- Check SRSCM
- DTC B1352, B1353: Passenger-Side Air Bag Resistance High Or Low
- DTC B1361, B1362, B1367, B1368 Driver Or Passenger Seat Belt PRETENSIONER Resistance High Or Low
- DTC B1378, B1379, B1382, B1383: Driver Or Passenger Side Impact Air Bag Resistance High Or Low
- DTC B1400, B1403, B1409, B1410 Satellite Sensor Defect/Communication Error
- DTC B1511, B1512, B1513, B1514 Seat Belt Switch Open Or Short To Battery/Short To Ground
- DTC B1620, B1650, B1655, B1657, B1661 SRSCM Internal Codes
- DTC B2500: Air Bag Warning Light
- Torque Specifications
- Wiring Diagrams
- Air Bag Restraint Systems
- Passive Restraints
- Air Bag, SRS
- Steering
- Manual Steering
- Mechanical Power Steering System
- General
- Specifications
- Tightening Torque
- Lubricants
- Special Tools
- Troubleshooting
- Service Adjustment Procedure
- Checking Steering Wheel Free Play
- Checking Steering Angle
- Checking The Tie Rod End Ball Joint Starting Torque
- Checking Stationary Steering Effort
- Checking Steering Wheel Return
- Checking Power Steering Belt Tension
- Checking Power Steering Fluid Level
- Replacing Power Steering Fluid
- Air Bleeding
- Oil Pump Pressure Test
- Mechanical Power Steering System
- General
- Mechanical Power Steering System
- Mechanical Power Steering System
- General
- Specifications
- Tightening Torque
- Lubricants
- Special Tools
- Troubleshooting
- Service Adjustment Procedure
- Checking Steering Wheel Free Play
- Checking Steering Angle
- Checking The Tie Rod End Ball Joint Starting Torque
- Checking Stationary Steering Effort
- Checking Steering Wheel Return
- Checking Power Steering Belt Tension
- Checking Power Steering Fluid Level
- Replacing Power Steering Fluid
- Air Bleeding
- Oil Pump Pressure Test
- Mechanical Power Steering System
- General
- Manual Steering
- Suspension
- Front Suspension System
- Rear Suspension System
- Wheel Alignment
- Wheels & Tire System
- Transmission
- Clutch
- Manual Trans
- Manual Transaxle Removal & Installation Procedure (***Important Information***)
- Manual Transaxles
- Servicing - Manual Transmission
- External Pages